Beruflich Dokumente
Kultur Dokumente
Living
Outside
Play
Technology
Workshop
Table of Contents
PWM and Frequency Controller (for lasers and diodes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Related Instructables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Advertisements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
http://www.instructables.com/id/PWM-and-Frequency-Controller-for-lasers-and-diode/
Author:Electo4fun MitchBot
Likes computer programming and electronics.
Image Notes
1. The dashed lines are the frequency changing. This was taken with a slow shutter camera.
http://www.instructables.com/id/PWM-and-Frequency-Controller-for-lasers-and-diode/
Jumper Wire
Breadboard
All of the parts can vary slightly! The diodes can be almost any type and the pots can be any value as well.
Image Notes
1. Brightness Pot
2. Duty Cycle Pot
3. Frequency Pot
4. Ignore these other circuits
5. LM555 Chip
6. Frequency Determining Capacitor
Image Notes
1. Dimmer Pot
2. Duty Cycle Pot
3. Frequency Pot
4. Voltage Regulator for Diodes
5. You may want to put a power resistor here for high amp sources or you can have two different supplies that are connected to ground. Don't forget about pin 5 and
7's positive connections.
http://www.instructables.com/id/PWM-and-Frequency-Controller-for-lasers-and-diode/
Image Notes
1. Variable Frequency
Image Notes
1. Brighter than the picture to the right. An example of the brightness pot.
Image Notes
1. Dimmer LED
http://www.instructables.com/id/PWM-and-Frequency-Controller-for-lasers-and-diode/
Image Notes
1. Dimmer Pot
2. Frequency Pot
3. Duty Cycle Pot
Image Notes
1. LED Power ON indicator
Image Notes
1. Dimmer Pot
2. Duty Cycle Pot
3. Frequency Pot
4. Voltage Regulator for Diodes
5. You may want to put a power resistor here for high amp sources or you can
have two different supplies that are connected to ground. Don't forget about pin 5
and 7's positive connections.
Related Instructables
Very simple
PWM with
555...Modulate
every thing by
shams
Simple PWM
Flyback driver
tutorial by
Electorials
Pulse Width
Modulated LED
Torch by
mathews
Music to RGB
leds by bthjehiel
Simple (and
dirty) Pulse
Width
Modulation
(PWM) With 555
Timer by Chein
Homemade
PWM and
frequency
controllable
flyback driver
(video) by
Electorials
http://www.instructables.com/id/PWM-and-Frequency-Controller-for-lasers-and-diode/
Advertisements
http://www.instructables.com/id/PWM-and-Frequency-Controller-for-lasers-and-diode/