Sie sind auf Seite 1von 152

Copyright Notice:

No part of this installation guide may be reproduced, transcribed, transmitted, or translated in any language, in any form or by any means, except duplication of documentation
by the purchaser for backup purpose, without written consent of ASRock Inc.
Products and corporate names appearing in this guide may or may not be registered
trademarks or copyrights of their respective companies, and are used only for identification or explanation and to the owners benefit, without intent to infringe.

Disclaimer:
Specifications and information contained in this guide are furnished for informational use
only and subject to change without notice, and should not be constructed as a commitment by ASRock. ASRock assumes no responsibility for any errors or omissions that may
appear in this guide.
With respect to the contents of this guide, ASRock does not provide warranty of any kind,
either expressed or implied, including but not limited to the implied warranties or conditions of merchantability or fitness for a particular purpose. In no event shall ASRock, its
directors, officers, employees, or agents be liable for any indirect, special, incidental, or
consequential damages (including damages for loss of profits, loss of business, loss of
data, interruption of business and the like), even if ASRock has been advised of the possibility of such damages arising from any defect or error in the guide or product.

This device complies with Part 15 of the FCC Rules. Operation is subject to the following
two conditions:
(1) this device may not cause harmful interference, and
(2) this device must accept any interference received, including interference that
may cause undesired operation.

English

CALIFORNIA, USA ONLY


The Lithium battery adopted on this motherboard contains Perchlorate, a toxic substance
controlled in Perchlorate Best Management Practices (BMP) regulations passed by the
California Legislature. When you discard the Lithium battery in California, USA, please
follow the related regulations in advance.
Perchlorate Material-special handling may apply, see
www.dtsc.ca.gov/hazardouswaste/perchlorate
ASRock Website: http://www.asrock.com

Published May 2011


Copyright2011 ASRock INC. All rights reserved.

ASRock H61M-ITX Motherboard

Motherboard Layout
2

17.0cm (6.7 in)


SATA_0 (PORT 0)

SATA_2 (PORT 4)

CMOS
Battery

ATXPWR1

CLRCMOS1

19

PANEL1

8
SATA_1 (PORT 1)

HDLED RESET

CHA_FAN1

CIR1

DVI_CON1

USB6_7

USB8_9

ATX12V1

DDR3

VGA1

Intel
H61

16
HDMI1

15

USB 3.0
T: USB4
B: USB5

Top:
RJ-45

Center:
FRONT

Top:
LINE IN

Bottom:
MIC IN

Top:
CTR BASS

Bottom:
Optical
SPDIF

Center:
REAR SPK

ErP/EuP Ready

ESATA1

USB 2.0
T: USB2
B: USB3

HD_AUDIO1

H61M-ITX

AUDIO
CODEC

PCIE1

HDMI 1.4a

USB 3.0

14

1
2
3
4
5
6
7
8
9
10
11

English
2

9
10

DDR3_B1 (64 bit, 240-pin module)

32Mb
BIOS

X Fast USB

CPU_FAN1

DDR3_A1 (64 bit, 240-pin module)

18
17

17.0cm (6.7 in)

PLED1

PS2
Keyboard

USB 2.0
T: USB0
B: USB1

Gigabit LAN

PLED PWRBTN

11

Designed in Taipei

RoHS

12

13

System Panel Header (PANEL1, White)


SATA2 Connector (SATA_1 (PORT 1), Blue)
SATA2 Connector (SATA_0 (PORT 0), Blue)
SATA2 Connector (SATA_2 (PORT 4), Blue)
Clear CMOS Jumper (CLRCMOS1)
Intel H61 Chipset
ATX Power Connector (ATXPWR1)
USB 2.0 Header (USB8_9, Blue)
Consumer Infrared Module Header (CIR1)
USB 2.0 Header (USB6_7, Blue)
2 x 240-pin DDR3 DIMM Slots
(Dual Channel: DDR3_A1, DDR3_B1, Blue)

12
13
14
15
16
17
18
19

1155-Pin CPU Socket


PCI Express 2.0 x16 Slot (PCIE1, Blue)
Front Panel Audio Header
(HD_AUDIO1, White)
ATX 12V Power Connector (ATX12V1)
32Mb SPI Flash
CPU Fan Connector (CPU_FAN1)
Chassis Fan Connector (CHA_FAN1)
Power LED Header (PLED1)

ASRock H61M-ITX Motherboard

I/O Panel
1

14

15
1
2
3
*4
5
6
7
8

13

** 9
10
11
12
13
14
15

10

11

12

USB 2.0 Ports (USB01)


D-Sub Port
USB 2.0 Ports (USB23)
LAN RJ-45 Port
Central / Bass (Orange)
Rear Speaker (Black)
Optical SPDIF Out Port
Line In (Light Blue)

Front Speaker (Lime)


Microphone (Pink)
USB 3.0 Ports (USB45)
eSATA2 Port
HDMI Port
DVI-D Port
PS/2 Keyboard Port (Purple)

* There are two LED next to the LAN port. Please refer to the table below for the LAN port LED
indications.

LAN Port LED Indications


Activity/Link LED
Status
Description

Status

Off
No Link
Blinking Data Activity
On
Link

Off
Orange
Green

ACT/LINK
LED

SPEED LED
Description

SPEED
LED

10Mbps connection
100Mbps connection
1Gbps connection
LAN Port

** If you use 2-channel speaker, please connect the speakers plug into Front Speaker Jack.
See the table below for connection details in accordance with the type of speaker you use.

TABLE for Audio Output Connection

2
4
6
8

V
V
V
V

-V
V
V

Central / Bass
(No. 5)
--V
V

Line In or
Side Speaker
(No. 8)
---V

English

Audio Output Channels Front Speaker Rear Speaker


(No. 9)
(No. 6)

To enable Multi-Streaming function, you need to connect a front panel audio cable to the front
panel audio header. After restarting your computer, you will find Mixer tool on your system.
Please select Mixer ToolBox
, click Enable playback multi-streaming, and click
ok. Choose 2CH, 4CH, 6CH, or 8CH and then you are allowed to select Realtek HDA
Primary output to use Rear Speaker, Central/Bass, and Front Speaker, or select Realtek
HDA Audio 2nd output to use front panel audio.

ASRock H61M-ITX Motherboard

1. Introduction
Thank you for purchasing ASRock H61M-ITX motherboard, a reliable motherboard
produced under ASRocks consistently stringent quality control. It delivers excellent
performance with robust design conforming to ASRocks commitment to quality and
endurance.
This Quick Installation Guide contains introduction of the motherboard and step-bystep installation guide. More detailed information of the motherboard can be found
in the user manual presented in the Support CD.
Because the motherboard specifications and the BIOS software might be
updated, the content of this manual will be subject to change without notice. In case any modifications of this manual occur, the updated version
will be available on ASRock website without further notice. You may find
the latest VGA cards and CPU support lists on ASRock website as well.
ASRock website http://www.asrock.com
If you require technical support related to this motherboard, please visit
our website for specific information about the model you are using.
www.asrock.com/support/index.asp

1.1 Package Contents


ASRock H61M-ITX Motherboard
(Mini-ITX Form Factor: 6.7-in x 6.7-in, 17.0 cm x 17.0 cm)
ASRock H61M-ITX Quick Installation Guide
ASRock H61M-ITX Support CD
2 x Serial ATA (SATA) Data Cables (Optional)
1 x 3.5mm Audio Cable (Optional)
1 x I/O Panel Shield
ASRock Reminds You...
To get better performance in Windows 7 / 7 64-bit / VistaTM / VistaTM 64bit, it is recommended to set the BIOS option in Storage Configuration to
AHCI mode. For the BIOS setup, please refer to the User Manual in our
support CD for details.

English
4

ASRock H61M-ITX Motherboard

1.2

Specifications

Platform

CPU

- Mini-ITX Form Factor: 6.7-in x 6.7-in, 17.0 cm x 17.0 cm


- All Solid Capacitor design (100% Japan-made high-quality
Conductive Polymer Capacitors)
- Supports 2nd Generation Intel CoreTM i7 / i5 / i3 in

Chipset

LGA1155 Package
- Supports Intel Turbo Boost 2.0 Technology
- Supports K-Series unlocked CPU
- Supports Hyper-Threading Technology (see CAUTION 1)
- Intel H61

Memory

Expansion Slot
Graphics

- Dual Channel DDR3 Memory Technology (see CAUTION 2)


- 2 x DDR3 DIMM slots
- Supports DDR3 1333/1066 non-ECC, un-buffered
memory
- Max. capacity of system memory: 16GB (see CAUTION 3)
- 1 x PCI Express 2.0 x16 slot (blue @ x16 mode)
- Supports Intel HD Graphics Built-in Visuals: Intel Quick
Sync Video, Intel InTruTM 3D, Intel Clear Video HD
Technology, Intel HD Graphics 2000/3000, Intel Advanced
Vector Extensions (AVX)
- Pixel Shader 4.1, DirectX 11 with Intel Ivy Bridge CPU,
DirectX 10.1 with Intel Sandy Bridge CPU

Audio
LAN

English

- Max. shared memory 1759MB (see CAUTION 4)


- Three VGA Output options: D-Sub, DVI-D and HDMI
(see CAUTION 5)
- Supports HDMI 1.4a Technology with max. resolution up to
1920x1200 @ 60Hz
- Supports DVI with max. resolution up to 1920x1200 @ 60Hz
- Supports D-Sub with max. resolution up to 2048x1536 @
75Hz
- Supports Auto Lip Sync, xvYCC and HBR (High Bit Rate
Audio) with HDMI (Compliant HDMI monitor is required)
(see CAUTION 6)
- Supports HDCP function with DVI and HDMI ports
- Supports Full HD 1080p Blu-ray (BD) / HD-DVD playback
with DVI and HDMI ports
- 7.1 CH HD Audio (Realtek ALC887 Audio Codec)
- Supports THX TruStudioTM
- PCIE x1 Gigabit LAN 10/100/1000 Mb/s
- Realtek RTL8111E
ASRock H61M-ITX Motherboard

Rear Panel I/O

USB 3.0
Connector

BIOS Feature

English

Support CD

Unique Feature

- Supports Wake-On-LAN
- Supports LAN Cable Detection
- Supports Energy Efficient Ethernet 802.3az
- Supports PXE
I/O Panel
- 1 x PS/2 Keyboard Port
- 1 x D-Sub Port
- 1 x DVI-D Port
- 1 x HDMI Port
- 1 x Optical SPDIF Out Port
- 4 x Ready-to-Use USB 2.0 Ports
- 1 x eSATA2 Connector
- 2 x Ready-to-Use USB 3.0 Ports
- 1 x RJ-45 LAN Port with LED (ACT/LINK LED and SPEED
LED)
- HD Audio Jack: Rear Speaker/Central/Bass/Line in/Front
Speaker/Microphone (see CAUTION 7)
- 2 x USB 3.0 ports by ASMedia ASM1042, support
USB 1.0/2.0/3.0 up to 5Gb/s
- 3 x SATA2 3.0 Gb/s connectors, support NCQ, AHCI and
Hot Plug functions
- 1 x CIR header
- 1 x Power LED header
- CPU/Chassis FAN connector
- 24 pin ATX power connector
- 4 pin 12V power connector
- Front panel audio connector
- 2 x USB 2.0 headers (support 4 USB 2.0 ports)
- 32Mb AMI BIOS
- AMI UEFI Legal BIOS with GUI support
- Supports Plug and Play
- ACPI 1.1 Compliance Wake Up Events
- Supports jumperfree
- SMBIOS 2.3.1 Support
- Drivers, Utilities, AntiVirus Software (Trial Version),
CyberLink MediaEspresso 6.5 Trial, ASRock Software Suite
(CyberLink DVD Suite - OEM and Trial)
- ASRock Extreme Tuning Utility (AXTU) (see CAUTION 8)
- ASRock Instant Boot
- ASRock Instant Flash (see CAUTION 9)
- ASRock APP Charger (see CAUTION 10)

ASRock H61M-ITX Motherboard

Hardware
Monitor

OS
Certifications

- ASRock SmartView (see CAUTION 11)


- ASRock XFast USB (see CAUTION 12)
- ASRock On/Off Play Technology (see CAUTION 13)
- Hybrid Booster:
- ASRock U-COP (see CAUTION 14)
- Boot Failure Guard (B.F.G.)
- Good Night LED
- CPU Temperature Sensing
- Chassis Temperature Sensing
- CPU/Chassis Fan Tachometer
- CPU/Chassis Quiet Fan (Allow Chassis Fan Speed
Auto-Adjust by CPU Temperature)
- CPU/Chassis Fan Multi-Speed Control
- Voltage Monitoring: +12V, +5V, +3.3V, CPU Vcore
- Microsoft Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit
/ XP / XP 64-bit compliant
- FCC, CE, WHQL
- ErP/EuP Ready (ErP/EuP ready power supply is required)
(see CAUTION 15)

* For detailed product information, please visit our website: http://www.asrock.com

English

WARNING
Please realize that there is a certain risk involved with overclocking, including
adjusting the setting in the BIOS, applying Untied Overclocking Technology, or
using the third-party overclocking tools. Overclocking may affect your system
stability, or even cause damage to the components and devices of your system.
It should be done at your own risk and expense. We are not responsible for possible
damage caused by overclocking.

ASRock H61M-ITX Motherboard

CAUTION!
1.
2.

3.

4.

5.

6.
7.

8.

About the setting of Hyper Threading Technology, please check page


39 of User Manual in the support CD.
This motherboard supports Dual Channel Memory Technology. Before
you implement Dual Channel Memory Technology, make sure to read the
installation guide of memory modules on page 14 for proper installation.
Due to the operating system limitation, the actual memory size may be
less than 4GB for the reservation for system usage under Windows 7 /
VistaTM / XP. For Windows OS with 64-bit CPU, there is no such limitation.
The maximum shared memory size is defined by the chipset vendor and
is subject to change. Please check Intel website for the latest information.
You can choose to use two of the four monitors only. D-Sub, DVI-D and
HDMI monitors cannot be enabled at the same time. Besides, with the
DVI-to-HDMI adapter, the DVI-D port can support the same features as
HDMIport.
xvYCC is only supported under Windows 7 64-bit / 7. HBR is supported
under Windows 7 64-bit / 7 / VistaTM 64-bit / VistaTM.
For microphone input, this motherboard supports both stereo and mono
modes. For audio output, this motherboard supports 2-channel, 4-channel, 6-channel, and 8-channel modes. Please check the table on page 3
for proper connection.
ASRock Extreme Tuning Utility (AXTU) is an all-in-one tool to fine-tune
different system functions in a user-friendly interface, which is including
Hardware Monitor, Fan Control, Overclocking, OC DNA and IES. In
Hardware Monitor, it shows the major readings of your system. In Fan
Control, it shows the fan speed and temperature for you to adjust. In
Overclocking, you are allowed to overclock CPU frequency for optimal
system performance. In OC DNA, you can save your OC settings as a
profile and share with your friends. Your friends then can load the OC
profile to their own system to get the same OC settings. In IES (Intelligent
Energy Saver), the voltage regulator can reduce the number of output
phases to improve efficiency when the CPU cores are idle without
sacrificing computing performance. Please visit our website for the
operation procedures of ASRock Extreme Tuning Utility (AXTU).
ASRock website: http://www.asrock.com

English
8

ASRock H61M-ITX Motherboard

9.

ASRock Instant Flash is a BIOS flash utility embedded in Flash ROM.


This convenient BIOS update tool allows you to update system BIOS
without entering operating systems first like MS-DOS or Windows. With
this utility, you can press <F6> key during the POST or press <F2> key to
BIOS setup menu to access ASRock Instant Flash. Just launch this tool
and save the new BIOS file to your USB flash drive, floppy disk or hard
drive, then you can update your BIOS only in a few clicks without preparing an additional floppy diskette or other complicated flash utility. Please
be noted that the USB flash drive or hard drive must use FAT32/16/12 file
system.
10. If you desire a faster, less restricted way of charging your Apple devices,
such as iPhone/iPod/iPad Touch, ASRock has prepared a wonderful
solution for you - ASRock APP Charger. Simply installing the APP Charger driver, it makes your iPhone charged much quickly from your computer and up to 40% faster than before. ASRock APP Charger allows you
to quickly charge many Apple devices simultaneously and even supports
continuous charging when your PC enters into Standby mode (S1), Suspend to RAM (S3), hibernation mode (S4) or power off (S5). With APP
Charger driver installed, you can easily enjoy the marvelous charging
experience than ever.
ASRock website: http://www.asrock.com/Feature/AppCharger/index.asp
11. SmartView, a new function of internet browser, is the smart start page for
IE that combines your most visited web sites, your history, your Facebook
friends and your real-time newsfeed into an enhanced view for a more
personal Internet experience. ASRock motherboards are exclusively
equipped with the SmartView utility that helps you keep in touch with
friends on-the-go. To use SmartView feature, please make sure your
OS version is Windows 7 / 7 64 bit / VistaTM / VistaTM 64 bit, and your

ASRock H61M-ITX Motherboard

English

browser version is IE8. ASRock website: http://www.asrock.com/Feature/


SmartView/index.asp
12. ASRock XFast USB can boost USB storage device performance. The
performance may depend on the property of the device.
13. ASRock On/Off Play Technology allows users to enjoy the great audio experience from the portable audio devices, such like MP3 player or mobile
phone to your PC, even when the PC is turned off (or in ACPI S5 mode)!
This motherboard also provides a free 3.5mm audio cable (optional) that
ensures users the most convenient computing environment.
14. While CPU overheat is detected, the system will automatically shutdown.
Before you resume the system, please check if the CPU fan on the
motherboard functions properly and unplug the power cord, then plug it
back again. To improve heat dissipation, remember to spray thermal
grease between the CPU and the heatsink when you install the PC system.

15. EuP, stands for Energy Using Product, was a provision regulated by European Union to define the power consumption for the completed system.
According to EuP, the total AC power of the completed system shall be
under 1.00W in off mode condition. To meet EuP standard, an EuP ready
motherboard and an EuP ready power supply are required. According to
Intels suggestion, the EuP ready power supply must meet the standard
of 5v standby power efficiency is higher than 50% under 100 mA current
consumption. For EuP ready power supply selection, we recommend you
checking with the power supply manufacturer for more details.

English
10

ASRock H61M-ITX Motherboard

2. Installation
Pre-installation Precautions
Take note of the following precautions before you install motherboard components or change any motherboard settings.
1. Unplug the power cord from the wall socket before touching any
component. Failure to do so may cause severe damage to the
motherboard, peripherals, and/or components.
2. To avoid damaging the motherboard components due to static
electricity, NEVER place your motherboard directly on the carpet or the like. Also remember to use a grounded wrist strap or
touch a safety grounded object before you handle components.
3. Hold components by the edges and do not touch the ICs.
4. Whenever you uninstall any component, place it on a grounded
antstatic pad or in the bag that comes with the component.
5. When placing screws into the screw holes to secure the motherboard to the chassis, please do not over-tighten the screws!
Doing so may damage the motherboard.

2.1 CPU Installation


For the installation of Intel 1155-Pin CPU,
please follow the steps below.

Load Plate

Load Lever

Contact Array

Socket Body

1155-Pin Socket Overview

ASRock H61M-ITX Motherboard

English

Before you insert the 1155-Pin CPU into the socket, please check if the
CPU surface is unclean or if there is any bent pin on the socket. Do not
force to insert the CPU into the socket if above situation is found. Otherwise, the CPU will be seriously damaged.

11

Step 1.

Open the socket:


Step 1-1. Disengaging the lever by depressing
down and out on the hook to clear
retention tab.

Step 1-2. Rotate the load lever to fully open position at approximately 135 degrees.
Step 1-3. Rotate the load plate to fully open position at approximately 100 degrees.
Step 2.

Remove PnP Cap (Pick and Place Cap).

1. It is recommended to use the cap tab to handle and avoid kicking


off the PnP cap.
2. This cap must be placed if returning the motherboard for after
service.

Step 3.

black line

Insert the 1155-Pin CPU:


Step 3-1. Hold the CPU by the edges where
are marked with black lines.

Step 3-2. Orient the CPU with IHS (Integrated


Heat Sink) up. Locate Pin1 and the
two orientation key notches.
orientation key notch

alignment key

Pin1

English

Pin1
alignment key
orientation key notch

1155-Pin Socket

1155-Pin CPU

For proper inserting, please ensure to match the two orientation key
notches of the CPU with the two alignment keys of the socket.

12

ASRock H61M-ITX Motherboard

Step 3-3. Carefully place the CPU into the


socket by using a purely vertical motion.
Step 3-4. Verify that the CPU is within the socket and properly mated to the orient
keys.
Step 4.

2.2

Close the socket:


Step 4-1. Rotate the load plate onto the IHS.
Step 4-2. While pressing down lightly on load
plate, engage the load lever.

Installation of CPU Fan and Heatsink

For proper installation, please kindly refer to the instruction manuals of your CPU
fan and heatsink.
Below is an example to illustrate the installation of the heatsink for 1155-Pin CPU.
Step 1. Apply thermal interface material onto center of
IHS on the socket surface.
Apply Thermal
Interface Material

Step 2.

Step 3.
Step 4.

Place the heatsink onto the socket. Ensure


fan cables are oriented on side closest to the
CPU fan connector on the motherboard (CPU_
FAN1, see page 2, No. 17).
Align fasteners with the motherboard throughholes.
Rotate the fastener clockwise, then press
down on fastener caps with thumb to install
and lock. Repeat with remaining fasteners.

Fan cables on side


closest to MB header

Fastener slots
pointing straight out

Press Down
(4 Places)

If you press down the fasteners without rotating them clockwise, the
heatsink cannot be secured on the motherboard.

Connect fan header with the CPU fan connector on the motherboard.
Secure excess cable with tie-wrap to ensure cable does not interfere with
fan operation or contact other components.

ASRock H61M-ITX Motherboard

English

Step 5.
Step 6.

13

2.3 Installation of Memory Modules (DIMM)


This motherboard provides two 240-pin DDR3 (Double Data Rate 3) DIMM slots,
and supports Dual Channel Memory Technology. For dual channel configuration,
you always need to install two identical (the same brand, speed, size and chiptype) memory modules in the DDR3 DIMM slots to activate Dual Channel Memory
Technology. Otherwise, it will operate at single channel mode.
1.

2.

3.

It is not allowed to install a DDR or DDR2 memory module into


DDR3 slot;otherwise, this motherboard and DIMM may be
damaged.
If you install only one memory module or two non-identical
memory modules, it is unable to activate the Dual Channel
Memory Technology.
Some DDR3 1GB double-sided DIMMs with 16 chips may not
work on this motherboard. It is not recommended to install them
on this motherboard.

Installing a DIMM
Please make sure to disconnect power supply before adding or
removing DIMMs or the system components.

Step 1.
Step 2.

Unlock a DIMM slot by pressing the retaining clips outward.


Align a DIMM on the slot such that the notch on the DIMM matches the
break on the slot.

notch
break

notch

English

break

The DIMM only fits in one correct orientation. It will cause permanent
damage to the motherboard and the DIMM if you force the DIMM into the slot
at incorrect orientation.

Step 3.

14

Firmly insert the DIMM into the slot until the retaining clips at both ends
fully snap back in place and the DIMM is properly seated.
ASRock H61M-ITX Motherboard

2.4 Expansion Slot (PCI Express Slot)


There is 1 PCI Express slot on this motherboard.
PCIE slots:
PCIE1 (PCIE x16 slot; Blue) is used for PCI Express x16 lane width
graphics cards.

Installing an expansion card

Step 2.
Step 3.
Step 4.
Step 5.
Step 6.

Before installing the expansion card, please make sure that the power
supply is switched off or the power cord is unplugged. Please read the
documentation of the expansion card and make necessary hardware
settings for the card before you start the installation.
Remove the system unit cover (if your motherboard is already installed
in a chassis).
Remove the bracket facing the slot that you intend to use. Keep the
screws for later use.
Align the card connector with the slot and press firmly until the card is
completely seated on the slot.
Fasten the card to the chassis with screws.
Replace the system cover.

English

Step 1.

ASRock H61M-ITX Motherboard

15

2.5 Dual Monitor and Surround Display Features


Dual Monitor Feature
This motherboard supports dual monitor feature. With the internal VGA output support (DVI-D, D-Sub and HDMI), you can easily enjoy the benefits of dual monitor
feature without installing any add-on VGA card to this motherboard. This motherboard also provides independent display controllers for DVI-D, D-Sub and HDMI to
support dual VGA output so that DVI-D, D-sub and HDMI can drive same or different
display contents.
To enable dual monitor feature, please follow the below steps:
1. Connect DVI-D monitor cable to DVI-D port on the I/O panel, connect D-Sub
monitor cable to D-Sub port on the I/O panel, or connect HDMI monitor
cable to HDMI port on the I/O panel.
D-Sub port

DVI-D port

HDMI port

2. If you have installed onboard VGA driver from our support CD to your system
already, you can freely enjoy the benefits of dual monitor function after your
system boots. If you havent installed onboard VGA driver yet, please install
onboard VGA driver from our support CD to your system and restart your
computer.
D-Sub, DVI-D and HDMI monitors cannot be enabled at the same time.
You can only choose the combination: DVI-D + HDMI, DVI-D + D-Sub,
or HDMI + D-Sub.

English
16

ASRock H61M-ITX Motherboard

Surround Display Feature


This motherboard supports surround display upgrade. With the internal VGA output
support (DVI-D, D-Sub and HDMI) and external add-on PCI Express VGA cards,
you can easily enjoy the benefits of surround display feature.
Please refer to the following steps to set up a surround display environment:
1. Install the PCI Express VGA card on PCIE1 slot. Please refer to page 15 for
proper expansion card installation procedures for details.
2. Connect DVI-D monitor cable to DVI-D port on the I/O panel, connect D-Sub
monitor cable to D-Sub port on the I/O panel, or connect HDMI monitor
cable to HDMI port on the I/O panel. Then connect other monitor cables to the
corresponding connectors of the add-on PCI Express VGA card on PCIE1 slot.
3. Boot your system. Press <F2> or <Del> to enter UEFI setup. Enter Share
Memory option to adjust the memory capability to [32MB], [64MB], [128MB],
[256MB] or [512MB] to enable the function of D-sub. Please make sure that
the value you select is less than the total capability of the system memory. If you
do not adjust the UEFI setup, the default value of Share Memory, [Auto], will
disable D-Sub function when the add-on VGA card is inserted to this
motherboard.
4. Install the onboard VGA driver and the add-on PCI Express VGA card driver to
your system. If you have installed the drivers already, there is no need to install
them again.
5. Set up a multi-monitor display.
For Windows XP / XP 64-bit OS:

ASRock H61M-ITX Motherboard

English

Right click the desktop, choose Properties, and select the Settings tab
so that you can adjust the parameters of the multi-monitor according to
the steps below.
A. Click the Identify button to display a large number on each monitor.
B. Right-click the display icon in the Display Properties dialog that you
wish to be your primary monitor, and then select Primary. When
you use multiple monitors with your card, one monitor will always be
Primary, and all additional monitors will be designated as Secondary.
C. Select the display icon identified by the number 2.
D. Click Extend my Windows desktop onto this monitor.
E. Right-click the display icon and select Attached, if necessary.
F. Set the Screen Resolution and Color Quality as appropriate for the
second monitor. Click Apply or OK to apply these new values.
G. Repeat steps C through E for the diaplay icon identified by the number
one, two, three and four.

17

For Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit OS:


Right click the desktop, choose Personalize, and select the Display
Settings tab so that you can adjust the parameters of the multi-monitor
according to the steps below.
A. Click the number 2 icon.
B. Click the items This is my main monitor and Extend the desktop onto
this monitor.
C. Click OK to save your change.
D. Repeat steps A through C for the display icon identified by the number
three and four.
6. Use Surround Display. Click and drag the display icons to positions representing
the physical setup of your monitors that you would like to use. The placement
of display icons determines how you move items from one monitor to another.

