Beruflich Dokumente
Kultur Dokumente
Properties
Uses
Appearance:
Specific gravity:
Chloride content:
Pink liquid
Typically 1.09 at 20oC
Nil to BS 5075
Compatibility
Advantages
!
!
!
!
!
Description
Dispensing
Conplast X421 chloride free integral waterproofing admixture
is based on a formulated blend of plasticisers. It is supplied as
a pink liquid, which instantly disperses in water.
The plasticisers in Conplast X421 improve the effectiveness
of water in the concrete mix, enabling desired levels of
workability to be obtained with lower water contents. This
produces a mix with a reduced water: cement ratio and
therefore reduced permeability.
Technical support
Fosroc provides a technical advisory service for on-site
assistance and advice on admixture selection, evaluation
trials and dispensing equipment. Technical data and guidance
can be provided for admixtures and other products for use
with fresh and hardened concrete.
Typical dosage
The optimum dosage of Conplast X421 to meet specific
requirements should always be determined by trials using the
materials and conditions that will be experienced in use. This
allows the optimization of admixture dosage and mix design
and provides a complete assessment of the mix. The normal
3
recommended dosage is 6 litres/m .
Use at other dosages
Dosages other than those given on this sheet may be used to
meet particular mix requirements provided that adequate
supervision is available. Compliance with requirements must
be assessed through trial mixes. Contact the Fosroc
Technical Service Department for advice in these cases.
Estimating - packaging
A typical performance example from evaluation on studies of
Conplast X421 is included on this data sheet. The values
quoted are representative of results obtained and are
provided as illustrations of the performance.
Conplast X421 is available in 25 Itr, 210 ltr drum and bulk supply.
Storage
Example 1:
Mix
Control
Conplast X421
2.0
0.60
0.56
0.48
0.13
Precautions
Limitations
The use of Conplast X421 will not make poor quality concrete
waterproof. Good concrete practice must be followed at all
times. Well-graded aggregate must be used and a minimum
3
cement content of 300 kg/ m is recommended. Consult the
fact sheet available on the use of Conplast plasticisers in
water retaining structures for further information. Adequate
water bars must be provided between lifts of concrete and
floor bays.
Fire
Additional information
Conplast X421 was previously known as Conplast Prolapin 421.
*see separate data sheet
*Denotes the trade marks of Fosroc International Limited
Jeddah Showroom
Dammam
Yanbu
Medinah
Head Office & Factory
Important note: Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard terms and conditions of
sale, copies of which may be obtained on request. Whist Fosroc endeavors to insure that any advice, recommendation, specification or information it may give
is accurate and correct, it cannot, because it has no direct or continuous control over where how its products are applied, accept any liability either directly or
indirectly arising from the use of its products, whether or not in accordance with any advice, specification, recommendation or information given by it
SAU/T1 CPWP20/95/A