Beruflich Dokumente
Kultur Dokumente
only. Determine the ratio of maximum to minimum in-plane shear stress in the cylinder.
Problem 2 (60 marks)
A steel cylinder of outer and inner radii of 200 and 100 mm is to be press-fit over a solid steel
shaft of radius 100.2 mm. Calculate
(a) the interface pressure, and
(b) the change in the outer diameter of the steel cylinder.
Quiz 3:
Problem 1 (30 marks)
A cylinder with closed ends with
= 0.5 m and
only. It the maximum tensile stress in the cylinder is limited by 100 MPa, determine the
allowable value of
Quiz 4:
Problem 1 (30 marks)
A steel tank having an internal diameter of 1.0 m is subjected to an internal pressure of 10
MPa. The (uniaxial) yield strengths of the material is 500 MPa. Assuming a factor of safety 2
and based on von-Mises theory, determine the wall thickness.
Problem 2 (70 marks)
A thin circular disk of Youngs modulus , Poissons ratio , inner radius
is shrunk onto a rigid plug of radius
, employing
von-Mises criterion.
(b) Find the allowable speed for a disk constructed of aluminium alloy with
= 0.2;
= 200 MPa;
= 100 mm.
= 0.5 m and
only. If the absolute value of the compressive stress in the cylinder is limited by 100 MPa,
determine the allowable value of
Problem 2 (70 marks)
A flat annular steel disk of 4 outer diameter and 2 inner diameter rotates at 5000 rpm. If the
maximum radial stress is to not exceed 50 MPa, taking typical material properties for steel
determine
(a) The radial wall thickness
and