HDCP Function
HDCP function is supported on this motherboard. To use HDCP
function with this motherboard, you need to adopt the monitor
that supports HDCP function as well. Therefore, you can enjoy
the superior display quality with high-definition HDCP
encryption contents. Please refer to below instruction for more
details about HDCP function.
What is HDCP?
HDCP stands for High-Bandwidth Digital Content Protection,
a specification developed by Intel for protecting digital
entertainment content that uses the DVI interface. HDCP is a
copy protection scheme to eliminate the possibility of
intercepting digital data midstream between the video source,
or transmitter - such as a computer, DVD player or set-top box and the digital display, or receiver - such as a monitor, television
or projector. In other words, HDCP specification is designed to
protect the integrity of content as it is being transmitted.

English

Products compatible with the HDCP scheme such as DVD


players, satellite and cable HDTV set-top-boxes, as well as few
entertainment PCs requires a secure connection to a compliant
display. Due to the increase in manufacturers employing HDCP
in their equipment, it is highly recommended that the HDTV or
LCD monitor you purchase is compatible.

18

ASRock H61M-ITX Motherboard

2.6 ASRock Smart Remote Installation Guide


ASRock Smart Remote is only used for ASRock motherboard with CIR header.
Please refer to below procedures for the quick installation and usage of ASRock
Smart Remote.
Step1.

Find the CIR header located next


to the USB 2.0 header on ASRock
motherboard.

USB 2.0 header (9-pin, blue)


CIR header (4-pin, white)

Step2.

Connect the front USB cable to the


USB 2.0 header (as below, pin 1-5)
and the CIR header. Please make
sure the wire assignments and the
pin assignments are matched
correctly.

USB_PWR
PP+
GND

2 3

DUMMY

4 5

GND
IRTX
IRRX
ATX+5VSB

Step3.

Install Multi-Angle CIR Receiver to


the front USB port. If Multi-Angle
CIR Receiver cannot successfully
receive the infrared signals from
MCE Remote Controller, please try
to install it to the other front USB
port.

3 CIR sensors in different angles

2.

3.

Only one of the front USB port can support CIR function. When
the CIR function is enabled, the other port will remain USB
function.
Multi-Angle CIR Receiver is used for front USB only. Please do
not use the rear USB bracket to connect it on the rear panel.
Multi-Angle CIR Receiver can receive the multi-direction infrared
signals (top, down and front), which is compatible with most of
the chassis on the market.
The Multi-Angle CIR Receiver does not support Hot-Plug

English

1.

function. Please install it before you boot the system.


* ASRock Smart Remote is only supported by some of ASRock motherboards. Please refer to
ASRock website for the motherboard support list: http://www.asrock.com

ASRock H61M-ITX Motherboard

19

2.7 Jumpers Setup


The illustration shows how jumpers are
setup. When the jumper cap is placed on
pins, the jumper is Short. If no jumper cap
is placed on pins, the jumper is Open. The
illustration shows a 3-pin jumper whose
pin1 and pin2 are Short when jumper cap
is placed on these 2 pins.
Jumper
Clear CMOS Jumper

Setting

Description

(CLRCMOS1)
(see p.2, No. 5)

Default

Clear CMOS

Note: CLRCMOS1 allows you to clear the data in CMOS. To clear and reset the
system parameters to default setup, please turn off the computer and unplug
the power cord from the power supply. After waiting for 15 seconds, use a
jumper cap to short pin2 and pin3 on CLRCMOS1 for 5 seconds. However,
please do not clear the CMOS right after you update the BIOS. If you need
to clear the CMOS when you just finish updating the BIOS, you must boot up
the system first, and then shut it down before you do the clear-CMOS action.
Please be noted that the password, date, time and user default profile will be
cleared only if the CMOS battery is removed.

2.8 Onboard Headers and Connectors


Onboard headers and connectors are NOT jumpers. Do NOT place
jumper caps over these headers and connectors. Placing jumper caps
over the headers and connectors will cause permanent damage of the
motherboard!

Serial ATAII Connectors


(SATA_0 (PORT 0):

SATA_0 (PORT 0) SATA_2 (PORT 4)

see p.2, No. 3)

English

(SATA_1 (PORT 1):


see p.2, No. 2)
(SATA_2 (PORT 4):

SATA_1 (PORT 1)

These three Serial ATAII


(SATAII) connectors support
SATA data cables for internal
storage devices. The current
SATAII interface allows up to
3.0 Gb/s data transfer rate.

see p.2, No. 4)

20

ASRock H61M-ITX Motherboard

Serial ATA (SATA)


Data Cable

Either end of the SATA data


cable can be connected to the
SATA / SATAII hard disk or the
SATAII connector on this
motherboard.

(Optional)

3.5mm Audio Cable

Either end of the 3.5mm audio


cable can be connected to the
portable audio devices, such
as MP3 player and mobile
phone or the Line-in port of
your PC.

(Optional)

USB 2.0 Headers

Besides four default USB 2.0

(9-pin USB6_7)

ports on the I/O panel, there


are two USB 2.0 headers on
this motherboard. Each
USB 2.0 header can support
two USB 2.0 ports.

(see p.2 No. 10)

USB_PWR
P-9
P+9
GND
DUMMY

(9-pin USB8_9)
(see p.2 No. 8)
1

GND
P+8
P-8
USB_PWR

(4-pin CIR1)

1
GND
IRTX
IRRX
ATX+5VSB

(see p.2 No. 9)

Front Panel Audio Header

GND
PRESENCE#
MIC_RET
OUT_RET

(9-pin HD_AUDIO1)
(see p.2 No. 14)
1

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

This header can be used to


connect the remote
controller receiver.
This is an interface for front
panel audio cable that allows
convenient connection and
control of audio devices.

ASRock H61M-ITX Motherboard

English

Consumer Infrared Module Header

21

1. High Definition Audio supports Jack Sensing, but the panel wire on
the chassis must support HDA to function correctly. Please follow the
instruction in our manual and chassis manual to install your system.
2. If you use AC97 audio panel, please install it to the front panel audio
header as below:
A. Connect Mic_IN (MIC) to MIC2_L.
B. Connect Audio_R (RIN) to OUT2_R and Audio_L (LIN) to OUT2_L.
C. Connect Ground (GND) to Ground (GND).
D. MIC_RET and OUT_RET are for HD audio panel only. You dont
need to connect them for AC97 audio panel.
E. To activate the front mic.
For Windows XP / XP 64-bit OS:
Select Mixer. Select Recorder. Then click FrontMic.
For Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit OS:
Go to the "FrontMic" Tab in the Realtek Control panel. Adjust
Recording Volume.

System Panel Header


(9-pin PANEL1)
(see p.2 No. 1)

This header accommodates


several system front panel
functions.

Connect the power switch, reset switch and system status indicator on the
chassis to this header according to the pin assignments below. Note the
positive and negative pins before connecting the cables.

English

PWRBTN (Power Switch):


Connect to the power switch on the chassis front panel. You may configure
the way to turn off your system using the power switch.
RESET (Reset Switch):
Connect to the reset switch on the chassis front panel. Press the reset
switch to restart the computer if the computer freezes and fails to perform a
normal restart.
PLED (System Power LED):
Connect to the power status indicator on the chassis front panel. The LED
is on when the system is operating. The LED keeps blinking when the system is in S1 sleep state. The LED is off when the system is in S3/S4 sleep
state or powered off (S5).
HDLED (Hard Drive Activity LED):
Connect to the hard drive activity LED on the chassis front panel. The LED
is on when the hard drive is reading or writing data.
The front panel design may differ by chassis. A front panel module mainly
consists of power switch, reset switch, power LED, hard drive activity LED,
speaker and etc. When connecting your chassis front panel module to this
header, make sure the wire assignments and the pin assign-ments are
matched correctly.

22

ASRock H61M-ITX Motherboard

Power LED Header

Please connect the chassis


power LED to this header to

(3-pin PLED1)

PLEDPLED+
PLED+

(see p.2 No. 19)

indicate system power status.


The LED is on when the system
is operating. The LED keeps
blinking in S1 state. The LED is
off in S3/S4 state or S5 state
(power off).

Chassis Fan Connector

Please connect the fan cables

(3-pin CHA_FAN1)

to the fan connectors and


match the black wire to the
ground pin.

(see p.2 No. 18)

CPU Fan Connectors

4 3 2 1

(4-pin CPU_FAN1)
GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

(see p.2 No. 17)

Please connect the CPU fan


cable to the connector and
match the black wire to the
ground pin.

Though this motherboard provides 4-Pin CPU fan (Quiet Fan) support, the 3-Pin
CPU fan still can work successfully even without the fan speed control function.
If you plan to connect the 3-Pin CPU fan to the CPU fan connector on this
motherboard, please connect it to Pin 1-3.
Pin 1-3 Connected
3-Pin Fan Installation

ATX Power Connector

24

13

12

(24-pin ATXPWR1)
(see p.2 No. 7)

Please connect an ATX power


supply to this connector.

Though this motherboard provides 24-pin ATX power connector, it can still work if
you adopt a traditional 20-pin ATX power supply. To use the 20-pin ATX power
supply, please plug your power supply along with Pin 1 and Pin 13.
24

13

12

ATX 12V Power Connector


(4-pin ATX12V1)

English

20-Pin ATX Power Supply Installation

Please connect an ATX 12V


power supply to this connector.

(see p.2 No. 15)

ASRock H61M-ITX Motherboard

23

2.9

Driver Installation Guide

To install the drivers to your system, please insert the support CD to your optical
drive first. Then, the drivers compatible to your system can be auto-detected and
listed on the support CD driver page. Please follow the order from up to bottom side
to install those required drivers. Therefore, the drivers you install can work properly.

2.10

Installing Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit / XP


/ XP 64-bit Without RAID Functions

If you want to install Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit / XP / XP 64bit OS on your SATA / SATAII HDDs without RAID functions, please follow below
procedures according to the OS you install.

2.10.1 Installing Windows XP / XP 64-bit Without RAID


Functions
If you want to install Windows XP / XP 64-bit OS on your SATA / SATAII HDDs
without RAID functions, please follow below steps.
Using SATA / SATAII HDDs without NCQ function
STEP 1: Set up UEFI.
A. Enter UEFI SETUP UTILITY
Advanced screen
SATA Configuration.
B. Set the option SATA Mode to [IDE].
STEP 2: Install Windows XP / XP 64-bit OS on your system.

2.10.2 Installing Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit


Without RAID Functions
If you want to install Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit OS on your SATA
/ SATAII HDDs without RAID functions, please follow below steps.
Using SATA / SATAII HDDs with NCQ function

English

STEP 1: Set Up UEFI.


A. Enter UEFI SETUP UTILITY
Advanced screen
SATA Configuration.
B. Set the option SATA Mode to [AHCI].
STEP 2: Install Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit OS on your
system.

24
ASRock H61M-ITX Motherboard

Using SATA / SATAII HDDs without NCQ function


STEP 1: Set up UEFI.
A. Enter UEFI SETUP UTILITY
Advanced screen
SATA Configuration.
B. Set the option SATA Mode to [IDE].
STEP 2: Install Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit OS on your
system.

3. BIOS Information
The Flash Memory on the motherboard stores BIOS Setup Utility. When you start up
the computer, please press <F2> or <Del> during the Power-On-Self-Test (POST)
to enter BIOS Setup utility; otherwise, POST continues with its test routines. If you
wish to enter BIOS Setup after POST, please restart the system by pressing <Ctl>
+ <Alt> + <Delete>, or pressing the reset button on the system chassis. The BIOS
Setup program is designed to be user-friendly. It is a menu-driven program, which
allows you to scroll through its various sub-menus and to select among the predetermined choices. For the detailed information about BIOS Setup, please refer to the
User Manual (PDF file) contained in the Support CD.

4. Software Support CD information

English

This motherboard supports various Microsoft Windows operating systems: 7 / 7


64-bit / VistaTM / VistaTM 64-bit / XP / XP 64-bit. The Support CD that came with the
motherboard contains necessary drivers and useful utilities that will enhance motherboard features. To begin using the Support CD, insert the CD into your CD-ROM
drive. It will display the Main Menu automatically if AUTORUN is enabled in your
computer. If the Main Menu does not appear automatically, locate and double-click
on the file ASSETUP.EXE from the BIN folder in the Support CD to display the
menus.

ASRock H61M-ITX Motherboard

25

1. Einfhrung
Wir danken Ihnen fr den Kauf des ASRock H61M-ITX Motherboard, ein zuverlssiges Produkt, welches unter den stndigen, strengen Qualittskontrollen von
ASRock gefertigt wurde. Es bietet Ihnen exzellente Leistung und robustes Design,
gem der Verpflichtung von ASRock zu Qualitt und Halbarkeit. Diese Schnellinstallationsanleitung fhrt in das Motherboard und die schrittweise Installation
ein. Details ber das Motherboard finden Sie in der Bedienungsanleitung auf der
Support-CD.
Da sich Motherboard-Spezifikationen und BIOS-Software verndern
knnen, kann der Inhalt dieses Handbuches ebenfalls jederzeit gendert
werden. Fr den Fall, dass sich nderungen an diesem Handbuch
ergeben, wird eine neue Version auf der ASRock-Website, ohne weitere
Ankndigung, verfgbar sein. Die neuesten Grafikkarten und untersttzten
CPUs sind auch auf der ASRock-Website aufgelistet.
ASRock-Website: http://www.asrock.com
Wenn Sie technische Untersttzung zu Ihrem Motherboard oder spezifische
Informationen zu Ihrem Modell bentigen, besuchen Sie bitte unsere
Webseite:
www.asrock.com/support/index.asp

1.1 Kartoninhalt
ASRock H61M-ITX Motherboard
(Mini-ITX-Formfaktor: 17.0 cm x 17.0 cm; 6.7 Zoll x 6.7 Zoll)
ASRock H61M-ITX Schnellinstallationsanleitung
ASRock H61M-ITX Support-CD
Zwei Serial ATA (SATA) -Datenkabel (optional)
Ein Audiokabel (3,5 mm, Klinke) (optional)
Ein I/O Shield
ASRock erinnert...

Deutsch

Zur besseren Leistung unter Windows 7 / 7, 64 Bit / VistaTM / VistaTM


64 Bit empfehlen wir, die Speicherkonfiguration im BIOS auf den AHCIModus einzustellen. Hinweise zu den BIOS-Einstellungen finden Sie in
der Bedienungsanleitung auf der mitgelieferten CD.

26

ASRock H61M-ITX Motherboard

Spezifikationen

Plattform

CPU

Chipsatz
Speicher

Erweiterungssteckpltze
Onboard-VGA

- Mini-ITX-Formfaktor: 17.0 cm x 17.0 cm; 6.7 Zoll x 6.7 Zoll


- Alle Feste Kondensatordesign (100% in Japan gefertigte,
erstklassige leitfhige Polymer-Kondensatoren)
- Untersttzt Intel CoreTM (2te Generation) i7 / i5 / i3 im
LGA1155-Paket
- Untersttzt Intel Turbo Boost 2.0-Technologie
- Untersttzt freigegebene CPU der K-Serie
- Untersttzt Hyper-Threading-Technologie
(siehe VORSICHT 1)
- Intel H61
- Untersttzung von Dual-Kanal-Speichertechnologie
(siehe VORSICHT 2)
- 2 x Steckpltze fr DDR3
- Untersttzt DDR3 1333/1066 non-ECC, ungepufferter
Speicher
- Max. Kapazitt des Systemspeichers: 16GB
(siehe VORSICHT 3)
- 1 x PCI Express 2.0 x16-Steckplatz (blau fr x16-Modus)
- Untersttzt hochauflsende integrierte Intel-Grafiklsungen:
Intel Quick-Sync-Video, Intel InTruTM 3D, Intel ClearVideo-Technik (HD), Intel HD Graphics 2000/3000, Intel
Advanced Vector Extensions (AVX)
- Pixel Shader 4.1, DirectX 11 mit Intel Ivy Bridge-Prozessor,
DirectX 10.1 mit Intel Sandy Bridge-Prozessor
- Maximal gemeinsam genutzter Speicher 1759MB
(siehe VORSICHT 4)
- Drei VGA-Ausgangsoptionen: D-Sub, DVI-D sowie HDMI
(siehe VORSICHT 5)
- Untersttzt HDMI 1.4a mit einer maximalen Auflsung von
1920 x 1200 bei 60 Hz
- Untersttzt DVI mit einer maximalen Auflsung von
1920 x 1200 bei 60 Hz
- Untersttzt D-Sub mit einer maximalen Auflsung von
2048 x 1536 bei 75 Hz
- Untersttzt Auto Lip Sync, xvYCC und HBR (High Bit
Rate-Audio) mit HDMI (kompatibler HDMI-Bildschirm
erforderlich) (siehe VORSICHT 6)
- Untersttzt HDCP-Funktion mit DVI- und HDMI-Ports
ASRock H61M-ITX Motherboard

Deutsch

1.2

27

Audio
LAN

E/A-Anschlsse
an der
Rckseite

USB3.0
Anschlsse

Deutsch

BIOS

28

- Unterstutzt 1080p Blu-ray (BD) / HD-DVD-Wiedergabe mit


DVI- und HDMI-Ports
- 7.1 CH HD Audio (Realtek ALC887 Audio Codec)
- Untersttzt THX TruStudioTM
- PCIE x1 Gigabit LAN 10/100/1000 Mb/s
- Realtek RTL8111E
- Untersttzt Wake-On-LAN
- Untersttzt LAN-Kabelerkennung
- Untersttzt energieeffizientes Ethernet 802.3az
- Untersttzt PXE
I/O Panel
- 1 x PS/2-Tastaturanschluss
- 1 x D-Sub port
- 1 x DVI-D port
- 1 x HDMI port
- 1 x optischer SPDIF-Ausgang
- 4 x Standard-USB 2.0-Anschlsse
- 1 x eSATA2-Anschluss
- 2 x Standard-USB 3.0-Anschlsse
- 1 x RJ-45 LAN Port mit LED (ACT/LINK LED und SPEED
LED)
- HD Audiobuchse: Lautsprecher hinten / Mitte/Bass /
Audioeingang / Lautsprecher vorne / Mikrofon
(siehe VORSICHT 7)
- 2 x USB 3.0-Ports an der Rckseite durch ASMedia
ASM1042, untersttzt USB 1.0/2.0/3.0 mit bis zu 5 Gb/s
- 3 x SATA2 3,0 GB/s-Anschlsse, untersttzen NCQ-, AHCIund Hot Plug (Hot-Plugging)- Funktionen
- 1 x Consumer Infrared-Modul-Header
- 1 x Betriebs-LED-Header
- CPU/Gehuselfter-Anschluss
- 24-pin ATX-Netz-Header
- 4-pin anschluss fr 12V-ATX-Netzteil
- Anschluss fr Audio auf der Gehusevorderseite
- 2 x USB 2.0-Anschlsse (Untersttzung 4 zustzlicher
USB 2.0-Anschlsse)
- 32Mb AMI BIOS
- AMIs Legal BIOS UEFI mit GUI-Untersttzung
- Untersttzung fr Plug and Play
- ACPI 1.1-Weckfunktionen
- JumperFree-bertaktungstechnologie
- SMBIOS 2.3.1
ASRock H61M-ITX Motherboard

Support-CD

Einzigartige
Eigenschaft

Hardware Monitor

Betriebssysteme
Zertifizierungen

- Treiber, Dienstprogramme, Anti-Virus-Software


(Testversion), CyberLink MediaEspresso 6.5-Testversion,
ASRock-Software-Suite (CyberLink DVD Suite - OEM- und
Testversion)
- ASRock Extreme Tuning Utility (AXTU) (siehe VORSICHT 8)
- ASRock Sofortstart
- ASRock Instant Flash (siehe VORSICHT 9)
- ASRock APP Charger (siehe VORSICHT 10)
- ASRock SmartView (siehe VORSICHT 11)
- ASRock XFast USB (siehe VORSICHT 12)
- ASRock ein/aus-Wiedergabetechnologie
(siehe VORSICHT 13)
- Hybrid Booster:
- ASRock U-COP (siehe VORSICHT 14)
- Boot Failure Guard (B.F.G. Systemstartfehlerschutz)
- Gute Nacht-LED
- berwachung der CPU-Temperatur
- Motherboardtemperaturerkennung
- Drehzahlmessung fr CPU/Gehuselfter
- Geruscharmer CPU-/Gehuselfter (ermglicht die au
tomatische Anpassung der Gehuselftergeschwindigkeit
durch CPU- oder Temperatur)
- Mehrstufige Geschwindigkeitsteuerung fr CPU-/
Gehuselfter
- Spannungsberwachung: +12V, +5V, +3.3V, Vcore
- Untersttzt Microsoft Windows 7 / 7 64-Bit / VistaTM /
VistaTM 64-Bit / XP / XP 64-Bit
- FCC, CE, WHQL
- Gem kodesign-Richtlinie (ErP/EuP) (Stromversorgung
gem kodesign-Richtlinie (ErP/EuP) erforderlich)
(siehe VORSICHT 15)

* Fr die ausfhrliche Produktinformation, besuchen Sie bitte unsere Website:


http://www.asrock.com

ASRock H61M-ITX Motherboard

Deutsch

WARNUNG
Beachten Sie bitte, dass Overclocking, einschlielich der Einstellung im BIOS,
Anwenden der Untied Overclocking-Technologie oder Verwenden von OverclockingWerkzeugen von Dritten, mit einem gewissen Risiko behaftet ist. Overclocking kann
sich nachteilig auf die Stabilitt Ihres Systems auswirken oder sogar Komponenten
und Gerte Ihres Systems beschdigen. Es geschieht dann auf eigene Gefahr und
auf Ihre Kosten. Wir bernehmen keine Verantwortung fr mgliche Schden, die
aufgrund von Overclocking verursacht wurden.

29

VORSICHT!
1.

2.

3.

4.
5.

6.
7.

8.

Die Einstellung der Hyper-Threading Technology, finden Sie auf Seite


39 des auf der Support-CD enthaltenen Benutzerhandbuches beschrieben.
Dieses Motherboard untersttzt Dual-Kanal-Speichertechnologie. Vor
Implementierung der Dual-Kanal-Speichertechnologie mssen Sie die
Installationsanleitung fr die Speichermodule auf Seite 14 zwecks
richtiger Installation gelesen haben.
Durch Betriebssystem-Einschrnkungen kann die tatschliche Speichergre weniger als 4 GB betragen, da unter Windows 7 / Vista / XP
etwas Speicher zur Nutzung durch das System reserviert wird. Unter
Windows OS mit 64-Bit-CPU besteht diese Einschrnkung nicht.
Die Maximalspeichergre ist von den Chipshndler definiert und umgetauscht. Bitte berprfen Sie Intel website fr die neuliche Information.
Sie knnen nur die Nutzung von zwei von drei Bildschirmen auswhlen.
Die D-Sub-, DVI-D- und HDMI-Bildschirme knnen nicht gleichzeitig
aktiviert werden. Zudem kann der DVI-D-Port mit DVI-zu-HDMI-Adapter
dieselben Funktionen wie der HDMI-Port untersttzen.
xvYCC werden nur unter Windows 7 64-Bit / 7 untersttzt. HBR wird

Deutsch

unter Windows 7 64 Bit / 7 / VistaTM 64 Bit / VistaTM untersttzt.


Der Mikrofoneingang dieses Motherboards untersttzt Stereo- und MonoModi. Der Audioausgang dieses Motherboards untersttzt 2-Kanal-,
4-Kanal-, 6-Kanal- und 8-Kanal-Modi. Stellen Sie die richtige Verbindung
anhand der Tabelle auf Seite 3 her.
ASRock Extreme Tuning Utility (AXTU) ist ein Alles-in-einemWerkzeug zur Feineinstellung verschiedener Systemfunktionen an
einer benutzerfreundlichen Schnittstelle; diese beinhaltet Hardwareberwachung, Lftersteuerung, bertaktung, OC DNA und IES. ber die
Hardware-berwachung knnen Sie die Hauptsystemdaten einsehen.
Die Lftersteuerung zeigt Ihnen zur Anpassung Lftergeschwindigkeit
und Temperatur an. Bei der bertaktung knnen Sie die CPU-Frequenz
zur Erzielung optimaler Systemleistung bertakten. OC DNA ermglicht
Ihnen die Speicherung Ihrer OC-Einstellungen als Profil, welches Sie
mit Freunden teilen knnen. Ihre Freunde knnen das OC-Profil dann
in ihrem System laden und so die gleichen OC-Einstellungen erzielen.
Per IES (Intelligent Energy Saver) kann der Spannungsregulator bei
Inaktivitt der CPU-Kerne die Anzahl an Ausgangsphasen zur Steigerung
der Effizienz reduzieren ohne die Rechenleistung zu beeintrchtigen.
Hinweise zur Bedienung der ASRock Extreme Tuning Utility (AXTU)
finden Sie auf unserer Webseite.
ASRock-Webseite: http://www.asrock.com

30

ASRock H61M-ITX Motherboard

9.

ASRock Instant Flash ist ein im Flash-ROM eingebettetes BIOS-FlashProgramm. Mithilfe dieses praktischen BIOS-Aktualisierungswerkzeugs
knnen Sie das System-BIOS aktualisieren, ohne dafr zuerst Betriebssysteme wie MS-DOS oder Windows aufrufen zu mssen. Mit diesem
Programm bekommen Sie durch Drcken der <F6>-Taste
whrend des POST-Vorgangs oder durch Drcken der <F2>-Taste im
BIOS-Setup-Men Zugang zu ASRock Instant Flash. Sie brauchen dieses
Werkzeug einfach nur zu starten und die neue BIOS-Datei auf Ihrem
USB-Flash-Laufwerk, Diskettenlaufwerk oder der Festplatte zu speichern,
und schon knnen Sie Ihr BIOS mit nur wenigen Klickvorgngen ohne
Bereitstellung einer zustzlichen Diskette oder eines anderen komplizierten Flash-Programms aktualisieren. Achten Sie darauf, dass das
USB-Flash-Laufwerk oder die Festplatte das Dateisystem FAT32/16/12
benutzen muss.
10. Wenn Sie nach einer schnelleren, weniger eingeschrnkten Mglichkeit zur Aufladung Ihrer Apple-Gerte (z. B. iPhone/iPad/iPod touch)
suchen, bietet ASRock Ihnen eine wunderbare Lsung den ASRock
APP Charger. Installieren Sie einfach den ASRock APP Charger-Treiber;
dadurch ldt sich Ihr iPhone wesentlich schneller ber einen Computerauf genaugenommen bis zu 40 % schneller als zuvor. Der ASRock APP
Charger ermglicht Ihnen die schnelle Aufladung mehrerer Apple-Gerte
gleichzeitig; der Ladevorgang wird sogar dann fortgesetzt, wenn der PC
den Ruhezustand (S1), Suspend to RAM-Modus (S3) oder Tiefschlafmodus (S4) aufruft oder ausgeschaltet wird (S5). Nach der Installation des
APP Charger-Treibers knnen Sie im Handumdrehen das groartigste
Ladeerlebnis berhaupt genieen. ASRock-Webseite: http://www.asrock.
com/Feature/AppCharger/index.asp
11. SmartView, eine neue Internetbrowserfunktion, ist eine intelligente IEStartseite, die meist besuchte Internetseiten, Ihren Browserverlauf,
Facebook-Freunde und Nachrichten in Echtzeit miteinander kombiniert:
In einer speziellen Ansicht, die das Internet noch angenehmer und aufregender macht. ASRock-Motherboards werden exklusiv mit der SmartView-Software geliefert, die auch dafr sorgt, dass Sie immer mit Ihren
Freunden in Verbindung bleiben. Die SmartView-Funktionen knnen Sie
mit den Windows-Betriebssystemen 7 / 7, 64 Bit / VistaTM / VistaTM 64 Bit

ASRock H61M-ITX Motherboard

Deutsch

und dem Internet Explorer ab Version 8 nutzen. ASRock-Website: http://


www.asrock.com/Feature/SmartView/index.asp
12. ASRocks XFast USB dient der Steigerung der Leistungsfhigkeit Ihrer
USB-Speichergerte. Die Leistung kann je nach Eigenschaften des
Gertes variieren.
13. Durch die ASRock ein/aus-Wiedergabetechnologie knnen Sie groartige
Klangerlebnisse von portablen Audiogerten, wie z. B. MP3-Playern oder
Mobiltelefonen, an Ihrem PC genieen selbst wenn der PC ausgeschaltet ist (oder sich im ACPI S5-Modus befindet)! Dieses Motherboard
wird zudem mit einem kostenlosen Audiokabel (3,5 mm, Klinke) (optional)
geliefert, was eine IT-Umgebung von hchster Benutzerfreundlichkeit
gewhrleistet.

