Beruflich Dokumente
Kultur Dokumente
TarGATE15
www.gateforum.com
A card is drawn at random from a pack of cards, if it is known that the card drawn is red,
what is the probability that it is a heart?
(A) 0.87
(B) 0.75
(C) 0.5
(D) 0.59
2.
3.
(B) -17
17
(D) 17
4.
(C)
t 12 if
f t
if
0
(A)
2e s
s3
t 1
0 t 1
(B)
es
s3
(C)
3e s
s2
(D)
2e s
s2
5.
6.
7.
For a laminar flow in a pipe, if height of the surface roughness is doubled then DarcyWeisbach friction factor will
(A) Remain unchanged
(B) Be halved
(C) Be doubled
(D) Increase four times
8.
For a turbulent boundary layer (under zero pressure gradient), the velocity profile is described
by the (1/5)th power law. Then the ratio of displacement thickness to boundary layer thickness
is _________________.
9.
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
TarGATE15
www.gateforum.com
10.
11.
The thickness of laminar and turbulent boundary layer of flat plate is proportional to
(A) x and
12.
(B)
x and x4/5
(C) x2 and x5
List II
(1) vdP
(3)
P1V1 P2 V2
r 1
(4)
P1V1 P2 V2
n 1
13.
Which of the following statements is CORRECT regarding the throttling process of wet
steam?
(1) Steam pressure and temperature decreases but enthalpy remains constant.
(2) Steam pressure decreases and temperature increases but the enthalpy remains constant.
(3) Entropy, specific volume and dryness fraction increases.
(4) Entropy increases but the volume and dryness fraction decreases.
(A) 1 & 4
(B) 2 & 3
(C) 1 & 3
(B) 2 & 4
14.
Which of the following statements are CORRECT, if a surface pockmarked with a number of
cavities compared to a smooth surface?
(P) Radiation will increase
(Q) Nucleate boiling will increase
(R) Conduction will increase
(S) Convection will increase
(A) P, Q & R
(B) P, Q & S
(C) P, R & S
(D) Q, R & S
15.
In a counter flow heat exchanger, the hot fluid is cooled from 110OC to 80OC by a cold fluid,
which gets heated from 30OC to 60OC. LMTD for the heat exchanger (OC) is
_________________.
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
TarGATE15
www.gateforum.com
16.
In the current carrying conductors, if the radius of the conductor is less than the critical
radius, then addition of electrical insulation is desirable as it
(A) Reduces the heat loss from the conductor and thereby enables the conductor to carry
higher current.
(B) Increases the heat loss from the conductor and there by enables the conductor to carry
higher current.
(C) Increases the thermal resistance of the insulation and there by enables the conductor to
carry higher current.
(D) Reduces the thermal resistance of the insulation and there by enables the conductor to
carry higher current.
17.
In an inter phase heat transfer process, the equilibrium state corresponds to the equality of
temperatures in the two phases, while in inter phase mass transfer process, equilibrium
corresponds to
(A) Equality of concentrations
(B) Equality of chemical potentials
(C) Equality of coefficients
(D) Equality of mass coefficients
18
The boundary conditions where the concentration and flux are constant at the plate is given as
(A) y 0,C1 Ci ,
y2
0
2 C1
2 C1
0
y2
(D) y 0,C1 0,
2 C1
0
y2
2 C1
0
y2
19.
If the reflux ratio of the fractionating column has/is_____________, then it has minimum
number of ideal stages.
(A) Zero
(B) Minimum reflux ratio
(C) Infinity
(D) Optimum reflux ratio
20.
For a fluid processing plant, the delivered equipment cost is Rs.20 lakhs. Using Lang
multiplication method, the total capital investment in lakhs is
(A) 46
(B) 92
(C) 57
(D) 114
21.
List-II
1.
Shower Plate
P.
2.
Valve Plate
Q.
3.
Bubble Plate
R.
4.
Sieve Plate
S.
(A) 1-S;2-Q;3-R;4-P
(C) 1-R;2-P;3-S;4-Q
(B) 1-Q;2-S;3-P;4-R
(D) 1-P;2-R;3-Q;4-S
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
22.
23.
TarGATE15
www.gateforum.com
mol
The individual mass transfer coefficients 2 for absorption of a solute from a gas
m s
mixture into a liquid solvent are K L 4.5 and KG 1.5 . If the slope of equilibrium line is 3,
then which of the following resistance controls the reaction?
(A) Liquid-side
(B) Gas-side
(C) Interfacial
(D) Both Liquid-side and Gas-side
(A)
T anh T
T
T
(B) T anh
T
(C)
T an hT
T anh T
1.25 104 K
, then what is the value of K at 670K?
