Beruflich Dokumente
Kultur Dokumente
004293
004327
INTRODUCTION
IMPORTANT
This equipment is designed for use on
only Class A Fires and Class B
Hydrocarbon Fires.
Bladder tanks are mechanical devices. They need periodic
care. Inspections provide reasonable assurance that the
bladder tank is full and the system is operable. Inspection
should take into consideration the environment, system use,
and user inspection policy; but as a minimum should be
conducted semi-annually. Maintenance, which provides
maximum assurance that the ANSUL foam concentrate is
effective and the system is operable, should be conducted
at annual intervals, or earlier when indicated by an
inspection.
WARNING
CAUTION
NOTICE
ANSUL Foam Concentrates must be
stored within the temperature range listed
on the tank nameplate. If the concentrates
require storage outside of these temperature ranges, consult Tyco Fire Protection
Products, Applications Engineering,
Marinette, Wl 54143-2542.
Also, particular attention should be given
to the Field Inspection Manual (Part No.
31274) which deals with the testing procedures for ANSUL Foam Concentrates.
CAUTION
Lifting lugs are designed to lift the tank empty while utilizing two lift lugs on vertical tanks and four lift lugs on horizontal tanks. The angle of the rope or chain from
horizontal must be 30 degrees or greater.
008397
TABLEOFCONTENTS
SECTION
________
PAGE
_____
Equipment Description
System Schematics
24
Installation
Initial Fill
78
Minor Refill*
9 10
Major Refill**
10 12
Inspection
13
Maintenance
14 15
16 18
EQUIPMENT DESCRIPTION
Page 1
EQUIPMENT DESCRIPTION
BLADDER VENT/
FILL VALVE
TANK SHELL
VENT VALVE
CONCENTRATE
OUTLET
TANK
WATER
INLET
BLADDER
CENTER
TUBE
TANK SHELL
DRAIN VALVE
BLADDER
DRAIN/FILL
VALVE
SIGHT GAUGE
TEE
FIGURE 1
004295
WATER
INLET
BLADDER VENT/
FILL VALVE
CONCENTRATE
OUTLET
TANK SHELL
VENT VALVE
CENTER
TUBES
TANK
WATER
CHANNEL
TANK SHELL
DRAIN VALVE
BLADDER
BLADDER DRAIN/
FILL VALVE
SIGHT
GAUGE TEE
FIGURE2
004296
SYSTEM SCHEMATICS
Page 2
SYSTEM SCHEMATICS
The following schematics (Figures 3 and 4) represent typical
system piping and valving arrangements for bladder proportioning systems with vertical or horizontal tank configurations. These systems, however, must be designed by
competent, experienced engineers to ensure equipment
compatibility; proper functioning of the system; and compliance with NFPA codes, as well as local and end-user
requirements.
Tyco Fire Protection Products typically supplies:
Foam agent
Bladder tank with tank valves
Proportioner with built-in metering orifice
Most discharge devices
IMPORTANT
Because of the similarities between vertical and horizontal bladder tanks, the
procedures and tank valve functions are
identical. Therefore, vertical bladder tank
schematics are used exclusively throughout the remainder of this manual. For horizontal bladder tanks, refer back to Figures
2 or 4 for valve locations.
TO DISCHARGE
DEVICES
Supplied by others:
Special operational valves (manual or automated)
Strainers
Interconnecting piping
STRAINER (REQUIRED
WITH PROTEIN-BASED
FOAMS)
BLADDER
VENT/FILL
VALVE
PROPORTIONER
BLADDER
VENT/FILL
VALVE
TO
DISCHARGE
DEVICES
SWING
CHECK VALVE
PRESSURIZED
WATER
SOURCE
CONCENTRATION
ISOLATION VALVE
WATER INLET VALVE
(MANUAL OR
AUTOMATED)
SYSTEM ACTUATION
VALVE (MANUAL OR
AUTOMATED)
TANK SHELL
VENT VALVE
SWING CHECK
VALVE
PRESSURIZED
WATER SOURCE
TANK SHELL
VENT VALVE
CONCENTRATE
ISOLATION
VALVE
BLADDER
DRAIN/FILL
VALVE
TANK SHELL DRAIN VALVE
WATER INLET
VALVE (MANUAL
OR AUTOMATED)
SIGHT
GAUGE TEE
FIGURE 4
004298
SIGHT
GAUGE TEE
TANK SHELL
DRAIN VALVE
BLADDER DRAIN/
FILL VALVE
FIGURE 3
004297
SYSTEMSCHEMATICS
Page 3
006912
SYSTEM SCHEMATICS
Page 4
ANSUL
SIGHT GAUGE
(OPTIONAL)
BLADDER TANK
ER
KL M
RIN AR
SP E-AL
FIR
NO.
10
11
SEE NOTE (8)
CLOSED
CLOSED
CLOSED
CLOSED
FLOWMAX CL
VARIABLE RANGE
PROPORTIONER
NORMAL POSITION
- 1"
CLOSED
CLOSED
DESCRIPTION
BLADDER VENT/FILL
- 1"
CLOSED
OPEN
8
---
---
---
CLOSED
- 1"
CLOSED
---
CLOSED
---
OPEN
DWN.
DATE
EEH
03-19-07
SCALE
APPD.
NONE
One Stanton
ANSULStreet
FIRE PROTECTION
MARINETTE,
WI 54143-2542
Marinette,
WI 54143
USA
CHKD.
SHEET 1 OF 1
AE-60124
DRAWING NUMBER
CLOSED OR OPEN
---
CLOSED
NOTES:
AUTO SYSTEM
2
- 1"
OPEN
CLOSED
3
BLADDER DRAIN/FILL
- 1/2"
MANUAL SYSTEM
DESCRIPTION
10
OS&Y - 6"
OPEN
11
CLOSED
12
REV.
007596
INSTALLATION
Page 5
INSTALLATION
To prepare the bladder tank for placement in service:
1. Remove all cord, wrapping, and banding ties. Examine
entire system and component parts for concealed shipping damage before placement or securement on site.
NOTICE
If the bladder tank is to be connected
to a Closed Head Sprinkler System,
contact Tyco Fire Protection Products,
Applications Engineering, Marinette,
Wl 54143-2542.
NOTICE
For bladder tank dimensions, refer to
Vertical and Horizontal Bladder Tank
Data Sheet (Form No. F-83179).
2.
CAUTION
CAUTION
NOTICE
The proportioner must be mounted at
the same elevation as the top flange
of the tank or a normally-closed valve
(manual or automated) must be
installed in the foam concentrate line
to prevent agent migration. A concentrate isolation valve is required to
isolate the tank during filling procedures.
WARNING
NOTICE
Prior to adding foam concentrate to
the tank, its refractive index should be
measured and recorded on the Field
Inspection Record (see FIeld
Inspection Manual), along with a
refractive index vs. concentration
curve. The procedures for these operations are covered in the Field
Inspection Manual (Part No. 31274). It
is also required that the batch
numbers from the concentrate pails
be recorded for future reference.
INITIAL FILL
Page 7
CAUTION
5. Open Tank Shell Vent Valve to pull the air out between
the bladder and tank shell, which will pull the bladder
out to the tank shell wall (see Figure 6).
6. When the change in pitch from the vacuum is heard,
this indicates the bladder is now completely pulled out
to the tank shell wall. First close the Tank Shell Vent
Valve, then turn off the vacuum (see Figure 6).
BLADDER
VENT/FILL VALVE
TANK SHELL
VENT VALVE
CONCENTRATE
ISOLATION
VALVE
WATER INLET
VALVE
(MANUAL
OR
AUTOMATED)
BLADDER
2 HP
WET/DRY
SHOP
VACUUM
BLADDER VENT/
FILL VALVE
TANK SHELL
DRAIN VALVE
BLADDER
DRAIN/FILL
VALVE
CONNECT
TO HOSE
FIGURE 6
TANK SHELL
VENT VALVE
CONCENTRATE
ISOLATION
VALVE
AIR
AIR
WATER INLET
VALVE
(MANUAL OR
AUTOMATED)
004301
NOTICE
If the type of foam concentrate is not
specified on the tank nameplate, this
information must be supplied by the
customers contracting/engineering
agent.
BLADDER
TANK SHELL
DRAIN VALVE
FIGURE 5
004299
INITIAL FILL
Page 8
CAUTION
AIR
CONCENTRATE
If Provided:
Sight Gauge Valve . . . . . . . . . . . . . . . . . . . . .Operating
2 HP
CONCENTRATE
PUMP
BLADDER VENT/
FILL VALVE
WET/DRY
SHOP
VACUUM
BLADDER
DRAIN/
FILL VALVE
TANK SHELL
VENT VALVE
PUMP VALVE
TANK SHELL
DRAIN VALVE
FIGURE 7
CONCENTRATE
ISOLATION
VALVE
WATER INLET
VALVE (MANUAL
OR AUTOMATED)
004311
CONCENTRATE
SIGHT
GAUGE TEE
BLADDER
DRAIN/FILL
VALVE
TANK SHELL
DRAIN VALVE
FIGURE 8
004312
16. Insert ring pins through valve handles into brackets and
install visual inspection seals.
17. To give maximum assurance that the system will
operate effectively and safely, a maintenance examination should be performed at this time.
18. Record date of placement in service and instruct
personnel in operation of the system.
MINOR REFILL
Page 9
TANK SHELL
VENT VALVE
Pour-In Method:
NOTICE
Pour-In Method may only be used in
Minor Refill procedures. Do not
attempt to use the Pour-In Method in
the Initial Fill or Major Refill sections.
4. Insert plastic funnel into Bladder Vent/Fill Valve and
pour in only the ANSUL foam concentrate specified
on tank nameplate until filled.