31

14. Wird eine berhitzung der CPU registriert, fhrt das System einen automatischen Shutdown durch. Bevor Sie das System neu starten,
prfen Sie bitte, ob der CPU-Lfter am Motherboard richtig funktioniert,
und stecken Sie bitte den Stromkabelstecker aus und dann wieder ein.
Um die Wrmeableitung zu verbessern, bitte nicht vergessen, etwas
Wrmeleitpaste zwischen CPU und Khlkrper zu sprhen.
15. EuP steht fr Energy Using Product und kennzeichnet die kodesign-Richtlinie, die von der Europischen Gemeinschaft zur Festlegung des Energieverbrauchs von vollstndigen Systemen in Kraft gesetzt wurde. Gem
dieser kodesign-Richtlinie (EuP) muss der gesamte Netzstromverbrauch
von vollstndigen Systemen unter 1,00 Watt liegen,
wenn sie ausgeschaltet sind. Um dem EuP-Standard zu entsprechen,
sind ein EuP-fhiges Motherboard und eine EuP-fhige Stromversorgung
erforderlich. Gem einer Empfehlung von Intel muss eine EuP-fhige
Stromversorgung dem Standard entsprechen, was bedeutet, dass bei
einem Stromverbrauch von 100 mA die 5-Volt-Standby-Energieeffizienz
hher als 50% sein sollte. Fr die Wahl einer EuP-fhigen Stromversorgung
empfehlen wir Ihnen, weitere Details beim Hersteller der Stromversorgung
abzufragen.

Deutsch
32

ASRock H61M-ITX Motherboard

1.3 Einstellung der Jumper


Die Abbildung verdeutlicht, wie Jumper
gesetzt werden. Werden Pins durch
Jumperkappen verdeckt, ist der Jumper
Gebrckt. Werden keine Pins durch
Jumperkappen verdeckt, ist der Jumper
Offen. Die Abbildung zeigt einen 3-Pin
Jumper dessen Pin1 und Pin2 Gebrckt sind, bzw. es befindet sich eine
Jumper-Kappe auf diesen beiden Pins.
Jumper

Einstellun

Beschreibung

CMOS lschen
(CLRCMOS1, 3-Pin jumper)
(siehe S.2, No. 5)

DefaultEinstellung

CMOS
lschen

Hinweis: CLRCMOS1 ermglicht Ihnen die Lschung der Daten im CMOS. Zum

Deutsch

Lschen und Zurcksetzen der Systemparameter auf die Standardeinrichtung


schalten Sie den Computer bitte aus und trennen das Netzkabel von der
Stromversorgung. Warten Sie 15 Sekunden, schlieen Sie dann Pin2 und
Pin3 am CLRCMOS1 ber einen Jumper fnf Sekunden lang kurz. Sie
sollten das CMOS allerdings nicht direkt nach der BIOS-Aktualisierung
lschen. Wenn Sie das CMOS nach Abschluss der BIOS-Aktualisierung
lschen mssen, fahren Sie zuerst das System hoch. Fahren Sie es dann
vor der CMOS-Lschung herunter. Bitte beachten Sie, dass Kennwort,
Datum, Uhrzeit und benutzerdefiniertes Profil nur gelscht werden, wenn
die CMOS-Batterie entfernt wird.

ASRock H61M-ITX Motherboard

33

1.4 Integrierte Header und Anschlsse


Integrierte Header und Anschlsse sind KEINE Jumper. Setzen Sie KEINE Jumperkappen auf diese Header und Anschlsse. Wenn Sie Jumperkappen auf Header und Anschlsse setzen, wird das Motherboard
unreparierbar beschdigt!

Seriell-ATAII-Anschlsse
(SATA_0 (PORT 0):

SATA_0 (PORT 0) SATA_2 (PORT 4)

siehe S.2 - No. 3)


(SATA_1 (PORT 1):
siehe S.2 - No. 2)

SATA_1 (PORT 1)

(SATA_2 (PORT 4):

Diese drei Serial ATAII(SATAII-)Verbnder


untersttzten SATA-Datenkabel
fr interne
Massenspeichergerte. Die
aktuelle SATAII-Schnittstelle

siehe S.2 - No. 4)

ermglicht eine
Datenbertragungsrate bis
3,0 Gb/s.

Serial ATA- (SATA-)


Datenkabel

SJedes Ende des SATA


Datenkabels kann an die SATA

(Option)

/ SATAII Festplatte
oder das SATAII
Verbindungsstck auf
dieser Hauptplatine
angeschlossen werden.

Audiokabel (3,5 mm, Klinke)

Beide Enden des 3,5-mm-Klin


kenaudiokabels knnen an
portable Audiogerte, wie z. B.
MP3-Player und Mobiltelefone,
oder den Line-in-Port Ihres PCs
angeschlossen werden.

(Option)

USB 2.0-Header
(9-pol. USB6_7)

Deutsch

(siehe S.2 - No. 10)

USB_PWR
P-9
P+9
GND
DUMMY

(9-pol. USB8_9)
(siehe S.2 - No. 8)

Zustzlich zu den vier


blichen USB 2.0-Ports an den
I/O-Anschlssen befinden sich
zwei USB 2.0Anschlussleisten am
Motherboard. Pro USB 2.0Anschlussleiste werden zwei
USB 2.0-Ports untersttzt.

1
GND
P+8
P-8
USB_PWR

34

ASRock H61M-ITX Motherboard

Consumer Infrared-Modul-Header
1

(4-pin CIR1)

GND
IRTX
IRRX
ATX+5VSB

(siehe S.2 - No. 9)

Anschluss fr Audio auf


der Gehusevorderseite

GND
PRESENCE#
MIC_RET
OUT_RET

(9-Pin HD_AUDIO1)
(siehe S.2 - No. 14)

1
OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

Dieser Header kann zum


Anschlieen RemoteEmpfnger.
Dieses Interface zu einem
Audio-Panel auf der Vorder
seite Ihres Gehuses,
ermglicht Ihnen eine bequeme
Anschlussmglichkeit und
Kontrolle ber Audio-Gerte.

1. High Definition Audio untersttzt Jack Sensing (automatische Erkennung


falsch angeschlossener Gerte), wobei jedoch die Bildschirmverdrahtung
am Gehuse HDA untersttzen muss, um richtig zu funktionieren.
Beachten Sie bei der Installation im System die Anweisungen in unserem
Handbuch und im Gehusehandbuch.
2. Wenn Sie die AC97-Audioleiste verwenden, installieren Sie diese wie
nachstehend beschrieben an der Front-Audioanschlussleiste:
A. Schlieen Sie Mic_IN (MIC) an MIC2_L an.
B. Schlieen Sie Audio_R (RIN) an OUT2_R und Audio_L (LIN) an OUT2_L an.
C. Schlieen Sie Ground (GND) an Ground (GND) an.
D. MIC_RET und OUT_RET sind nur fr den HD-Audioanschluss gedacht. Diese
Anschlsse mssen nicht an die AC97-Audioleiste angeschlossen werden.
E. So aktivieren Sie das Mikrofon an der Vorderseite.
Bei den Betriebssystemen Windows XP / XP 64 Bit:

System Panel-Header

Dieser Header untersttzt

(9-pin PANEL1)

mehrere Funktion der


Systemvorderseite.

(siehe S.2 - No. 1)

Deutsch

Whlen Sie Mixer. Whlen Sie Recorder (Rekorder). Klicken Sie dann
auf FrontMic (Vorderes Mikrofon).
Bei den Betriebssystemen Windows 7 / 7 64 Bit / VistaTM / VistaTM 64 Bit:
Whlen Sie im Realtek-Bedienfeld die FrontMic (Vorderes Mikrofon)Registerkarte. Passen Sie die Recording Volume (Aufnahmelautstrke)
an.

Schlieen Sie die Ein-/Austaste, die Reset-Taste und die


Systemstatusanzeige am Gehuse an diesen Header an; befolgen Sie
dabei die nachstehenden Hinweise zur Pinbelegung. Beachten Sie die
positiven und negativen Pins, bevor Sie die Kabel anschlieen.

ASRock H61M-ITX Motherboard

35

PWRBTN (Ein-/Ausschalter):
Zum Anschlieen des Ein-/Ausschalters an der Frontblende des Gehu
ses. Sie knnen konfigurieren, wie das System mit Hilfe des
Ein-/Ausschalters ausgeschaltet werden knnen soll.
RESET (Reset-Taste):
Zum Anschlieen der Reset-Taste an der Frontblende des Gehuses.
Mit der Reset-Taste knnen Sie den Computer im Falle eines Absturzes
neu starten.
PLED (Systembetriebs-LED):
Zum Anschlieen der Betriebsstatusanzeige an der Frontblende des
Gehuses. Die LED leuchtet, wenn das System in Betrieb ist. Die LED
blinkt, wenn sich das System im Ruhezustand S1 befindet. Die LED
schaltet sich aus, wenn sich das System in den Modi S3/S4 befindet
oder ausgeschaltet ist (S5).
HDLED (Festplattenaktivitts-LED):
Zum Anschlieen der Festplattenaktivitts-LED an der Frontblende des
Gehuses. Die LED leuchtet, wenn die Festplatte Daten liest oder
schreibt.
Das Design der Frontblende kann je nach Gehuse variiere. Ein
Frontblendenmodul besteht hauptschlich aus einer Ein-/Austaste, einer
Reset-Taste, einer Betriebs-LED, einer Festplattenaktivitts-LED,
Lautsprechern, etc. Stellen Sie beim Anschlieen des
Frontblendenmoduls Ihres Gehuses an diesem Header sicher, dass die
Kabel- und Pinbelegung korrekt bereinstimmen.

Betriebs-LED-Header
(3-pin PLED1)

1
PLEDPLED+
PLED+

(siehe S.2 - No. 19)

Deutsch

Gehuse lfteranschlsse
(3-pin CHA_FAN1)
(siehe S.2 - No. 18)

36

Bitte schlieen Sie die


Betriebs-LED des Gehuses
zur Anzeige des
Systembetriebsstatus an
diesem Header an. Die LED
leuchtet, wenn das System in
Betrieb ist. Die LED blinkt im
S1-Zustand. Im S3-/S4- oder
S5-Zustand (ausgeschaltet)
leuchtet die LED nicht.
Verbinden Sie die Lfterkabel mit
den Lfteranschlssen, wobei
der schwarze Draht an den
Schutzleiterstift angeschlossen
wird.

ASRock H61M-ITX Motherboard

CPU-Lfteranschluss

4 3 2 1

(4-pin CPU_FAN1)
(siehe S.2 - No. 17)

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

Verbinden Sie das CPU Lfterkabel mit diesem


Anschluss und passen Sie den
schwarzen Draht dem
Erdungsstift an.

Obwohl dieses Motherboard einen vierpoligen CPU-Lfteranschluss


(Quiet Fan) bietet, knnen auch CPU-Lfter mit dreipoligem Anschluss
angeschlossen werden; auch ohne Geschwindigkeitsregulierung. Wenn
Sie einen dreipoligen CPU-Lfter an den CPU-Lferanschluss dieses
Motherboards anschlieen mchten, verbinden Sie ihn bitte mit den
Pins 1 3.
Pins 13 anschlieen
Lfter mit dreipoligem Anschluss installieren

ATX-Netz-Header

24

13

12

(24-pin ATXPWR1)
(siehe S.2 - No. 7)

Verbinden Sie die ATXStromversorgung mit diesem


Header.

Obwohl dieses Motherboard einen 24-pol. ATX-Stromanschluss bietet,


kann es auch mit einem modifizierten traditionellen 20-pol. ATX-Netzteil
verwendet werden. Um ein 20-pol. ATX-Netzteil zu verwenden, stecken
Sie den Stecker mit Pin 1 und Pin 13 ein.
24
13

Installation eines 20-pol. ATX-Netzteils

(4-pin ATX12V1)

Bitte schlieen Sie an diesen


Anschluss die ATX 12V

(siehe S.2 - No. 15)

Stromversorgung an.

Deutsch

ATX 12V Anschluss

12

ASRock H61M-ITX Motherboard

37

2. BIOS-Information
Das Flash Memory dieses Motherboards speichert das Setup-Utility. Drcken Sie
<F2> oder <Del> whrend des POST (Power-On-Self-Test) um ins Setup zu gelangen, ansonsten werden die Testroutinen weiter abgearbeitet. Wenn Sie ins Setup
gelangen wollen, nachdem der POST durchgefhrt wurde, mssen Sie das System
ber die Tastenkombination <Ctrl> + <Alt> + <Delete> oder den Reset-Knopf auf
der Gehusevorderseite, neu starten. Natrlich knnen Sie einen Neustart auch
durchfhren, indem Sie das System kurz ab- und danach wieder anschalten.
Das Setup-Programm ist fr eine bequeme Bedienung entwickelt worden. Es ist
ein mengesteuertes Programm, in dem Sie durch unterschiedliche Untermens
scrollen und die vorab festgelegten Optionen auswhlen knnen. Fr detaillierte
Informationen zum BIOS-Setup, siehe bitte das Benutzerhandbuch (PDF Datei) auf
der Support CD.

3. Software Support CD information


Dieses Motherboard untersttzt eine Reiche von Microsoft Windows Betriebssystemen: 7 / 7 64-Bit / VistaTM / VistaTM 64-Bit / XP / XP 64-Bit. Die Ihrem Motherboard
beigefgte Support-CD enthlt hilfreiche Software, Treiber und Hilfsprogramme, mit
denen Sie die Funktionen Ihres Motherboards verbessern knnen Legen Sie die
Support-CD zunchst in Ihr CD-ROM-Laufwerk ein. Der Willkommensbildschirm
mit den Installationsmens der CD wird automatisch aufgerufen, wenn Sie die
Autorun-Funktion Ihres Systems aktiviert haben.
Erscheint der Wilkommensbildschirm nicht, so doppelklicken Sie bitte auf das File
ASSETUP.EXE im BIN-Verzeichnis der Support-CD, um die Mens aufzurufen.
Das Setup-Programm soll es Ihnen so leicht wie mglich machen. Es ist mengesteuert, d.h. Sie knnen in den verschiedenen Untermens Ihre Auswahl treffen und
die Programme werden dann automatisch installiert.

Deutsch
38

ASRock H61M-ITX Motherboard

1. Introduction
Merci pour votre achat dune carte mre ASRock H61M-ITX, une carte mre trs
fiable produite selon les critres de qualit rigoureux de ASRock. Elle offre des performances excellentes et une conception robuste conformment lengagement
dASRock sur la qualit et la fiabilit au long terme.
Ce Guide dinstallation rapide prsente la carte mre et constitue un guide
dinstallation pas pas. Des informations plus dtailles concernant la carte
mre pourront tre trouves dans le manuel lutilisateur qui se trouve sur le CD
dassistance.
Les spcifications de la carte mre et le BIOS ayant pu tre mis
jour, le contenu de ce manuel est sujet des changements sans
notification. Au cas o nimporte quelle modification intervenait sur ce
manuel, la version mise jour serait disponible sur le site web
ASRock sans nouvel avis. Vous trouverez les listes de prise en
charge des cartes VGA et CPU galement sur le site Web ASRock.
Site web ASRock, http://www.asrock.com
Si vous avez besoin de support technique en relation avec cette carte
mre, veuillez consulter notre site Web pour de plus amples
informations particulires au modle que vous utilisez.
www.asrock.com/support/index.asp

1.1 Contenu du paquet


Carte mre ASRock H61M-ITX
(Facteur de forme Mini-ITX: 6.7 pouces x 6.7 pouces, 17.0 cm x 17.0 cm)
Guide dinstallation rapide ASRock H61M-ITX
CD de soutien ASRock H61M-ITX
Deux cbles de donnes de srie ATA (SATA) (en option)
Un Cble audio 3,5mm (en option)
Un I/O Panel Shield
ASRock vous rappelle...

ASRock H61M-ITX Motherboard

Franais

Pour bnficier des meilleures performances sous Windows 7 / 7 64 bits


/ VistaTM / VistaTM 64 bits, il est recommand de paramtrer l'option BIOS
dans Configuration de stockage en mode AHCI. Pour plus de dtails sur
l'installation BIOS, rfrez-vous au "Mode d'emploi" sur votre CD de support.

39

1.2 Spcifications
Format

CPU

Chipsets
Mmoire

Slot dextension
VGA sur carte

- Facteur de forme Mini-ITX:


6.7 pouces x 6.7 pouces, 17.0 cm x 17.0 cm
- Accessoires de Carte mre (condensateurs 100% polymre
conducteur de haute qualit fabriqu au Japon)
- Prend en charge les processeurs Intel CoreTM i7 / i5 / i3 de
deuxime gnration dans lensemble LGA1155
- Prend en charge la technologie Intel Turbo Boost 2.0
- Prise en charge des units centrales non verrouilles de
srie K
- Prise en charge de la technologie Hyper-Threading
(voir ATTENTION 1)
- Intel H61
- Compatible avec la Technologie de Mmoire Canal
Double (voir ATTENTION 2)
- 2 x slots DIMM DDR3
- Supporter DDR3 1333/1066 non-ECC, sans amortissement
mmoire
- Capacit maxi de mmoire systme: 16GB
(voir ATTENTION 3)
- 1 x slot PCI Express 2.0 x16 (bleu @ mode x16)
- Supporte Intel HD Graphics Built-in Visuals: Intel Quick
Sync Video, Intel InTruTM 3D, Intel Clear Video HD
Technology, Intel HD Graphics 2000/3000, Intel Advanced
Vector Extensions (AVX)
- Pixel Shader 4.1, DirectX 11 avec CPU Intel Ivy Bridge,

Franais

DirectX 10.1 avec CPU Intel Sandy Bridge


- mmoire partage max 1759MB (voir ATTENTION 4)
- Trois options de sortie VGA: D-Sub, DVI-D et HDMI
(voir ATTENTION 5)
- Prend en charge le HDMI 1.4a avec une rsolution
maximale jusqu 1920x1200 @ 60Hz
- Prend en charge le DVI avec une rsolution maximale
jusqu 1920x1200 @ 60Hz
- Prend en charge le D-Sub avec une rsolution maximale
jusqu 2048x1536 @ 75Hz
- Prend en charge Lip Sync, xvYCC et HBR (High Bit Rate
Audio: Audio haut dbit binaire) avec HDMI (Moniteur
compatible HDMI requis) (voir ATTENTION 6)

40

ASRock H61M-ITX Motherboard

LAN

Panneau arrire

USB 3.0
Connecteurs

- 1 x LED di accensione
- Connecteur pour ventilateur de CPU/Chssis
- br. 24 connecteur dalimentation ATX
- br. 4 connecteur dalimentation 12V ATX
- Connecteur audio panneau avant
- 2 x En-tte USB 2.0 (prendre en charge 4 ports USB 2.0
supplmentaires)

ASRock H61M-ITX Motherboard

Franais

Audio

- Prise en charge de la fonction HDCP avec ports DVI et


HDMI
- Supporter 1080p Blu-ray(BD)/ lecteur de HD-DVD avec
ports DVI et HDMI
- 7,1 CH HD Audio (Realtek ALC887 Audio Codec)
- Prend en charge THX TruStudioTM
- PCIE x1 Gigabit LAN 10/100/1000 Mb/s
- Realtek RTL8111E
- Supporte du Wake-On-LAN
- Prise en charge de la dtection de cble LAN
- Prend en charge la norme Energy Efficient Ethernet
(Ethernet efficacit nergtique) 802.3az
- Supporte PXE
I/O Panel
- 1 x port clavier PS/2
- 1 x port D-Sub
- 1 x port DVI-D
- 1 x port HDMI
- 1 x Port de sortie optique SPDIF
- 4 x ports USB 2.0 par dfaut
- 1 x Connecteur eSATA2
- 2 x ports USB 3.0 par dfaut
- 1 x port LAN RJ-45 avec LED (ACT/LED CLIGNOTANTE et
LED VITESSE)
- Prise HD Audio: Haut-parleur arrire / Central /Basses /
Entre Ligne / Haut-parleur frontal / Microphone
(voir ATTENTION 7)
- 2 x ports USB3.0 larrire par ASMedia ASM1042,
prennent en charge USB 1.0/2.0/3.0 jusqu 5 Gb/s
- 3 x connecteurs SATA2, prennent en charge un taux de
transfert de donnes pouvant aller jusqu 3.0Go/s,
supporte NCQ, AHCI et Hot Plug (Branche ment
chaud)
- 1 x Barrette pour module infrarouges grand public

41

BIOS

CD dassistance

Caractristique
unique

Surveillance
systme

OS
Certifications

- 32Mb BIOS AMI


- AMI UEFI Legal BIOS avec support GUI
- Support du Plug and Play
- Compatible pour vnements de rveil ACPI 1.1
- Gestion jumperless
- Support SMBIOS 2.3.1
- Pilotes, utilitaires, logiciel anti-virus (version dvaluation),
CyberLink MediaEspresso 6.5 Trial, Suite logicielle ASRock
(CyberLink DVD Suite et Version OEM et dessai)
- Utilitaire ASRock Extreme Tuning (AXTU)
(voir ATTENTION 8)
- ASRock lInstant Boot
- ASRock Instant Flash (voir ATTENTION 9)
- Chargeur ASRock APP (voir ATTENTION 10)
- ASRock SmartView (voir ATTENTION 11)
- ASRock XFast USB (voir ATTENTION 12)
- Technologie Lecture Marche/Arrt ASRock
(voir ATTENTION 13)
- Lacclrateur hybride:
- ASRock U-COP (voir ATTENTION 14)
- Garde dchec au dmarrage (B.F.G.)
- DEL veilleuse
- Contrle de la temprature CPU
- Mesure de temprature de la carte mre
- Tachomtre ventilateur processeur/chssis
- Ventilateur silencieux pour unit centrale/chssis (permet le
rglage automatique de la vitesse du ventilateur pour chssis, selon la temprature de lunit centrale)
- Commande de ventilateur CPU/chssis plusieurs vitesses
- Monitoring de la tension: +12V, +5V, +3.3V, Vcore
- Microsoft Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit

Franais

/ XP / XP 64-bit
- FCC, CE, WHQL
- Prt pour ErP/EuP (alimentation Prt pour ErP/EuP requise)
(voir ATTENTION 15)

* Pour de plus amples informations sur les produits, sil vous plat visitez notre site web:
http://www.asrock.com

42

ASRock H61M-ITX Motherboard

ATTENTION
Il est important que vous ralisiez quil y a un certain risque effectuer
loverclocking, y compris ajuster les rglages du BIOS, appliquer la technologie
Untied Overclocking, ou utiliser des outils de tiers pour loverclocking. Loverclocking
peut affecter la stabilit de votre systme, ou mme causer des dommages aux
composants et dispositifs de votre systme. Si vous le faites, cest vos frais et
vos propres risques. Nous ne sommes pas responsables des dommages possibles
causs par loverclocking.

ATTENTION!

2.

3.

4.

5.

6.
7.

8.

En ce qui concerne le paramtrage Hyper-Threading Technology,


veuillez consulter la page 39 du manuel de lutilisateur sur le CD technique.
Cette carte mre supporte la Technologie de Mmoire Canal Double.
Avant dintgrer la Technologie de Mmoire Canal Double, assurezvous de bien lire le guide dinstallation des modules mmoire en page 14
pour raliser une installation correcte.
Du fait des limites du systme dexploitation, la taille mmoire relle
rserve au systme pourra tre infrieure 4 Go sous Windows 7 /
VistaTM / XP. Avec Windows OS avec CPU 64 bits, il ny a pas ce genre
de limitation.
La dimension maximum du memoire partage est definie par le vendeur
de jeu de puces et est sujet de changer. Veuillez verifier la Intel website
pour les informations recentes SVP.
Vous pouvez choisir de nutiliser que deux moniteurs sur trois. Les
moniteurs D-Sub, DVI-D et HDMI ne peuvent pas tre activs en mme
temps. En outre, avec ladaptateur DVI-HDMI, le port DVI-D peut prendre
en charge les mmes fonctions que le port HDMI.
xvYCC ne sont pris en charge que sous Windows 7 64-bit / 7. HBR est
pris en charge sous Windows 7 64-bit / 7 / VistaTM 64-bit / VistaTM.
Pour lentre microphone, cette carte mre supporte les deux modes
stro et mono. Pour la sortie audio, cette carte mre supporte les
modes 2-canaux, 4-canaux, 6-canaux et 8-canaux. Veuillez vous rfrer
au tableau en page 3 pour effectuer la bonne connexion.
ASRock Extreme Tuning Utility (AXTU) est un utilitaire tout-en-un
qui permet de rgler prcisment diffrentes fonctions du systme,
via une interface facile utiliser, incluant Moniteur de priphriques,
Contrle du ventilateur, Overclocking, OC DNA et IES. Dans Moniteur
de priphriques, il affiche les valeurs principales de votre systme.
Dans Contrle du ventilateur, il affiche la vitesse du ventilateur et la
temprature, que vous pouvez ajuster. Dans Overclocking, vous pouvez
overclocker la frquence du CPU pour amliorer les performances du

ASRock H61M-ITX Motherboard

Franais

1.

43

systme. Dans OC DNA, vous pouvez enregistrer vos rglages OC dans


un profil et les partager avec vos amis. Vos amis pourront alors installer
le profil OC sur leur systme pour utiliser les mmes rglages OC.
Dans IES (Intelligent Energy Saver Fonction intelligente dconomie
dnergie), le contrleur de la tension peut rduire le nombre de phases
de sortie pour amliorer le fonctionnement lorsque les cores du CPU
ne sont pas utilises, sans diminuer les performances de lordinateur.
Veuillez visiter notre site Web pour plus dinformations sur lutilisation des
fonctions de lutilitaire ASRock Extreme Tuning Utility (AXTU).
Site Web de ASRock : http://www.asrock.com
9.

