Beruflich Dokumente
Kultur Dokumente
: _____
Enrolment No.______
Date: 25-05-2011
Instructions:
1. Attempt all questions.
2. Make suitable assumptions wherever necessary.
3. Figures to the right indicate full marks.
Q.1 (a) Do as directed
(i) State theorem of moment area method.
(ii) Sketch a beam with SI=2 & KI=2 ( neglect axial deformations)
(iii) Sketch kern of rectangular section 600 x 900 mm.
(iv) Write predominant actions in structural elements column, beam, arch
and cable.
(v) State Maxwells reciprocal theorem
(vi) Define : Resilience, Modulus of resilience
(vii) Write down any four assumptions made for derivation of Eulers
crippling load formula.
(b) Do as directed
(i) Find SI and KI of structures shown at fig.1(a) & fig.1 (b)
(ii) For the portal shown in the fig.2,find out moment at B ,shear and axial
force in member AB.
Q.2 (a) A solid steel shaft has to transmit 120 kW at 600 r.p.m.Find the diameter of
the shaft if the shear stress is to be limited to 100 N/mm2. Estimate the
possible % saving in the material of the shaft if hollow shaft of internal
diameter equals 0.75 times external diameter is replaced against solid shaft.
(b) A 1500 mm long wire of 25 mm2 cross sectional area is hanged vertically. It
receives a sliding collar of 100 N weight and stopper at the bottom end. The
collar is allowed to fall on stopper through 200 mm height. Determine the
instantaneous stress induced in the wire and corresponding elongation. Also
determine the strain energy stored in the wire. Take modulus of elasticity of
wire as 200 GPa.
OR
(b) A solid cast iron circular column of 4.0 m height is to be erected such that
its one end remains fixed and other end remains hinged. Find the size of the
section, if column has to carry a safe axial load of 300 kN. Take factor
safety of 5,fc =500 N/mm2,Rankines constant = 1/ 1500.
Q.3 (a) Find the slope and deflection at point B and C for the beam shown in the
fig.3 Take EI=3000 kN.m2
(b) For a trapezoidal masonry dam as shown in the fig.4, plot the stress
distribution at the base. Take density of masonry = 20 kN / m3.
OR
Q.3 (a) Find the slope at A and deflection under C for the beam shown in the fig.5
Take EI=3000 kN.m2
1/3
07
04
03
07
07
07
07
07
07
Q.4
Q.4
Q.5
Q.5
*************
2/3
07
07
03
04
07
07
07
07
07
07
B.E.SEM-III(CIVIL)
S.A-I(SUBJECT CODE-130604)
Internal Hinge
fig.1(a) Q:1(b)(i)
fig.1(b) Q:1(b)(i)
10 kN
B
10 kN
10 kN
2.0 m
5.0 m
10 kN.m
5.0 m
2.0 m
C
A
EI
2EI
2.0 m
2.0 m
fig.3 Q:3(a)
fig.2 Q:1(b)(ii)
20 kN
1.0 m
1.0 m
10 kN/m
A
4.0 m
B
3.0 m
3.0 m
EI = CONSTANT
fig.5 Q: 3(a) OR
3.0 m
fig.4 Q:3(b)
1m
U2
U3
U4
U5
U6
U7
D
4m
3m
U1
2m
L1
4m
L2 4 m L3 4 m L4 4 m L5 4 m
fig.6 Q:4(a)
fig.7
50 kN
7.5 m
4.58 m
15.0 m
15.0 m
fig.8 Q:5(b)
3/3
Q:4(b) OR
L6 4 m
L7