0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
16 Ansichten1 Seite
1. This document discusses pump selection and installation for waste water systems. It describes wet-installed pumps, which are installed directly in the suction chamber and surrounded by waste water during operation. These were mainly used for smaller flow rates up to 1,600 qpm.
2. For pipe connections on wet-installed pumps, the inside diameter of discharge lines must be equal to or greater than the pump nozzle diameter. Valves and fittings must comply with standards, and butterfly valves are not suitable for waste water. Isolating gate valves with specific material requirements are recommended.
3. Material selection for pipes and supports is also discussed, noting corrosion resistance requirements. Pipes should have a smooth inner surface and be
1. This document discusses pump selection and installation for waste water systems. It describes wet-installed pumps, which are installed directly in the suction chamber and surrounded by waste water during operation. These were mainly used for smaller flow rates up to 1,600 qpm.
2. For pipe connections on wet-installed pumps, the inside diameter of discharge lines must be equal to or greater than the pump nozzle diameter. Valves and fittings must comply with standards, and butterfly valves are not suitable for waste water. Isolating gate valves with specific material requirements are recommended.
3. Material selection for pipes and supports is also discussed, noting corrosion resistance requirements. Pipes should have a smooth inner surface and be
1. This document discusses pump selection and installation for waste water systems. It describes wet-installed pumps, which are installed directly in the suction chamber and surrounded by waste water during operation. These were mainly used for smaller flow rates up to 1,600 qpm.
2. For pipe connections on wet-installed pumps, the inside diameter of discharge lines must be equal to or greater than the pump nozzle diameter. Valves and fittings must comply with standards, and butterfly valves are not suitable for waste water. Isolating gate valves with specific material requirements are recommended.
3. Material selection for pipes and supports is also discussed, noting corrosion resistance requirements. Pipes should have a smooth inner surface and be
Edo-wms-coe-cor-Int-xxx-014-247-275-Rev-d-methode Statment of Cathodic Protection System - Thermal Zinc or Aluminimum Alloys Spraying - of Concrete Surfaces