O ASRock Instant Flash um utilitrio de flash do BIOS incorporado na


memria Flash ROM. Esta prtica ferramenta de actualizao do BIOS
permite-lhe actualizar o BIOS do sistema sem necessitar de entrar nos
sistemas operativos, como o MS-DOS ou o Windows. Com este
utilitrio, poder premir a tecla <F6> durante o teste de arranque POST
ou premir a tecla <F2> para exibir o menu de configurao do BIOS para
aceder ao ASRock Instant Flash. Execute esta ferramenta para guardar
o novo ficheiro de BIOS numa unidade flash USB, numa disquete ou
num disco rgido, em seguida, poder actualizar o BIOS com
apenas alguns cliques sem ter de utilizar outra disquete ou outro complicado utilitrio de flash. Note que a unidade flash USB ou a unidade de
disco rgido devem utilizar o sistema de ficheiros FAT32/16/12.
10. Si vous dsirez un moyen plus rapide et moins contraignant de recharger
vos appareils Apple tels que iPhone/iPod/iPad Touch, ASRock a prpar
pour vous la solution idale - le chargeur ASRock APP. Il suffit dinstaller
le pilote du chargeur APP, et vous pourrez recharger rapidement votre
iPhone partir de votre ordinateur, jusqu 40% plus vite quavant. Le
chargeur ASRock APP vous permet de charger rapidement et simultanment plusieurs appareils Apple, et le chargement continu est mme
pris en charge lorsque le PC passe en mode Veille (S1), Suspension la
RAM (S3), hibernation (S4) ou hors tension (S5). Lorsque le pilote du
chargeur APP est install, vous dcouvrez un mode de mise en charge
tout fait indit.
Site web ASRock : http://www.asrock.com/Feature/AppCharger/index.asp
11. SmartView, une nouvelle fonction du navigateur Internet, est une page

Franais

de dmarrage intelligente de IE, comportant la fois vos sites Internet


les plus visits, votre historique, vos amis Facebook et lactualit en
temps rel, le tout sur une vue optimise pour une exprience de lInternet
encore plus personnelle. Les cartes mres ASRock sont quipes en exclusivit de lutilitaire SmartView, ce qui vous permet de garder le contact
avec vos amis itinrants. Pour utiliser la fonction SmartView, veuillez
vous assurez que votre version de systme dexploitation est Windows
7 / 7 64 bits / VistaTM / VistaTM 64 bits, et que vous utilisez le navigateur
IE8. Site Internet ASRock : http://www.asrock.com/Feature/SmartView/
index.asp

44

ASRock H61M-ITX Motherboard

Franais

12. ASRock XFast USB permet damliorer les performances de votre priphrique de stockage USB. Les performances relles dpendent des
proprits du priphrique.
13. La Technologie Lecture Marche/Arrt ASRock permet aux utilisateurs
dexpriencer laudio incroyable partir dappareils audio portables
comme un lecteur MP3 ou un tlphone portable, sur votre PC, mme
lorsque le PC est teint (ou en mode ACPI S5)! Cette carte mre fournie
aussi un cble audio 3,5mm gratuit (optionnel) qui facilite beaucoup dans
les environnements informatiques.
14. Lorsquune surchauffe du CPU est dtecte, le systme sarrte
automatiquement. Avant de redmarrer le systme, veuillez vrifier que
le ventilateur dUC sur la carte mre fonctionne correctement et dbranchez le cordon dalimentation, puis rebranchez-le. Pour amliorer la dissipation de la chaleur, noubliez pas de mettre de la pte thermique entre
le CPU le dissipateur lors de linstallation du PC.
15. EuP, qui signifie Energy Using Product (Produit Utilisant de lEnergie),
est une disposition tablie par lUnion Europenne pour dfinir la consommation de courant pour le systme entier. Conformment la norme
EuP, le courant CA total du systme entier doit tre infrieur 1 W en
mode darrt. Pour tre conforme la norme EuP, une carte mre EuP
et une alimentation EuP sont requises. Selon les suggestions dIntel,
lalimentation lectrique EuP doit correspondre la norme, qui est que
lefficacit lectrique de 5v en mode de veille doit tre suprieure 50%
pour 100 mA de consommation de courant. Pour choisir une alimentation
lectrique conforme la norme EuP, nous vous recommandons de consulter votre fournisseur de courant pour plus de dtails.

ASRock H61M-ITX Motherboard

45

1.3 Rglage des cavaliers


Lillustration explique le rglage des cavaliers. Quand un capuchon est plac sur les
broches, le cavalier est FERME . Si aucun capuchon ne relie les broches,le cavalier est OUVERT . Lillustration montre un
cavalier 3 broches dont les broches 1 et 2
sont FERMEES quand le capuchon est
plac sur ces 2 broches.
Le cavalier
Effacer la CMOS
(CLRCMOS1)
(voir p.2 fig. 5)

Description

Paramtres
par dfaut

Effacer la
CMOS

Remarque : CLRCMOS1 vous permet deffacer les donnes du CMOS. Pour effacer
et rinitialiser les paramtres du systme la configuration originale,
veuillez teindre lordinateur et dbrancher le cordon dalimentation de
la prise de courant. Aprs 15 secondes, utilisez un couvercle de jumper
pour court-circuiter les broches pin2 et pin3 de CLRCMOS1 pendant 5
secondes. Veuillez cependant ne pas effacer le CMOS immdiatement
aprs avoir mis jour le BIOS. Si vous avez besoin deffacer le CMOS
aprs avoir mis jour le BIOS, vous devez allumer en premier le
systme, puis lteindre avant de continuer avec lopration deffacement
du CMOS. Veuillez noter que le mot de passe, la date, lheure et le profil par dfaut de lutilisateur seront effacs seulement si la batterie du
CMOS est enleve.

Franais
46

ASRock H61M-ITX Motherboard

1.4 En-ttes et Connecteurs sur Carte


Les en-ttes et connecteurs sur carte NE SONT PAS des cavaliers.
NE PAS placer les capuchons de cavalier sur ces en-ttes et connecteurs. Le fait de placer les capuchons de cavalier sur les en-ttes
et connecteurs causera la carte mre des dommages irrversibles!

Connecteurs Srie ATAII


(SATA_0 (PORT 0):

SATA_0 (PORT 0) SATA_2 (PORT 4)

voir p.2 No. 3)

Ces trois connecteurs Srie


ATAII (SATAII) prennent en
charge les cbles SATA pour

(SATA_2 (PORT 4):

les priphriques de stockage


internes. Linterface SATAII
actuelle permet des taux

voir p.2 No. 4)

transferts de donnes pouvant

(SATA_1 (PORT 1):


voir p.2 No. 2)

SATA_1 (PORT 1)

aller jusqu 3,0 Gb/s.


Cble de donnes
Srie ATA (SATA)

Toute cote du cable de data


SATA peut etre connecte au

(en option)

disque dur SATA / SATAII /


ou au connecteur SATAII sur la
carte mere.

Cble audio 3,5mm

Lune des extrmits du cble

(en option)

audio 3,5mm peut tre


branche sur des appareils
audio portatifs comme un
lecteur MP3 ou un tlphone
portable, ou le port Entre Ligne
de votre PC.
USB_PWR
P-9
P+9
GND
DUMMY

(USB6_7 br.9)
(voir p.2 No. 10)
1

GND
P+8
P-8
USB_PWR
USB_PWR
P-11
P+11
GND
DUMMY

(USB8_9 br.9)
(voir p.2 No. 8)

A ct des quatre ports


USB 2.0 par dfaut sur le
panneau E/S, il y a deux
embases USB 2.0 sur cette
carte mre. Chaque embase
USB 2.0 peut prendre en
charge 2 ports USB 2.0.

Franais

En-tte USB 2.0

1
GND
P+10
P-10
USB_PWR

Barrette pour module infrarouges grand public

Cette barrette peut tre utilise

(CIR1 br.4)

pour connecter des rcepteur

(voir p.2 No. 9)

1
GND
IRTX
IRRX
ATX+5VSB

ASRock H61M-ITX Motherboard

47

Connecteur audio panneau

GND
PRESENCE#
MIC_RET
OUT_RET

(HD_AUDIO1 br. 9)
(voir p.2 No. 14)
1

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

Cest une interface pour


un cble avant audio en faade
qui permet le branchement et
le contrle commodes de
priphriques audio.

1. Laudio haute dfinition (HDA) prend en charge la dtection de fiche,


mais le fil de panneau sur le chssis doit prendre en charge le HDA pour
fonctionner correctement. Veuillez suivre les instructions dans notre
manuel et le manuel de chssis afin installer votre systme.
2. Si vous utilisez le panneau audio AC97, installez-le sur ladaptateur audio
du panneau avant conformment la procdure ci-dessous :
A. Connectez Mic_IN (MIC) MIC2_L.
B. Connectez Audio_R (RIN) OUT2_R et Audio_L (LIN) OUT2_L.
C. Connectez Ground (GND) Ground (GND).
D. MIC_RET et OUT_RET sont rservs au panneau audio HD. Vous
navez pas besoin de les connecter pour le panneau audio AC97.
E. Pour activer le micro avant.
Pour les systmes dexploitation Windows XP / XP 64 bits :
Slectionnez Mixer. Slectionnez Recorder (Enregistreur). Puis
cliquez sur FrontMic (Micro avant).
Pour les systmes dexploitation Windows 7 / 7 64 bits / VistaTM /
VistaTM 64 bits :
Allez sur longlet FrontMic (Micro avant) sur le Panneau de contrle
Realtek. Ajustez Recording Volume (Volume denregistrement).

En-tte du panneau systme

Cet en-tte permet dutiliser

(PANEL1 br.9)

plusieurs fonctions du
panneau systme frontal.

(voir p.2 No. 1)

Connectez linterrupteur dalimentation, linterrupteur de rinitialisation et


lindicateur dtat du systme du chssis sur cette barrette en respectant
laffectation des broches dcrite ci-dessous. Faites attention aux broches
positives et ngatives avant de connecter les cbles.

Franais

PWRBTN (Interrupteur dalimentation):


Connectez ici le connecteur dalimentation sur le panneau avant du
chssis. Vous pouvez configurer la faon de mettre votre systme hors
tension avec linterrupteur dalimentation.
RESET (Interrupteur de rinitialisation):
Connectez ici le connecteur de rinitialisation sur le panneau avant du
chssis. Appuyez sur linterrupteur de rinitialisation pour redmarrer
lordinateur sil se bloque ou sil narrive pas redmarrer normalement.

48

ASRock H61M-ITX Motherboard

PLED (DEL alimentation systme):


Connectez ici lindicateur dtat de lalimentation sur le panneau avant
du chssis. Ce voyant DEL est allum lorsque le systme est en
marche. Le voyant DEL clignote lorsque le systme est en mode veille
S1. Le voyant DEL est teint lorsque le systme est en mode veille S3/
S4 ou lorsquil est teint (S5).
HDLED (DEL activit du disque dur):
Connectez ici le voyant DEL dactivit du disque dur sur le panneau
avant du chssis. Ce voyant DEL est allum lorsque le disque dur est en
train de lire ou dcrire des donnes.
Le design du panneau avant peut varier en fonction du chssis. Un
module de panneau avant consiste principalement en : interrupteur
dalimentation, interrupteur de rinitialisation, voyant DEL dalimentation,
voyant DEL dactivit du disque dur, haut-parleur, etc. Lorsque vous
connectez le panneau avant de votre chssis sur cette barrette, vrifiez
bien faire correspondre les fils et les broches.

LED di accensione

Collegare il LED di accensione


chassi per indicare lo stato di
alimentazione del sistema. Il
LED acceso quando il sistema
in funzione. Il LED continua a
lampeggiare in stato S1. Il LED
spento in stato S3/S4 o S5
(spegnimento).

(3-pin PLED1)

PLEDPLED+
PLED+

(vedi p.2 Nr. 19)

Connecteur pour chssis

Branchez les cbles du


ventilateur aux connecteurs pour
ventilateur et faites correspondre
le fil noir la broche de terre.

(CHA_FAN1 br. 3)
(voir p.2 No. 18)

Connecteur du ventilateur
de lUC
(voir p.2 No. 17)

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

connecteur et brancher le fil


noir sur la broche de terre.

Bien que cette carte mre offre un support de (Ventilateur silencieux


ventilateur de CPU 4 broches , le ventilateur de CPU 3 broches peut
bien fonctionner mme sans la fonction de commande de vitesse du
ventilateur. Si vous prvoyez de connecter le ventilateur de CPU 3
broches au connecteur du ventilateur de CPU sur cette carte mre,
veuillez le connecter aux broches 1-3.

Franais

(CPU_FAN1 br. 4)

Veuillez connecter le cble de


ventilateur dUC sur ce

4 3 2 1

Installation de ventilateur 3 broches


Broches 1-3 connectes

ASRock H61M-ITX Motherboard

49

En-tte dalimentation ATX

24

13

12

(ATXPWR1 br. 24)


(voir p.2 No. 7)

Veuillez connecter lunit


dalimentation ATX sur cet entte.

Bien que cette carte mre fournisse un connecteur de courant ATX 24


broches, elle peut encore fonctionner si vous adopter une alimentation
traditionnelle ATX 20 broches. Pour utiliser une alimentation ATX 20
broches, branchez lalimentation lectrique ainsi quaux broches 1 et
13.
24
13

20-Installation de lalimentation lectrique ATX

Connecteur ATX 12V


(ATX12V1 br.4)
(voir p.2 No. 15)

Veuillez connecter une unit


dalimentation lectrique ATX
12V sur ce connecteur.

Franais
50

12

ASRock H61M-ITX Motherboard

2. Informations sur le BIOS


La puce Flash Memory sur la carte mre stocke le Setup du BIOS. Lorsque vous
dmarrez lordinateur, veuillez presser <F2> ou <Del> pendant le POST (Power-OnSelf-Test) pour entrer dans le BIOS; sinon, le POST continue ses tests de routine. Si
vous dsirez entrer dans le BIOS aprs le POST, veuillez redmarrer le systme en
pressant <Ctl> + <Alt> + <Suppr>, ou en pressant le bouton de reset sur le botier
du systme. Vous pouvez galement redmarrer en teignant le systme et en le
rallumant. Lutilitaire dinstallation du BIOS est conu pour tre convivial. Cest un
programme pilot par menu, qui vous permet de faire dfiler par ses divers sousmenus et de choisir parmi les choix prdtermins. Pour des informations dtailles
sur le BIOS, veuillez consulter le Guide de lutilisateur (fichier PDF) dans le CD
technique.

3. Informations sur le CD de support

Franais

Cette carte mre supporte divers systmes dexploitation Microsoft Windows:


7 / 7 64 bits / VistaTM / VistaTM 64 bits / XP / XP 64 bits. Le CD technique livr avec
cette carte mre contient les pilotes et les utilitaires ncessaires pour amliorer les
fonctions de la carte mre. Pour utiliser le CD technique, insrez-le dans le lecteur
de CD-ROM. Le Menu principal saffiche automatiquement si AUTORUN est activ
dans votre ordinateur. Si le Menu principal napparat pas automatiquement, localisez dans le CD technique le fichier ASSETUP.EXE dans le dossier BIN et doublecliquez dessus pour afficher les menus.

ASRock H61M-ITX Motherboard

51

1. Introduzione
Grazie per aver scelto una scheda madre ASRock H61M-ITX, una scheda madre affidabile prodotta secondo i severi criteri di qualit ASRock. Le prestazioni eccellenti
e il design robusto si conformano allimpegno di ASRock nella ricerca della qualit e
della resistenza.
Questa Guida Rapida allInstallazione contiene lintroduzione alla motherboard e la
guida passo-passo allinstallazione. Informazioni pi dettagliate sulla motherboard si
possono trovare nel manuale per lutente presente nel CD di supporto.
Le specifiche della scheda madre e il software del BIOS possono
essere aggiornati, pertanto il contenuto di questo manuale pu subire
variazioni senza preavviso. Nel caso in cui questo manuale sia
modificato, la versione aggiornata sar disponibile sul sito di ASRock
senza altro avviso. Sul sito ASRock si possono anche trovare le pi
recenti schede VGA e gli elenchi di CPU supportate.
ASRock website http://www.asrock.com
Se si necessita dellassistenza tecnica per questa scheda madre,
visitare il nostro sito per informazioni specifiche sul modello che si
sta usando.
www.asrock.com/support/index.asp

1.1 Contenuto della confezione


Scheda madre ASRock H61M-ITX
(Mini-ITX Form Factor: 6.7-in x 6.7-in, 17.0 cm x 17.0 cm)
Guida di installazione rapida ASRock H61M-ITX
CD di supporto ASRock H61M-ITX
Due cavi dati Serial ATA (SATA) (opzionali)
Un cavo audio da 3,5 mm (opzionali)
Un I/O Shield
ASRock vi ricorda...

Italiano

Per ottenere migliori prestazioni in Windows 7 / 7 64-bit / VistaTM / VistaTM


64-bit, si consiglia di impostare l'opzione BIOS in Storage Configuration
(Configurazione di archiviazione) sulla modalit AHCI. Per l'impostazione
BIOS, fare riferimento a User Manual (Manuale dell'utente) nel CD di
supporto per dettagli.

52

ASRock H61M-ITX Motherboard

1.2 Specifiche
Piattaforma

Processore

Chipset
Memoria

Slot di
espansione
VGA su scheda

- Mini-ITX Form Factor: 6.7-in x 6.7-in, 17.0 cm x 17.0 cm


- Design condensatore compatto (condensatori a conduttore in
polimero di alta qualit realizzati al 100% in Giappone)
- Supporta Intel CoreTM i7 / i5 / i3 di seconda generazione in
pacchetto in LGA1155
- Supporto della tecnologia Intel Turbo Boost 2.0
- Supporta CPU unlocked serie K
- Supporto tecnologia Hyper Threading (vedi ATTENZIONE 1)
- Intel H61
- Supporto tecnologia Dual Channel Memory
(vedi ATTENZIONE 2)
- 2 x slot DDR3 DIMM
- Supporto DDR3 1333/1066 non-ECC, momoria senza buffer
- Capacit massima della memoria di sistema: 16GB
(vedi ATTENZIONE 3)
- 1 x Alloggi PCI Express 2.0 x16 (blu a modalit x16)
- Supporta Intel HD Graphics Built-in Visuals: Intel Quick Sync
Video, Intel InTruTM 3D, Intel Clear Video HD Technology,
Intel HD Graphics 2000/3000, Intel Advanced Vector
Extensions (AVX)
- Pixel Shader 4.1, DirectX 11 con CPU Intel Ivy Bridge,

Audio

ASRock H61M-ITX Motherboard

Italiano

DirectX 10.1 con CPU Intel Sandy Bridge


- Memoria massima condivisa 1759MB (vedi ATTENZIONE 4)
- Tre opzioni doutput VGA: D-Sub, DVI-D e HDMI
(vedi ATTENZIONE 5)
- Supporta HDMI 1.4a con risoluzione massima fino a
1920x1200 @ 60Hz
- Supporta DVI con risoluzione massima fino a 1920x1200 @
60Hz
- Supporta D-Sub con risoluzione massima fino a 2048x1536 @
75Hz
- Supporto delle funzioni Auto Lip Sync, xvYCC e HBR (High Bit
Rate Audio) con HDMI ( necessario un monitor compatibile
HDMI) (vedi ATTENZIONE 6)
- Supporto della funzione HDCP con le porte DVI e HDMI
- Supporto 1080p Blu-ray (BD) / HD-DVD riproduzione con le
porte DVI e HDMI
- 7.1 CH HD Audio (Realtek ALC887 Audio Codec)
- Supporto THX TruStudioTM

53

LAN

Pannello
posteriore I/O

USB 3.0
Connettori

BIOS

Italiano
54

- PCIE x1 Gigabit LAN 10/100/1000 Mb/s


- Realtek RTL8111E
- Supporta Wake-On-LAN
- Supporta il rilevamento cavo LAN
- Supporto di Energy Efficient Ethernet 802.3az
- Supporta PXE
I/O Panel
- 1 x porta PS/2 per tastiera
- 1 x Porta D-Sub
- 1 x Porta DVI-D
- 1 x Porta HDMI
- 1 x Porta ottica SPDIF Out
- 4 x porte USB 2.0 gi integrate
- 1 x Connettore eSATA2
- 2 x porte USB 3.0 gi integrate
- 1 x porte LAN RJ-45 con LED (LED azione/collegamento e
LED velocit)
- Connettore HD Audio: cassa posteriore / cassa centrale /
bassi / ingresso linea / cassa frontale / microfono
(vedi ATTENZIONE 7)
- 2 x porte USB 3.0 posteriori amministrate dal controller
ASMedia ASM1042, supporto di USB 1.0/2.0/3.0 fino a 5Gb/s
- 3 x connettori SATA2 3.0Go/s, sopporta delle funzioni NCQ,
AHCI e Hot Plug
- 1 x Connettore modulo infrarosso consumer
- 1 x LED di accensione
- Connettore ventolina CPU/telaio
- 24-pin collettore alimentazione ATX
- 4-pin connettore ATX 12V
- Connettore audio sul pannello frontale
- 2 x Collettore USB 2.0 (supporta 4 porte USB 2.0)
- 32Mb AMI BIOS
- AMI UEFI Legal BIOS con interfaccia di supporto
- Supporta Plug and Play
- Compatibile con ACPI 1.1 wake up events
- Supporta jumperfree
- Supporta SMBIOS 2.3.1

ASRock H61M-ITX Motherboard

CD di
supporto
Caratteristica
speciale

Monitoraggio
Hardware

Compatibilit SO
Certificazioni

- Driver, Utilit, Software AntiVirus (versione di prova),


CyberLink MediaEspresso 6.5 Trial, Suite software ASRock
(Suite CyberLink DVD OEM e Versione demo)
- ASRock Extreme Tuning Utility (AXTU) (vedi ATTENZIONE 8)
- ASRock Instant Boot
- ASRock Instant Flash (vedi ATTENZIONE 9)
- Caricatore ASRock APP Charger (vedi ATTENZIONE 10)
- ASrock SmartView (vedi ATTENZIONE 11)
- ASRock XFast USB (vedi ATTENZIONE 12)
- Tecnologia ASRock On/Off Play (vedi ATTENZIONE 13)
- Booster ibrido:
- ASRock U-COP (vedi ATTENZIONE 14)
- Boot Failure Guard (B.F.G.)
- LED notturno
- Sensore per la temperatura del processore
- Sensore temperatura scheda madre
- Indicatore di velocit per la ventola del CPU/Chassis/
Alimentazione
- Ventola CPU/Chassis silenziosa (permette la regolazione
automatica della ventola dello chassis in base alla temperatura
della CPU madre)
- Ventola CPU/Chassis con controllo di varie velocit
- Voltaggio: +12V, +5V, +3.3V, Vcore
- Microsoft Windows 7 / 7 64 bit / VistaTM / VistaTM 64 bit / XP /
XP 64 bit
- FCC, CE, WHQL
- Predisposto ErP/EuP ( necessaria lalimentazione
predisposta per il sistema ErP/EuP) (vedi ATTENZIONE 15)

* Per ulteriori informazioni, prego visitare il nostro sito internet: http://www.asrock.com

ASRock H61M-ITX Motherboard

Italiano

AVVISO
Si prega di prendere atto che la procedura di overclocking implica dei rischi, come
anche la regolazione delle impostazioni del BIOS, lapplicazione della tecnologia
Untied Overclocking Technology, oppure luso di strumenti di overclocking forniti da
terzi. Loverclocking pu influenzare la stabilit del sistema, ed anche provocare
danni ai componenti ed alle periferiche del sistema. La procedura eseguita a pro
prio rischio ed a proprie spese. Noi non possiamo essere ritenuti responsabili per
possibili danni provocati dalloverclocking.

55

ATTENZIONE!
1.
2.

3.

4.

5.

6.

Per il settaggio della Tecnologia Hyper-Threading, per favore controllare


pagina 39 del Manuale dellutente allinterno del CD di supporto.
Questa scheda madre supporta la tecnologia Dual Channel Memory. Prima
di implementare la tecnologia Dual Channel Memory, assicurarsi di leggere
la guida allinstallazione dei moduli di memoria, a pagina 14, per seguire
uninstallazione appropriata.
A causa delle limitazioni del sistema operativo, le dimensioni effettive della
memoria possono essere inferiori a 4GB per laccantonamento riservato
alluso del sistema sotto Windows 7 / VistaTM / XP. Per Windows OS con
CPU 64-bit, non c tale limitazione.
La dimensione massima della memoria condivisa viene stabilita dal venditore del chipset ed e soggetta a modificazioni. Prego fare riferimento al
sito internet Intel per le ultime informazioni.
Si pu solo scegliere di usare due dei tre monitor. I monitor D-Sub, DVID e HDMI non possono essere abilitati contemporaneamente. Inoltre,
usando ladattatore DVI a HDMI la porta DVI-D pu supportare le stesse
funzioni della porta HDMI.
Le funzioni xvYCC sono supportate solo sotto Windows 7 64-bit / 7. La
funzione HBR supportata sotto Windows 7 64-bit / 7 / VistaTM 64-bit /
VistaTM.

7.

Questa scheda madre supporta lingresso stereo e mono per il microfono.


Questa scheda madre supporta le modalit 2 canali, 4 canali, 6 canali e
8 canali per luscita audio. Controllare la tavola a pagina 3 per eseguire il
collegamento appropriato.

8.

Lutilit AXTU (ASRock Extreme Tuning Utility) uno strumento tutto


in uno per regolare varie funzioni del sistema in uninterfaccia facile da
usare che include monitoraggio hardware, controllo ventola, overclocking,
OC DNA ed IES. Hardware Monitor (Monitoraggio hardware) mostra le
letture principali del sistema. Fan Control (Controllo ventola) mostra la
velocit e la temperatura che possono essere regolate. Overclocking
permette di eseguire loverclocking della frequenza della CPU per
ottenere le prestazioni ottimali del sistema. OC DNA permette di salvare
le impostazioni OC come un profilo da condividere con gli amici! Gli amici
possono scaricare il profilo OC sul loro sistema operativo per ottenere le
stesse impostazioni OC Il regolatore di tensione di IES (Intelligent Energy

Italiano

Saver) pu ridurre il numero di fasi duscita per migliorare lefficienza


quando i core CPU sono inattivi senza sacrificare le prestazioni di
computazione. Vistare il nostro per informazioni sulle procedure operative
dellutilit AXTU (ASRock Extreme Tuning Utility).
Sito ASRock: http://www.asrock.com

56

ASRock H61M-ITX Motherboard

9.

ASRock Instant Flash una utilit Flash BIOS integrata nella Flash ROM.
Questo comodo strumento daggiornamento del BIOS permette di aggiornare il sistema BIOS senza accedere a sistemi operativi come MS-DOS
or Windows. Con questa utilit, si pu premere il tasto <F6> durante il
POST, oppure il tasto <F2> nel menu BIOS per accedere ad ASRock In-

stant Flash. Avviare questo strumento e salvare il nuovo file BIOS nellunit
Flash USB, dischetto (disco floppy) o disco rigido; poi si pu aggiornare il
BIOS con pochi clic, senza preparare altri dischetti (dischi floppy) o altre
complicate utilit Flash. Si prega di notare che lunit Flash USB o il disco
rigido devono usare il File System FAT32/16/12.
10. Se vuoi un modo rapido e indipendente per caricare i dispositivi Apple,
come iPhone/iPod/iPad Touch, ASRock ha preparato una soluzione
meravigliosa: ASRock APP Charger. Basta installare il driver APP Charger per caricare liPhone pi rapidamente rispetto al computer, con una
velocit maggiore del 40%. ASRock APP Charger permette di caricare
simultaneamente molti dispositivi Apple in modo rapido e supporta anche il
caricamento continuato quando il PC accede alla modalit di Standby (S1),
Sospensione su RAM (S3), Ibernazione (S4) o Spegnimento (S5). Una
volta installato il driver APP Charger si otterranno prodigi e comodit mai
avuti prima.
Sito ASRock: http://www.asrock.com/Feature/AppCharger/index.asp
11. SmartView, una nuova funzione di browser Internet, la pagina iniziale
intelligente di IE che unisce i siti web pi visitati, la cronologia, gli amici di
Facebook e il newsfeed in tempo reale in una visione migliorata per una
esperienza Internet pi personale. Le schede madri ASRock sono dotate
in modo esclusivo dellutility SmartView, che consente di mantenersi
sempre in contatto con gli amici. Per utilizzare la funzione SmartView, assicurarsi che la versione del sistema operativo sia Windows 7 / 7 64 bit

ASRock H61M-ITX Motherboard

Italiano

/ VistaTM / VistaTM 64 bit e che la versione del browser sia IE8. Sito web
ASRock: http://www.asrock.com/Feature/SmartView/index.asp
12. ASRock XFast USB pu accelerare le prestazioni del dispositivo
darchiviazione USB. Le prestazioni dipendono dalle propriet del
dispositivo.
13. La tecnologia ASRock On/Off Play consente agli utenti di godere di una
esperienza audio eccezionale tramite i dispositivi audio portatili come i
lettori MP3 o il cellulare sul proprio PC, anche quando il PC spento (oppure in modalit ACPI S5)! Questa scheda madre fornisce inoltre un cavo
audio libero da 3,5 mm (opzionale) che garantisce agli utenti lambiente
di elaborazione pi comodo.
14. Se il processore si surriscalda, il sistema si chiude automaticamente. Prima di riavviare il sistema, assicurarsi che la ventolina CPU della scheda
madre funzioni correttamente; scollegare e ricollegare il cavo dalimentazione. Per migliorare la dissipazione del calore, ricordare di applicare
lapposita pasta siliconica tra il processore e il dissipatore quando si
installa il sistema.

