Beruflich Dokumente
Kultur Dokumente
99000118
Table of Contents
Rear Blower
Operating Instructions
The blower will not turn on until the appliance is up to temperature. Once up to temperature, the blower will
operate at the speed determined by the position of the blower knob (see the illustration below). The blower
will shut off once the appliance cools.
OFF
Turn the knob
all the way
counterclockwise to
turn off.
HIGH
Turn the knob
clockwise from
the off position
until it clicks.
LOW
Turn the knob
all the way
clockwise to
turn to low.
Page 1 of 5
17601791.docx - 5/2/13
Snap Disk
Assembly
Ashlip
2A Secure the snap disk wires in place following the directions below. Go to step 3.
Snap Disk
Wires
NOTE:
2B
(Liberty, Endeavor only)
Install the snap disk assembly inside the heat shield following the directions below. Secure the snap disk
wires in place following the directions below.
Hang the snap disk assembly in
the space between the stove
and rear heat shield on the left
side. Bend the legs of the
assembly to ensure a tight fit.
Wire Clip
Secure the snap disk wires in place following the directions below.
NOTE: The wires must be properly secured to prevent them from contacting the firebox and
shorting out the blower circuit.
Page 2 of 5
17601791.docx - 5/2/13
A ll Other Models :
NOT E :
P rior to attaching the blower, tuck all exces s
wire into the area ins ide the blower.
Page 3 of 5
17601791.docx - 5/2/13
b
a
P lace the s nap dis k as s embly over the s nap dis k extender
(included with the s tove) and bend thes e tabs to s ecure.
Snap Disk
As s embly
Snap Disk
Extender
A s hlip
3/8" Wrench
f
h
Page 4 of 5
P os ition the blower near the rear of the s tove. T uck all exces s wire into the
blower box, making s ure it does not contact any moving parts . Make s ure when
ins talling the blower, thes e wires do not become loos e.
P lug the blower in. Do not route the power cord under or over the s tove or in a
location where it may become damaged.
17601791.docx - 5/2/13
c
a
b
Place the blower near the
back edge of the stove.
3/8" Wrench
f
Attach the blower to the
stove with the three screws
included with the blower.
Attach
the2rheostat
rheostat
Use the
includedbox
M8and
bolts
to attach the
mounting
bracket (upside
rheostat bracket
(upsidedown)
down)totothe
the
2underside
bolts located
on the
underside
theleft
of the
stove
behindofthe
stove
front behind
leg. the left front leg.
With the blower near the rear of the stove, tuck all excess wire into the blower
box, making sure it does not contact any moving parts. Make sure when
installing the blower, these wires do not become loose.
Page 5 of 5
Plug the blower in. Do not route the power cord under or over the stove or in a
location where it may become damaged.
17601791.docx - 5/2/13