T
(B) 2.8 x 10-5 S-1
(C) 4.8 x 10-5 S-1
(D) 1.8 x 10-5 S-1
If the values of Ka and Kb at 25OC for the first order reaction R P are
1.5 x 104 S-1 and 3.0 x 105 S-1 respectively, then calculate the relaxation time.
26.
27.
(B) r kc t sin
(C) r k 1 cos
(D) r kc t cos
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
TarGATE15
28.
29.
, is ________.
3
9
3
(B)
9 3
2
(C)
9
2
(D)
37
3
The value of b by fitting a line y = a + bx for the given data with method of least squares is
x
(A) 0
31.
30.
www.gateforum.com
(B) 2
(C) 1
(D) 1
If water of =1 centistokes flows through a pipe of 1cm diameter, then critical flow
corresponding to a discharge is (approximately)
(A) 0.008 l/s
(C) 0.016
32.
An oil of viscosity 9 poise is flowing through a horizontal pipe of 60mm diameter. If the flow
is laminar, then the pressure drop in 100m length of the pipe is 1800kN/m2. Find the average
velocity flow of the oil (m/s).
33.
A venturimeter is used for measuring discharge of water in a horizontal pipeline. The ratio of
upstream pipe diameter to that of the throat is 2:1, upstream diameter is 300mm, the
difference of pressure between the throat and upstream is 3m head of water and loss of head
through meter is 1/8th of the throat velocity head. Find the discharge in the pipe.
(A) 121.5l/s
34.
(C) 141.25l/s
(D) 127.93l/s
35.
(B) 131.5l/s
(B) 3.141m
(C) 6.23m
(D) 9.8m
If a fluid of kinematic viscosity of 0.4 cm2/sec flows through 8 cm diameter pipe, then the
maximum velocity of the laminar flow will be
(A) Less than1m/sec
(B) 1m/sec
(C) 1.5m/sec
(D) 2m/sec
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
TarGATE15
www.gateforum.com
36.
Two small orifices A and B of diameters 1cm and 2cm respectively are placed on the sides of
a tank at depths of h1 and h2 below the open liquid surface. If the discharges through A and B
are equal, then the ratio of h1 to h2 (assuming equal Cd values) will be
(A) 16: 1
(B) 2: 1
(C) 8: 1
(D) 4: 1
37.
List II
(P) Nylon
List II
P.
Nyloy-66
1.
Q.
Terylene
2.
R.
Nylon-6
3.
S.
Orlon
4.
Polymer of vinylcyanide
If for a counter flow heat exchanger with Th' 80C, TCO 60o C, ThO 50C,TC1 30C
and temperature difference between two streams being the same everywhere along z, then the
direction of flow of hot fluid and temperature profile should satisfy which of the following
relation?
(A)
40.
d2T
0
dz 2
(B)
d2T
0
dz 2
(C)
d2T
0
dz 2
(D)
dT
0
dz
Air at 20OC at atmospheric pressure is flowing over a flat plate at a velocity of 3m/sec. If the
plate is 30cm wide and is at 60OC, calculate boundary layer thickness (in mm) at x = 30cm.
Properties of air at mean temperature 40OC.
1.128kg / m3 , 19.1106 kg / m s
cP 1007kJ / kg, k 0.0273W / m k
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
41.
42.
TarGATE15
www.gateforum.com
If the velocity constant for the decomposition of nitrous oxide is 5.16x104 at 1125K and 3.76
x 103 at 1085K, then calculate the activation energy.
(A) 1.78 x 105 cal mol-1
List II
(3) Distillation
(S) Selectivity
43.
A new piece of completely installed equipment costs Rs.28000 and has scrap value of
Rs.2000 at the end of its constructive life. If constructive life period is 10 years and the
interest is compounded at 8% per year, the capitalized cost of equipment is
Rs.__________________.
44.
A column costs Rs.5 lakhs and has constructive life of 10 years. Using the double declining
balance depreciation method, the book value of the unit at the end of 5 years is
(A) Rs.1.21 lakhs
(B) Rs.1.31 lakhs
(C) Rs.1.64 lakhs
(D) Rs.2.05 lakhs
45.
A 20kg solid at 100OC with a specific heat of 0.8kJ/kgOC is immersed in a 30kg of 20OC
liquid with a specific heat of 4 kg/kgOC. The temperature (OC) after longtime, if the container
is insulated is __________________.
46.
47.
K1
K2
For the consecutive reaction A
B
C numerical values are
TarGATE15
www.gateforum.com
48.
