Beruflich Dokumente
Kultur Dokumente
User Manual
+86-27-87691549
Fax:
+86-27-87691755
Trademarks
TM
TM
TM
II
Packing List
After opening the packing case of AN5506-04, please check whether the
corresponding articles are in the packing case according to Packing List
as below:
Name
Quantity
Remark
AN5506-04 equipment
Certificate of conformity
Optional.
adapter
Wall-hung screws
III
Contents
1.2
2.2
3 Installation ....................................................................................3-1
3.1
3.2
3.3
3.1.2
Installation Precautions.............................................3-1
3.2.2
3.3.2
3.3.3
3.3.4
3.4
Figures
Tables
Table 1-2
Table 2-1
Table 2-2
Product Introduction
1.1
Product Functions
AN5506-04 is a kind of FTTH GPON optical network unit. It provides
communication and entertainment services in multiple modes such as data
and voice for subscribers, so as to meet integrated access demand of
families or small enterprises.
The networking diagram of AN5506-04 is shown as below:
INTERNET
PC
GPON uplink
NGN
Phone
AN5506-04
AN5516-01
CATV
Phone
1-1
1-2
Product Introduction
1-3
1.2
Technical Specifications
The following introduces the technical specifications of AN5506-04 (for
example) are introduced in detail as below.
Table 1-1
Type
Item
Description
Supports H.248, MGCP and SIP voice protocols;
Voice
VLAN
Service
parameter
MAC address
Multicast
QoS
Wire speed
layer 2 / 3
switch
Network side
PON interface
interface
LAN interface
Phone
interface
Mechanical
parameter
1-4
Subscriber
side interface
Size
Weight
About 650g.
1
Type
Item
Product Introduction
Description
Power supply
AC
10W
parameter
Power
consumption
parameter
Operating
-10 to 45
temperature
Environment
Storage
parameter
temperature
-30 to 60
Ambient
10% to 90%, non-condensing.
humidity
Note: Four Ethernet ports on AN5506-04 can not be set to the same VLAN in untag
mode. They should have different VLAN IDs.
1-5
Appearance Description
2.1
2-1
Figure 2-1
Indicator
Indicator LED
Color
State
Description
The
On
equipment
has
been
VoIP
IAD state
Green
Blink
A call is in progress.
The equipment has not been
Off.
On
Phone1 / 2
Phone state
Green
Blink
Off
2-2
2
Indicator
Indicator LED
Color
State
Description
On
(Yellow)
Power
Power state
Yellow-green
Appearance Description
On
(Green)
Off
equipment
is
not
has
been
electrified.
On
The
equipment
Registration state
Green
Blink
An
error
occurs
during
registration.
Off
On
LOS
Red
Off
The
equipment
receives
optical signals.
This interface is connected
On
Ethernet
transmission.
interface
LAN1/ 2 / 3 / 4
Green
state
Blinking
Off
On
Battery
Note
Storage
Blinking
battery
Green
state
Note: when AC adapter is adopted for power supply, Battery LED is off and meaningless.
2-3
2.2
2-4
Appearance Description
Interface or
Meaning
Type
Power switch
Button
Description
Button
Power
Power
interface
adapter.
Storage
USB
battery
interface
adapter.
CATV
CATV
interface
box.
Ethernet
LAN1 to LAN4
interface
and so on.
Network
For local equipment
interface for
Console
RJ-45
local
subscribers.
debugging
Optical
PON
interface
Phone1 to
splitter.
Phone
Phone2
interface
subscriber phone.
Note: USB interface is available only in AN5506-04 adopting USB power supply
2-5
Installation
3.1
Installation Preparations
3.1.1
Unpacking Check
After opening the packing case of AN5506-04, please check articles in the
packing case according to Packing List. If it is found that articles in the
packing case do not comply with the list, please contact the local office of
FiberHome directly.
3.1.2
Installation Precautions
Before installing AN556-04 please ensure that the following requirements
are met:
3-1
3.2
Fixation of Equipment
AN5506-04 can be laid on a stable plane (such as a desk), or be hung on
the wall. Subscribers can select suitable installation mode on their
demand. The fixation methods of the two modes are as follows.
3.2.1
Flat Fixation
1)
2)
3.2.2
Wall-hung Fixation
1)
2)
Align the recesses on AN5506-04 bottom panel with the screws and
fix up slightly.
3)
3-2
Installation
3.3
3.3.1
Plan the wiring and cabling mode of the network cable, measure the
distance between AN5506-04 LAN interface and the subscriber
terminal, and select the network cable with a suitable length;
2)
Fix the network cable and then make Ethernet connectors for both
ends;
3)
3-3
4)
5)
Optical Splitter
Switch
AC power
adapter
Phone
PC
Phone
Mains Supply
PC
PC
3.3.2
3-4
1)
Installation
Plan the wiring and cabling mode of the phone cable, measure the
distance between AN5506-04 Phone interface and the subscriber
phone, and select the phone cable with a suitable length;
2)
Fix the phone cable and then make RJ-11 connectors for both ends;
3)
3.3.3
4)
5)
Plan the wires and cables layout mode of the optical fiber; measure
the distance between AN5506-04 PON interface and upstream
optical splitter; select the optical jumper with suitable length;
2)
Fix the optical fiber; remove the protection covers of the optical
jumper and AN5506-04 optical interface;
3)
Insert one end of the optical jumper into AN5506-04 PON interface
slightly;
4)
Connect the other end of the optical jumper with the optical splitter;
5)
Caution 1: if the optical fiber jumpers are not used, make sure
optical fiber jumpers and AN5506-04 optical interfaces are
covered to avoid dust contamination and water penetration,
which lead to the uselessness of optical fiber jumpers and
AN5506-04 optical interfaces.
3-5
3.3.4
AC Power Connection
1)
2)
3)
4)
2)
3)
4)
3-6
Installation
Note: USB storage battery power adapter has a Battery LED. When the
storage battery is being recharged, it is lit red. When battery recharging is
finished, it is lit green.
Optical Splitter
USB storage
battery power
adapter
Switch
Phone
PC
Phone
Mains Supply
PC
PC
3-7
3.4
2)
3)
4)
5)
6)
Observe the status of Phone indicator LED. If before and after the
phone is picked up, Phone indicator LED turns OFF to ON, it means
the phone cable is connected normally; otherwise, please check
whether the connection of phone cable is correct.
7)
3-8
4-1
4-2
feedback
is
an
important
way
for
us
to
receive
questions,
comments
and
Excellent
Good
Normal
Bad
Expression
Integrity
Exactitude
Structure
Illustration
Getup
General
2. Please give your advices on the items listed below about this manual by the symbol .
Adjust its structure
5. The personal inform ation requested is used for no other purposes than to respond to your feedback
Name
Job/Position
Working Unit
+86-27-87691549
Fax:
+86-27-87691755
Website: http://www.fiberhomegroup.com