Beruflich Dokumente
Kultur Dokumente
Connectors
Service Information
S600-12-1
Contents
General 1
Safety Information 2
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Isolating and Grounding a Cable Requiring
Repair 3
Reconnecting Cable to Apparatus Bushing 6
caution
Eaton's Cooper Power Systems 600 A T-OP II
terminator is designed to be operated in accordance
with normal safe operating procedures. These
instructions are not intended to supersede or replace
existing safety and operating procedures. Terminators
must be de-energized during operation or
maintenance. Visible break and adequate grounding
must be provided before cable work proceeds.
General
Equipment required
1 Voltage Tester
3 Grounding Elbows
1 Hotstick
Silicone Grease
Figure 2. One-line diagram of a three-phase cable connected to a three-phase switch on either end.
SAFETY
FOR LIFE
SAFETY
FOR LIFE
Eaton's Cooper Power Systems products meet or exceed all applicable industry standards relating to product safety. We
actively promote safe practices in the use and maintenance of our products through our service literature, instructional
training programs, and the continuous efforts of all Eaton's Cooper Power Systems employees involved in product design,
manufacture, marketing, and service.
We strongly urge that you always follow all locally approved safety procedures and safety instructions when working around
high voltage lines and equipment, and support our Safety For Life mission.
Safety information
The instructions in this manual are not intended as a
substitute for proper training or adequate experience
in the safe operation of the equipment described.
Only competent technicians who are familiar with this
equipment should install, operate, and service it.
Safety Instructions
WARNING
Before installing, operating, maintaining, or testing
this equipment, carefully read and understand
the contents of this manual. Improper operation,
handling or maintenance can result in death, severe
personal injury, and equipment damage.
G101.0
WARNING
WARNING
WARNING
DANGER
CAUTION
Indicates a hazardous situation which, if not avoided,
could result in minor or moderate injury.
Caution: Indicates a hazardous situation which, if
not avoided, could result in equipment damage only.
DANGER
APPARATUS BUSHING
LOADBREAK TAP
REDUCING PLUG
(LRTP)
URD CABLE
Operation
Isolating and grounding a cable requiring repair
Step 1.
De-energize cables.
Step 2.
Determine that cables are de-energized.
Step 3.
Provide a visible break.
WARNING
Do not proceed until cables are de-energized.
STEP 4
Provide a visible ground.
Grasp pulling eye of cap with hotstick and pull fully into
the stick.
Using the shotgun, install protective cap on to the
exposed apparatus bushing by threading the cap on to
the bushing stud.
Turn until tight and remove hotstick.
Repeat this procedure on both ends, for each cable to be
grounded. (Refer to Figure 10.)
Step 2.
Connect cable to apparatus bushing.
Step 1.
Determine that bushings are de-energized.
WARNING
Do not proceed until apparatus is de-energized.
SAFETY
FOR LIFE
Eaton
1000 Eaton Boulevard
Cleveland, OH 44122
United States
Eaton.com
Eatons Cooper Power Systems
Business
2300 Badger Drive
Waukesha, WI 53188
cooperpower.com
2013 Eaton
All Rights Reserved
Printed in USA
Publication No. S600-12-1 / March 1995
Eaton, Cooper Power Systems, and T-OP are valuable trademarks of Eaton, in the U.S. and
other countries. You are not permitted to use these trademarks without the prior written
consent of Eaton.