57

15. EuP, che sta per Energy Using Product (Prodotto che consuma energia) ,
era una normativa emanata dallUnione Europea che definiva il consumo
energetico del sistema completo. In base allEuP, lalimentazione totale
del sistema completo deve essere inferiore a 1,00 W quando spento.
Per soddisfare la norma EuP sono necessari un alimentatore e una
scheda elettrica predisposti EuP. In base ai suggerimenti Intel lalimentatore predisposto EuP deve soddisfare lo standard secondo cui lefficienza
energetica in standby di 5 v pi alta del 50% con un consumo di corrente di 100 mA. Per la scelta di unalimentatore predisposto EuP consigliamo di verificare ulteriori dettagli con il produttore.

Italiano
58

ASRock H61M-ITX Motherboard

1.3

Setup dei Jumpers

Lillustrazione mostra come sono settati i jumper. Quando il ponticello posizionato sui pin,
il jumper CORTOCIRCUITATO. Se sui pin
non ci sono ponticelli, il jumper APERTO.
Lillustrazione mostra un jumper a 3 pin in cui il
pin1 e il pin2 sono CORTOCIRCUITATI quando il ponticello posizionato su questi pin.
Jumper
Settaggio del Jumper
Resettare la CMOS
(CLRCMOS1)
(vedi p.2 item 5)

Impostazione
predefinita

Azzeramento CMOS

Nota: CLRCMOS1 permette si azzerare i dati nella CMOS. Per cancellare e ripristinare
i parametri del sistema sulla configurazione iniziale, spegnere il computer e
scollegare il cavo dalimentazione dalla presa di corrente. Attendere 15 secondi,

Italiano

poi usare un cappuccio jumper per cortocircuitare il pin 2 ed il pin 3 su


CLRCMOS1 per 5 secondi. Tuttavia, si consiglia di non cancellare la CMOS
subito dopo avere aggiornato il BIOS. Se si deve azzerare la CMOS quando si
completato laggiornamento del BIOS, necessario per prima cosa avviare il
sistema e poi spegnerlo prima di eseguire lazzeramento della CMOS. Notare
che password, data, ore e profilo utente predefinito saranno cancellati solo se
rimossa la batteria della CMOS.

ASRock H61M-ITX Motherboard

59

1.4

Collettori e Connettori su Scheda


I collettori ed i connettori su scheda NON sono dei jumper. NON installare cappucci per jumper su questi collettori e connettori. Linstallazione
di cappucci per jumper su questi collettori e connettori provocher
danni permanenti alla scheda madre!

Connettori Serial ATAII


(SATA_0 (PORT 0):
vedi p.2 Nr. 3)

SATA_0 (PORT 0) SATA_2 (PORT 4)

Questi tre connettori Serial


ATAII (SATAII) supportano cavi
dati SATA per dispositivi di

vedi p.2 Nr. 4)

immagazzinamento interni.
ATAII (SATAII) supportano cavi
SATA per dispositivi di memoria
interni. Linterfaccia SATAII
attuale permette velocit di
trasferimento dati fino a
3.0 Gb/s.

Cavi dati Serial ATA (SATA)

Una o altra estremit del cavo

(Opzionale)

di dati SATA pu essere


collegata al disco rigido SATA /
SATAII o al connettore
di SATAII su questa
cartolina base.

Cavo audio da 3,5 mm

Una delle estremit del cavo


audio da 3,5 mm pu essere
collegata ai dispositivi audio
portatili come lettori MP3 o
cellulari, oppure alla porta
Line-in del computer.

(SATA_1 (PORT 1):


vedi p.2 Nr. 2)

SATA_1 (PORT 1)

(SATA_2 (PORT 4):

(Opzionale)

Collettore USB 2.0


(9-pin USB6_7)
(vedi p.2 Nr. 10)

Italiano
USB_PWR
P-9
P+9
GND
DUMMY

(9-pin USB8_9)
(vedi p.2 Nr. 8)

Oltre alle quattro porte USB 2.0


predefinite nel pannello I/O, la
scheda madre dispone di
due intestazioni USB 2.0.
Ciascuna intestazione USB 2.0
supporta due porte USB 2.0.

1
GND
P+8
P-8
USB_PWR

60

ASRock H61M-ITX Motherboard

Connettore modulo infrarosso consumer

Questo connettore pu essere

(4-pin CIR1)

utilizzato per collegare


ricevitore remoto.

1
GND
IRTX
IRRX
ATX+5VSB

(vedi p.2 Nr. 9)

GND
PRESENCE#
MIC_RET
OUT_RET

Connettore audio sul


pannello frontale
(9-pin HD_AUDIO1)
1

(vedi p.2 Nr. 14)

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

uninterfaccia per il cavo del


pannello audio. Che consente
connessione facile e controllo
dei dispositivi audio.

1. La caratteristica HDA (High Definition Audio) supporta il rilevamento dei


connettori, per il pannello dei cavi sul telaio deve supportare la funzione
HDA (High Definition Audio) per far s che questa operi in modo corretto.
Attenersi alle istruzioni del nostro manuale e del manuale del telaio per
installare il sistema.
2. Se si utilizza un pannello audio AC97, installarlo nellintestazione audio
del pannello anteriore, come indicato di seguito:
A. Collegare Mic_IN (MIC) a MIC2_L.
B. Collegare Audio_R (RIN) a OUT2_R e Audio_L (LIN) ad OUT2_L.
C. Collegare Ground (GND) a Ground (GND).
D. MIC_RET e OUT_RET sono solo per il pannello audio HD. Non
necessario collegarli per il pannello audio AC97.
E. Per attivare il microfono frontale.
Sistema operativo Windows XP / XP 64-bit:
Selezionare Mixer. Selezionare Recorder (Registratore). Poi, fare
clic su FrontMic (Microfono frontale).
Sistema operativo Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit:

Collettore pannello di sistema


(9-pin PANEL1)

Questo collettore accomoda


diverse funzioni di sistema

(vedi p.2 Nr. 1)

pannello frontale.

Italiano

Andare alla scheda FrontMic (Microfono frontale) del pannello di


controllo Realtek. Regolare la voce Recording Volume (Volume
registrazione).

Collegare linterruttore dalimentazione, linterruttore di ripristino,


lindicatore di stato del sistema del pannello frontale del telaio a questo
header in base allassegnazione dei pin definita di seguito. Determinare i
pin positivi e negativi prima di collegare i cavi.
PWRBTN (interruttore dalimentazione):
Va collegato allinterruttore dalimentazione del pannello frontale del
telaio. Usando linterruttore dalimentazione si pu configurare il modo in
cui si spegne il sistema.

ASRock H61M-ITX Motherboard

61

RESET (interruttore di ripristino):


Va collegato allinterruttore di ripristino del pannello frontale del telaio.
Premere linterruttore di ripristino per riavviare il sistema se il computer si
blocca e non riesce ad eseguire un normale riavvio.
PLED (LED alimentazione del sistema):
Va collegato allindicatore di stato dalimentazione del pannello frontale
del telaio. Il LED acceso quando il sistema operativo. Il LED continua
a lampeggiare quando il sistema in stato di standby S1. Il LED
spento quando il sistema in stato di sospensione /ibernazione S3/S4
oppure spento (S5).
HDLED (LED attivit disco rigido):
Va collegato al LED attivit disco rigido del pannello frontale del telaio. Il
LED acceso quando disco rigido legge e scrive i dati.
Il design del pannello frontale pu variare in base ai telai. Il modulo di
un pannello frontale pu consistere di: interruttore dalimentazione,
interruttore di ripristino, LED dalimentazione, LED attivit disco rigido,
casse, eccetera. Quando si collega il modulo del pannello frontale a
questo header, assicurarsi che lassegnazione dei fili e dei pin sia fatta
corrispondere in modo appropriato.

LED di accensione
(3-pin PLED1)

1
PLEDPLED+
PLED+

(vedi p.2 Nr. 19)

Collettori Chassis ventola

Collegare i cavi della ventola ai


corrispondenti connettori

(3-pin CHA_FAN1)

facendo combaciare il cavo


nero col pin di terra.

(vedi p.2 Nr. 18)

Connettore ventolina CPU

4 3 2 1

Italiano

(4-pin CPU_FAN1)
(vedi p.2 Nr. 17)

62

Collegare il LED di accensione


chassi per indicare lo stato di
alimentazione del sistema. Il
LED acceso quando il sistema
in funzione. Il LED continua a
lampeggiare in stato S1. Il LED
spento in stato S3/S4 o S5
(spegnimento).

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

Collegare il cavo della ventolina


CPU a questo connettore e far
combaciare il filo nero al pin
terra.

ASRock H61M-ITX Motherboard

Sebbene la presente scheda madre disponga di un supporto per ventola


CPU a 4 piedini (ventola silenziosa), la ventola CPU a 3 piedini in
grado di funzionare anche senza la funzione di controllo della velocit
della ventola. Se si intende collegare la ventola CPU a 3 piedini al
connettore della ventola CPU su questa scheda madre, collegarla ai
piedini 1-3.
Piedini 1-3 collegati
Installazione della ventola a 3 piedini

Connettore alimentazione ATX

24

13

12

(24-pin ATXPWR1)
(vedi p.2 Nr. 7)

Collegare la sorgente
dalimentazione ATX a questo
connettore.

Con questa scheda madre, c in dotazione un connettore elettrico ATX


a 24 pin, ma pu funzionare lo stesso se si adotta un alimentatore ATX a
20 pin. Per usare lalimentatore ATX a 20 pin, collegare lalimentatore
24
13
con il Pin 1 e il Pin 13.

Installazione dellalimentatore ATX a 20 pin

Connettore ATX 12 V
(4-pin ATX12V1)

12

Collegare un alimentatore ATX


12 V a questo connettore.

Italiano

(vedi p.2 Nr. 15)

ASRock H61M-ITX Motherboard

63

2. Informazioni sul BIOS


La Flash Memory sulla scheda madre contiene le Setup Utility. Quando si avvia il
computer, premi <F2> o <Del> durante il Power-On-Self-Test (POST) della Setup
utility del BIOS; altrimenti, POST continua con i suoi test di routine. Per entrare il
BIOS Setup dopo il POST, riavvia il sistema premendo <Ctl> + <Alt> + <Delete>, o
premi il tasto di reset sullo chassis del sistema. Per informazioni pi dettagliate circa
il Setup del BIOS, fare riferimento al Manuale dellUtente (PDF file) contenuto nel cd
di supporto.

3. Software di supporto e informazioni su


CD
Questa scheda madre supporta vari sistemi operativi Microsoft Windows: 7 /
7 64-bit / VistaTM / VistaTM 64-bit / XP / XP 64-bit. Il CD di supporto a corredo della
scheda madre contiene i driver e utilit necessari a potenziare le caratteristiche
della scheda.
Inserire il CD di supporto nel lettore CD-ROM. Se la funzione AUTORUN attivata
nel computer, apparir automaticamente il Men principale. Se il Men principale
non appare automaticamente, posizionarsi sul file ASSETUP.EXE nel CESTINO
del CD di supporto e cliccare due volte per visualizzare i men.

Italiano
64

ASRock H61M-ITX Motherboard

1. Introduccin
Gracias por su compra de ASRock H61M-ITX placa madre, una placa de confianza
producida bajo el control de calidad estricto y persistente. La placa madre provee
realizacin excelente con un diseo robusto conforme al compromiso de calidad y
resistencia de ASRock.
Esta Gua rpida de instalacin contiene una introduccin a la placa base y una
gua de instalacin paso a paso. Puede encontrar una informacin ms detallada
sobre la placa base en el manual de usuario incluido en el CD de soporte.
Porque las especificaciones de la placa madre y el software de BIOS
podran ser actualizados, el contenido de este manual puede ser cambiado
sin aviso. En caso de cualquier modificacin de este manual, la versin
actualizada estar disponible en el website de ASRock sin previo aviso.
Tambin encontrar las listas de las ltimas tarjetas VGA y CPU soportadas
en la pgina web de ASRock.
Website de ASRock http://www.asrock.com
Si necesita asistencia tcnica en relacin con esta placa base, visite
nuestra pgina web con el nmero de modelo especfico de su placa.
www.asrock.com/support/index.asp

1.1 Contenido de la caja


Placa base ASRock H61M-ITX
(Factor forma Mini-ITX: 17,0 cm x 17,0 cm, 6,7 x 6,7)
Gua de instalacin rpida de ASRock H61M-ITX
CD de soporte de ASRock H61M-ITX
Dos cables de datos Serial ATA (SATA) (Opcional)
Una Cable de audio de 3,5 mm (Opcional)
Una proteccin I/O
ASRock le recuerda...

ASRock H61M-ITX Motherboard

Espaol

Para mejorar el rendimiento en Windows 7 / 7 64 bits / VistaTM / VistaTM


64 bits, es recomendable establecer la opcin del BIOS de la configuracin de almacenamiento en el modo AHCI. Para obtener detalles sobre
la configuracin del BIOS, consulte el Manual del usuario que se encuentra en nuestro CD de soporte.

65

1.2 Especificacin
Plataforma

Procesador

- Factor forma Mini-ITX: 17,0 cm x 17,0 cm, 6,7 x 6,7


- Todo diseo de Capacitor Slido (condensadores de
polmero conductor de alta calidad 100% fabricados en
Japn)
- Admite los procesadores Intel CoreTM i7 / i5 / i3 de segunda

Chipset

generacin en el paquete LGA1155


- Admite la tecnologa Intel Turbo Boost 2.0 Technology
- Admite procesador desbloqueado de la serie K
- Admite tecnologa Hyper Threading (ver ATENCIN 1)
- Intel H61

Memoria

Ranuras de
Expansin
VGA OnBoard

- Soporte de Tecnologa de Memoria de Doble Canal


(ver ATENCIN 2)
- 2 x DDR3 DIMM slots
- Apoya DDR3 1333/1066 non-ECC, memoria de un-buffered
- Mxima capacidad de la memoria del sistema: 16GB
(vea ATENCIN 3)
- 1 x ranura PCI Express 2.0 x16 (azul @ modo x16)
- Admite Intel HD Graphics Built-in Visuals: Intel Quick Sync
Video, Intel InTruTM 3D, Intel Clear Video HD Technology,
Intel HD Graphics 2000/3000 e Intel Advanced Vector

Espaol

Extensions (AVX)
- Pixel Shader 4.1, DirectX 11 con CPU Intel Ivy Bridge,
DirectX 10.1 con CPU Intel Sandy Bridge
- 1759MB de Memoria mxima compartida (vea ATENCIN 4)
- Tres opciones de salida VGA: D-Sub, DVI-D y HDMI
(ver ATENCIN 5)
- Admite HDMI 1.4a con una resolucin mxima de
1920x1200 a 60 Hz
- Admite DVI con una resolucin mxima de 1920x1200 a
60 Hz
- Admite D-Sub con una resolucin mxima de 2048x1536 a
75 Hz
- Admite Sincronizacin automtica entre audio y vdeo,
xvYCC y HBR (audio de alta tasa de bits) con HDMI
(se necesita un monitor compatible con HDMI)
(ver ATENCIN 6)
- Admite la funcin HDCP con puertos DVI y HDMI
- Apoya la reproduccin de Blu-rayo de 1080p (BD) / HD-DVD
con puertos DVI y HDMI

66

ASRock H61M-ITX Motherboard

Audio

- 7.1 CH HD Audio (Realtek ALC887 Audio Codec)


- Compatible con THX TruStudioTM

LAN

- PCIE x1 Gigabit LAN 10/100/1000 Mb/s


- Realtek RTL8111E
- Soporta Wake-On-LAN
- Admite deteccin de conexin de cable LAN
- Compatible con Ethernet 802.3az de bajo consumo
energtico
- Compatible con PXE
I/O Panel
- 1 x puerto de teclado PS/2
- 1 x puerto D-Sub
- 1 x puerto DVI-D
- 1 x puerto HDMI
- 1 x puerto de salida ptica SPDIF
- 4 x puertos USB 2.0 predeterminados
- 1 x Conector eSATA2
- 2 x puertos USB 3.0 predeterminados
- 1 x Puerto LAN RJ-45 con LED (LED de ACCIN/ENLACE y
LED de VELOCIDAD)
- Conexin de audio: Altavoz trasero / Central/Bajos /
Entrada de lnea / Altavoz frontal / Micrfono
(ver ATENCIN 7)
- 2 x puertos USB 3.0 traseros de ASMedia ASM1042,
compatible con USB 1.0/2.0/3.0 de hasta 5 GB/s
- 3 x conexiones SATA2, admiten una velocidad de
transferencia de datos de hasta 3,0Gb/s, soporta NCQ, AHCI
y Conexin en caliente
- 1 x Base de conexiones del mdulo de infrarrojos para el

Entrada/Salida
de Panel
Trasero

USB 3.0
Conectores

consumidor
- 1 x cabecera de indicador LED de encendido

ASRock H61M-ITX Motherboard

Espaol

BIOS

- Conector de ventilador de CPU / chasis


- 24-pin cabezal de alimentacin ATX
- 4-pin conector de ATX 12V power
- Conector de audio de panel frontal
- 2 x Cabezal USB 2.0 (admite 4 puertos USB 2.0 adicionales)
- 32Mb AMI BIOS
- BIOS legal UEFI AMI compatible con GUI
- Soporta Plug and Play
- ACPI 1.1 compliance wake up events
- Soporta jumper free

67

CD de soport

Caracterstica
nica

Monitor
Hardware

OS
Certificaciones

- Soporta SMBIOS 2.3.1


- Controladores, utilidades, software de antivirus (versin de
prueba), Prueba de CyberLink MediaEspresso 6.5, conjunto
de aplicaciones ASRock (CyberLink DVD Suite - OEM y
versin de prueba)
- ASRock Extreme Tuning Utility (AXTU) (vea ATENCIN 8)
- ASRock Instant Boot
- ASRock Instant Flash (vea ATENCIN 9)
- ASRock APP Charger (vea ATENCIN 10)
- ASRock SmartView (vea ATENCIN 11)
- ASRock XFast USB (vea ATENCIN 12)
- Tecnologa de activacin y desactivacin de la
reproduccin de ASRock (vea ATENCIN 13)
- Amplificador Hbrido:
- ASRock U-COP (vea ATENCIN 14)
- Proteccin de Falla de Inicio (B.F.G..)
- Indicador LED nocturno
- Sensibilidad a la temperatura del procesador
- Sensibilidad a la temperatura de la placa madre
- Taqumetros de los ventiladores del procesador y del CPU /
chasis
- Ventilador silencioso del procesador y el chasis (ajuste
automtico de la velocidad del ventilador del chasis en
funcin de la temperatura del procesador)
- Control de ajuste de la velocidad del ventilador de la CPU /
chasis
- Monitor de Voltaje: +12V, +5V, +3.3V, Vcore
- En conformidad con Microsoft Windows 7 / 7 64 bits /
VistaTM / VistaTM 64 bits / XP / XP 64 bits
- FCC, CE, WHQL
- Cumple con la directiva ErP/EuP (se requiere una fuente de
alimentacin que cumpla con la directiva ErP/EuP)
(vea ATENCIN 15)

Espaol

* Para ms informacin sobre los productos, por favor visite nuestro sitio web:
http://www.asrock.com

68

ASRock H61M-ITX Motherboard

ADVERTENCIA
Tenga en cuenta que hay un cierto riesgo implcito en las operaciones de aumento
de la velocidad del reloj, incluido el ajuste del BIOS, aplicando la tecnologa de
aumento de velocidad liberada o utilizando las herramientas de aumento de
velocidad de otros fabricantes. El aumento de la velocidad puede afectar a la
estabilidad del sistema e, incluso, daar los componentes y dispositivos del
sistema. Esta operacin se debe realizar bajo su propia responsabilidad y Ud. debe
asumir los costos. No asumimos ninguna responsabilidad por los posibles daos
causados por el aumento de la velocidad del reloj.

ATENCIN !
2.

3.

4.

5.

6.

7.

8.

Por favor consulte pgina 39 del Manual del Usuario en el soporte CD


sobre la configuracin de Hyper-Threading Technology.
Esta placa base soporta Tecnologa de Memoria de Doble Canal. Antes
de implementar la Tecnologa de Memoria de Doble Canal, asegrese de
leer la gua de instalacin de mdulos de memoria en la pgina 14 para
su correcta instalacin.
Debido a las limitaciones del sistema, el tamao real de la memoria debe
ser inferior a 4GB para que el sistema pueda funcionar bajo Windows
7 / VistaTM / XP. Para equipos con Windows OS con CPU de 64-bit, no
existe dicha limitacin.
El tamao de la memoria compartido mximo es definido por el vendedor
del chipset y est conforme al cambio. Por favor compruebe el Web site
de Intel para la informacin ms ltima.
Puede elegir entre dos de los tres monitores solamente. Los monitores
D-Sub, DVI-D y HDMI no se pueden habilitar al mismo tiempo. Adems,
con el adaptador DVI a HDMI, el puerto DVI-D puede admitir las mismas
funciones que el puerto HDMI.
Las funciones xvYCC solamente se admiten con el sistema operativo
Windows 7 de 64 bits/ 7. HBR se admite en Windows 7 64 bits / 7 /
VistaTM 64 bits / VistaTM.
Para la entrada de micrfono, esta placa madre ofrece soporte para
modos estreo y mono. Para salida de audio, este placa madre ofrece
soporte para modos de 2 canales, 4 canales, 6 canales y 8 canales.
Consulte la tabla en la pgina 3 para una conexin correcta.
ASRock Extreme Tuning Utility (AXTU) es una herramienta todo en
uno que permite realizar ajustes precisos en diferentes funciones del
sistema mediante una interfaz sencilla, que incluye supervisin de
hardware, control de ventiladores, funcin de aumento de la velocidad
del reloj, DNA OC y IES. La funcin de supervisin de hardware,
muestra las principales lecturas del sistema. La funcin de control de los
ventiladores, muestra la velocidad y la temperatura de los ventiladores y
permite ajustarlas. La funcin de aumento de la velocidad del reloj,
permite aumentar la frecuencia de la CPU para conseguir un

ASRock H61M-ITX Motherboard

Espaol

1.

69

rendimiento ptimo del sistema. La funcin DNA OC permite guardar la


configuracin OC como un perfil y compartirla con sus amigos. Despus,
sus amistados pueden cargar el perfil OC en sus propios sistemas para
obtener la misma configuracin OC. En el protector de energa
inteligente (IES, Intelligent Energy Saver), el regulador de voltaje puede
reducir el nmero de fases de salida para mejorar la eficiencia cuando
los ncleos de la CPU estn inactivos sin que el rendimiento de clculo
disminuya. Visite nuestro sitio Web para obtener los procedimientos de
funcionamiento de ASRock Extreme Tuning Utility (AXTU).
Sitio Web de ASRock: http://www.asrock.com
9.

ASRock Instant Flash es una utilidad de programacin del BIOS que


se encuentra almacenada en la memoria Flash ROM. Esta sencilla herramienta de actualizacin de BIOS le permitir actualizar el BIOS del
sistema sin necesidad de acceder a ningn sistema operativo, como MSDOS o Windows. Gracias a esta utilidad, slo necesitar pulsar <F6>

durante la fase POST o pulsar <F2> para acceder al men de configuracin del BIOS y a la utilidad ASRock Instant Flash. Ejecute esta herramienta y guarde el archivo correspondiente al sistema BIOS nuevo
en su unidad flash USB, unidad de disco flexible o disco duro para poder
actualizar el BIOS con slo pulsar un par de botones, sin necesidad de
preparar un disco flexible adicional ni utilizar complicadas utilidades de
programacin. Recuerde que la unidad flash USB o disco duro utilizado
debe disponer del sistema de archivos FAT32/16/12.
10. Si desea una forma ms rpida y menos limitada de cargar sus dispositivos de Apple; como por ejemplo iPhone, iPod o iPad Touch, ASRock
ha creado una fantstica solucin para usted: ASRock APP Charger.
Simplemente mediante la instalacin del controlador de APP Charger,
podr cargar su iPhone de forma mucho ms rpida que antes, hasta un
40%, desde su equipo. ASRock APP Charger le permite cargar de forma
rpida muchos dispositivos de Apple simultneamente e incluso podr
continuar la carga cuando su PC entre en modo de espera (S1), suspendido en RAM (S3), modo de hibernacin (S4) o se apague (S5). Una vez
instalado el controlador de APP Charger, podr disfrutar fcilmente de
una fantstica carga sin precedentes.
Sitio web de ASRock: http://www.asrock.com/Feature/AppCharger/index.
asp
11. SmartView, una nueva funcin el explorador de Internet, es la pgina de

Espaol

inicio inteligente para IE que combina los sitios Web ms visitados, su


historial, sus amigos de Facebook y su fuente de noticias en una vista
mejorada para disfrutar de una experiencia en Internet ms personal.
Las placas base ASRock estn exclusivamente equipadas con la utilidad
SmartView que le ayuda a seguir en contacto con sus amigos sobre la
marcha. Para utilizar la funcin SmartView asegrese de que la versin
de su sistema operativo es Windows 7 / 7 64 bits / VistaTM / VistaTM 64
bits y que la versin de su explorador es IE8. Sitio Web de ASRock:
http://www.asrock.com/Feature/SmartView/index.asp

70

ASRock H61M-ITX Motherboard

Espaol

12. ASRock XFast USB puede aumentar el rendimiento de los dispositivos


de almacenamiento USB. El rendimiento depende de las propiedades
del dispositivo.
13. La tecnologa de activacin y desactivacin de la reproduccin de ASRock permite a los usuarios disfrutar de una excelente experiencia de
audio de los dispositivos de audio porttiles, como por ejemplo reproductores MP3 o telfonos mviles, en su PC, incluso cuando su PC est
apagado (o en el modo ACPI S5)! Esta placa base tambin proporciona
un cable de audio de 3,5 mm (opcional) que garantiza a los usuarios el
entorno de clculo ms prctico.
14. Cuando la temperatura de CPU est sobre-elevada, el sistema va a
apagarse automaticamente. Antes de reanudar el sistema, compruebe si
el ventilador de la CPU de la placa base funciona
apropiadamente y desconecte el cable de alimentacin, a continuacin,
vuelva a conectarlo. Para mejorar la disipacin de calor, acurdese de
aplicar thermal grease entre el procesador y el disipador de calor cuando
usted instala el sistema de PC.
15. EuP, siglas de Energy Using Product (Producto que Utiliza Energa),
es una disposicin regulada por la Unin Europea para establecer el
consumo total de energa de un sistema. Segn la disposicin EuP, la
alimentacin de CA total para el sistema completo ha de ser inferior a
1,00W en modo apagado. Para cumplir con el estndar EuP, se
requieren una placa base y una fuente de alimentacin que cumplan con la
directiva EuP. Segn las directrices de Intel, una fuente de alimentacin
que cumpla con la directiva EuP debe satisfacer el estndar, es decir,
la eficiencia de energa de 5v en modo de espera debera ser mayor
del 50% con un consumo de corriente de 100mA. Para seleccionar una
fuente de alimentacin que cumpla la directiva EuP, le recomendamos
que consulte con el fabricante de la fuente de alimentacin para obtener
ms detalles.

ASRock H61M-ITX Motherboard

71

1.3

Setup de Jumpers

La ilustracin muestra como los jumpers


son configurados. Cuando haya un jumpercap sobre los pins, se dice gue el jumper
est Short. No habiendo jumper cap sobre
los pins, el jumper est Open. La ilustracin muesta un jumper de 3 pins cuyo
pin 1 y pin 2 estn Short.
Jumper
Limpiar CMOS

Setting

(CLRCMOS1, jumper de 3 pins)


(ver p.2, No. 5)

Valor predeterminado

Restablecimiento de
la CMOS

Nota: CLRCMOS1 permite borrar los datos de la memoria CMOS. Para borrar los
parmetros del sistema y restablecer la configuracin predeterminada de los mismos,
apague el equipo y desenchufe el cable de alimentacin de la toma de corriente
elctrica. Deje que transcurran 15 segundos y, despus, utilice un puente para
cortocircuitar los contactos 2 y 3 de CLRCMOS1 durante 5 segundos. No borre
la memoria CMOS justamente despus de actualizar el BIOS. Si necesita borrar
la memoria CMOS justamente despus de actualizar el BIOS, debe iniciar primero
el sistema y, a continuacin, cerrarlo antes de llevar a cabo el borrado de
dicha memoria. Tenga en cuenta que la contrasea, la fecha, la hora y el perfil
predeterminado del usuario solamente se borrar si la batera CMOS se quita.

