Beruflich Dokumente
Kultur Dokumente
(b) (i) Determine the current through each resistor in the circuit
shown in Fig.11(b) (i)(6) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(ii) Find out the current in each branch of the circuit shown in Fig.12
(a) (ii)(8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
Unit 1
1. Find the equivalent resistance of the circuit shown in Fig.
(ANNA UNIV MAY-JUNE 2014)(Reg 2013)
2. Define RMS voltage. (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
11.(a) (i) Find the current I and Voltage across 30 of the circuit
shown in Fig.11(a) (i)(8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(ii)Determine,the current in all resistors of the circuit shown in
Fig.11(a) (ii)(8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(b) (i) Determine the current through each resistor in the circuit
shown in Fig.11(b) (i)(6) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(ii) When a DZC voltage is applied to a capacitor, voltage across its
terminals is found to build up in accordance with Vc=50(1-e100t
).After 0.01S the current flow is equal to 2mA. (ANNA UNIV MAYJUNE 2014) (Reg 2013)
(1)Find the value of capacitance in farad. (ANNA UNIV MAY-JUNE
2014) (Reg 2013)
(2)How much energy stored in the electric field?(10) (ANNA UNIV
MAY-JUNE 2014) (Reg 2013)
Unit 2
1. What is reciprocity theorem.(ANNA UNIV MAY-JUNE 2014) (Reg
2013)
2. Why do you short circuit the voltage source and open the
current sources when you find Theveniss voltage of a
Network. (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
12 (a) (i) Determine the current in the 5 resistor in the network
shown in Fig.12(a) (i)(8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(ii) Find out the current in each branch of the circuit shown in Fig.12
(a) (ii)(8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(b) (i) Determine current in each mesh of the circuit shown in
Fig.12(b) (i) (8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
(ii)Determine the in each mesh of the circuit shown in Fig.12(b) (ii)
(8) (ANNA UNIV MAY-JUNE 2014) (Reg 2013)
Unit 3
1. Define quality factor in the resonant circuit. (ANNA UNIV MAYJUNE 2014) (Reg 2013)
2. Determine the quality factor of a coil for the series resonant
circuit consisting of R=10ohm,L=0.1H,and C=10microfard.
(ANNA UNIV MAY-JUNE 2014) (Reg 2013)
Unit 4
1. Distinguish between natural and forced response. (ANNA UNIV
MAY-JUNE 2014) (Reg 2013)
2. What is the time constant for RL and RC circuit? (ANNA UNIV
MAY-JUNE 2014) (Reg 2013)
Unit 5
1. Write the effect of power factor in energy consumption billing.
(ANNA UNIV MAY-JUNE 2014) (Reg 2013)
2. Distinguish between unbalanced source and unbalanced load.
(ANNA UNIV MAY-JUNE 2014) (Reg 2013)