Beruflich Dokumente
Kultur Dokumente
Document Title:
Information
general
Function Group:
display, 387
Information Type:
Service Information
Date:
29/10/2013
Profile:
WLO, L120F [GB]
Figure 1
Instrument panel
1
Keypad
Display unit
The information panel provides the operator with information, messages, warnings, and alarms. With the keypad, the
operator can select group/function from which to read information. The keypad is also used to make settings and enter
number values.
The information panel and keypad are located on the instrument panel. The information panel is connected to the
instrument control unit (I-ECU).
When the machine is started, the latest figure is shown from the time that the machine was turned off. The information can
be adapted to the operator by selecting language and display format for units, time, and date.
Information organization
The information in the information panel is built up in a number of groups/functions:
Initial display
Operating information
Engine
Transmission
Hydraulics
Axles/Brakes
Electrical system
Vehicle information
Vehicle messages
Service
Setup
For detailed information, see description of each group.
Changing display screen
Move between groups/functions with the function keys on the keypad. When changing group/function, you always arrive at
the top figure in each function group. Return to the figure for operating information takes place with the ESC-key or
automatically when machine speed is over 20 km/h (12 mph).
Keypad
The following can be performed with the keypad:
Figure 2
Keypad
Select group
Scroll within group
Activate/deactivate functions
Reset and acknowledge
Setup (settings)
The keys' function are also described in the following table.
Certain keys also correspond to a digit which is shown on the key's lower right corner. The number values are used, e.g.,
when setting date and entering PIN-code for theft protection.
The key SELECT
malfunctions.
The key
is used to, e.g., make selections, acknowledge, and to get detailed information about any
1
Return
Engine
Scroll up
Axles
Hydraulic system
Vehicle information
Transmission
Electrical system
SETUP
Scroll down
Vehicle messages
Service
Setup (settings)
SELECT
Confirm
Service mode
The information panel has a function called Service mode. With active Service mode it is possible to access additional or
alternative information, e.g., numerical values instead of bars and part numbers for software. Service mode also has
additional functions, e.g., simultaneous acknowledgement of all alarms.
The following conditions must be fulfilled to activate Service mode:
engine off
Parking brake applied
Service key pressed in for more than 3 seconds
Approved message Enter Service mode with SELECT-key within 10 seconds.
When Service mode is active the symbol
in the Service-key for at least 3 seconds.
is shown in the lower field in the operating display. To leave Service mode, press
The functions for Service mode are described further under each group.
Warnings and alarms
Warnings and alarms from the machine are obtained through a combination of central warning, buzzer, and messages in
the information panel. For further information about central warning, see 387 Central warning.
Messages about alarms in the information panel are either instructional or informative. In case of serious malfunction, both
instructional and informative messages are obtained as follows:
First the instructional message is obtained, e.g. Stop vehicle or Turn Off Engine.
After the instruction has been performed, the informative message is obtained, e.g. Low oil level engine.
WARNING
Do not ignore the alarm and continue to operate the machine! Safely shut down the machine. Inspect and
repair the fault. Failure to comply could result in injury!
For further information about alarms, see 387 Alarm, description.