Espaol
72

ASRock H61M-ITX Motherboard

1.4

Cabezales y Conectores en Placas


Los conectores y cabezales en placa NO son puentes. NO coloque
las cubiertas de los puentes sobre estos cabezales y conectores. El
colocar cubiertas de puentes sobre los conectores y cabezales provocar un dao permanente en la placa base.

(SATA_0 (PORT 0):

SATA_0 (PORT 0) SATA_2 (PORT 4)

vea p.2, N. 3)

Estas tres conexiones de


serie ATAII (SATAII) admiten
cables SATA para dispositivos

(SATA_2 (PORT 4):

de almacenamiento internos.
La interfaz SATAII actual
permite una velocidad de

vea p.2, N. 4)

transferencia de 3.0 Gb/s.

Cable de datos de
serie ATA (SATA)

Cualquier extremo del cable de


los datos de SATA puede ser
conectado con el disco duro
de SATA / SATAII o el
conectador de SATAII en esta
placa base.

(SATA_1 (PORT 1):


vea p.2, N. 2)

SATA_1 (PORT 1)

(Opcional)

Cable de audio de 3,5 mm

Cualquier extremo del cable de

(Opcional)

audio de 3,5 mm se puede


conectar a los dispositivos de
audio porttiles, como por
ejemplo reproductores MP3 y
telfonos mviles, o al puerto
Entrada de lnea de su PC.

Cabezal USB 2.0

Adems de cuatro puertos

(9-pin USB6_7)

USB 2.0 predeterminados en el


panel de E/S, hay dos bases
de conexiones USB 2.0 en
esta placa base. Cada una de
estas bases de conexiones

(vea p.2, N. 10)

USB_PWR
P-9
P+9
GND
DUMMY

(9-pin USB8_9)
(vea p.2, N. 8)

Espaol

Conexiones de serie ATAII

admite dos puertos USB 2.0.

1
GND
P+8
P-8
USB_PWR

ASRock H61M-ITX Motherboard

73

Base de conexiones del mdulo de


infrarrojos para el consumidor
(4-pin CIR1)

1
GND
IRTX
IRRX
ATX+5VSB

Esta base de conexiones se


puede utilizar para conectar
receptor remoto.

(vea p.2, N. 9)
GND
PRESENCE#
MIC_RET
OUT_RET

Conector de audio de
panel frontal
(9-pin HD_AUDIO1)
1

(vea p.2, N. 14)

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

Este es una interface para


cable de audio de panel frontal
que permite conexin y control
conveniente de apparatos de
Audio.

1. El Audio de Alta Definicin soporta la deteccin de conector, pero


el cable de panel en el chasis debe soportar HDA para operar
correctamente. Por favor, siga las instrucciones en nuestro manual y
en el manual de chasis para instalar su sistema.
2. Si utiliza el panel de sonido AC97, instlelo en la cabecera de sonido
del panel frontal de la siguiente manera:
A. Conecte Mic_IN (MIC) a MIC2_L.
B. Conecte Audio_R (RIN) a OUT2_R y Audio_L (LIN) en OUT2_L.
C. Conecte Ground (GND) a Ground (GND).
D. MIC_RET y OUT_RET son slo para el panel de sonido HD. No
necesitar conectarlos al panel de sonido AC97.
E. Activacin del micrfono frontal.
En sistemas operativos Windows XP / XP 64-bit:
Seleccione Mixer (Mezclador). Seleccione Recorder (Grabadora).
A continuacin, haga clic en FrontMic (Micrfono frontal).
En sistemas operativos Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit:
Acceda a la ficha FrontMic (Micrfono frontal) del panel de control
Realtek. Ajuste la posicin del control deslizante Recording Volume
(Volumen de grabacin).

Cabezal de panel de sistema


(9-pin PANEL1)
(vea p.2, N. 1)

Este cabezar acomoda varias


dunciones de panel frontal de
sistema.

Espaol

Conecte el interruptor de alimentacin, el interruptor de restablecimiento


y el indicador de estado del sistema situados en el chasis con esta
cabecera en funcin de las siguientes asignaciones de contacto. Preste
atencin a los contactos positivos y negativos antes de conectar los
cables.

74

ASRock H61M-ITX Motherboard

PWRBTN (interruptor de alimentacin):


Conecte el interruptor de encendido situado en el panel frontal del
chasis. Puede configurar la forma de apagar su sistema mediante el
interruptor de alimentacin.
RESTABLECER (interruptor de restablecimiento):
Conecte el interruptor de restablecimiento situado en el panel frontal del
chasis. Pulse el interruptor de restablecimiento para restablecer el
equipo si se bloquea y no se reinicia con normalidad.
PLED (LED de alimentacin del sistema):
Conecte el indicador de estado de alimentacin situado en el panel
frontal del chasis. El LED se enciende cuando el sistema est en
funcionamiento. El LED parpadea cuando el sistema se encuentre en
estado de suspensin S1. El LED se apaga cuando el sistema se
encuentre en estado de suspensin S3/S4 o se apaga (S5).
HDLED (LED de actividad del disco duro):
Conecte el LED de actividad de disco duro situado en el panel frontal
del chasis. El LED se enciende cuando el disco duro est leyendo o
escribiendo datos.
Es posible que el diseo del panel frontal vare en funcin del chasis. Un
mdulo del panel frontal consiste principalmente de interruptor de
alimentacin, interruptor de restablecimiento, LED de alimentacin, LED
de actividad del disco duro, altavoz, etc. Al conectar el mdulo del panel
frontal del chasis a esta cabecera, asegrese de que las asignaciones
de cables y las asignaciones de contactos coincidan correctamente.

(3-pin PLED1)
(vea p.2, N. 19)

1
PLEDPLED+
PLED+

Conectores de ventilador de chasis


(3-pin CHA_FAN1)
(vea p.2, N. 18)

Conecte el indicador LED de


encendido del chasis a esta
cabecera para conocer el
estado de encendido del
sistema. El indicador LED se
encender si el sistema se
encuentra en funcionamiento.
El indicador LED parpadear
en el estado S1. El indicador
LED se apagar en los estados
S3/S4 o S5 (apagado).

Espaol

Cabecera de indicador LED de encendido

Por favor, conecte los cables del


ventilador a los conectores de
ventilador, haciendo coincidir el
cable negro con la patilla de
masa.

ASRock H61M-ITX Motherboard

75

Conector del ventilador


de la CPU

4 3 2 1

(4-pin CPU_FAN1)

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

(vea p.2, N. 17)

Conecte el cable del ventilador


de la CPU a este conector y
haga coincidir el cable negro
con el conector de tierra.

Aunque esta placa base proporciona compatibilidad para un ventilador


(silencioso) de procesador de 4 contactos, el ventilador de procesador
de 3 contactos seguir funcionando correctamente incluso sin la funcin
de control de velocidad del ventilador. Si pretende enchufar el ventilador
de procesador de 3 contactos en el conector del ventilador de
procesador de esta placa base, conctelo al contacto 1-3.
Contacto 1-3 conectado
Instalacin del ventilador de 3 contactos

Cabezal de alimentacin ATX

24

13

12

(24-pin ATXPWR1)
(vea p.2, N. 7)

Conecte la fuente de
alimentacin ATX a su cabezal.

A pesar de que esta placa base incluye in conector de alimentacin ATX


de 24 pins, sta puede funcionar incluso si utiliza una fuente de alimen
tacin ATX de 20 pins tradicional. Para usar una fuente de alimentacin
ATX de 20 pins, por favor, conecte su fuente de alimentacin usando los
24
13
Pins 1 y 13.
Instalacin de una Fuente de Alimentacin ATX de 20 Pins
12

Conector de ATX 12V power

Tenga en cuenta que es

(4-pin ATX12V1)

necesario conectar este


conector a una toma de
corriente con el enchufe ATX
12V, de modo que proporcione
suficiente electricidad. De lo
contrario no se podr encender.

(vea p.2, N. 15)

Espaol
76

ASRock H61M-ITX Motherboard

2. BIOS Informacin
El Flash Memory de la placa madre deposita SETUP Utility. Durante el Power-Up
(POST) apriete <F2> o <Del> para entrar en la BIOS. S usted no oprime ninguna
tecla, el POST contina con sus rutinas de prueba. Si usted desea entrar en la
BIOS despus del POST, por favor reinicie el sistema apretando <Ctl> + <Alt> +
<Borrar>, o apretando el botn Reset en el panel del ordenador. Para informacin
detallada sobre como configurar la BIOS, por favor refirase al Manual del Usuario
(archivo PDF) contenido en el CD.

3. Informacin de Software Support CD


Esta placa-base soporta diversos tipos de sistema operativo Windows: 7 / 7 64
bits / VistaTM / VistaTM 64 bits / XP / XP 64 bits. El CD de instalacin que acompaa

Espaol

la placa-base trae todos los drivers y programas utilitarios para instalar y configurar
la placa-base. Para iniciar la instalacin, ponga el CD en el lector de CD y se desplegar el Men Principal automticamente si AUTORUN est habilitado en su
computadora.
Si el Men Principal no aparece automticamente, localice y doble-pulse en el archivo ASSETUP.EXE para iniciar la instalacin.

ASRock H61M-ITX Motherboard

77

1.
ASRock H61M-ITX
, ASRock
.
, ASRock
.

.
- .

BIOS ,
.

- ASRock . ,

ASRock.
- ASRock
http://www.asrock.com

-
.
www.asrock.com/support/index.asp

1.1
ASRock H61M-ITX
(- Mini-ITX: 6,7 x 6,7 / 17,0 x 17,0 )
ASRock H61M-ITX
- ASRock H61M-ITX
2 x Serial ATA (SATA) ()
1 x 3,5- ()
1 x I/O /

ASRock ...

Windows
7 / 7 64-bit / VistaTM / VistaTM 64-bit BIOS
Storage Configuration (
) AHCI. BIOS .
-.

78

ASRock H61M-ITX Motherboard

1.2

- - Mini-ITX: 6,7 x 6,7 / 17,0 x 17,0


- (
; 100%
)
- Intel CoreTM i7 / i5 / i3 2-
LGA1155
- Intel Turbo Boost 2.0
- K
- Hyper-Threading
(. , 1)
- Intel H61
- Dual Channel DDR3 Memory Technology
(. , 2)
- 2 x DDR3 DIMM
- DDR3 1333/1066 - ECC,
- : 16
(. , 3)
- 1 x PCI Express 2.0 x16 ( x16)
- Intel HD: Intel
Quick Sync Video, Intel InTruTM 3D, Intel Clear Video HD,
Intel HD Graphics 2000/3000, Intel Advanced Vector Extensions (AVX)
- Pixel Shader 4.1, DirectX 11 Intel Ivy Bridge,
DirectX 10.1 Intel Sandy Bridge
- . 1759
(. , 4)
- VGA-: D-Sub, DVI-D HDMI (. , 5)
- HDMI 1.4a 19201200
@ 60
- DVI 19201200 @
60
- D-Sub 20481536 @
75
- Auto Lip Sync, xvYCC HBR (High Bit Rate Audio)
HDMI ( HDMI)
(. , 6)

- HDCP DVI HDMI


- Blu- 1080p ( ) /
HD-DVD DVI HDMI
- 7.1 CH HD HD (- Realtek ALC887)
- THX TruStudioTM
- PCIE x 1 Gigabit LAN 10/100/1000 Mb/s
- Realtek RTL8111E
- Wake-On-LAN
-

ASRock H61M-ITX Motherboard

79

- Ethernet 802.3az
- PXE
I/O Panel
- 1 x PS/2

- 1 x D-Sub
- 1 x DVI-D
- 1 x HDMI
- 1 x Optical SPDIF Out
- 4 x USB 2.0
- 1 x eSATA2
- 2 x USB 3.0
- 1 x RJ-45 LAN (
ACT/LINK SPEED)
- : /
/ / / /
USB 3.0

BIOS

80

(. 7)
- 2 x USB 3.0 ASMedia ASM1042
USB 1.0/2.0/3.0
5 /
- 3 x SATA2 3,0 /, NCQ, AHCI

- 1 x
- 1 x Power LED
- : CPU/Chassis FAN
- 24- ATX
- 4- ATX 12
-
- 2 x USB 2.0 ( 4
USB 2.0
- 32Mb AMI BIOS
- AMI UEFI Legal BIOS

- Plug and Play


- ACPI 1.1,
-
- SMBIOS 2.3.1
- , ,
( ),
CyberLink MediaEspresso 6.5, ASRock (CyberLink
DVD Suite OEM- )

ASRock H61M-ITX Motherboard

- ASRock Extreme Tuning Utility (AXTU)


(. , 8)
- ASRock Instant Boot
- ASRock Instant Flash (. , 9)
- ASRock APP Charger (. , 10)
- ASRock SmartView (. , 11)
- ASRock XFast USB (. , 12)
- ASRock
(. , 13)
- Hybrid Booster:
- ASRock U-COP (. , 14)
- Boot Failure Guard (B.F.G)
- LED-
-
-
- CPU/Chassis FAN
- / (

)
- /
- = : +12V, +5V, +3.3V, Vcore
- Microsoft Windows 7 / 7 64-bit / VistaTM /

64- VistaTM / XP / XP 64-bit

- FCC, CE, WHQL

- ErP/EuP Ready (
ErP/EuP) (. , 15)

* , :
http://www.asrock.com

,
, BIOS,
Untied Overclocking
.

. ,

.
.

ASRock H61M-ITX Motherboard

81

!
1.

2.

3.

4.

5.

6.

7.

8.

(HyperThreading Technology) . 39
- .

Dual Channel Memory Technology.

(. 14).

4
Windows 7 / VistaTM / XP.
Windows OS 64-bit .

. Intel , .

. D-Sub, DVI-D HDMI - . DVI-to-HDMI
DVI-D , HDMI.
xvYCC Windows 7 64- / 7.
HBR Windows 7 64- / 7 / VistaTM 64- /
VistaTM.
.
2-, 4-, 6- 8- .
. 3.
ASRock Extreme Tuning Utility (AXTU)

, Hardware
Monitor ( ), Fan Control (
), Overclocking ( ), OC DNA (
) and IES ( ).
Hardware Monitor ( )
. Fan
Control ( )
, . Overclocking

( ) ,
. OC DNA
( )
,
.
.
IES ( )
,
,

82

ASRock H61M-ITX Motherboard

. ,
ASRock Extreme Tuning Utility (AXTU),
. ASRock: http://www.asrock.com
9.

ASRock Instant Flash BIOS,


Flash ROM. BIOS
, MS-DOS Windows.
<F6>
(POST) BIOS
<F2> ASRock Instant Flash .
BIOS USB-,
. BIOS,
,
. , USB-

FAT32/16/12.
10.
Apple, iPhone, iPod iPad Touch, ASRock
ASRock APP Charger.
APP Charger, iPhone
, 40%. ASRock
APP Charger Apple
,
(S1),
(S3), (S4)
(S5). APP Charger,
.
- ASRock: http://www.asrock.com/Feature/AppCharger/index.asp
11. SmartView
IE, -,
, Facebook .

. ASRock
SmartView,
. SmartView Windows 7 / 7 64 bit /

VistaTM / VistaTM 64 bit IE8. - ASRock: http://www.asrock.


com/Feature/SmartView/index.asp
12. ASRock XFast USB
USB. .
13. ASRock

, MP3- ,
,
( ACPI S5)!
, ()
3,5- ,
.

ASRock H61M-ITX Motherboard

83

14.
. ,

, .
,
.
15. EuP Energy Using Product.

. EuP
1 .
EuP .
Intel , EuP
50% 5V
100 ( ).
, EuP.

84

ASRock H61M-ITX Motherboard

1.3


.
,
(short). ,
(open).
3-
, 1 2
.

CMOS
(CLRCMOS1,
3- )
(. . 2, . 5)

CMOS

CLRCMOS1 CMOS.


. 15 5
2 3 CLRCMOS1.
CMOS BIOS.
CMOS BIOS, ,
CMOS, ,
. , , , ,

, CMOS.

ASRock H61M-ITX Motherboard

85

1.4



.

!

Serial ATAII
(SATA_0 (PORT 0),
. . 2, . 3)

SATA_0 (PORT 0) SATA_2 (PORT 4)

(SATA_1 (PORT 1),


. . 2, . 2)
(SATA_2 (PORT 4),

SATA_1 (PORT 1)

. . 2, . 4)

Serial ATA (SATA)

Serial ATAII




SATAII.
SATA

\ 3,0 /.

SATA / SATAII
.


SATAII
.

()

3,5-

3,5-

,
MP3-
,
.

()

USB 2.0
(9- USB6_7)
(. . 2, . 10)

USB_PWR
P-9
P+9
GND
DUMMY

(9- USB8_9)
(. . 2, . 8)


USB 2.0 ,

USB 2.0.
USB 2.0
USB 2.0.

1
GND
P+8
P-8
USB_PWR


(4- CIR1)
(. . 2, . 9)

86

1
GND
IRTX
IRRX
ATX+5VSB

ASRock H61M-ITX Motherboard

GND
PRESENCE#
MIC_RET
OUT_RET

(9- HD_AUDIO1)
(. c. 2, .14)

1
OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L



,


.

1. High Definition Audio


(Jack Sensing),
p
HDA. ,

.
2. AC97,
:
A. Mic_IN (MIC) MIC2_L.
B. Audio_R (RIN) OUT2_R,
Audio_L (LIN) OUT2_L.
C. Ground (GND) Ground (GND).
D. MIC_RET OUT_RET
HD. AC97
.
E. .
Windows XP / XP 64-:
Mixer (). Recorder (
). FrontMic ( ).
Windows 7 / 7 64-, VistaTM / VistaTM 64-:
FrontMic ( )
Realtek. Recording
Volume ( ).

(9- PANEL1)
(. . 2, . 1)

,

.

.
PWRBTN ( ):

.
.

ASRock H61M-ITX Motherboard

87

RESET ( ):

. ,

.
PLED ( ):

. ,
. ,
S1. ,
S3 S4, (S5).
HDLED ( ):

. ,
.

.
, , ,
, ..
,
.

Power LED
(3- PLED1)
(. . 2, . 19)

Power LED
1
PLEDPLED+
PLED+

Chassis Fan-

(3- CHA_FAN1)
(. . 2, . 18)

(4- CPU_FAN1)
(. . 2, . 17)

88


.

S1.
S3/S4
S5 ( ).

4 3 2 1

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL



,
.

ASRock H61M-ITX Motherboard


4- ( ),
3-
,
.
3-
,
1-3.
1-3
3-

ATX

24

13

12

(24- ATXPWR1)
(. . 2, . 7)


ATX.

,
24- ATX, ,
20-
ATX. 20-
ATX 1
24
13
13.

20- ATX

(4- ATX12V1)
(. . 2, . 15)

,


ATX 12 ,

.

.

12V-ATX

12

ASRock H61M-ITX Motherboard

89

2. BIOS
BIOS (BIOS Setup) - .
BIOS Setup, <F2>
<Del> (Power-On-Self-Test POST).
, POST
. BIOS Setup POST,
<Ctrl> + <Alt> + <Delete>
. BIOS Setup
( PDF) - .

3.

Microsoft

Windows : 7 / 7 64-bit / VistaTM / VistaTM 64-bit / XP / XP 64-bit.


- ,
.
- , CD-ROM.
(AUTORUN),
- (Main Menu).
, BIN - ASSETUP.EXE
, .

90

ASRock H61M-ITX Motherboard

1. Giri
ASRockn kesintisiz titiz kalite denetimi altnda retilen gvenilir bir anakart olan
ASRock H61M-ITX anakartn satn aldnz iin teekkr ederiz. ASRockn kalite
ve dayankllk konusundaki kararllna uygun gl tasarmyla mkemmel bir
performans sunar.
Bu Hzl Takma Klavuzu anakarta giri ve adm adm takma klavuzu ierir. Anakart
hakknda daha ayrntl bilgiyi Destek CDsinde sunulan kullanc klavuzunda bulabilirsiniz.
Anakart zellikleri ve BIOS yazlm gncelletirilebileceinden bu klavuzun ierii
nceden haber verilmeksizin deiebilir. Bu belgede deiiklik yaplmas durumun
-da, gncelletirilmi srm ayrca haber verilmeksizin ASRock web sitesinde
sunulur. En son VGA kartlarn ve CPU destek listelerini de ASRock web sitesinde
bulabilirsiniz. ASRock web sitesi http://www.asrock.com
Bu anakartla ilgili teknik destee ihtiyacnz olursa, kullandnz modele zel bilgiler
iin ltfen web sitemizi ziyaret edin.
www.asrock.com/support/index.asp

1.1 Paket indekiler


ASRock H61M-ITX Anakart
(Mini-ITX Form Faktr: 6,7-in x 6,7-in, 17,0 cm x 17,0 cm)
ASRock H61M-ITX Hzl Takma Klavuzu
ASRock H61M-ITX Destek CDsi
2 x Seri ATA (SATA) Veri Kablosu (stee Bal)
1 x 3,5mm Ses Kablosu (stee Bal)
1 x G/ Panel Kalkan
ASRock Size unu Hatrlatr...

Trke

Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit ile daha iyi performans


elde etmek iin, Depolama Konfigrasyonundaki BIOS seeneini AHCI
moduna ayarlamanz tavsiye edilir. BIOS ayar iin, ayrntlar renmek
zere ltfen destek CD'mizdeki "Kullanc Klavuzu"na bakn.

ASRock H61M-ITX Motherboard

91

1.2

zellikler

Platform

CPU

Yonga seti
Bellek

Geniletme
Yuvas
Grafikler

- Mini-ITX Form Faktr: 6,7-in x 6,7-in, 17,0 cm x 17,0 cm


- Tm Kat Kapasitr tasarm (%100 Japon yapm yksek
kaliteli Polimer Kapasitrler)
- Nesil Intel CoreTM i7 / i5 / i3 in LGA1155 Paketini destekle
- Intel Turbo Boost 2.0 Teknolojisini destekler
- K-Serisi kilidi kaldrlm ilemciyi destekler
- Hyper-Threading Teknolojisini destekler (bkz. DKKAT 1)
- Intel H61
- ift Kanall DDR3 Bellei Teknolojisi (bkz. DKKAT 2)
- 2 x DDR3 DIMM yuva
- DDR3 1333/1066 ECC olmayan, ara belleksiz bellek
- Sistem belleinin maks. kapasitesi: 16 GB (bkz. DKKAT 3)
- 1 x PCI Express 2.0 x16 yuva (mavi @ x16 modu)
- Intel HD Graphics Dahili Grselleri: Intel Hzl Eitleme
Videosu, Intel InTruTM 3D, Intel Clear Video HD Teknolojisi,

Trke
Ses
LAN

92

Intel HD Graphics 2000/3000, Intel Gelimi Vektr


Uzantlar (AVX)
- Pixel Shader 4.1, Intel Ivy Bridge ilemciye sahip DirectX 11,
Intel Sandy Bridge ilemciye sahip DirectX 10.1
- Maks. paylalan bellek 1759 MB (bkz. DKKAT 4)
- VGA k seenei: D-Sub, DVI-D ve HDMI
(bkz. DKKAT 5)
- 60Hzde 1920x1200e kadar maks. znrlkle HDMI 1.4a
Teknolojisini destekler
- 60Hzde 1920x1200e kadar maks. znrlkle DVIy
destekler
- 75Hzde 2048x1536ya kadar maks. znrlkle D-Sub
destekler
- Auto Lip Sync, HDMI ile xvYCC ve HBRyi (Yksek Bit Hzl
Ses) destekler (Uyumlu HDMI monitr gerekir)
(bkz. DKKAT 6)
- DVI ve HDMI portlaryla HDCP ilevini destekler
- DVI ve HDMI portlaryla Tam HD 1080p Blu-ray (BD) /
HD-DVD oynatmn destekler
- 7,1 Kanal HD Ses (Realtek ALC887 Ses Codeci)
- THX TruStudioTM destei
- PCIE x1 Gigabit LAN 10/100/1000 Mb/sn
- Realtek RTL8111E
- LANda Uyan zelliini destekler
ASRock H61M-ITX Motherboard

USB 3.0
Konektr

BIOS zellii

Destek CDsi

Benzersiz
zellik

- 1 x G LEDi fii
- CPU/Kasa FAN konektr
- 24 pin ATX g konektr
- 4 pin 12V g konektr
- n panel ses konektr
- 2 x USB 2.0 fi (4 USB 2.0 portu destekler)
- 32 Mb AMI BIOS
- GUI destekli AMI UEFI Geerli BIOS
- Tak altr destekler
- ACPI 1.1 Uyumlu Uyandrma Olaylar
- Jumpersz ayarlamay destekler
- AMBIOS 2.3.1 Destei
- Srcler, Yardmc Programlar, AntiVirs Yazlm (Deneme
Srm), CyberLink MediaEspresso 6.5 Deneme Srm,
ASRock Yazlm Paketi (CyberLink DVD Paketi) (OEM ve
Deneme Srm)
- ASRock Extreme Tuning Utility (AXTU) (bkz. DKKAT 8)
- ASRock Annda nykleme
- ASRock Annda Flash (bkz. DKKAT 9)
- ASRock APP Charger (bkz. DKKAT 10)
- ASRock SmartView (bkz. DKKAT 11)

ASRock H61M-ITX Motherboard

Trke

Arka Panel
G/

- LAN Kablo Alglamay destekler


- Enerji Verimli Ethernet 802.3az destei
- PXEyi destekler
G/ Paneli
- 1 x PS/2 Klavye Portu
- 1 x D-Sub Portu
- 1 x DVI-D Portu
- 1 x HDMI Portu
- 1 x Optik SPDIF k Portu
- 4 x Kullanma Hazr USB 2.0 Portu
- 1 x eSATA2 Portu
- 2 x Kullanma Hazr USB 3.0 Portu
- 1 x RJ-45 LAN Portu, LEDli (AKT/LNK LEDi ve HIZ LEDi)
- HD Ses Jak: Arka Hoparlr/Orta/Bas/Hat Girii/n Hoparlr/
Mikrofon (bkz. DKKAT 7)
- ASMedia ASM1042 tarafndan 2 x Arka USB 3.0 balant
noktas, 5Gb/sye kadar USB 1.0/2.0/3.0
- 3 x SATA2 3,0Gb/sn, donanm NCQ, AHCI ve Sistem Akken
Bileen Takma ilevlerini
- 1 x Kullanc Kzltesi Modl Balants

93

Donanm
Monitr

S
Sertifikalar

- ASRock XFast USB (bkz. DKKAT 12)


- ASRock Ak/Kapal alma Teknolojisi (bkz. DKKAT 13)
- Hibrit Ykseltici:
- ASRock U-COP (bkz. DKKAT 14)
- nykleme Hatas Korumas (B.F.G.)
- yi Geceler LEDi
- CPU Scaklk Duyarll
- Kasa Scaklk Duyarll
- CPU/Kasa Fan Takometresi
- lemci/Kasa Sessiz Fan (Kasa Fan Hznn lemci scakl
ile Otomatik Ayarna izin verir)
- CPU/Kasa Fan oklu-Hz Kontrol
- Voltaj zleme: +12V, +5V, +3,3V, CPU Vcore
- Microsoft Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit / XP /
XP 64-bit uyumlu
- FCC, CE, WHQL
- ErP/EuP Hazr (ErP/EuP hazr g kayna gerekli)
(bkz. DKKAT 15)

* Ayrntl rn bilgileri iin ltfen web sitemizi ziyaret edin: http://www.asrock.com


UYARI
Ltfen, ayar BIOS'da ayarlama, Untied Overclocking Teknolojisi'ni uygulama veya
nc taraf ar hzlandrma aralarn kullanma gibi durumlarda ar hzlandrmayla
ilgili risk olduunu unutmayn. Ar hzlandrma sisteminizin kararlln etkiler veya
hatta sisteminizin bileenlerini ve cihazlarna zarar verebilir. Bu risk size aittir ve zarar
siz dersiniz. Ar hzlandrmadan kaynaklanan olas zarardan sorumlu deiliz.

