Beruflich Dokumente
Kultur Dokumente
AIS Beacon
6V Lithium Metal
By service centre
Logged by microcontroller
OPERATION
Activation
Self test (short)
GPS Self test (long)
TRANSPORTATION
Air cargo
Classification
ELECTRICAL
AIS Transmitter
AIS channel 1- 161.975 MHz, AIS channel 2 - 162.025 MHz
Frequency
Power
2W nominal
Transmit antenna
Integrated PCB
AIS messages transmitted Message 1 (ID, GPS position, SOG,COG,UTC)
Message 14 (MOB-ACTIVE or MOB TEST)
ID number
Factory programmed
GPS receiver
GPS type
50 channel
Antenna type
Ceramic patch
GPS position update
Every minute
nM
anually activated personal safety
device to aid recovery of persons in
difficulty
n Transmits GPS target tracking
information over AIS
n Unique serialized ID
n Small and light for unobtrusive carriage
n Waterproof, buoyant and
fully submersible to 60 meters
n Flashing LED light
n Minimum 24 hour continuous operation
n 5 year battery storage life
PHYSICAL
Length
Diameter at widest point
Weight
Deployment
Hands free
Hand held
Security
Smartfind S10
AIS Beacon
NEW
199mm (7.8)
51mm (2.0)
186g (6.5oz)
Belt or arm pouch with head band strap included
Wrist lanyard included
lanyard fixing point
FUNCTIONAL
First transmission
Range
Secondary location device
PART NUMBER
Smartfind S10 AIS Beacon retail pack
98-051-001A
Dealer:
Orolia Ltd. Silver Point, Airport Service Road, Portsmouth. PO3 5PB. United Kingdom
Tel: +44 (0) 23 9262 3900 Fax: +44 (0) 23 9262 3998
E-mail: sales.mcmurdo@orolia.com www.mcmurdomarine.com
Please note that all information given in this brochure is intended to be useful and informative and is
correct to the best of our knowledge at time of print. No liability can be accepted for inaccuracies or
omissions. The right is reserved to amend this information without prior notice.
www.mcmurdomarine.com
waterproof
and fully
submersible
to 60 meters
Activated
Smartfind S10
AIS Beacon
Simple to activate
Smartfind S10 AIS Beacon is simple to operate, even in
a gloved hand. When the person in trouble has been
successfully retrieved from the water, the beacon can be
switched off. A built in test facility indicates whether or not
battery replacement is advised.
As AIS SARTs are still very new, not all small-craft chart plotters with AIS show the
as recommended by the IMO. At the very least, they will show
correct SART icon
the same icon as used for other craft normally an arrow. In addition, user settings
generally allow you to configure the display to show the MMSI number, which in the S10
always begins with 972. This way you can differentiate the S10 from other vessels. If in
doubt, check with your plotter manufacturer how they display SARTs on screen.
correctly.
All new ECDIS plotters (on ships over 300 tonnes) will display the SART icon
*For use with AIS enabled chart plotters, contact your chart plotter manufacturer for
further info.
www.mcmurdomarine.com