IMPORTANT
CONCENTRATE
ISOLATION
VALVE
WATER INLET
VALVE (MANUAL
OR AUTOMATED)
SIGHT
GAUGE TEE
BLADDER
DRAIN/FILL
VALVE
FIGURE 9
004313
WARNING
NOTICE
Either the Pour-In Method of filling,
Steps 4 and 5, or Pump-In Method of
filling, Steps 6 through 13, may be
used.
IMPORTANT
If the type of foam concentrate is not
specified on the tank nameplate, this
information must be supplied by the
customers contracting/engineering
agent.
8. Start concentrate fill pump, open pump valve, and build
pump pressure.
9. Slowly open the Bladder Drain/Fill Valve and start
pumping the concentrate into bladder until the bladder
is filled with the amount of concentrate stamped on tank
nameplate.
10. Close Bladder Drain/Fill Valve and disconnect concentrate pump.
MAJORREFILL
Page 10
BLADDER VENT/
FILL VALVE
CONNECT
TO HOSE
TANK SHELL
VENT VALVE
CONCENTRATE
ISOLATION
VALVE
BLADDER
13. Record date of Minor Refill and notify operating personnel that system is back in service.
AIR
AIR
WATER INLET
VALVE
(MANUAL
OR AUTOMATED)
WARNING
BLADDER
DRAIN/FILL
VALVE
TANK SHELL
DRAIN VALVE
FIGURE 10
004314
MAJOR REFILL
Page 11
BLADDER VENT/
FILL VALVE
CAUTION
WATER INLET
VALVE
(MANUAL OR
AUTOMATED)
AIR
BLADDER
2 HP
WET/DRY
SHOP
VACUUM
BLADDER
DRAIN/
FILL VALVE
CONCENTRATE
TANK SHELL
DRAIN VALVE
2 HP
CONCENTRATE
PUMP
FIGURE 11
004315
NOTICE
If the type of foam concentrate is not
specified on the tank nameplate, this
information must be supplied by the
customers contracting/engineering
agent.
11. Start concentrate fill pump and open pump valve, then
open Bladder Drain/Fill Valve.
WET/DRY
SHOP
VACUUM
BLADDER
DRAIN/
FILL VALVE
PUMP VALVE
TANK SHELL
DRAIN VALVE
FIGURE 12
004311
MAJOR REFILL
Page 12
TANK SHELL
VENT VALVE
CONCENTRATE
ISOLATION
VALVE
WATER INLET
VALVE (MANUAL
OR AUTOMATED)
CONCENTRATE
SIGHT
GAUGE TEE
BLADDER
DRAIN/FILL
VALVE
TANK SHELL
DRAIN VALVE
FIGURE 13
004312
17. Insert ring pins through valve handles into brackets and
install visual inspection seals.
18. Record date of Major Refill and notify operating personnel that system is back in service.
INSPECTION
Page 13
Inspection should take into consideration the environment, system use, and user inspection policy; but as a
minimum should be conducted semi-annually.
To provide reasonable assurance that the ANSUL
bladder tank is full and operable:
1. Note general appearance of the system and component
parts, checking for mechanical damage or corrosion.
2. Inspect all auxiliary equipment in accordance with the
manufacturers instructions.
3. Check all nameplates for readability.
4. Examine piping and supports for mechanical damage or
corrosion.
5. Check the concentrate fill level by referring to the
Bladder Tank Measurement Guide (Part No. 71676).
6. Make certain bladder tank valve handles are ringpinned and sealed in the operating positions (see
Figure 14):
Water Inlet Valve . . . . . . . . . . . . . . . . . . . . . . . . . .Open
Tank Shell Drain Valve . . . . . . . . . . . . . . . . . . . .Closed
Bladder Drain/Fill Valve . . . . . . . . . . . . . . . . . . . .Closed
Tank Shell Vent Valve . . . . . . . . . . . . . . . . . . . . .Closed
Bladder Vent/Fill Valve . . . . . . . . . . . . . . . . . . . . .Closed
Concentrate Isolation
Valve . . . . . . . . . . . . . . . . . . .Normal Operating Position
If Provided:
Sight Gauge Valve . . . . . . . . . . . . . . . . . . . . .Operating
PROPORTIONER
BLADDER VENT/
FILL VALVE
TO
DISCHARGE
DEVICES
PRESSURIZED
WATER SOURCE
TANK SHELL
VENT VALVE
SWING
CHECK VALVE
CONCENTRATE
ISOLATION
VALVE
WATER INLET
VALVE (MANUAL
OR AUTOMATED)
CONCENTRATE
SIGHT
GAUGE TEE
BLADDER
DRAIN/FILL
VALVE
TANK SHELL
DRAIN VALVE
FIGURE 14
004312
MAINTENANCE
Page 14
6. Make certain bladder tank valve handles are ringpinned in the operating position (see Figure 15):
Concentrate Isolation
Valve . . . . . . . . . . . . . . . . . .Normal Operating Position
If Provided:
Sight Gauge Valve . . . . . . . . . . . . . . . . . . . . . .Operating
10. Insert ring pins through valve handles into brackets and
install visual inspection seals.
11. Record date of annual maintenance examination and
any service performed.
12. Notify operating personnel that system is back in service.
PROPORTIONER
If Provided:
Sight Gauge Valve . . . . . . . . . . . . . . . . . . . . .Operating
7. Collect a foam solution sample by completing the
following steps:
a. Turn on the water supply and allow system to
discharge for two minutes.
BLADDER VENT/
FILL VALVE
TO
DISCHARGE
DEVICES
PRESSURIZED
WATER SOURCE
TANK SHELL
VENT VALVE
SWING
CHECK VALVE
NOTICE
Make certain solution is properly
disposed of in accordance with
applicable laws, codes and regulations.
CONCENTRATE
ISOLATION
VALVE
WATER INLET
VALVE (MANUAL
OR AUTOMATED)
CONCENTRATE
TANK SHELL
DRAIN VALVE
FIGURE 15
004312
MAINTENANCE
Page 15
SERVICEANDREPAIR
Page 16
The best assurance against system malfunction is proper operation, recharge, inspection, and maintenance. To
remedy, as quickly as possible, any disorder that may occur, the following table lists some of the probable irregularities that may develop and gives suggestions for corrective action.
To remedy any disorder detected through periodic inspection and maintenance examinations:
Component
__________
Disorder
_______
Corrective Action
________________
Bladder Tanks
Dents* or Abrasions
Paint Peeling
Torn or Ruptured
Unreadable Wording
Use a mild abrasive (scouring powder) to clean plate. If readability cannot be improved, replace nameplate.
Loose
Missing
Replace chain.
Bladder
Nameplate
Valves
*RECORD DENTS FOR REFERENCE IN FUTURE SERVICING, REPLACING TANK IF DENTS ARE DEEP.
SERVICEANDREPAIR
Page 17
CAUTION
NOTICE
Review all steps before beginning procedure.
1. Remove all water from tank shell by opening both the
Tank Shell Vent Valve and the Tank Shell Drain Valve.
A hose should be connected to the drain valve to direct
the flow of water to an approved disposal area.
2. Remove all foam concentrate from the bladder by
opening the Bladder Vent/Fill Valve and the Bladder
Drain/Fill Valve. A hose should be connected to the
Bladder Drain/Fill Valve to direct the concentrate using
a transfer pump to an approved disposal containment
tank/drums.
3. Remove top and bottom flange from the tank.
4. Slowly remove the vertical center tube out through the
top flange opening. This tube must be removed on all
horizontal tanks. (If the center tube cannot be
completely removed on the vertical tanks, drop the
tube through the lower flange opening and remove
bladder out through the top flange opening sliding the
bladder past the center tube.)
5. Remove end flanges on horizontal tanks and slowly
remove the horizontal center tube so as not to damage
the bladder.
6. Before removing the bladder, attach cords (ropes) to
the flange bolt holes on all ends of the bladder with the
exception of the end where the bladder will be pulled
out. The cords will also be used for installing the new
bladder. After the cords are attached, slowly pull the
bladder out of the end that does not have the cords
attached.
7. Prior to reinstalling the replacement bladder, mark the
bladder flanges to ensure proper alignment once it has
been reinstalled. Re-attach the cords on the flange
ends to help guide them back into place. Use of duct
tape to compress bladder flanges is helpful in reinstalling the bladder.
8. Re-install the bladder and check to ensure that the
bladder is properly aligned. Before re-inserting the
center tubes, close the Tank Shell Drain Valve and
attach a vacuum cleaner hose to the Tank Shell Vent
Valve. With this valve open, start the vacuum. This will
pull the bladder out toward the tank shell wall. Once
the bladder has been sucked out toward the shell wall,
look through the flange end to ensure that the bladder
is not twisted (if twisted make the adjustment to correct
this). Once the bottom flange opening is visible, close
the Tank Shell Vent Valve and then shut vacuum off.
SERVICEANDREPAIR
Page 18
NOTICE
Torque specification below is a
maximum. If during torquing of bolts
bladder flange appears to become
deformed, stop torquing at this point.
Only torque bolts further if a leak is
present while inspecting during tank
pressurization.
Re-install the flanges following the procedure for bolting
instruction per ASME flange torquing procedures. This is
tightening the bolts to 162 ft lb (219.6 Nm) each in 1/5
increments using 0-180, 90-270, 45-225, 135-315 degree
sequence.
