Beruflich Dokumente
Kultur Dokumente
Steps
Request: Electra/Huawei
Document Information
Prepared by: R & D Group
Author(s): Harman PS Grewal
Document creation date: 6-19-13
Revision History
Re
Date
6-19-13
Author
Harman
Description
Initial Draft
2
3
4
5
6
7
Document Approvals
Approver
Onur Yildirim
Organization
Telecom Technology Services Inc.
Date
6-19-13
The information in this document is intended for Telecom Technology Services, Inc. No part of this document may
be reproduced or transmitted in any form or by any means, electronic or mechanical, for any purposes, without
written permission of Telecom Technology Services, Inc.
1) Site Plan
First Step involved in creating S-info is Site Plan table, source file for creating Site
plan is csv or .xls file containing physical information for all the sites in the given
area. This contains all the basic information i.e. Site ID, Cell name, Latitude,
Longitude, M-tilt, E-tilt just a few to mention. Attached xls sheet below is a sample
source file for Site Plan table creation.
GSM_UMTS_SITE_DA
TA.XLSX
After Selecting Create Site Plan new Window shows up as shown below
User has options for Creating Cellname, Sitename and Sector Symbol
Option
Column Setup: This is the most crucial part, user needs to match the
Column names and Column # from Input Source file.User also has option
to save this sequence as Default using Save Default option. Site name,
Cell name, Latitude and Longitude , Azimuth, LAC & CI are
mandatory parameters for creating Site plan, others can be skipped(if un
available)
With the information put in, Hit Create and Opt PCS will Start
processing, results stored in the Output Site-plan Location and loaded in
Opt PCS as shown in Fig 03 below.
Site Plan has only Physical Parameters only i.e. Latitude, Longitude
,Azimuth, Height etc etc
3) S-info
With the Site plan created the next step is to create S-info which will require the
corresponding CM- Configuration Management also known as Switch data which
contains all the important parameters all the site RNC vise for a given market.
Similar to Site plan creation, user needs to
After selecting create SInfo UMTS new window shows up as shown above
in Fig 05
Input Source: This would be the Site Plan created in Step 1 using
Site Data
Vendors: Opt PCS has the capability to create S-info for different
Vendors viz a viz Ericsson, Lucent (ALU) and Nokia for each of these
we have GSM, UMTS and LTE separately. Electra or Huwaie is closer to
Ericson, so Ericson option can be used as of now, albeit a new radio
button can be added as the need arises.
Matching Key: very Import to select the matching key either with CI
or cell name, it depends on the CM data and the site plan created.
Switch Data: User needs to select/Upload the CM XML file here. User
can upload multiple XML files as per requirement.
Output Location: User needs to specify the Output path where S-Info
will be stored.
Once the Processing is done, Sinfo created is uploaded in Opt PCS and
result folder can be checked for set of files for the S-Info.