Trke
94

ASRock H61M-ITX Motherboard

DKKAT!
1.
2.

3.

4.

5.

6.
7.

8.

"Hyper Threading Teknolojisi" ayar hakknda ltfen destek CD'sindeki


"Kullanc Klavuzu"nda sayfa 39'ye bakn.
Bu anakart ift Kanall Bellek Teknolojisi'ni destekler. ift Kanall Bellek
Teknolojisi'ni uygulamadan nce, uygun ykleme hakknda sayfa 14'teki
bellek modllerinin ykleme klavuzunu okuduunuzdan emin olun.
letim sistemi kstlamas nedeniyle, Windows 7 / VistaTM / XP altnda
sistem kullanm iin ayrmak iin gerek bellek boyutu 4 GB'den az olabilir.
64-bit CPU'lu Windows OS iin bu tr bir snrlama yoktur.
Maksimum paylalan bellek boyutu yonga seti satcs tarafndan
tanmlanr ve deiebilir. Ltfen en son bilgileri iin Intel web sitesini
kontrol edin.
monitrden yalnzca ikisini kullanmay seebilirsiniz. D-Sub, DVI-D
ve HDMI monitrler ayn anda etkinletirilemez. Ayrca, DVI - HDMI
adaptryle, DVI-D portu HDMI portu ile ayn zellikleri destekleyebilir.
xvYCC yalnzca Windows 7 64-bit / 7de desteklenir. HBR Windows 7
64-bit / 7 / Vista 64-bit / Vista altnda desteklenir.
Mikrofon k iin, bu anakart hem stereo hem de mono modlarn
destekler. Ses k iin, bu anakart 2 kanall, 4 kanall, 6 kanall ve 8
kanall modlar destekler. Dzgn balant iin sayfa 3teki tabloyu kontrol
edin.
ASRock Extreme Tuning Utility (AXTU) hepsi bir arada bir ara olup
kullanc ile dost bir arayzde farkl sistem ilevlerinin ince ayarn yapmak
iin kullanlmakta olup buna Donanm Monitr, Fan Kontrol, Hz Artma,
OC DNA ve IES dahildir. Donanm Monitrnde sisteminizde okunan
nemli deerleri gsterir. Fan Kontrolnde ayarlamanz iin fan hzn ve
scakln gsterir. Hz artmada optimum sistem performans
almak iin CPU frekansn hz artma yapmanza izin verilmitir. OC
DNAda OC ayarlarnz bir profil olarak kaydedebilir ve arkadalarnz
ile paylaabilirsiniz. Ardndan arkadalarnz OC profilini kendi sistemine
ekleyerek ayn OC ayarlarn alabilir. IESde (Akll Enerji Tasarrufu), CPU
ekirdekleri bota olduunda bilgisayarn performansndan dn vermeden
gerilim dzenleyicisi k fazlarnn saysn drerek verimlilii iyiletirir.
ASRock Extreme Tuning Utility (AXTU)nun alma prosedrleri iin ltfen
web sitemizi ziyaret ediniz. ASRock web sitesi: http://www.asrock.com
ASRock Annda Flash, Flash ROMa kattrlm bir BIOS flash yardmc
programdr. Bu kullanl BIOS gncelleme arac, sistem BIOSunu MSDOS veya Windows gibi ilk nce iletim sistemine girmeden gncellemenizi salar. Bu yardmc programla, POST srasnda <F6> tuuna basabilirsiniz veya BIOS ayarlar mensnn ASRock Annda Flasha erimesi
iin <F2> tuuna basabilirsiniz. Bu arac balatn ve yeni BIOS dosyasn
USB flash srcnze, diskete veya sabit srcye kaydedin, sonra
BIOSunuzu yalnzca birka tklatma ile ek bir disket veya dier karmak

ASRock H61M-ITX Motherboard

Trke

9.

95

flash yardmc programlarn hazrlamadan gncelleyebilirsiniz. Ltfen USB


flash srcnn veya sabit diskin FAT32/16/12 dosya sistemi kullanmas
gerektiini unutmayn.
10. iPhone/iPod/iPad Touch gibi Apple cihazlarnz arj etmek iin daha
hzl ve daha zgr bir biimde arj etmek istiyorsanz, ASRock sizin iin
mkemmel bir zm hazrlad - ASRock APP Charger. Sadece APP
Charger srcn kurarak, iPhoneunuzu bilgisayarnzdan daha abuk ve
eskisinden 40% daha hzl ekilde arj edebilirsiniz. ASRock APP Charger
birok Apple cihazn ayn anda ve hzl bir biimde arj etmenize olanak
tanr ve hatta bilgisayarnz Bekleme modunda (S1), RAMde Askya
Al modunda (S3), uyku modunda (S4) veya kapal(S5) iken srekli arj
etmeyi destekler. APP Charger srcs kurulu iken kolaylkla imdiye hi
olmad kadar harika bir arj deneyimi yaayabilirsiniz.
ASRock internet sitesi: http://www.asrock.com/Feature/AppCharger/index.
asp
11. nternet taraycsnn yeni bir ilevi olan SmartView, en sk ziyaret ettiiniz
web sitelerini, gemiinizi, Facebook arkadalarnz ve sizin gerek
zamanl haber beslemelerinizi, daha kiisel bir nternet deneyimi iin
gelitirilmi bir grnmde birletiren IE iin akll balang sayfasdr.
ASRock anakartlar, hareket halindeki arkadalarnzla irtibat halinde
kalmanza yardm eden SmartView yardmc program ile donatlmtr.
SmartView zelliini kullanmak iin iletim sistemi srmnzn Windows
7 / 7 64 bit / VistaTM / VistaTM 64 bit, ve tarayc srmnzn IE8 olmasna
dikkat edin. ASRock web sitesi: http://www.asrock.com/Feature/SmartView/
index.asp
12. ASRock XFast USB, USB bellek aygt performansn arttrabilir. Performans aygtnn zelliine gre deiiklik gsterebilir.
13. ASRock Ak/Kapal alma Teknolojisi kullanclarn bilgisayar kapalyken
(veya ACPI S5 modundayken) bile bilgisayara bal MP3 alar, cep telefonu gibi tanabilir ses aygtlarnda mkemmel ses deneyiminin keyfini
karmalarna izin verir! Bu ana kart ayn zamanda kullanclar iin en
elverili bilgisayar kullanm ortamn sunan cretsiz 3,5mm ses kablosu
(istee bal) salamaktadr.
14. CPU ar snmas alglandnda, sistem otomatik olarak kapatlr. Sistemi
devam ettirmeden nce, ltfen anakarttaki CPU fannn dzgn altn
kontrol edin ve g kablosunu karn, sonra geri takn. Is geiini artrmak
iin, PC sistemini yklediinizde CPU ile s emici arasna s macunu
srmeyi unutmayn.

Trke
96

ASRock H61M-ITX Motherboard

Trke

15. Enerji Kullanan rn anlamna gelen EuP, tamamlanm sistemler iin g


tketimini tanmlamak iin Avrupa Birlii tarafndan dzenlenen bir gerekliliktir. EuPa gre, kapal mod durumunda tamamlanm sistemin toplam AC
gc 1,00W altnda olmaldr. EuP standardn karlamak iin, EuP hazr
anakart ve EuP hazr g kayna gerekir. Intelin nerisine gre, EuP
hazr g kaynann 100 mA akm tketiminde 5v beklemede g etkinlii
%50den yksektir standardn karlamas gerekir. EuP hazr g kayna
seimi iin, daha fazla ayrnt iin g kayna reticisine bavurmanz
neririz.

ASRock H61M-ITX Motherboard

97

1.3

Jumper'larn Ayar

ekilde jumper'larn nasl ayarlandklar


gsterilmektedir. Jumper kapa pinler zerine
yerletirildiinde jumper "Kapal" dr. Jumper
kapa pinler zerindeyken jumper "Ak" tr.
ekilde pin1 ve pin2'si "Kapal" olan jumper
kapa bu 2 pine yerletirilmi 3-pinli jumper
gsterilmektedir.
Jumper
CMOSu temizleme

Ayar

(CLRCMOS1, 3-pinli jumper)


(bkz. s.2 No. 5)

Default

Clear CMOS

Not: CLRCMOS1, CMOSdaki verilerinizi temizlemenize olanak salar. Sistem


parametrelerini temizlemek ve varsaylan ayara sfrlamak iin ltfen bilgisayar
kapatn ve g kablosunun fiini g kaynandan ekin. 15 saniye bekledikten
sonra, pin2 ve pin3 CLRCMOS1de 5 saniye ksaltmak iin bir atlatc apkas
kullann. Ancak, BIOSu gncelledikten hemen sonra ltfen CMOSu temizlemeyin.
BIOSu gncellemeyi tamamladnzda CMOSu temizlemeniz gerekirse,
ilk olarak sistemi balatmanz ve ardndan CMOS temizleme ilemini
gerekletirmeden nce kapatmanz gereklidir. Parola, tarih, saat ve kullanc
varsaylan profili yalnzca CMOS pili karldnda temizleneceini ltfen
aklnzda bulundurunuz.

Trke
98

ASRock H61M-ITX Motherboard

1.4

Yerleik Filer ve Konektrler

Yerleik filer ve konektrler jumper DELDR. Bu filerin ve konektrlerin zerine


jumper kapaklar YERLETRMEYN. Filerin ve konektrlerin zerine jumper
kapaklar yerletirmek anakartn kalc olarak zarar grmesine neden olabilir!
Seri ATAII Konektrler

Bu Seri ATAII (SATAII)

(SATA_0 (PORT 0):

konektr, dahili depolama


cihazlar iin SATA veri
kablolarn destekler. Geerli

SATA_0 (PORT 0) SATA_2 (PORT 4)

bkz. s.2, No. 3)


(SATA_1 (PORT 1):
bkz. s.2, No. 2)

SATAII arayz 3,0 Gb/sn veri


aktarm hzna izin verir.

SATA_1 (PORT 1)

(SATA_2 (PORT 4):


bkz. s.2, No. 4)

Seri ATA (SATA)


Veri Kablosu

SATA veri kablosunu her iki ucu


da SATA / SATAII sabit

(stee bal)

diskine veya anakarttaki


SATAII konektrne
balanabilir.

3,5mm Ses Kablosu

3,5 mm ses kablosunun her iki


ucuda MP3 alar ve cep
telefonu gibi tanabilir ses
aygtlarna veya bilgisayarn
Line-in (Hat Giri) yuvasna
balanabilir.

(stee bal)

USB 2.0 Fileri

G/ panelindeki varsaylan
drt USB 2.0 portundan baka,
bu anakartta iki USB 2.0 fii
bulunur. Her USB 2.0 fii iki
USB 2.0 portunu destekler.

(9-pinli USB6_7)
(bkz. s.2 No. 10)

USB_PWR
P-9
P+9
GND
DUMMY

(9-pinli USB8_9)
(bkz. s.2 No. 8)

Trke

1
GND
P+8
P-8
USB_PWR

Kullanc Kzltesi Modl Balants


(4-pinli CIR1)
(bkz. s.2 No. 9)

1
GND
IRTX
IRRX
ATX+5VSB

Bu fi, uzaktan kumanda alcs


destekler.

ASRock H61M-ITX Motherboard

99

n Panel Ses Fii

GND
PRESENCE#
MIC_RET
OUT_RET

(9-pinli HD_SES1)
(bkz. s.2 No. 14)
1

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

Bu, panel ses kablosu iin


uygun balant salayan ve
ses cihazlarn kontrol
etmeyi salayan bir arayzdr.

1. Ykse Tanml Ses Jak Duyarlln destekler, ancak kasadaki panel


kablosunun HDA'nn dzgn almasn desteklemesi gerekir. Ltfen
sisteminizi yklemek iin klavuzumuzdaki ve kasa klavuzundaki
talimatlar izleyin.
2. AC'97 ses paneli kullanyorsanz, ltfen n panel ses fiine aadaki gibi
takn:
A. Mic_IN'i (MIC) MIC2_L'ye balayn.
B. Audio_R'yi (RIN) OUT2_R'ye ve Audio_L'yi (LIN) OUT2_L'ye balayn.
C. Ground'u (GND) Ground'a (GND) balayn.
D. MIC_RET ve OUT_RET yalnzca HD ses paneli iindir. Bunlar AC97 ses
paneli iin balamanz gerekmez.
E. n mikrofonu etkinletirmek iin
Windows XP / XP 64-bit S iin:
"Kartrc"y sein. "Kaydedici"yi sein. Sonra "n Mikrofon"u tklatn.
Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit S iin:
Realtek Kontrol panelinde "n Mikrofon" Sekmesine gidin. "Kayt Ses
Seviyesi"ni ayarlayn.

Sistem Paneli Fii


(9-pinli PANEL1)

Bu fi, birok sistem n paneli


ilevini barndrr.

(bkz. s.2 No. 1)

Kasa zerindeki g anahtarn, sfrlama anahtarn ve sistem durumu


gstergesini aadaki pin atamalarna gre bu balantya balayn.
Kablolar balamadan nce pozitif ve negatif pinlere dikkat edin.

Trke

PWRBTN (G Anahtar):
Kasa zerindeki g anahtarn n panele balayn. G anahtarn
kullanarak sisteminizi kapatma eklinizi yaplandrabilirsiniz.
RESET (Sfrlama Anahtar):
Kasa zerindeki sfrlama anahtarn n panele balayn. Bilgisayar
donarsa veya normal bir yeniden balatma gerekletirilemezse,
bilgisayar yeniden balatmak iin sfrlama anahtarna basn.
PLED (Sistem Gc LEDi):
Kasa zerindeki g durumu gstergesini n panele balayn. Sistem
alrken LED yanar. Sistem S1 uyku modunda iken LED yanp sn
meye devam eder. Sistem S3/S4 uyku modunda veya kapal (S5) iken
LED sner.

100

ASRock H61M-ITX Motherboard

HDLED (Sabit Disk alma LEDi):


Kasa zerindeki sabit disk alma LEDini n panele balayn. Sabit
disk veri okurken veya yazarken LED yanar.
n panel tasarm kasaya gre deiiklik gsterebilir. n panel
modlnde temel olarak g anahtar, sfrlama anahtar, g LEDi,
sabit disk alma LEDi, hoparlr vb. bulunur. Kasa n panel
modlnz bu balantya balarken, kablo atamalarnn ve pin
atamalarnn doru biimde eletirildiinden emin olun.

G LED'i Fii

Sistem gc durumunu
belirtmek iin ltfen kasa g
LED'ini bu fie balayn. Sistem
alrken LED aktr. LED S1
durumunda yanp snmeye
devam eder. LED S3/S4
durumunda veya S5 durumun
da (g kapal) kapaldr.

(3-pinli PLED1)

PLEDPLED+
PLED+

(bkz. s.2 No. 19)

Conector do ventilador do chassis

Ligue o cabo do ventilador


neste conector, coincidindo o fio
preto com o pino de aterramen
to.

(CHA_FAN1 de 3 pinos)
(veja a folha 2, No. 18)

CPU Fan Konektr

Ltfen fan kablolarn CPU


fanna bu konektre balayn

4 3 2 1

(4-pinli CPU_FAN1)
(bkz. s.2 No. 17)

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

ve siyah kabloyu toprak pinine


balayn.

Bu anakart 4-Pinli CPU fan (Sessiz Fan) destei salasa da, 3-Pinli CPU
fan hz kontrol ilevi olmadan bile hala baarl bir ekilde alabilir.
3-Pinli CPU fan bu konektrdeki CPU fan konektrne balamay
planlyorsanz, ltfen Pin 1-3'e balayn.
Pin 1-3 Bal

ATX G Konektr

24

13

12

Ltfen bir ATX g kaynan


bu konektre balayn.

(24-pinli ATXPWR1)
(bkz. s.2 No. 7)

Trke

3-Pinli Fan Takma

ASRock H61M-ITX Motherboard

101

Bu anakart 24-pinli ATX g konektr salasa da geleneksel bir 20-pinli


ATX g kayna balarsanz da alabilir. 20-pinli ATX g kaynan
kullanmak iin, ltfen g kaynanz Pin 1 ve Pin 13'le birlikte takn.

20-Pinli ATX G Kaynan Takma

ATX 12V G Konektr


(4-pinli ATX12V1)
(bkz. s.2 No. 15)

13

12

Ltfen bir ATX 12V g


kaynan bu konektre
balayn.

Trke
102

24

ASRock H61M-ITX Motherboard

2. BIOS Bilgileri
Anakarttaki Flash Bellek BIOS Ayarlar Yardmc Programn ierir. Bilgisayar
balattnzda, ltfen Otomatik G Snamas (POST) srasnda BIOS Ayarlar
yardmc programna girmek iin <F2> veya <Del> tuuna basn; aksi halde, POST
test rutinlerine devam eder. BIOS Ayarlarna POST'tan sonra girmek istiyorsanz,
ltfen <Ctl> + <Alt> + <Delete> tularna basarak veya sistem kasasndaki sfrlama
dmesine basarak sistemi yeniden balatn. BIOS Ayarlar program kullanc
dostu olacak ekilde tasarlanmtr. eitli alt menler arasnda dolamanza ve
nceden belirlenen seenekler arasndan seim yapmanza izin veren men tabanl
bir programdr. BIOS Ayarlar hakknda ayrntl bilgi iin, ltfen Destek CD'sinde
bulunan Kullanc Klavuzu'na (PDF dosyas) bavurun.

3. Yazlm Destek CDsi bilgileri


Bu anakart eitli Microsoft Windows iletim sistemleri destekler: 7 / 7 64-bit
/ VistaTM / VistaTM 64-bit / XP / XP 64-bit. Anakartla birlikte gelen Destek CD'si

Trke

anakart zelliklerini genileten gerekli srcleri ve kullanl yardmc programlar


ierir. Destek CD'sini kullanmaya balamak iin, CD'yi CDROM srcnze takn.
Bilgisayarnzda "OTOMATK KULLAN" zellii etkinletirilmise, Ana Meny
otomatik olarak grntler. Ana Men otomatik olarak grntlenmezse, menleri
grntlemek iin Destek CD'sinin BIN klasrndeki "ASSETUP.EXE" dosyasn
bulun ve ift tklatn.

ASRock H61M-ITX Motherboard

103

1.
ASRock H61M-ITX .
.
ASRock
.
. CD
.

.
ASRock
.
VGA CPU .
ASRock http://www.asrock.com .

.
www.asrock.com/support/index.asp

1.1
ASRock H61M-ITX
(Mini-ITX : 6.7 x 6.7, 17.0 x 17.0 cm)
ASRock H61M-ITX
ASRock H61M-ITX CD
ATA (SATA) 2 ( )
3.5mm 1 ( )
I/O 1

ASRock ...

Windows 7 / 7 64- / VistaTM / VistaTM 64-


Storage Configuration( ) BIOS AHCI
. BIOS
CD .

104

ASRock H61M-ITX Motherboard

1.2

CPU

- Mini-ITX : 6.7 x 6.7, 17.0 x 17.0 cm


- (100%
)

- LGA1155 2 Intel CoreTM i7 / i5 / i3

- Intel Turbo Boost 2.0


- K- CPU
- - ( 1 )

- Intel H61


VGA

- ( 2 )
- DDR3 DIMM 2
- DDR3 1333/1066 -ECC,
- : 16GB ( 3 )
- PCI Express 2.0 x16 (x16 ) 1

- Intel HD : Intel Quick Sync

Video, Intel InTruTM 3D, Intel Clear Video HD

Technology, Intel HD Graphics 2000/3000, Intel Advanced

Vector Extensions (AVX)

- Pixel Shader 4.1, Intel Ivy Bridge CPU DirectX

11, Intel Sandy Bridge CPU DirectX 10.1


- 1759MB ( 4 )
- 3 VGA : D-Sub, DVI-D HDMI
( 5 )
- 1920x1200 @ 60Hz HDMI 1.4a
- 1920x1200 @ 60Hz DVI
- 2048x1536 @ 75Hz D-Sub
- (Auto Lip Sync), xvYCC, HBR(
), HDMI (HDMI ) ( 6 )
- DVI HDMI HDCP
- DVI HDMI 1080p Blu-ray (BD) /
HD-DVD
- 7.1 CH HD Audio (Realtek ALC887 Audio Codec)
- THX TruStudioTM
- PCIE x1 Gigabit LAN 10/100/1000 Mb/s
- Realtek RTL8111E
- - -
- LAN
- 802.3az
- PXE

ASRock H61M-ITX Motherboard

105

I/O

USB 3.0

BIOS

CD

106

I/O Panel
- 1 PS/2
- 1 D-Sub
- 1 DVI-D
- 1 HDMI
- 1 SPDIF
- 4 USB 2.0
- 1 eSATA2
- 2 USB 3.0
- 1 LED(ACT/LINK LED SPEED LED) RJ-45
LAN
- : / / / / /
( 7 )
- ASMedia ASM1042 USB 3.0 2 ,
5Gb/s USB 1.0/2.0/3.0
- 3 SATA2 3.0Gb/s , NCQ, AHCI

- 1
- LED 1
- CPU/
- 24 ATX
- 4 ATX 12V
-
- USB 2.0 2 (4 USB 2.0
2)
- 32Mb AMI BIOS
- GUI AMI UEFI BIOS
-
- ACPI 1.1 -
-
- SMBIOS 2.3.1
- , , ( ), CyberLink
MediaEspresso 6.5 , ASRock
(CyberLink DVD - OEM )
- ASRock Extreme Tuning Utility (AXTU) ( 8 )
- ASRock Instant Boot
- ASRock Instant Flash ( 9 )
- ASRock APP Charger ( 10 )
- ASRock SmartView ( 11 )
- ASRock XFast USB ( 12 )

ASRock H61M-ITX Motherboard

OS

- ASRock On/Off Play ( 13 )


- :
- ASRock U-COP ( 14 )
- B.F.G..(Boot Failure Guard)
- LED
- CPU
-
- CPU/ : ( )
- CPU/ (CPU
)
- CPU/
- : +12V,+5V,+3.3V,Vcore

- Windows 7/7 64 /VistaTM/


VistaTM 64 / XP/XP 64
- FCC, CE, WHQL
- ErP/EuP (ErP/EuP )
( 15 )

* . http://www.asrock.com

BIOS Untied Overclocking Technology



.
.
.
.

ASRock H61M-ITX Motherboard

107

!
1.
2.

3.

- CD 39
.
.
14
.

Windows 7 / Vista / XP

4.

5.

6.

4 GB . 64 CPU Windows OS
.

, Intel
.
. D-Sub,
DVI-D, HDMI . DVIHDMI , DVI-D HDMI
.

xvYCC Windows 7 64-bit / 7 . HBR

7.

8.

Windows 7 64-bit / 7 / VistaTM 64-bit / VistaTM .



. 2 , 4 , 6
8 . 3
.
AXTU (ASRock Extreme Tuning Utility)
,
, , , OC DNA, IES
.
. .
CPU
. OC DNA OC
. OS
OS
. IES (Intelligent Energy Saver) ,
CPU
. ASRock AXTU
(Extreme Tuning Utility)
. ASRock : http://www.asrock.com

9.

108

ASRock Instant Flash ROM BIOS


. BIOS MS-DOS

Windows BIOS
. POST BIOS <F6>
<F2> ASRock Instant Flash
.. USB
, BIOS

ASRock H61M-ITX Motherboard

BIOS .
USB FAT32/16/12
.
10. / / Apple
, ASRock
ASRock APP Charger . APP Charger

40% . ASRock APP
Charger Apple ,
PC (S1), RAM (S3),
(S4) (S5)
. APP Charger
. ASRock : http://www.
asrock.com/Feature/AppCharger/index.asp
11. SmartView
, , ,
IE .
ASRock SmartView
. SmartView OS

Windows 7 / 7 64 / VistaTM / VistaTM 64


IE8 . ASRock : http://www.asrock.com/

ASRock H61M-ITX Motherboard

Feature/SmartView/index.asp
12. ASRock XFast USB USB .
.
13. ASRock On/Off Play MP3
PC
PC ( ACPI S5
) .
3.5 mm
( ) .
14. CPU
.
PC CPU
.
15. EuP Energy Using Product ( )

. EuP , AC
1.00W . EuP
EuP EuP .
(Intel) EuP 5V
100 mA 50%
. EuP
.

109

1.3
.
, .
.
3 1-2
,
.

CMOS
(CLRCMOS1, 3 )
(2 , 5 )

CMOS

CLRCMOS1 CMOS .
,
. 15
CLRCMOS1 2 3 5 . BIOS
CMOS . BIOS CMOS
CMOS
. CMOS , , ,
.

110

ASRock H61M-ITX Motherboard

1.4
!
.
. !

ATAII
SATA_0 (PORT 0) SATA_2 (PORT 4)

2 , 3 )
(SATA_1 (PORT 1):
2 , 2 )

SATA_1 (PORT 1)

(SATA_2 (PORT 4):


2 , 4 )

ATA(SATA)

3 ATAII
(SATA)
SATA
.
SATA
. SATAII
3.0 Gb/s

.
SATA
SATA /
SATAII
SATAII
.

( )

3.5mm

3.5 mm
MP3

PC
.

( )

USB 2.0
(9 USB6_7)
(2 , 10 )

USB_PWR
P-9
P+9
GND
DUMMY

(9 USB8_9)
(2 , 8 )

I/O
4 USB 2.0
USB 2.0 2
. USB 2.0
2 USB 2.0
.

(SATA_0 (PORT 0):

1
GND
P+8
P-8
USB_PWR


(4 CIR1)
(2 , 9 )

1
GND
IRTX
IRRX
ATX+5VSB

ASRock H61M-ITX Motherboard

111

GND
PRESENCE#
MIC_RET
OUT_RET


(9 HD_AUDIO1)
(2 , 14 )
1

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

1.

2.

High Definition Audio( ) ,


HAD .
.
AC97 ,
.
A.
Mic_IN (MIC) MIC2_L .
B.
Audio_R (RIN) OUT2_R , Audio_L (LIN)
OUT2_L .
C.
Ground (GND) Ground (GND) .
D.
MIC_RET OUT_RET HD .
AC97 .
E.
.

Windows XP / XP 64 OS :
Mixer ( ) Recorder ( )
FrontMic ( ) .

Windows 7 / 7 64 / VistaTM / VistaTM 64 OS


:
Realtek FrontMic ( )
Recording Volume ( ) .


(9 PANEL1)
(2 , 1 )

, ,
.
.

PWRBTN( ):
.
.
RESET( ):
.

.

112

ASRock H61M-ITX Motherboard

PLED( LED):
.
LED . S1 LED
. S3/S4 (S5)
LED .
HDLED( LED):
LED .
LED .
.
, , LED, LED,
.
.

LED


LED
.
LED
. S1 LED
. S3/S4
S5 LED
( ).

(3 PLED1)
(2 , 19 )

PLEDPLED+
PLED+

(3 CHA_FAN1)
(2 , 18 )

CPU

CPU

4 3 2 1

(4 CPU_FAN1)
(2 , 17 )

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

4 CPU ( )
3 CPU .
CPU 3 CPU 1-3
.
1-3
3

ATX

24

13

(2 , 7 )

ATX
.

(24 ATXPWR1)
12

ASRock H61M-ITX Motherboard

113

24 ATX , 20 ATX
. 20 ATX
, Pin 1 Pin 13 .
24

13

12

20 ATX

ATX 12V

ATX 12V

(4 ATX12V1)



.

.

(2 , 15 )

114

ASRock H61M-ITX Motherboard

2.
.
, (POST) <F2>
<Del> ; POST
. POST
,<Ctl>+<Alt>+<Delete> ,
.
.
.
CD (PDF )
.