004316
TABLE Of CONTENTS
Section
_______
Page(s)
_______
MEASUREMENTPROCEDURES
Introduction
Using The Sight Gauge
Using a Dip Stick/Line
VERTICALBLADDERTANK
MEASUREMENTTABLES
50 Gallon Vertical Bladder Tank
100 Gallon Vertical Bladder Tank
150 Gallon Vertical Bladder Tank
200 Gallon Vertical Bladder Tank
300 Gallon Vertical Bladder Tank
12
1
1
2
3 24
4
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25 41
26
26
27
27
28
28
29
29
30
30
31
31
32
32
33
33
34
34
35
35
36
36
37
Section
_______
Page(s)
_______
37
38
38
39
39
40
40
41
MEASUREMENT PROCEDURES
Page 1
Introduction
Depending on the equipment provided, two methods are acceptable for estimating the foam concentrate contained within the
bladder: (1) Using The Sight Gauge or (2) Using A Dip Stick/Line.
Both methods can be used for either vertical or horizontal tanks.
Neither of the methods is exact, but both will provide a close estimate of the bladder contents.
The measurement tables listed in this guide provide an estimate
of the amount of concentrate remaining in the tank after operation.
The approximate quantity of gallons (liters) required to refill the
bladder can be determined by subtracting the table reading
(Concentrate In Tank) from the capacity specified on the tank
nameplate:
Tank Capacity
(gallons (L))
Concentrate
In Tank
(gallons (L))
Concentrate
Required
To Refill
(gallons (L))
NOTICE
It is also a good idea to mark the full
level on the sight gauge tube. Do this
after initially filling the tank with the
exact amount of concentrate as specified on the tank nameplate. The full
level can then be verified following
tank refills or during inspection and
maintenance procedures.
Tank Capacity
X 100
(gallons (L))
Percentage (%)
of Concentrate
to be Replaced
DANGER
MEASURE
CONCENTRATE
DEPTH
Drain all water and relieve all pressure from tank before
operating any valves or the sight gauge. Do not put your
face in front of valve outlets or near sight gauge tube while
operating. Failure to comply will result in personal injury or
sight gauge damage due to the unrestricted release of
water or concentrate through the valve outlet or into the
sight gauge.
GAUGE USE
OPERATING
NOTICE
To obtain an accurate reading, all
water must be drained and all pressure must be relieved from tank.
3. Pull ring pin and turn sight gauge valve handle to READ position. Allow concentrate to enter and come to a stable level in
sight gauge tube.
fIGURE 1
004317
MEASUREMENT PROCEDURES
Page 2
NOTICE
It is also a good idea to mark the full
level on the dip stick/line. Do this after
initially filling the tank with the exact
amount of concentrate as specified on
the tank nameplate. The full level can
then be verified following tank refills or
during inspection and maintenance
procedures.
BLADDER VENT/
FILL VALVE
DIP
STICK/LINE
TANK SHELL
VENT VALVE
NOTICE
To obtain an accurate reading, all
water must be drained and all pressure must be relieved from tank.
3. Open the Bladder Vent/Fill Valve and lower the dip stick/line
through the valve until it reaches the bottom of the tank.
(When using a dip line, it will begin to slacken when the weight
has reached the bottom of the tank.)
MEASURE
CONCENTRATE
DEPTH
4. Remove the dip stick/line from the tank. Measure and record
the length of the dampened portion of the dip stick/line. This
measurement is the depth of the concentrate in the bladder as
shown in Figures 2 and 3.
TANK SHELL
DRAIN VALVE
fIGURE 3
004319
BLADDER VENT/
FILL VALVE
DIP
STICK/LINE
TANK SHELL
VENT VALVE
TANK SHELL
DRAIN VALVE
fIGURE 2
004318
VERTICALBLADDERTANKMEASUREMENTTABLES
50 GALLONVERTICALBLADDERTANK
100 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
Concentrate in Tank
gal.
(L)
___
___
0
(0)
1
(2)
2
(6)
3
(11)
5
(17)
6
(24)
8
(31)
10
(38)
12
(45)
14
(53)
16
(60)
18
(67)
20
(74)
21
(81)
23
(88)
25
(95)
27
(102)
29
(109)
31
(116)
33
(124)
35
(131)
36
(138)
38
(145)
40
(152)
42
(159)
44
(166)
46
(173)
48
(180)
50
(189)
Concentrate in Tank
gal.
(L)
___
___
0
(0)
1
(2)
2
(6)
3
(11)
5
(17)
6
(24)
8
(31)
10
(38)
12
(45)
14
(53)
16
(60)
18
(67)
20
(74)
21
(81)
23
(88)
25
(95)
27
(102)
29
(109)
31
(116)
33
(124)
35
(131)
36
(138)
38
(145)
40
(152)
42
(159)
44
(166)
46
(173)
48
(180)
50
(188)
51
(195)
53
(202)
55
(209)
57
(216)
59
(223)
61
(230)
63
(237)
65
(244)
66
(251)
68
(259)
70
(266)
72
(273)
74
(280)
76
(287)
78
(294)
80
(301)
81
(308)
83
(315)
85
(323)
87
(330)
89
(337)
91
(344)
93
(351)
95
(358)
96
(365)
98
(372)
100
(379)
150 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
Concentrate in Tank
gal.
(L)
___
___
0
(1)
1
(5)
3
(12)
5
(20)
8
(29)
10
(40)
13
(51)
16
(62)
19
(73)
22
(84)
25
(95)
28
(106)
31
(117)
34
(128)
37
(140)
40
(151)
43
(162)
46
(173)
49
(184)
52
(195)
55
(206)
57
(217)
60
(229)
63
(240)
66
(251)
69
(262)
72
(273)
75
(284)
78
(295)
81
(306)
84
(318)
87
(329)
90
(340)
93
(351)
96
(362)
99
(373)
102
(384)
104
(395)
107
(407)
110
(418)
113
(429)
116
(440)
119
(451)
122
(462)
125
(473)
128
(484)
131
(496)
134
(507)
137
(518)
140
(529)
143
(540)
146
(551)
149
(562)
200 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate in Tank
gal.
(L)
___
___
0
(1)
1
(5)
3
(12)
5
(20)
8
(29)
10
(40)
13
(51)
16
(62)
19
(73)
22
(84)
25
(95)
28
(106)
31
(117)
34
(128)
37
(140)
40
(151)
43
(162)
46
(173)
49
(184)
52
(195)
55
(206)
57
(217)
60
(229)
63
(240)
66
(251)
69
(262)
72
(273)
75
(284)
78
(295)
81
(306)
84
(318)
87
(329)
90
(340)
93
(351)
96
(362)
99
(373)
102
(384)
104
(395)
107
(407)
110
(418)
113
(429)
116
(440)
119
(451)
122
(462)
125
(473)
128
(484)
131
(496)
134
(507)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
Concentrate in Tank
gal.
(L)
___
___
137
(518)
140
(529)
143
(540)
146
(551)
149
(562)
151
(573)
154
(585)
157
(596)
160
(607)
163
(618)
166
(629)
169
(640)
172
(651)
175
(662)
178
(674)
181
(685)
184
(696)
187
(707)
190
(718)
193
(729)
196
(740)
199
(751)
300 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate in Tank
gal.
(L)
___
___
0
(2)
2
(6)
4
(14)
6
(24)
10
(37)
13
(50)
17
(65)
21
(81)
26
(97)
30
(113)
34
(129)
38
(145)
43
(161)
47
(177)
51
(193)
55
(209)
60
(226)
64
(242)
68
(258)
72
(274)
77
(290)
81
(306)
85
(322)
89
(338)
93
(354)
98
(370)
102
(386)
106
(402)
110
(418)
115
(434)
119
(450)
123
(466)
127
(482)
132
(498)
136
(514)
140
(530)
144
(546)
149
(562)
153
(578)
157
(594)
161
(610)
166
(626)
170
(642)
174
(659)
178
(675)
182
(691)
187
(707)
191
(723)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
Concentrate
gal.
___
195
199
204
208
212
216
221
225
229
233
238
242
246
250
254
259
263
267
271
276
280
284
288
293
297
in Tank
(L)
___
(739)
(755)
(771)
(787)
(803)
(819)
(835)
(851)
(867)
(883)
(899)
(915)
(931)
(947)
(963)
(979)
(995)
(1011)
(1027)
(1043)
(1059)
(1075)
(1091)
(1108)
(1124)
42 INCH DIAMETER*
400 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
*Not available after 1996.
Concentrate in Tank
gal.
(L)
___
___
0
(2)
2
(8)
4
(17)
8
(29)
12
(44)
16
(61)
21
(80)
27
(101)
32
(122)
38
(144)
44
(166)
50
(188)
55
(210)
61
(232)
67
(254)
73
(276)
79
(298)
84
(320)
90
(342)
96
(364)
102
(386)
108
(407)
113
(429)
119
(451)
125
(473)
131
(495)
137
(517)
142
(539)
148
(561)
154
(583)
160
(605)
166
(627)
171
(649)
177
(671)
183
(693)
189
(715)
195
(737)
200
(759)
206
(781)
212
(803)
218
(825)
224
(846)
229
(868)
235
(890)
241
(912)
247
(934)
253
(956)
258
(978)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
Concentrate in Tank
gal.
(L)
___
___
264
(1000)
270
(1022)
276
(1044)
282
(1066)
287
(1088)
293
(1110)
299
(1132)
305
(1154)
311
(1176)
316
(1198)
322
(1220)
328
(1242)
334
(1264)
340
(1285)
345
(1307)
351
(1329)
357
(1351)
363
(1373)
369
(1395)
374
(1417)
380
(1439)
386
(1461)
392
(1483)
398
(1505)
48 INCH DIAMETER
400 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate
gal.
