Beruflich Dokumente
Kultur Dokumente
lb
hb
Vb1
Vb1
Mb1 Mb1
C D C D
Pc Pc
Vc Vc
Mc Mc
rebar
actual
Anchorage ACI Joint Design Procedures
• Experimental observations show that joint strength
is fairly independent of transverse reinforcement if
minimum amounts are provided. This is the basis
for US approaches.
• Committee 352-2001 and 318-2002are different in
their details, but follow same general approach.
• Basic steps:
– Classify joints according to demands and geometry.
– Define joint demands
– Define joint capacity
– Provide joint confinement
– Provide reinforcement development
– Provide adequate strength in columns
Beam Section
Joint Demands (cont’d) Joint Shear Strength
Vu = φVn = γ f c' b j h ; φ = 0.85
Values of γ
Classification interior exterior corner
/type
cont. column. 20 (24) 15 (20) 12 (15)
Type 2 (1)
R oof 15 (20) 12 (15) 8 (12)
Type 2 (1)
Beam Strength:
Column Strength:
Model for Reinforced Joints
Strut and Tie - Allows designer flexibility in load path. One
approach is to assign all forces in longitudinal reinforcement to a
truss mechanism, and all compression in the flexural compression
zone to a single strut.