3. CD

:
7/7 64 /VistaTM/VistaTM 64 /XP/XP 64 .
CD
. CD , CD-ROM CD
. AUTORUN
.
, CD BIN ASSETUP.EXE
.
(D: \ BIN \ ASSETUP.EXE, D: CD-ROM )

ASRock H61M-ITX Motherboard

115


ASRock H61M-ITX

CD
BIOS

VGA CPU
ASRock
http://www.asrock.com
Web

www.asrock.com/support/index.asp

1.1

ASRock H61M-ITX
(Mini-ITX : 6.7-in x 6.7-in, 17.0 cm x 17.0 cm)
ASRock H61M-ITX
ASRock H61M-ITX CD
2 x ATA (SATA)
1 x 3.5mm
1 x I/O

ASRock ...
Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit
BIOSAHCI
B I O SC D

116

ASRock H61M-ITX Motherboard

1.2

CPU

- Mini-ITX :
6.7-in x 6.7-in, 17.0 cm x 17.0 cm
- (100%
)
- 2 Intel CoreTM i7 / i5 / i3 in LGA1155

- Intel Turbo 2.0


- K CPU
- ( 1 )
- Intel H61
- DDR3
( 2 )
- DDR3 DIMM x 2
- DDR3 1333/1066 non-ECC, un-buffered
- : 16GB ( 3 )
- 1 x PCI Express 2.0 x16 ( @ x16 )
- Intel HD :Intel
Quick Sync VideoIntel InTruTM 3DIntel Clear
Video HD TechnologyIntel HD Graphics
2000/3000Intel Advanced Vector Extensions (AVX)

LAN

- Pixel Shader 4.1Intel Ivy Bridge CPU


DirectX 11Intel Sandy Bridge CPU
DirectX 10.1
- 1759MB ( 4 )
- 3 VGA :D-SubDVI-DHDMI
( 5 )
- 1920x1200 @ 60Hz HDMI 1.4a
- 1920x1200 @ 60Hz DVI
- 2048x1536 @ 75Hz D-Sub
- xvYCCHBRHigh Bit Rate
HDMI HDMI ( 6 )
- HDCP DVI HDMI
- 1080p Blu-ray (BD) / HD-DVD DVI
HDMI
- 7.1 CH HD (Realtek ALC887 Codec)
- THX TruStudioTM
PCIE x1 Gigabit LAN 10/100/1000 Mb/s
Realtek RTL8111E
Wake-On-LAN
LAN
ASRock H61M-ITX Motherboard

117


I/O

USB 3.0

BIOS

CD

118

- Energy Efficient Ethernet 802.3az


- PXE
I/O Panel
- PS/2 x 1
- D-Sub x 1
- DVI-D x 1
- HDMI x 1
- SPDIF x 1
- Ready-to-Use USB 2.0 x 4
- eSATA2 x 1
- Ready-to-Use USB 3.0 x 2
- LEDACT/LINK LED SPEED LED RJ-45 LAN
x 1
-
( 7 )
- 2 x USB 3.0 (ASMedia ASM1042)USB
1.0/2.0/3.0 5Gb/s
- 3 x SATA2 3.0Gb/ NCQAHCI Hot
Plug ( )
- x 1
-

LED x 1
CPU/
24 ATX
4 12V

USB 2.0 (USB 2.0 4 ) x 2


32Mb AMI BIOS
AMI UEFI Legal BIOSGUI

ACPI 1.1
jumperfree
SMBIOS 2.3.1
AntiVirus (
)CyberLink MediaEspresso 6.5 ASRock
(CyberLink DVD OEM )

ASRock H61M-ITX Motherboard

OS

- ASRock Extreme (AXTU)


( 8 )
- ASRock
- ASRock Instant Flash ( 9 )
- ASRock APP ( 10 )
- ASRock SmartView ( 11 )
- ASRock XFast USB ( 12 )
- ASRock / ( 13 )
- :
- ASRock U-COP ( 14 )
- (Boot Failure Guard:B.F.G.)
- LED
- CPU
-
- CPU/
- CPU/ CPU

- CPU/
- : +12V, +5V, +3.3V, Vcore
- Microsoft Windows 7 / 7 64-bit / VistaTM

/ VistaTM 64-bit / XP / XP 64-bit compliant


- FCC, CE, Microsoft WHQL

- ErP/EuP ErP/EuP
( 15 )
* http://www.asrock.com

BIOS

ASRock H61M-ITX Motherboard

119


1.
2.

3.

4.
5.

6.
7.

8.

CD
39
(Dual
Channel Memory Technology

14

Windows 7 / VistaTM / XP
4GB
64 CPU Windows OS

Intel WEB
3 2 D-SubDVI-D
HDMI DVI HDMI
DVI-D HDMI
xvYCC Windows 7 64-bit / 7 HBR
Windows 7 64-bit / 7 / VistaTM 64-bit / VistaTM

2
4 6 8
3
ASRock Extreme Tuning Utility (AXTU)

OC DNAES

CPU
OC DNA OC
OC
OC IES (
) CPU

ASRock Extreme Tuning


Utility (AXTU) Web
ASRock Web :http://www.asrock.com

120

ASRock H61M-ITX Motherboard

10.

11.

12.
13.

ASRock Instant Flash Flash ROM ROM


BIOS BIOS
MS-DOS Windows
BIOS
POST <F6> BIOS
<F2> ASRock Instant Flash
BIOS USB

BIOS USB
FAT32/16/12

iPhone/iPod/iPad Touch Apple


ASRock ASRock APP
APP
iPhone
40% ASRock APP
Apple
PC (S1) (S3)
(S4) (S5) APP

ASRock Web : http://www.


asrock.com/Feature/AppCharger/index.asp
SmartView
Facebook

IE ASRock
SmartView
SmartView
OS Windows 7 / 7 64 bit / VistaTM /
VistaTM 64 bit IE8
ASRock http://www.asrock.com/Feature/
SmartView/index.asp
ASRock XFast USB USB

ASRock / PC
ACPI S5 MP3
PC
3.5mm

ASRock H61M-ITX Motherboard

9.

121

14.

15.

CPU
CPU

PC
CPU

Energy Using Product EuP


EuP
AC 1.00W
EuP EuP EuP
Intel EuP
5v 100 mA
50% EuP

122

ASRock H61M-ITX Motherboard

1.3



1-2

CMOS

(CLRCMOS1
( 5

CMOS

: CLRCMOS1 CMOS
15
CLRCMOS1 2 3 5
BIOS CMOS BIOS CMOS
CMOS

CMOS

ASRock H61M-ITX Motherboard

123

1.4

ATAII

3 ATAII
(SATAII
SATA_0 (PORT 0) SATA_2 (PORT 4)
2, 3
SATA
SATA_0 (PORT 0):

SATAII

3.0 Gb/s

SATA_1 (PORT 1):


2, 2
SATA_2 (PORT 4):

SATA_1 (PORT 1)

2, 4

ATASATA

SATA
SATA /SATAII
SATAII

3.5mm

3.5mm
MP3
PC

USB 2.0

I/O 4
USB 2.0
2 USB 2.0

USB 2.0 2

(9 USB6_7)
, 10

(9 USB8_9)
, 8

USB_PWR
P-9
P+9
GND
DUMMY

USB 2.0

GND
P+8
P-8
USB_PWR

(4 CIR1)
, 9

124

1
GND
IRTX
IRRX
ATX+5VSB

ASRock H61M-ITX Motherboard

GND
PRESENCE#
MIC_RET
OUT_RET

(9 HD_AUDIO1)
, 14
1

OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

1.

2.

HAD

AC97

A.
Mic_IN (MIC) MIC2_L
B.
Audio_R (RIN) OUT2_R Audio_L (LIN)
OUT2_L
C.
Ground (GND) Ground (GND)

D.
MIC_RET OUT_RET
AC97
E.

Windows XP / XP 64-bit OS :
Mixer ( ) Recorder (
) FrontMic ( )

Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit OS

(9 PANEL1)

, 1

:
Realtek FrontMic (
) Recording Volume( )

PWRBTN ( ):

ASRock H61M-ITX Motherboard

125

RESET ( ):

PLED ( LED):

LED LED
S1 S3 S4
(S5) LED
HDLED ( LED):
LED
LED

LED
LED

LED
1

(3 PLED1)
, 19

PLEDPLED+
PLED+

(3 CHA_FAN1)
, 18

CPU

4 3 2 1

(4 CPU_FAN1)
, 17

LED

LED

S1 LED
S3/S4
S5 ( )
LED

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

CPU

4 CPU ( )
3 CPU 3
CPU CPU
1-3
1-3
3

126

ASRock H61M-ITX Motherboard

ATX
(24 ATXPWR1)
, 7

24

13

12

ATX

24 ATX 20 ATX
20 ATX 1
13 24
13

20 ATX
12

(4 ATX12V1)
, 15

CPU Vcore
ATX 12V

ATX 12V

ASRock H61M-ITX Motherboard

127

2BIOS
BIOS
POSTF2 <Del>
BIOS POST
BIOS POST
CtrlAltDelete
BIOS

BIOS
CD (PDF )

3 CD
Microsoft Windows 7 / 7 64-bit / VistaTM / VistaTM 64bit / XP / XP 64-bit
CD
CD
CDROM CD AUTORUN
AUTORUN CD
BIN ASSETUP.EXE

128

ASRock H61M-ITX Motherboard

1.
H61M - I T X , , , ,

BIOS ,

CPU
http://www.asrock.com
,

www.asrock.com/support/index.asp

1.1
H61M-ITX
(Mini-ITX : 6.7 X 6.7 , 17.0 X 17.0 )
H61M-ITX
H61M-ITX
Serial ATA(SATA) ( )
3.5mm ( )
I/O

ASRock ...

Windows 7 / 7 64-bit / VistaTM / VistaTM 64-bit


BIOSStorage Configuration
AHCIBIOSUser Manual

ASRock H61M-ITX Motherboard

129

1.2

- Mini-ITX :
6.7 X 6.7 , 17.0 X 17.0
- (100% )

- Intel CoreTM i7 / i5 / i3 (LGA1155 )

- Intel Turbo Boost 2.0


- K- CPU
- Hyper-Threading 1

- Intel H61

DDR3 2
2 DDR3 DIMM
DDR3 1333/1066 non-ECCun-buffered
16GB 3
1 x PCI Express 2.0 x16 ( @ x16 )

Intel HD Graphics :Intel Quick Sync

VideoIntel InTruTM 3DIntel Clear Video HD

Intel HD Graphics 2000/3000Intel Advanced Vector


Extensions(AVX

LAN

130

- Pixel Shader 4.1 Intel Ivy Bridge CPU

DirectX 11Intel Sandy Bridge CPU DirectX 10.1


- 1759MB 4
- VGA :D-SubDVI-D HDMI
( 5
- HDMI 1.4a, 1920x1200 @ 60Hz
- DVI, 1920x1200 @ 60Hz
- D-Sub, 2048x1536 @ 75Hz
- HDMI, Auto Lip SyncxvYCC HBR( )
( HDMI )( 6
- DVI HDMI HDCP
- DVI HDMI 10800 (BD) /
HD-DVD
- 7.1 (Realtek ALC887 )
- THX TruStudioTM
-

PCIE x1 Gigabit LAN 10/100/1000 Mb/s


Realtek RTL8111E
Wake-On-LAN

Energy Efficient Ethernet 802.3az


PXE

ASRock H61M-ITX Motherboard

USB 3.0

BIOS

I/O
- 1 PS/2
- 1 D-Sub
- 1 DVI-D
- 1 HDMI
- 1 SPDIF
- 4 USB 2.0
- 1 eSATA2
- 2 USB 3.0
- 1 RJ-45 LED (ACT/LINK LED
SPEED LED)
- / / /
/ / ( 7)
- 2 x ASMedia ASM1042 USB 3.0
USB 1.0/2.0/3.0 5Gb/s
- 3 x SATA2 3.0Gb/s , NCQ, AHCI

- 1 x
- 1 x
- CPU/
- 24 ATX
- 4 12V
-
- 2 x USB 2.0 ( 4 USB 2.0 )
- 32Mb AMI BIOS
- AMI UEFI Legal BIOS GUI
- Plug and Play,PnP
- ACPI 1.1
-
- jumperfree
- , , ),CyberLink
MediaEspresso 6.5 , (CyberLink DVD
Suite - OEM )
- ASRock Extreme Tuning Utility (AXTU) 8
-
- Instant Flash 9
- APP Charger 10
- SmartView 11
- XFast USB 12
- / 13

ASRock H61M-ITX Motherboard

Rear Panel
I/O
( /
)

131

- Hybrid Booster( ):
- ASRock U-COP 14
- Boot Failure Guard (B.F.G., )
-
- CPU
-
- CPU/
- CPU/ CPU

- CPU/
- +12V, +5V, +3.3V,

- Microsoft Windows 7/7 64 /VistaTM/VistaTM 64 /


XP/XP 64
- FCC, CE, WHQL
- ErP/EuP( ErP/EuP
) 15

* : http://www.asrock.com

, BIOS
,
,

132

ASRock H61M-ITX Motherboard


1 Hyper-Threading Technology CD
User Manual( , ) 39 , UEFI
7 ( )
2
14

3 Windows 7 / VistaTM / XP

4GB Windows 64 CPU ,

4 Intel

5 D-SubDVI-D HDMI
, DVI HDMI , DVI-D HDMI

6 Windows 7 64 /7 xvYCC Windows 7 64 /7/


VistaTM 64 /VistaTM HBR
7
2 4 6 8
3
8 ASRock Extreme Tuning Utility (AXTU)
O C
DNA IES Hardware Monitor
Fan Control
Overclocking CPU
OC DNA OC
O C
OC IES CPU
ASRock Extreme
Tuning Utility (AXTU)

ASRock H61M-ITX Motherboard

http://www.asrock.com
9 Instant Flash Flash ROM BIOS

BIOS ( MS-DOS Windows )


B I O S < F6> B I O S
<F2> Instant Flash
, B I O S U ,
B I O S ,
:U FAT32/64
10 , i P h o n e / i P a d / i P o d
touch , - APP Charger
APP Charger , iPhone
40% APP Charger ,
( S1) ( S3) ( S4) ( S5)
APP Charger ,

133

11 S m a r t V i e w I n t e r n e t I E

F a c e b o o k
Internet SmartView
SmartView

Windows 7 / 7 64 / VistaTM / VistaTM 64


IE8http://www.asrock.com/Feature/SmartView/index.asp
12 XFast USB USB

13 / M P3
P C P C
ACPI S5 3.5mm

14 CPU
C P U
PC CPU
15 EuP, Energy Using Product( ),
E u P ,
1.00W EuP , EuP

EuP Intel , EuP


100m A ,5V s b 50% E u P
,

134

ASRock H61M-ITX Motherboard

1.3

,
,
3
, 1 2

CMOS

(CLRCMOS1, 3 )
( 2 5 )

CMOS

C L R C M O S1 C M O S
15
C L R C M O S1 2 3 5 B I O S
C M O S B I O S C M O S C M O S
C M O S

ASRock H61M-ITX Motherboard

135

1.4

Serial ATAII
(SATA_0 (PORT 0):

SATA_0 (PORT 0) SATA_2 (PORT 4)

2 3 )
(SATA_1 (PORT 1):
2 2 )

SATA_1 (PORT 1)

(SATA_2 (PORT 4):

Serial ATAII
(SATAII) Serial
(SATA)
SATAII
3.0Gb/s

2 4 )

Serial ATA (SATA)

SATA
SATA/SATAII

( )

SATAII

3.5mm

3.5mm

( )

MP3
PC

USB 2.0

I/O
USB 2.0
USB 2.0
USB 2.0
USB 2.0

(9 USB6_7)
( 2 10 )

(9 USB8_9)

USB_PWR
P-9
P+9
GND
DUMMY

( 2 8 )

1
GND
P+8
P-8
USB_PWR

(4 CIR1)
( 2 9 )

136

GND
IRTX
IRRX
ATX+5VSB

ASRock H61M-ITX Motherboard

GND
PRESENCE#
MIC_RET
OUT_RET

(9 HD_AUDIO1)
( 2 14 )

1
OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

1. (High Definition Audio, HDA)


(Jack Sensing), HDA

2. AC97 , :
A. Mic_IN(MIC) MIC2_L
B. Audio_R(RIN) OUT2_R, Audio_L(LIN)
OUT2_L
C. Ground(GND) Ground(GND)
D. MIC_RET OUT_RET HD
AC97
E.

Windows XP / XP 64 :
MixerRecorder
FrontMic

Windows 7 / 7 64 / VistaTM / VistaTM 64


:
Realtek FrontMicRecording
Volume

(9 PANEL1)

( 2 1 )

ASRock H61M-ITX Motherboard

PWRBTN( ):

RESET( ):
,

PLED( ):
,
S1 , S3/S4
(S5) ,
HD LED( ):
,

137

(3 PLED1)

PLEDPLED+
PLED+

( 2 19 )

LED S1
LED
S3/S4 S5 (
) LED

(3 CHA_FAN1)

( 2 18 )

CPU

CPU

4 3 2 1

(4 CPU_FAN1)
( 2 17 )

GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

4-Pin CPU (Quiet Fan, ),


3-Pin CPU 3-Pin CPU
CPU , Pin 1-3
Pin 1-3
3-Pin

ATX

24

13

12

(24 ATXPWR1)
( 2 7 )

ATX

24-pin ATX , 20-pin


ATX 20-pin ATX , Pin 1 Pin 13

24

13

12

20-Pin ATX

ATX 12V
(4 ATX12V1)

ATX 12V

( 2 15 )

138

ASRock H61M-ITX Motherboard

2. BIOS
Flash Memory BIOS (POST)
< F2> < D e l > B I O S ( P O S T )
( P O S T ) B I O S
<Ctrl>+<Alt>+<Delete>
BIOS (PDF )

3.

Microsoft Windows 7/7 64 /Vista TM /


VistaTM 64 /XP/XP 64

BIN ASSETUP.EXE

ASRock H61M-ITX Motherboard

139


SJ/T 11364-2006

10

(Pb) (Cd) (Hg) (Cr(VI)) (PBB) (PBDE)

O: SJ/T 11363-2006

X: SJ/T 11363-2006
2002/95/EC
:

140

ASRock H61M-ITX Motherboard

1.
H61M-ITX , , , ,

BIOS ,

CPU
http://www.asrock.com
,

www.asrock.com/support/index.asp

1.1
H61M-ITX
(Mini-ITX : 6.7 x 6.7 , 17.0 x 17.0 )
H61M-ITX
H61M-ITX
Serial ATA(SATA) ( )
3.5mm
I/O

ASRock...
ASRock

Windows 7 / 7 64 / VistaTM / VistaTM 64


BIOSAHCIBIOS

ASRock H61M-ITX Motherboard

141

1.2

- Mini-ITX :
6.7 x 6.7 , 17.0 x 17.0
- (100% )
- Intel CoreTM i7 / i5 / i3 (LGA1155 )

Intel Turbo Boost 2.0


K CPU
Hyper-Threading 1
Intel H61

DDR3 2
2 DDR3 DIMM
DDR3 1333/1066 non-ECCun-buffered
16GB 3
1 x PCI Express 2.0 x16 ( @ x16 )
Intel HD Graphics (Built-in

Visuals)Intel Quick Sync VideoIntel InTruTM 3D


Intel Clear Video HD TechnologyIntel HD Graphics
-

Rear Panel
I/O
( /
)

142

2000/3000Intel Advanced Vector Extensions (AVX)


Pixel Shader 4.1 Intel Ivy Bridge CPU
DirectX 11Intel Sandy Bridge CPU DirectX 10.1
1759MB 4
VGA :D-SubDVI-D HDMI ( 5
HDMI 1.4a, 1920x1200 @ 60Hz
DVI, 1920x1200 @ 60Hz
D-Sub, 2048x1536 @ 75Hz
HDMI, Auto Lip SyncxvYCC HBR(
)( HDMI ) ( 6
DVI HDMI HDCP
DVI HDMI 1080p (BD) / HD-DVD
7.1 (Realtek ALC887 )
THX TruStudioTM

- PCIE x1 Gigabit LAN 10/100/1000 Mb/s


- Realtek RTL8111E
- Wake-On-LAN
-
- Energy Efficient Ethernet 802.3az
- PXE
I/O
- 1 PS/2
- 1 D-Sub
- 1 DVI-D
ASRock H61M-ITX Motherboard

USB 3.0

BIOS

1 HDMI
1 SPDIF
4 USB 2.0
1 eSATA2
2 USB 3.0
1 RJ-45 LED (ACT/LINK LED
SPEED LED)
/ / /
/ / ( 7)
2 x ASMedia ASM1042 USB 3.0 USB 1.0/2.0/3.0
5Gb/s
3 x SATA2 3.0Gb/s , NCQ, AHCI
1 x
1 x
CPU/
24 ATX
4 12V

2 x USB 2.0 ( 4 USB 2.0 )


32Mb AMI BIOS
AMI UEFI Legal BIOS ( GUI)
Plug and Play,PnP
ACPI 1.1

jumperfree
, , ),CyberLink
MediaEspresso 6.5 , (CyberLink DVD
Suite - OEM )
ASRock Extreme Tuning Utility (AXTU) 8

Instant Flash 9
APP Charger 10
SmartView 11
XFast USB 12
On/Off Play 13
Hybrid Booster( ):
- ASRock U-COP 14
- Boot Failure Guard (B.F.G., )
LED

ASRock H61M-ITX Motherboard

143

CPU

CPU/
CPU/ ( CPU
)
- CPU/
- +12V, +5V, +3.3V,
- Microsoft Windows 7/7 64 /VistaTM/VistaTM 64 /
XP/XP 64
- FCC, CE, WHQL
- ErP/EuP( ErP/EuP )
15

* : http://www.asrock.com

, BIOS
,
,

144

ASRock H61M-ITX Motherboard


1 Hyper-Threading Technology CD User
Manual( , ) 39
2
14
3 Windows 7 / VistaTM / XP
4GB Windows 64 CPU
,
4 Intel

5 D-SubDVI-D HDMI
, DVI HDMI , DVI-D HDMI

6 Windows 7 64 /7 xvYCC Windows 7 64 /7/


VistaTM 64 /VistaTM HBR
7
2 4 6 8
3
8 ASRock Extreme Tuning Utility (AXTU)
Hardware Monitor
Fan ControlOverclockingOC DNA IESHardware Monitor
Fan Control
Overclocking CPU OC DNA
O C O C
OC IES (Intelligent
Energy Saver) CPU
ASRock Extreme Tuning Utility
(AXTU) ASRock

http://www.asrock.com
9 Instant Flash Flash ROM BIOS
BIOS ( MS-DOS
Windows ) BIOS <F6>
BIOS <F2> Instant Flash
, B I O S ,
B I O S ,
: FAT32/64

ASRock H61M-ITX Motherboard

145

10 , i P h o n e / i P a d / i P o d
touch , - APP Charger
APP Charger , iPhone
40% APP Charger ,
( S1) ( S3) ( S4) ( S5)
APP Charger ,

11 S m a r t V i e w I E
F a c e b o o k

ASRock SmartView
SmartView
Windows 7 / 7 64 / VistaTM / VistaTM 64
IE8ASRock http://www.asrock.com/Feature/SmartView/
index.asp
12 XFast USB USB

13 On/Off Play
PC MP3 PC ACPI S5
3.5m m

14 C P U
C P U
PC CPU
15 EuP, Energy Using Product( ),
EuP ,
1.00W EuP , EuP
EuP Intel , EuP
100mA ,5Vsb 50% EuP
,

146

ASRock H61M-ITX Motherboard

1.3

,
,
3
, 1 2

CMOS
(CLRCMOS1, 3 )
( 2 5 )

CMOS

C L R C M O S1 C M O S
15
CLRCMOS1 pin2 pin3 5 BIOS
CMOS BIOS CMOS CMOS
C M O S

ASRock H61M-ITX Motherboard

147

1.4

Serial ATAII
(SATA_0 (PORT 0):

SATA_0 (PORT 0) SATA_2 (PORT 4)

Serial ATAII
(SATAII) SATA

SATA_1 (PORT 1)

SATAII
3.0Gb/s

2 3 )
(SATA_1 (PORT 1):
2 2 )

(SATA_2 (PORT 4):


2 4 )

Serial ATA (SATA)

SATA
SATA/SATAII
SATAII

( )

3.5mm

3.5mm
MP3
PC
(Line-in)

( )

USB 2.0

I/O
USB 2.0
USB 2.0
USB 2.0
USB 2.0

(9 USB6_7)
( 2 10 )

USB_PWR
P-9
P+9
GND
DUMMY

(9 USB8_9)
( 2 8 )
1

GND
P+8
P-8
USB_PWR

(4 CIR1)
( 2 9 )

148

1
GND
IRTX
IRRX
ATX+5VSB

ASRock H61M-ITX Motherboard

GND
PRESENCE#
MIC_RET
OUT_RET

(9 HD_AUDIO1)
( 2 14 )

1
OUT2_L
J_SENSE
OUT2_R
MIC2_R
MIC2_L

1. (High Definition Audio, HDA)


(Jack Sensing), HDA

2. AC97 , :
A. Mic_IN(MIC) MIC2_L
B. Audio_R(RIN) OUT2_R, Audio_L(LIN)
OUT2_L
C. Ground(GND) Ground(GND)
D. MIC_RET OUT_RET HD
AC97
E.
Windows XP / XP 64 :
MixerRecorder
FrontMic
Windows 7 / 7 64 / VistaTM / VistaTM 64
:
Realtek FrontMicRecording
Volume

(9 PANEL1)

( 2 1 )

ASRock H61M-ITX Motherboard

PWRBTN( ):

RESET( ):
,

PLED( ):
,
S1 , S3/S4
(S5) ,
HD LED( ):
,

149

(3 PLED1)

PLEDPLED+
PLED+

( 2 19 )

LED S1
LED
S3/S4 S5 (
) LED

(3 CHA_FAN1)

( 2 18 )

CPU

4 3 2 1

(4 CPU_FAN1)
GND
+12V
CPU_FAN_SPEED
FAN_SPEED_CONTROL

( 2 17 )

CPU

4-Pin CPU (Quiet Fan, ),


3-Pin CPU 3-Pin CPU
CPU , Pin 1-3
Pin 1-3
3-Pin

ATX

24

13

12

(24 ATXPWR1)
( 2 7 )

ATX

24-pin ATX , 20-pin


ATX 20-pin ATX , Pin 1 Pin 13

20-Pin ATX

ATX 12V
(4 ATX12V1)
( 2 15 )

150

24

13

12

ATX 12V

ASRock H61M-ITX Motherboard

2. BIOS
Flash Memory BIOS (POST)
<F2> <Del> BIOS
BIOS <Ctl> + <Alt> +
<Delete>

B I O S
(PDF )

3.
Windows Microsoft Windows 7/7 64 /

VistaTM/VistaTM 64 /XP/XP 64

BIN ASSETUP.EXE

ASRock H61M-ITX Motherboard

151

Installing OS on a HDD Larger Than 2TB


This motherboard is adopting UEFI BIOS that allows Windows OS to be installed
on a large size HDD (>2TB). Please follow below procedure to install the operating
system.
1. Please make sure to use Windows VistaTM 64-bit (with SP1 or above) or
Windows 7 64-bit.
2. Press <F2> or <Delete> at system POST. Set AHCI Mode in UEFI Setup Utility >
Advanced > Storage Configuration > SATA Mode.
3. Choose the item UEFI:xxx to boot in UEFI Setup Utility > Boot > Boot Option #1.
(xxx is the device which contains your Windows installation files. Normally it is
an optical drive.) You can also press <F11> to launch boot menu at system POST
and choose the item UEFI:xxx to boot.
4. Start Windows installation.
5. If you install Windows 7 64-bit OS, OS will be formatted by GPT (GUID Partition
Table). Please install the hotfix file from Microsoft:
http://support.microsoft.com/kb/979903

English
152

ASRock H61M-ITX Motherboard

Das könnte Ihnen auch gefallen