___
0
2
5
9
13
19
25
31
38
45
53
60
68
75
83
91
98
106
113
121
128
136
143
151
158
166
173
181
189
196
204
211
219
226
234
241
249
256
264
272
279
287
294
302
309
317
324
332
in Tank
(L)
___
(2)
(8)
(19)
(33)
(50)
(70)
(93)
(118)
(144)
(171)
(200)
(228)
(257)
(286)
(314)
(343)
(371)
(400)
(428)
(457)
(485)
(514)
(542)
(571)
(600)
(628)
(657)
(685)
(714)
(742)
(771)
(799)
(828)
(857)
(885)
(914)
(942)
(971)
(999)
(1028)
(1056)
(1085)
(1113)
(1142)
(1171)
(1199)
(1228)
(1256)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
Concentrate
gal.
___
339
347
355
362
370
377
385
392
398
in Tank
(L)
___
(1285)
(1313)
(1342)
(1370)
(1399)
(1427)
(1456)
(1485)
(1505)
42 INCH DIAMETER*
500 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
*Not available after 1996.
Concentrate in Tank
gal.
(L)
___
___
0
(2)
2
(8)
4
(17)
8
(29)
12
(44)
16
(61)
21
(80)
27
(101)
32
(122)
38
(144)
44
(166)
50
(188)
55
(210)
61
(232)
67
(254)
73
(276)
79
(298)
84
(320)
90
(342)
96
(364)
102
(386)
108
(407)
113
(429)
119
(451)
125
(473)
131
(495)
137
(517)
142
(539)
148
(561)
154
(583)
160
(605)
166
(627)
171
(649)
177
(671)
183
(693)
189
(715)
195
(737)
200
(759)
206
(781)
212
(803)
218
(825)
224
(846)
229
(868)
235
(890)
241
(912)
247
(934)
253
(956)
258
(978)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
Concentrate
gal.
___
264
270
276
282
287
293
299
305
311
316
322
328
334
340
345
351
357
363
369
374
380
386
392
398
403
409
415
421
427
432
438
444
450
456
461
467
473
479
485
490
496
in Tank
(L)
___
(1000)
(1022)
(1044)
(1066)
(1088)
(1110)
(1132)
(1154)
(1176)
(1198)
(1220)
(1242)
(1264)
(1285)
(1307)
(1329)
(1351)
(1373)
(1395)
(1417)
(1439)
(1461)
(1483)
(1505)
(1527)
(1549)
(1571)
(1593)
(1615)
(1637)
(1659)
(1681)
(1703)
(1724)
(1746)
(1768)
(1790)
(1812)
(1834)
(1856)
(1878)
48 INCH DIAMETER
500 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate
gal.
___
0
2
5
9
13
19
25
31
38
45
53
60
68
75
83
91
98
106
113
121
128
136
143
151
158
166
173
181
189
196
204
211
219
226
234
241
249
256
264
272
279
287
294
302
309
317
324
332
in Tank
(L)
___
(2)
(8)
(19)
(33)
(50)
(70)
(93)
(118)
(144)
(171)
(200)
(228)
(257)
(286)
(314)
(343)
(371)
(400)
(428)
(457)
(485)
(514)
(542)
(571)
(600)
(628)
(657)
(685)
(714)
(742)
(771)
(799)
(828)
(857)
(885)
(914)
(942)
(971)
(999)
(1028)
(1056)
(1085)
(1113)
(1142)
(1171)
(1199)
(1228)
(1256)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
Concentrate
gal.
___
339
347
355
362
370
377
385
392
400
407
415
422
430
437
445
453
460
468
475
483
490
496
in Tank
(L)
___
(1285)
(1313)
(1342)
(1370)
(1399)
(1427)
(1456)
(1485)
(1513)
(1542)
(1570)
(1599)
(1627)
(1656)
(1684)
(1713)
(1742)
(1770)
(1799)
(1827)
(1856)
(1878)
600 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate
gal.
___
0
2
5
9
13
19
25
31
38
45
53
60
68
75
83
91
98
106
113
121
128
136
143
151
158
166
173
181
189
196
204
211
219
226
234
241
249
256
264
272
279
287
294
302
309
317
324
332
in Tank
(L)
___
(2)
(8)
(19)
(33)
(50)
(70)
(93)
(118)
(144)
(171)
(200)
(228)
(257)
(286)
(314)
(343)
(371)
(400)
(428)
(457)
(485)
(514)
(542)
(571)
(600)
(628)
(657)
(685)
(714)
(742)
(771)
(799)
(828)
(857)
(885)
(914)
(942)
(971)
(999)
(1028)
(1056)
(1085)
(1113)
(1142)
(1171)
(1199)
(1228)
(1256)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
Concentrate
gal.
___
339
347
355
362
370
377
385
392
400
407
415
422
430
437
445
453
460
468
475
483
490
498
505
513
520
528
536
543
551
558
566
573
581
588
594
in Tank
(L)
___
(1285)
(1313)
(1342)
(1370)
(1399)
(1427)
(1456)
(1485)
(1513)
(1542)
(1570)
(1599)
(1627)
(1656)
(1684)
(1713)
(1742)
(1770)
(1799)
(1827)
(1856)
(1884)
(1913)
(1941)
(1970)
(1998)
(2027)
(2056)
(2084)
(2113)
(2141)
(2170)
(2198)
(2225)
(2250)
700 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate
gal.
___
0
2
5
9
13
19
25
31
38
45
53
60
68
75
83
91
98
106
113
121
128
136
143
151
158
166
173
181
189
196
204
211
219
226
234
241
249
256
264
272
279
287
294
302
309
317
324
332
in Tank
(L)
___
(2)
(8)
(19)
(33)
(50)
(70)
(93)
(118)
(144)
(171)
(200)
(228)
(257)
(286)
(314)
(343)
(371)
(400)
(428)
(457)
(485)
(514)
(542)
(571)
(600)
(628)
(657)
(685)
(714)
(742)
(771)
(799)
(828)
(857)
(885)
(914)
(942)
(971)
(999)
(1028)
(1056)
(1085)
(1113)
(1142)
(1171)
(1199)
(1228)
(1256)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
Concentrate
gal.
___
339
347
355
362
370
377
385
392
400
407
415
422
430
437
445
453
460
468
475
483
490
498
505
513
520
528
536
543
551
558
566
573
581
588
596
603
611
619
626
634
641
649
656
664
671
679
686
693
700
in Tank
(L)
___
(1285)
(1313)
(1342)
(1370)
(1399)
(1427)
(1456)
(1485)
(1513)
(1542)
(1570)
(1599)
(1627)
(1656)
(1684)
(1713)
(1742)
(1770)
(1799)
(1827)
(1856)
(1884)
(1913)
(1941)
(1970)
(1998)
(2027)
(2056)
(2084)
(2113)
(2141)
(2170)
(2198)
(2227)
(2255)
(2284)
(2312)
(2341)
(2370)
(2398)
(2427)
(2455)
(2484)
(2512)
(2541)
(2569)
(2597)
(2624)
(2650)
48 INCHDIAMETER
800 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
Concentrate in Tank
gal.
(L)
___
___
0
(2)
2
(8)
5
(19)
9
(33)
13
(50)
19
(70)
25
(93)
31
(118)
38
(144)
45
(171)
53
(200)
60
(228)
68
(257)
75
(286)
83
(314)
91
(343)
98
(371)
106
(400)
113
(428)
121
(457)
128
(485)
136
(514)
143
(542)
151
(571)
158
(600)
166
(628)
173
(657)
181
(685)
189
(714)
196
(742)
204
(771)
211
(799)
219
(828)
226
(857)
234
(885)
241
(914)
249
(942)
256
(971)
264
(999)
272
(1028)
279
(1056)
287
(1085)
294
(1113)
302
(1142)
309
(1171)
317
(1199)
324
(1228)
332
(1256)
339
(1285)
347
(1313)
355
(1342)
362
(1370)
370
(1399)
377
(1427)
385
(1456)
Depth of Concentrate
in.
(cm)
__
____
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
111
(281.9)
112
(284.5)
Concentrate
gal.
___
392
400
407
415
422
430
437
445
453
460
468
475
483
490
498
505
513
520
528
536
543
551
558
566
573
581
588
596
603
611
619
626
634
641
649
656
664
671
679
686
694
702
709
717
724
732
739
747
754
762
769
777
785
792
799
in Tank
(L)
___
(1485)
(1513)
(1542)
(1570)
(1599)
(1627)
(1656)
(1684)
(1713)
(1742)
(1770)
(1799)
(1827)
(1856)
(1884)
(1913)
(1941)
(1970)
(1998)
(2027)
(2056)
(2084)
(2113)
(2141)
(2170)
(2198)
(2227)
(2255)
(2284)
(2312)
(2341)
(2370)
(2398)
(2427)
(2455)
(2484)
(2512)
(2541)
(2569)
(2597)
(2627)
(2657)
(2684)
(2714)
(2741)
(2771)
(2797)
(2828)
(2854)
(2884)
(2911)
(2941)
(2972)
(2998)
(3025)
54 INCHDIAMETER*
800 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
*Not available after 1996.
Concentrate
gal.
___
0
1
3
7
11
17
23
30
38
47
56
65
74
84
94
103
113
122
132
141
151
161
170
180
189
199
209
218
228
237
247
256
266
276
285
295
304
314
324
333
343
352
362
372
381
391
400
410
419
in Tank
(L)
___
(0)
(3)
(12)
(25)
(42)
(63)
(87)
(115)
(145)
(177)
(210)
(245)
(281)
(318)
(354)
(390)
(426)
(463)
(499)
(535)
(572)
(608)
(644)
(680)
(717)
(753)
(789)
(826)
(862)
(898)
(934)
(971)
(1007)
(1043)
(1080)
(1116)
(1152)
(1188)
(1225)
(1261)
(1297)
(1334)
(1370)
(1406)
(1442)
(1479)
(1515)
(1551)
(1588)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
Concentrate
gal.
