Beruflich Dokumente
Kultur Dokumente
P
O
W
E
R
R
X
T
X
P
O
W
E
R
O
N
D
-
S
U
B
9
M
A
L
E
FEMALE
F
E
M
A
L
E
COM port
CABLE 1
(max 6 M)
Computer
with RS232
Computer
with USB
adapter
USB to
RS232
adapter
C
A
B
L
E
2
(
m
a
x
5
0
0
M
)
4 poles
FEMALE
pitch 3.81mm
4 poles
FEMALE
pitch 3.81mm
2 poles
FEMALE
pitch 5mm
INSTRUCTION OF USE:
1. Connect to using .
2. Connect to using .
3. Connect
4. Turn ON power supply to .
5. Turn ON the and start the software. Setup
the parameters acordingly to the User Manual.
Green led and red led should blink acordingly to
the received / transmitted data between and
.
C232-485 PC CABLE 1
C232-485 BE xxx CABLE 2
POWER SUPPLY.
BE xxx
PC
PC
C232-485
C232-485 to a
Y
e
l
l
o
w
G
r
e
e
n
R
e
d
- 9.0 - Contents of the Pages
9.01: Alarm Status Page iIt indicates the alarms in real time
9.02: Engine Parameters Page iIt contains all parameters of the engine
9.03: Generator Parameters Page iIt contains all parameters of the generator
9.04: Measurement Page iIt indicates all measurements
9.05: Miscellaneous Parameters Page iIt contains miscellaneous parameters
9.06: Sensors Characteristics Page iIt contains the settings of the sensors
9.07: Alarm Setting & Options iIt contains options for the alarms
9.08: Mains Setting & Options iIt contains all parameters of the Mains
9.09: Inputs & Outputs options iIt allows you to program the I/O
9.10: Event History iIt displays the memory and the sequence of the events
9.11: Control Panel
The control panel is located in the Measurements page (see section 9.04).
You can perform the following operations
- Start engine test - it stats the engine (the Be42 must be in Auto mode)
- Stop engine test - it terminate the engine test
- Start genset test - it starts the engine and transfer the LOAD to generator
- Stop genset test - it terminate the genset test
- Memory init - it cancel the memory and put the factory programming parameters
- Clear events - it cancels the events
- Select a mode of operation. it allows you to select a mode of operation
- Control the contactors - it allows you to open/close the contactor (in Manual mode)