Mild steel sphere of 12mm diameter (K = 42.5W/mK) is exposed to cooling airflow at 27OC
resulting into the convective coefficient h = 114W/m2k. The relevant properties of mild steel
are density = 7850 kg/m2, specific heat C = 475J/kg, and thermal diffusivity =
0.043m2/hr. The time (min) required to cool the sphere from 540OC to 95OC will be
________________.
49.
A spherical thin walled metallic container is used to store liquid nitrogen at 77K. The
container has a diameter of 0.7m and is covered with an evacuated, reflective insulation
composed of silica powder. The insulation is 50mm thick, and its outer surface is exposed to
ambient air at 300 K. The convection co-efficient is known to be 25W / m2 K . The latent
heat
of
vaporization
and
density
of
liquid
nitrogen
are
5
3
2 10 J / kg and800kg / m , respectively. What is the rate of heat transfer to the liquid
nitrogen? Assume Ksilca 0.0015W / m.K.
(A) 25W
(B) 22W
(C) 27W
(D) 20W
50.
A plant produces phenol. The variable cost in rupees per tonne of phenol allied to the plant
capacity P (in tonnes/day) as (45000 + 5P). The fixed charges are Rs.100000 per day and the
selling price of phenol is Rs 50000 per tonne. The optimal plant capacity (in tonnes per day)
for minimum cost per tonne of phenol is
(A) 101
(B) 141
(C) 283
(D) 422
51.
52.
2000
.
s s 10 s 20
The breakaway points of an open-loop transfer function are located at -7.73 and
-4.27 in the root locus. Find the value of a, if the open loop transfer function is represented
K s a
as G s H s
.
s 3 s 5
(A) 5
(B) 3
(C) 6
(D) K
54.
Oil with viscosity 8poise and specific gravity of 1.2 is flowing through a horizontal pipe of 80
mm diameter. The pressure drop is 1500KN/m2 and length of the pipe is 100m. The rate of
flow of oil in m3/sec is
(A) 0.032
(B) 0.0188
(C) 0.063
(D) 0.0332
55.
The payback period of production equipment, which costs 2 lakhs is 6 years. What will be the
expected return value per annum, if the corporate tax is 40% of the gross return and the
salvage value is Rs.20000?
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
56.
57.
TarGATE15
www.gateforum.com
58.
(B) commotion
(C) stagnant
(D) dejected
Choose the word from the options given below that is most nearly opposite in meaning to the
given word:
RECALCITRANT
(A) refractory
59.
(B) repulsive
(C) obedient
(D) considerable
Choose the most appropriate word from the options given below to complete the following
sentence:
Autumn 2003 marked the start of the 50th anniversary _________ of Dylan Thomas
untimely death.
(A) celebration
60.
(B) congress
(C) commemorations
(D) proceedings
Directions for the Question: Considering the statements a, b and c to be true, choose the
conclusions which are definitely true from the statements disregarding commonly known
facts.
(a) All Ts are Ss
(b) All Ss are Rs
(C) All Rs are Us
Conclusions:
(i) Some Us are Ts
(ii) Some Us are Ss
(iii) Some Rs are Ss
(A) Only (ii) follows
61.
Two explosions took place at a time interval of 60 minutes at same location. A biker moving
away from the place heard the first explosion when he was at place X and heard the next
explosion at a place Y after 63 minutes. What is the distance between the two places X and
Y, if the speed of sound was 267 m/s?
(A) 27.9 Km
(B) 48.6 Km
(C) 48.06 Km
(D) 52.06 Km
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
TarGATE15
62.
What could be the maximum number of distinct divisions a plane can be divided using 101
lines?
(A) 202
63.
www.gateforum.com
(B) 203
(C) 5151
(D) 5152
400
325
300
300
250
225
225
200
175
200
185
150
175
95
75
100
0
1996-97
1997-98
1998-99
1999-00
2000-01
2001-02
years
What is the ratio of number of years in which the actual production was above the average
production to the number of years whose actual production is below the average production?
(A) 2 : 1
(B) 1 : 1
(C) 1 : 2
(D) 3 : 2
64.
Two containers contain wine and water in the ratio 7:6 and 7:2 respectively. What quantity
(approximately) from the first container should be mixed with 714.42 litres of the second
such that the new mixture contains wine and water in the ratio 7:3?
(A) 714 litres
(B) 388 litres
(C) 398 litres
(D) 344 litres
65.
ICPIntensive Classroom Program eGATE-Live Internet Based Classes DLP TarGATE-All India Test Series
All rights reserved by Gateforum Educational Services Pvt. Ltd. No part of this booklet may be reproduced or utilized in any form
without the written permission.
10