___
429
439
448
458
467
477
487
496
506
515
525
534
544
554
563
573
582
592
602
611
621
630
640
650
659
669
678
688
697
707
717
726
736
745
755
765
774
783
792
in Tank
(L)
___
(1624)
(1660)
(1696)
(1733)
(1769)
(1805)
(1842)
(1878)
(1914)
(1950)
(1987)
(2023)
(2059)
(2096)
(2132)
(2168)
(2204)
(2241)
(2277)
(2313)
(2350)
(2386)
(2422)
(2458)
(2495)
(2531)
(2567)
(2604)
(2640)
(2676)
(2712)
(2749)
(2785)
(2821)
(2858)
(2894)
(2930)
(2965)
(2999)
48 INCHDIAMETER
900 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
Concentrate
gal.
___
0
2
5
9
13
19
25
31
38
45
53
60
68
75
83
91
98
106
113
121
128
136
143
151
158
166
173
181
189
196
204
211
219
226
234
241
249
256
264
272
279
287
294
302
309
317
324
332
339
347
355
362
370
377
385
392
400
407
415
422
430
437
in Tank
(L)
___
(2)
(8)
(19)
(33)
(50)
(70)
(93)
(118)
(144)
(171)
(200)
(228)
(257)
(286)
(314)
(343)
(371)
(400)
(428)
(457)
(485)
(514)
(542)
(571)
(600)
(628)
(657)
(685)
(714)
(742)
(771)
(799)
(828)
(857)
(885)
(914)
(942)
(971)
(999)
(1028)
(1056)
(1085)
(1113)
(1142)
(1171)
(1199)
(1228)
(1256)
(1285)
(1313)
(1342)
(1370)
(1399)
(1427)
(1456)
(1485)
(1513)
(1542)
(1570)
(1599)
(1627)
(1656)
Depth of Concentrate
in.
(cm)
__
____
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
111
(281.9)
112
(284.5)
113
(287.0)
114
(289.6)
115
(292.1)
116
(294.6)
117
(297.2)
118
(299.7)
119
(302.3)
120
(304.8)
121
(307.3)
122
(309.9)
123
(312.4)
124
(315.0)
125
(317.5)
Concentrate
gal.
___
445
453
460
468
475
483
490
498
505
513
520
528
536
543
551
558
566
573
581
588
596
603
611
619
626
634
641
649
656
664
671
679
686
694
702
709
717
724
732
739
747
754
762
769
777
785
792
800
807
815
822
830
837
845
852
860
868
875
883
890
897
in Tank
(L)
___
(1684)
(1713)
(1742)
(1770)
(1799)
(1827)
(1856)
(1884)
(1913)
(1941)
(1970)
(1998)
(2027)
(2056)
(2084)
(2113)
(2141)
(2170)
(2198)
(2227)
(2255)
(2284)
(2312)
(2341)
(2370)
(2398)
(2427)
(2455)
(2484)
(2512)
(2541)
(2569)
(2597)
(2627)
(2657)
(2684)
(2714)
(2741)
(2771)
(2797)
(2828)
(2854)
(2884)
(2911)
(2941)
(2972)
(2998)
(3028)
(3055)
(3085)
(3112)
(3142)
(3168)
(3199)
(3225)
(3255)
(3285)
(3312)
(3343)
(3369)
(3396)
54 INCHDIAMETER*
900 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
*Not available after 1996.
Concentrate
gal.
___
0
1
3
7
11
17
23
30
38
47
56
65
74
84
94
103
113
122
132
141
151
161
170
180
189
199
209
218
228
237
247
256
266
276
285
295
304
314
324
333
343
352
362
372
381
391
400
410
419
in Tank
(L)
___
(0)
(3)
(12)
(25)
(42)
(63)
(87)
(115)
(145)
(177)
(210)
(245)
(281)
(318)
(354)
(390)
(426)
(463)
(499)
(535)
(572)
(608)
(644)
(680)
(717)
(753)
(789)
(826)
(862)
(898)
(934)
(971)
(1007)
(1043)
(1080)
(1116)
(1152)
(1188)
(1225)
(1261)
(1297)
(1334)
(1370)
(1406)
(1442)
(1479)
(1515)
(1551)
(1588)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
Concentrate
gal.
___
429
439
448
458
467
477
487
496
506
515
525
534
544
554
563
573
582
592
602
611
621
630
640
650
659
669
678
688
697
707
717
726
736
745
755
765
774
784
793
803
813
822
832
841
851
860
870
880
889
898
in Tank
(L)
___
(1624)
(1660)
(1696)
(1733)
(1769)
(1805)
(1842)
(1878)
(1914)
(1950)
(1987)
(2023)
(2059)
(2096)
(2132)
(2168)
(2204)
(2241)
(2277)
(2313)
(2350)
(2386)
(2422)
(2458)
(2495)
(2531)
(2567)
(2604)
(2640)
(2676)
(2712)
(2749)
(2785)
(2821)
(2858)
(2894)
(2930)
(2966)
(3003)
(3039)
(3075)
(3112)
(3148)
(3184)
(3220)
(3257)
(3293)
(3329)
(3364)
(3398)
48 INCHDIAMETER
1000 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
Concentrate
gal.
___
0
2
5
9
13
19
25
31
38
45
53
60
68
75
83
91
98
106
113
121
128
136
143
151
158
166
173
181
189
196
204
211
219
226
234
241
249
256
264
272
279
287
294
302
309
317
324
332
339
347
355
362
370
377
385
392
400
407
415
422
430
437
445
453
460
468
475
483
490
in Tank
(L)
___
(2)
(8)
(19)
(33)
(50)
(70)
(93)
(118)
(144)
(171)
(200)
(228)
(257)
(286)
(314)
(343)
(371)
(400)
(428)
(457)
(485)
(514)
(542)
(571)
(600)
(628)
(657)
(685)
(714)
(742)
(771)
(799)
(828)
(857)
(885)
(914)
(942)
(971)
(999)
(1028)
(1056)
(1085)
(1113)
(1142)
(1171)
(1199)
(1228)
(1256)
(1285)
(1313)
(1342)
(1370)
(1399)
(1427)
(1456)
(1485)
(1513)
(1542)
(1570)
(1599)
(1627)
(1656)
(1684)
(1713)
(1742)
(1770)
(1799)
(1827)
(1856)
Depth of Concentrate
in.
(cm)
__
____
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
111
(281.9)
112
(284.5)
113
(287.0)
114
(289.6)
115
(292.1)
116
(294.6)
117
(297.2)
118
(299.7)
119
(302.3)
120
(304.8)
121
(307.3)
122
(309.9)
123
(312.4)
124
(315.0)
125
(317.5)
126
(320.0)
127
(322.6)
128
(325.1)
129
(327.7)
130
(330.2)
131
(322.7)
132
(335.3)
133
(337.8)
134
(340.4)
135
(342.9)
136
(345.4)
137
(348.0)
138
(350.5)
139
(353.1)
Concentrate
gal.
___
498
505
513
520
528
536
543
551
558
566
573
581
588
596
603
611
619
626
634
641
649
656
664
671
679
686
694
702
709
717
724
732
739
747
754
762
769
777
785
792
800
807
815
822
830
837
845
852
860
868
875
883
890
898
905
913
920
928
935
943
951
958
964
971
979
986
993
1000
in Tank
(L)
___
(1884)
(1913)
(1941)
(1970)
(1998)
(2027)
(2056)
(2084)
(2113)
(2141)
(2170)
(2198)
(2227)
(2255)
(2284)
(2312)
(2341)
(2370)
(2398)
(2427)
(2455)
(2484)
(2512)
(2541)
(2569)
(2597)
(2627)
(2657)
(2684)
(2714)
(2741)
(2771)
(2797)
(2828)
(2854)
(2884)
(2911)
(2941)
(2972)
(2998)
(3028)
(3055)
(3085)
(3112)
(3142)
(3168)
(3199)
(3225)
(3255)
(3285)
(3312)
(3343)
(3369)
(3399)
(3426)
(3456)
(3483)
(3513)
(3539)
(3570)
(3600)
(3626)
(3649)
(3676)
(3706)
(3732)
(3759)
(3785)
54 INCHDIAMETER*
1000 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
*Not available after 1996.
Concentrate
gal.
___
0
1
3
7
11
17
23
30
38
47
56
65
74
84
94
103
113
122
132
141
151
161
170
180
189
199
209
218
228
237
247
256
266
276
285
295
304
314
324
333
343
352
362
372
381
391
400
410
419
429
439
448
458
467
in Tank
(L)
___
(0)
(3)
(12)
(25)
(42)
(63)
(87)
(115)
(145)
(177)
(210)
(245)
(281)
(318)
(354)
(390)
(426)
(463)
(499)
(535)
(572)
(608)
(644)
(680)
(717)
(753)
(789)
(826)
(862)
(898)
(934)
(971)
(1007)
(1043)
(1080)
(1116)
(1152)
(1188)
(1225)
(1261)
(1297)
(1334)
(1370)
(1406)
(1442)
(1479)
(1515)
(1551)
(1588)
(1624)
(1660)
(1696)
(1733)
(1769)
Depth of Concentrate
in.
(cm)
__
____
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
Concentrate
gal.
___
477
487
496
506
515
525
534
544
554
563
573
582
592
602
611
621
630
640
650
659
669
678
688
697
707
717
726
736
745
755
765
774
784
793
803
813
822
832
841
851
860
870
880
889
899
908
918
928
937
947
956
966
976
985
994
in Tank
(L)
___
(1805)
(1842)
(1878)
(1914)
(1950)
(1987)
(2023)
(2059)
(2096)
(2132)
(2168)
(2204)
(2241)
(2277)
(2313)
(2350)
(2386)
(2422)
(2458)
(2495)
(2531)
(2567)
(2604)
(2640)
(2676)
(2712)
(2749)
(2785)
(2821)
(2858)
(2894)
(2930)
(2966)
(3003)
(3039)
(3075)
(3112)
(3148)
(3184)
(3220)
(3257)
(3293)
(3329)
(3366)
(3402)
(3438)
(3474)
(3511)
(3547)
(3583)
(3620)
(3656)
(3692)
(3728)
(3763)
1100 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
Concentrate
gal.
