Beruflich Dokumente
Kultur Dokumente
To create sample tracks the EXS24 sampler is a must have plug-in. It comes with the
logic software and functions either through logic library sounds or the use of your
own recorded audio. To begin my sample tracks, I first recorded in some audio. These
were short, simple sounds, as my plan was to manipulate them using the internal plugins. My aim was to then create three 2 minute & 30 seconds long tracks using 1 sound
if not, maximum of 3 sounds.
To begin with I recorded in audio like so,
Once my audio was all recorded in I had to bounce them into an mp3 so that I can
import them into the EXS24 sampler. I did this by clicking bounce on the right
channel (bottom left) and saved it to the appropriate folder. I did each sound
individually so that I didnt bounce two sounds onto one mp3.
Once I had created all my sounds I then put them into the EXS24 sampler like so;
1. First of all I selected a software instrument track
4. On the tabs at the top of the window the only buttons necessary are zone and
instrument.
5. I clicked zone which then had a drop down menu. From the menu, I chose
the option load multiple samples.
8. After I did this I then clicked instruments and saved it to the sampler
instruments folder in logic.
9. Once I could get the sound up in logic I then started to experiment with other
plug-ins such as tape delay, reverb, distortion etc to manipulate the same
sound in different ways.
10. Once I had all my sounds in the sampler and edited I began to structure my
track.