Beruflich Dokumente
Kultur Dokumente
UncleBEE
1/6
7/5/12
Considering a rise of 6 dB, the RTWP is 99.9 dBm. That is, the RTWP reaches the maximum
threshold when no UE is accessed. The LST CELLCAC command can be used to view the
BackgroundNoise value.
4. After confirming the improper RTWP causes a low HUSPA throughput, we enabled the automatic
update switch for background noise with the command: MOD CELLCAC: CellId=11111,
BGNSwitch=ON; This function can automatically update the background noise in a period every
day, for example, 1:00 a.m. to 6:00 a.m. (default value). If the RTWP is proper before, the automatic
update switch for background noise can be enabled to solve the problem.
5. If the problem is not solved after the automatic update switch for background noise is enabled, to
avoid affecting the project progress or acceptance, the following temporary solution can be used to
ensure that the acceptance of a single site is passed. The fundamental cause for the problem is that
the actual background noise differs from the configured one. Therefore, it is necessary to manually
set them to the same value.
The procedure is as follows:
1) Track the RTWP in the current cell at the RNC to obtain the current RTWP, for example,
CurrentRTWP.
Modify the background noise in the current cell with the following command:
MOD CELLCAC: CellId=11111, BackgroundNoise=(CurrentRTWP+112)*10;
Disable the automatic update switch for background noise.
2) After modification, test the HUSPA throughput at the place near to the cell. Generally, the
problem can be solved.
3) After testing, modify the background noise to the baseline value and enable the automatic update
switch for background noise.
The purpose of the temporary solution is to ensure that the acceptance of a single site can be passed.
The solution for an improper RTWP is the most fundamental, but it usually takes a very long time.
Suggestions and Summary : After the preceding solution is applied to project V, the HSUPA
throughput is proper.
In practice, some causes may lead to an improper RTWP that affects the HSUPA throughput. The
preceding solution is applicable to such problem.
Category:
RF
Leave a comment
Blog at WordPress.com
. | Theme: Spectrum
thebeeliever.wordpress.com/2011/05/20/rf-a-low-hspua-throughput-caused-by-improper-rtwp/
by Ignacio Ricci
2/6
7/5/12
thebeeliever.wordpress.com/2011/05/20/rf-a-low-hspua-throughput-caused-by-improper-rtwp/
3/6
7/5/12
thebeeliever.wordpress.com/2011/05/20/rf-a-low-hspua-throughput-caused-by-improper-rtwp/
4/6
7/5/12
thebeeliever.wordpress.com/2011/05/20/rf-a-low-hspua-throughput-caused-by-improper-rtwp/
5/6
7/5/12
thebeeliever.wordpress.com/2011/05/20/rf-a-low-hspua-throughput-caused-by-improper-rtwp/
6/6