___
0
1
4
9
14
21
28
37
46
56
67
78
89
101
113
125
137
148
160
172
184
196
208
220
232
243
255
267
279
291
303
315
327
338
350
362
374
386
398
410
422
434
445
457
469
481
493
505
517
in Tank
(L)
___
(0)
(6)
(16)
(32)
(53)
(78)
(106)
(139)
(174)
(212)
(252)
(294)
(338)
(382)
(427)
(472)
(517)
(562)
(607)
(652)
(697)
(742)
(787)
(832)
(877)
(922)
(967)
(1012)
(1056)
(1101)
(1146)
(1191)
(1236)
(1281)
(1326)
(1371)
(1416)
(1461)
(1506)
(1551)
(1596)
(1641)
(1686)
(1731)
(1776)
(1821)
(1866)
(1910)
(1955)
Depth of Concentrate
in.
(cm)
__
____
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
Concentrate
gal.
___
529
540
552
564
576
588
600
612
624
635
647
659
671
683
695
707
719
730
742
754
766
778
790
802
814
825
837
849
861
873
885
897
909
920
932
944
956
968
980
992
1004
1015
1027
1039
1051
1063
1075
1087
1099
in Tank
(L)
___
(2000)
(2045)
(2090)
(2135)
(2180)
(2225)
(2270)
(2315)
(2360)
(2405)
(2450)
(2495)
(2540)
(2585)
(2630)
(2675)
(2720)
(2765)
(2809)
(2854)
(2899)
(2944)
(2989)
(3034)
(3079)
(3124)
(3169)
(3214)
(3259)
(3304)
(3349)
(3394)
(3439)
(3484)
(3529)
(3574)
(3619)
(3664)
(3708)
(3753)
(3798)
(3843)
(3888)
(3933)
(3978)
(4023)
(4068)
(4113)
(4158)
1200 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
Concentrate
gal.
___
0
1
4
9
14
21
28
37
46
56
67
78
89
101
113
125
137
148
160
172
184
196
208
220
232
243
255
267
279
291
303
315
327
338
350
362
374
386
398
410
422
434
445
457
469
481
493
505
517
529
540
552
564
576
in Tank
(L)
___
(0)
(6)
(16)
(32)
(53)
(78)
(106)
(139)
(174)
(212)
(252)
(294)
(338)
(382)
(427)
(472)
(517)
(562)
(607)
(652)
(697)
(742)
(787)
(832)
(877)
(922)
(967)
(1012)
(1056)
(1101)
(1146)
(1191)
(1236)
(1281)
(1326)
(1371)
(1416)
(1461)
(1506)
(1551)
(1596)
(1641)
(1686)
(1731)
(1776)
(1821)
(1866)
(1910)
(1955)
(2000)
(2045)
(2090)
(2135)
(2180)
Depth of Concentrate
in.
(cm)
__
____
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
Concentrate
gal.
___
588
600
612
624
635
647
659
671
683
695
707
719
730
742
754
766
778
790
802
814
825
837
849
861
873
885
897
909
920
932
944
956
968
980
992
1004
1015
1027
1039
1051
1063
1075
1087
1099
1122
1134
1146
1158
1170
1182
1194
in Tank
(L)
___
(2225)
(2270)
(2315)
(2360)
(2405)
(2450)
(2495)
(2540)
(2585)
(2630)
(2675)
(2720)
(2765)
(2809)
(2854)
(2899)
(2944)
(2989)
(3034)
(3079)
(3124)
(3169)
(3214)
(3259)
(3304)
(3349)
(3394)
(3439)
(3484)
(3529)
(3574)
(3619)
(3664)
(3708)
(3753)
(3798)
(3843)
(3888)
(3933)
(3978)
(4023)
(4068)
(4113)
(4158)
(4248)
(4293)
(4338)
(4383)
(4428)
(4473)
(4518)
1300 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
Concentrate
gal.
___
0
1
4
9
14
21
28
37
46
56
67
78
89
101
113
125
137
148
160
172
184
196
208
220
232
243
255
267
279
291
303
315
327
338
350
362
374
386
398
410
422
434
445
457
469
481
493
505
517
529
540
552
564
576
588
600
612
in Tank
(L)
___
(0)
(6)
(16)
(32)
(53)
(78)
(106)
(139)
(174)
(212)
(252)
(294)
(338)
(382)
(427)
(472)
(517)
(562)
(607)
(652)
(697)
(742)
(787)
(832)
(877)
(922)
(967)
(1012)
(1056)
(1101)
(1146)
(1191)
(1236)
(1281)
(1326)
(1371)
(1416)
(1461)
(1506)
(1551)
(1596)
(1641)
(1686)
(1731)
(1776)
(1821)
(1866)
(1910)
(1955)
(2000)
(2045)
(2090)
(2135)
(2180)
(2225)
(2270)
(2315)
Depth of Concentrate
in.
(cm)
__
____
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
111
(281.9)
112
(284.5)
113
(287.0)
114
(289.6)
115
(292.1)
116
(294.6)
Concentrate
gal.
___
624
635
647
659
671
683
695
707
719
730
742
754
766
778
790
802
814
825
837
849
861
873
885
897
909
920
932
944
956
968
980
992
1004
1015
1027
1039
1051
1063
1075
1087
1099
1110
1122
1134
1146
1158
1170
1182
1194
1205
1217
1229
1241
1253
1265
1277
1289
1300
in Tank
(L)
___
(2360)
(2405)
(2450)
(2495)
(2540)
(2585)
(2630)
(2675)
(2720)
(2765)
(2809)
(2854)
(2899)
(2944)
(2989)
(3034)
(3079)
(3124)
(3169)
(3214)
(3259)
(3304)
(3349)
(3394)
(3439)
(3484)
(3529)
(3574)
(3619)
(3664)
(3708)
(3753)
(3798)
(3843)
(3888)
(3933)
(3978)
(4023)
(4068)
(4113)
(4158)
(4203)
(4248)
(4293)
(4338)
(4383)
(4428)
(4473)
(4518)
(4562)
(4607)
(4652)
(4697)
(4742)
(4787)
(4832)
(4877)
(4921)
1400 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Concentrate
gal.
___
0
1
4
9
14
21
28
37
46
56
67
78
89
101
113
125
137
148
160
172
184
196
208
220
232
243
255
267
279
291
303
315
327
338
350
362
374
386
398
410
422
434
445
457
469
481
493
505
517
529
540
552
564
576
588
600
612
624
635
647
659
in Tank
(L)
___
(0)
(6)
(16)
(32)
(53)
(78)
(106)
(139)
(174)
(212)
(252)
(294)
(338)
(382)
(427)
(472)
(517)
(562)
(607)
(652)
(697)
(742)
(787)
(832)
(877)
(922)
(967)
(1012)
(1056)
(1101)
(1146)
(1191)
(1236)
(1281)
(1326)
(1371)
(1416)
(1461)
(1506)
(1551)
(1596)
(1641)
(1686)
(1731)
(1776)
(1821)
(1866)
(1910)
(1955)
(2000)
(2045)
(2090)
(2135)
(2180)
(2225)
(2270)
(2315)
(2360)
(2405)
(2450)
(2495)
Depth of Concentrate
in.
(cm)
__
____
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
111
(281.9)
112
(284.5)
113
(287.0)
114
(289.6)
115
(292.1)
116
(294.6)
117
(297.2)
118
(299.7)
119
(302.3)
120
(304.8)
121
(307.3)
122
(309.9)
123
(312.4)
124
(315.0)
Concentrate
gal.
___
671
683
695
707
719
730
742
754
766
778
790
802
814
825
837
849
861
873
885
897
909
920
932
944
956
968
980
992
1004
1015
1027
1039
1051
1063
1075
1087
1099
1110
1122
1134
1146
1158
1170
1182
1194
1205
1217
1229
1241
1253
1265
1277
1289
1300
1312
1324
1336
1348
1360
1372
1384
1395
in Tank
(L)
___
(2540)
(2585)
(2630)
(2675)
(2720)
(2765)
(2809)
(2854)
(2899)
(2944)
(2989)
(3034)
(3079)
(3124)
(3169)
(3214)
(3259)
(3304)
(3349)
(3394)
(3439)
(3484)
(3529)
(3574)
(3619)
(3664)
(3708)
(3753)
(3798)
(3843)
(3888)
(3933)
(3978)
(4023)
(4068)
(4113)
(4158)
(4203)
(4248)
(4293)
(4338)
(4383)
(4428)
(4473)
(4518)
(4562)
(4607)
(4652)
(4697)
(4742)
(4787)
(4832)
(4877)
(4922)
(4967)
(5012)
(5057)
(5102)
(5147)
(5192)
(5237)
(5282)
1500 GALLONVERTICALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
63
(160.0)
64
(162.6)
65
(165.1)
66
(167.6)
67
(170.2)
Concentrate
gal.
