Beruflich Dokumente
Kultur Dokumente
323
H.225-- Call setup message
H.245-- Capability exchange
show voice port (Check for configuration information, including loopstart or gro
undstart.)
show call history voice
show call history voice last 1
show call active voice
show ip route
show logging
show debugging
show dial-peer voice
show dialplan number
show dialplan (on both the local and remote routers verify that the data is config
ured correctly.)
show num-exp (if number expansion is configured) check that the partial number on
the local router maps to the correct full E.164 telephone number on the remote r
outer.
debug vpm signal (Collect debug information about signaling events, such as dete
ction of a ring, a call connection, or a disconnect.)
debug vpm spi verify the output string the router dials is correct. This is not av
ailble on 124 IOS ???
debug cch323 rtp check RTP packet transport.
debug cch323 h225 check the call setup.
CME1#show dialplan number 201
Macro Exp.: 201
VoiceEncapPeer101
peer type = voice, information type = voice,
description = ` ,
tag = 101, destination-pattern = `201',
answer-address = ` , preference=0,
CLID Restriction = None
CLID Network Number = `
CLID Second Number sent
CLID Override RDNIS = disabled,
source carrier-id = ` , target carrier-id = ` ,
source trunk-group-label = ` , target trunk-group-label = ` ,
numbering Type = `unknown
group = 101, Admin state is up, Operation state is up,
Outbound state is up,
incoming called-number = ` , connections/maximum = 0/unlimited,
DTMF Relay = disabled,
URI classes:
Destination =
huntstop = disabled,
in bound application associated: DEFAULT
out bound application associated:
dnis-map =
permission :both
incoming COR list:maximum capability
outgoing COR list:minimum requirement
Translation profile (Incoming):
Translation profile (Outgoing):
incoming call blocking:
translation-profile = `
disconnect-cause = `no-service