___
0
1
4
9
14
21
28
37
46
56
67
78
89
101
113
125
137
148
160
172
184
196
208
220
232
243
255
267
279
291
303
315
327
338
350
362
374
386
398
410
422
434
445
457
469
481
493
505
517
529
540
552
564
576
588
600
612
624
635
647
659
671
683
695
707
719
in Tank
(L)
___
(0)
(6)
(16)
(32)
(53)
(78)
(106)
(139)
(174)
(212)
(252)
(294)
(338)
(382)
(427)
(472)
(517)
(562)
(607)
(652)
(697)
(742)
(787)
(832)
(877)
(922)
(967)
(1012)
(1056)
(1101)
(1146)
(1191)
(1236)
(1281)
(1326)
(1371)
(1416)
(1461)
(1506)
(1551)
(1596)
(1641)
(1686)
(1731)
(1776)
(1821)
(1866)
(1910)
(1955)
(2000)
(2045)
(2090)
(2135)
(2180)
(2225)
(2270)
(2315)
(2360)
(2405)
(2450)
(2495)
(2540)
(2585)
(2630)
(2675)
(2720)
Depth of Concentrate
in.
(cm)
__
____
68
(172.7)
69
(175.3)
70
(177.8)
71
(180.3)
72
(182.9)
73
(185.4)
74
(188.0)
75
(190.5)
76
(193.0)
77
(195.6)
78
(198.1)
79
(200.7)
80
(203.2)
81
(205.7)
82
(208.3)
83
(210.8)
84
(213.4)
85
(215.9)
86
(218.4)
87
(221.0)
88
(223.5)
89
(226.1)
90
(228.6)
91
(231.1)
92
(233.7)
93
(236.2)
94
(238.8)
95
(241.3)
96
(243.8)
97
(246.4)
98
(248.9)
99
(251.5)
100
(254.0)
101
(256.5)
102
(259.1)
103
(261.6)
104
(264.2)
105
(266.7)
106
(269.2)
107
(271.8)
108
(274.3)
109
(276.9)
110
(279.4)
111
(281.9)
112
(284.5)
113
(287.0)
114
(289.6)
115
(292.1)
116
(294.6)
117
(297.2)
118
(299.7)
119
(302.3)
120
(304.8)
121
(307.3)
122
(309.9)
123
(312.4)
124
(315.0)
125
(317.5)
126
(320.0)
127
(322.6)
128
(325.1)
129
(327.7)
130
(330.2)
131
(332.7)
132
(335.3)
Concentrate
gal.
___
730
742
754
766
778
790
802
814
825
837
849
861
873
885
897
909
920
932
944
956
968
980
992
1004
1015
1027
1039
1051
1063
1075
1087
1099
1110
1122
1134
1146
1158
1170
1182
1194
1205
1217
1229
1241
1253
1265
1277
1289
1300
1312
1324
1336
1348
1360
1372
1384
1395
1407
1419
1431
1443
1455
1467
1479
1490
in Tank
(L)
___
(2765)
(2809)
(2854)
(2899)
(2944)
(2989)
(3034)
(3079)
(3124)
(3169)
(3214)
(3259)
(3304)
(3349)
(3394)
(3439)
(3484)
(3529)
(3574)
(3619)
(3664)
(3708)
(3753)
(3798)
(3843)
(3888)
(3933)
(3978)
(4023)
(4068)
(4113)
(4158)
(4203)
(4248)
(4293)
(4338)
(4383)
(4428)
(4473)
(4518)
(4562)
(4607)
(4652)
(4697)
(4742)
(4787)
(4832)
(4877)
(4922)
(4967)
(5012)
(5057)
(5102)
(5147)
(5192)
(5237)
(5282)
(5327)
(5372)
(5417)
(5461)
(5506)
(5551)
(5596)
(5641)
HORIZONTAL BLADDERTANKMEASUREMENTTABLES
100 GALLONHORIZONTALBLADDERTANK
150 GALLONHORIZONTALBLADDERBANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
Concentrate in Tank
gal.
(L)
___
___
0
(1)
2
(9)
5
(20)
9
(34)
13
(51)
18
(69)
23
(88)
29
(109)
35
(131)
40
(153)
46
(176)
53
(199)
59
(222)
65
(245)
71
(268)
77
(290)
82
(311)
88
(332)
93
(351)
98
(369)
Concentrate in Tank
gal.
(L)
___
___
0
(1)
2
(8)
5
(20)
9
(36)
14
(53)
19
(73)
25
(95)
31
(118)
38
(142)
44
(168)
51
(194)
58
(221)
66
(249)
73
(277)
81
(305)
88
(333)
96
(362)
103
(390)
110
(417)
117
(444)
124
(471)
131
(496)
137
(520)
144
(543)
149
(565)
200 GALLONHORIZONTALBLADDERTANK
300 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
Concentrate in Tank
gal.
(L)
___
___
0
(1)
3
(11)
7
(27)
13
(47)
19
(71)
26
(97)
33
(125)
41
(155)
49
(187)
58
(220)
67
(254)
77
(290)
86
(326)
96
(362)
105
(399)
115
(436)
125
(472)
134
(509)
144
(544)
153
(580)
162
(614)
171
(647)
179
(678)
187
(708)
195
(736)
Concentrate
gal.
___
0
3
8
14
21
28
37
46
56
66
77
88
99
111
123
135
147
159
171
183
195
207
219
231
242
253
263
274
283
292
in Tank
(L)
___
(1)
(12)
(29)
(52)
(78)
(108)
(140)
(175)
(212)
(250)
(291)
(332)
(375)
(419)
(464)
(509)
(555)
(601)
(647)
(693)
(739)
(784)
(829)
(872)
(915)
(957)
(997)
(1036)
(1072)
(1107)
48 INCHDIAMETER
400 GALLONHORIZONTALBLADDERTANK
42 INCHDIAMETER*
400 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
*Not available after 1996.
Concentrate
gal.
___
0
3
8
14
21
29
37
47
57
68
79
90
102
115
127
140
153
167
180
194
207
221
234
248
261
274
288
300
313
325
337
349
360
371
381
390
399
in Tank
(L)
___
(1)
(12)
(29)
(52)
(79)
(109)
(142)
(178)
(216)
(256)
(298)
(342)
(388)
(434)
(482)
(531)
(580)
(631)
(682)
(733)
(784)
(835)
(887)
(938)
(989)
(1039)
(1088)
(1137)
(1185)
(1231)
(1277)
(1320)
(1362)
(1402)
(1440)
(1476)
(1509)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Concentrate
gal.
___
0
2
6
11
17
23
30
37
46
54
63
73
82
92
102
113
124
135
146
157
169
180
191
203
214
226
238
249
261
271
283
294
305
315
325
335
345
354
363
371
379
387
394
400
in Tank
(L)
___
(1)
(8)
(23)
(42)
(64)
(87)
(114)
(140)
(174)
(205)
(239)
(276)
(310)
(348)
(386)
(428)
(469)
(511)
(553)
(594)
(640)
(681)
(723)
(768)
(810)
(856)
(901)
(943)
(988)
(1026)
(1071)
(1113)
(1155)
(1192)
(1230)
(1268)
(1306)
(1340)
(1374)
(1404)
(1435)
(1465)
(1492)
(1514)
48 INCHDIAMETER
500 GALLONHORIZONTALBLADDERTANK
42 INCHDIAMETER*
500 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
*Not available after 1996.
Concentrate
gal.
___
0
4
10
17
26
36
47
58
71
84
98
112
127
142
157
173
189
205
222
238
255
272
288
305
321
337
354
369
385
400
415
429
442
455
468
479
490
500
in Tank
(L)
___
(1)
(15)
(37)
(65)
(99)
(136)
(177)
(221)
(268)
(318)
(370)
(424)
(480)
(537)
(596)
(655)
(716)
(778)
(840)
(903)
(965)
(1028)
(1091)
(1154)
(1216)
(1277)
(1338)
(1398)
(1456)
(1514)
(1569)
(1623)
(1675)
(1724)
(1771)
(1815)
(1855)
(1892)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Concentrate
gal.
___
0
3
8
14
21
29
37
46
57
68
79
91
103
115
128
141
155
169
182
196
211
225
239
254
268
283
297
311
326
339
354
367
381
394
406
419
431
443
454
464
474
484
492
500
in Tank
(L)
___
(0)
(11)
(30)
(53)
(80)
(110)
(140)
(174)
(216)
(257)
(299)
(345)
(390)
(435)
(485)
(534)
(587)
(640)
(689)
(742)
(799)
(852)
(905)
(962)
(1015)
(1071)
(1124)
(1177)
(1234)
(1283)
(1340)
(1389)
(1442)
(1492)
(1537)
(1586)
(1632)
(1677)
(1719)
(1756)
(1794)
(1832)
(1862)
(1893)
700 GALLONHORIZONTALBLADDERTANK
600 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Concentrate
gal.
___
0
3
9
16
24
34
44
55
67
80
94
108
122
137
153
168
185
201
218
235
252
269
286
304
321
338
356
373
390
407
423
440
456
472
487
502
517
530
544
556
568
580
590
599
in Tank
(L)
___
(0)
(13)
(33)
(60)
(91)
(127)
(166)
(209)
(255)
(303)
(354)
(407)
(462)
(519)
(577)
(637)
(699)
(761)
(824)
(888)
(953)
(1018)
(1083)
(1149)
(1215)
(1281)
(1346)
(1411)
(1476)
(1540)
(1603)
(1665)
(1726)
(1786)
(1844)
(1900)
(1955)
(2008)
(2058)
(2106)
(2152)
(2194)
(2233)
(2268)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Concentrate
gal.
___
0
4
11
19
29
40
52
65
80
94
110
127
144
161
179
198
217
236
255
275
295
315
335
355
375
396
416
436
456
475
495
514
533
551
569
587
603
620
635
650
664
677
689
700
in Tank
(L)
___
(1)
(15)
(40)
(71)
(109)
(151)
(197)
(247)
(301)
(358)
(417)
(479)
(544)
(610)
(678)
(748)
(820)
(892)
(966)
(1040)
(1116)
(1192)
(1268)
(1344)
(1421)
(1498)
(1574)
(1650)
(1725)
(1799)
(1873)
(1945)
(2016)
(2086)
(2154)
(2220)
(2284)
(2346)
(2405)
(2461)
(2514)
(2564)
(2610)
(2650)
54 INCHDIAMETER*
800 GALLONHORIZONTALBLADDERTANK
48 INCHDIAMETER
800 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Concentrate
gal.
___
0
5
13
22
33
46
59
74
91
109
126
145
165
184
205
226
248
270
291
314
337
360
383
406
429
453
475
498
521
543
566
587
609
630
650
671
690
709
726
743
759
774
787
800
in Tank
(L)
___
(1)
(19)
(49)
(83)
(125)
(174)
(223)
(280)
(345)
(413)
(477)
(549)
(625)
(697)
(776)
(856)
(939)
(1022)
(1102)
(1189)
(1276)
(1363)
(1450)
(1537)
(1624)
(1715)
(1798)
(1885)
(1972)
(2056)
(2143)
(2222)
(2305)
(2385)
(2461)
(2540)
(2612)
(2684)
(2748)
(2813)
(2873)
(2930)
(2979)
(3028)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
*Not available after 1996.
Concentrate
gal.
___
0
4
10
18
27
37
49
62
75
90
105
121
138
155
172
190
209
228
247
267
287
307
328
348
369
390
410
431
452
473
493
514
534
555
574
594
613
632
651
669
686
703
720
736
751
765
779
791
in Tank
(L)
___
(1)
(14)
(37)
(67)
(102)
(142)
(186)
(234)
(286)
(340)
(398)
(458)
(521)
(585)
(652)
(721)
(791)
(863)
(936)
(1011)
(1086)
(1163)
(1240)
(1318)
(1396)
(1475)
(1553)
(1632)
(1711)
(1790)
(1868)
(1945)
(2023)
(2099)
(2174)
(2248)
(2321)
(2393)
(2463)
(2532)
(2598)
(2663)
(2725)
(2785)
(2842)
(2896)
(2947)
(2994)
54 INCHDIAMETER*
900 GALLONHORIZONTALBLADDERTANK
48 INCHDIAMETER
900 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Concentrate
gal.
___
0
5
14
24
37
51
67
84
103
122
141
163
185
207
230
255
279
303
328
354
379
405
431
456
482
509
535
561
586
611
636
661
685
708
732
755
777
797
816
836
854
870
886
900
in Tank
(L)
___
(1)
(19)
(53)
(91)
(140)
(193)
(254)
(318)
(390)
(462)
(534)
(617)
(700)
(784)
(871)
(965)
(1056)
(1147)
(1242)
(1340)
(1435)
(1533)
(1632)
(1726)
(1825)
(1927)
(2025)
(2124)
(2218)
(2313)
(2408)
(2502)
(2593)
(2680)
(2771)
(2858)
(2941)
(3017)
(3089)
(3165)
(3233)
(3293)
(3354)
(3407)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
*Not available after 1996.
Concentrate
gal.
___
0
4
11
20
31
43
56
70
86
102
119
137
156
175
195
215
236
257
279
301
324
346
369
392
415
439
462
485
509
532
555
578
601
624
646
668
690
711
732
752
772
791
810
827
844
861
876
890
in Tank
(L)
___
(1)
(16)
(42)
(76)
(116)
(162)
(212)
(266)
(324)
(386)
(451)
(519)
(589)
(662)
(737)
(815)
(894)
(975)
(1057)
(1140)
(1225)
(1311)
(1397)
(1485)
(1572)
(1661)
(1749)
(1837)
(1926)
(2014)
(2101)
(2189)
(2275)
(2361)
(2445)
(2529)
(2611)
(2691)
(2770)
(2847)
(2922)
(2994)
(3065)
(3132)
(3196)
(3257)
(3315)
(3369)
48 INCHDIAMETER
1000 GALLONHORIZONTALBLADDERTANK
54 INCHDIAMETER*
1000 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
Concentrate
gal.
___
0
6
16
27
41
57
74
93
114
136
157
181
206
230
256
283
310
337
364
393
421
450
479
507
536
566
594
623
651
679
707
734
761
787
813
839
863
886
907
929
949
967
984
1000
in Tank
(L)
___
(1)
(23)
(61)
(102)
(155)
(216)
(280)
(352)
(432)
(515)
(594)
(685)
(780)
(871)
(969)
(1071)
(1173)
(1276)
(1378)
(1487)
(1594)
(1703)
(1813)
(1919)
(2029)
(2143)
(2249)
(2358)
(2464)
(2570)
(2676)
(2779)
(2881)
(2979)
(3078)
(3176)
(3267)
(3354)
(3433)
(3517)
(3592)
(3631)
(3725)
(3785)
Concentrate
gal.
___
0
5
13
23
35
48
63
79
96
114
133
153
174
195
217
240
263
287
311
336
360
385
411
436
462
488
514
540
565
591
617
642
668
693
718
742
766
790
813
835
857
879
899
919
938
956
973
989
in Tank
(L)
___
(1)
(18)
(48)
(86)
(131)
(181)
(237)
(298)
(363)
(432)
(504)
(579)
(658)
(739)
(823)
(908)
(996)
(1086)
(1177)
(1270)
(1364)
(1459)
(1555)
(1652)
(1749)
(1847)
(1945)
(2043)
(2140)
(2238)
(2335)
(2432)
(2528)
(2623)
(2716)
(2809)
(2900)
(2989)
(3077)
(3162)
(3245)
(3326)
(3404)
(3479)
(3551)
(3619)
(3683)
(3743)
1100 GALLONHORIZONTALBLADDERTANK
1200 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
Concentrate
gal.
___
1
6
14
24
36
50
64
80
97
115
134
154
175
196
218
241
264
288
312
337
362
388
414
440
466
493
519
546
573
600
627
654
681
708
734
761
787
813
838
864
889
913
937
961
984
1006
1027
1048
1069
1088
in Tank
(L)
___
(3)
(24)
(54)
(93)
(137)
(188)
(244)
(304)
(368)
(437)
(508)
(584)
(662)
(743)
(826)
(912)
(1000)
(1091)
(1183)
(1276)
(1372)
(1468)
(1566)
(1665)
(1765)
(1865)
(1966)
(2068)
(2170)
(2272)
(2374)
(2476)
(2577)
(2678)
(2779)
(2879)
(2978)
(3077)
(3174)
(3269)
(3364)
(3456)
(3547)
(3636)
(3723)
(3807)
(3889)
(3968)
(4044)
(4117)
Concentrate
gal.
___
1
7
16
27
40
54
71
88
107
126
147
169
191
214
238
263
288
314
341
368
395
423
451
479
508
537
566
595
624
653
682
712
741
770
799
827
856
884
912
939
966
993
1019
1045
1070
1094
1117
1140
1162
1183
in Tank
(L)
___
(4)
(26)
(60)
(102)
(151)
(206)
(267)
(333)
(403)
(478)
(556)
(638)
(723)
(811)
(902)
(996)
(1092)
(1190)
(1290)
(1392)
(1495)
(1600)
(1706)
(1814)
(1922)
(2031)
(2141)
(2251)
(2362)
(2472)
(2583)
(2694)
(2804)
(2914)
(3023)
(3132)
(3240)
(3346)
(3452)
(3556)
(3658)
(3759)
(3857)
(3954)
(4049)
(4140)
(4230)
(4316)
(4399)
(4478)
1300 GALLONHORIZONTALBLADDERTANK
1400 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
Concentrate
gal.
___
1
8
17
29
43
59
77
96
116
137
160
183
207
233
259
285
313
341
369
398
428
458
488
519
549
581
612
643
675
706
738
769
801
832
863
894
925
955
985
1015
1044
1073
1101
1129
1156
1182
1207
1232
1256
1279
1300
in Tank
(L)
___
(4)
(28)
(65)
(111)
(164)
(225)
(291)
(362)
(438)
(519)
(604)
(693)
(785)
(880)
(979)
(1080)
(1183)
(1289)
(1397)
(1507)
(1619)
(1732)
(1847)
(1963)
(2080)
(2197)
(2316)
(2435)
(2554)
(2673)
(2793)
(2912)
(3031)
(3150)
(3268)
(3385)
(3501)
(3616)
(3730)
(3842)
(3953)
(4061)
(4168)
(4272)
(4374)
(4474)
(4570)
(4663)
(4753)
(4839)
(4921)
Concentrate
gal.
___
1
8
19
32
47
64
83
103
125
148
172
197
224
251
279
307
337
367
398
429
460
493
525
558
591
624
658
692
725
759
793
827
861
894
928
961
994
1027
1059
1091
1122
1153
1183
1213
1242
1270
1297
1324
1349
1374
1397
in Tank
(L)
___
(4)
(31)
(71)
(120)
(178)
(243)
(314)
(391)
(473)
(560)
(652)
(747)
(846)
(949)
(1055)
(1163)
(1275)
(1389)
(1505)
(1623)
(1743)
(1864)
(1987)
(2112)
(2237)
(2363)
(2490)
(2618)
(2746)
(2874)
(3002)
(3130)
(3258)
(3385)
(3512)
(3637)
(3762)
(3886)
(4008)
(4128)
(4247)
(4364)
(4478)
(4591)
(4700)
(4807)
(4911)
(5011)
(5108)
(5201)
(5289)
1500 GALLONHORIZONTALBLADDERTANK
1600 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
Concentrate
gal.
___
1
9
20
34
51
69
89
111
134
159
185
212
240
269
299
329
361
393
426
459
493
527
562
597
633
668
704
740
776
812
849
885
921
957
992
1028
1063
1098
1132
1166
1200
1233
1265
1297
1328
1358
1387
1416
1443
1469
1494
in Tank
(L)
___
(5)
(33)
(76)
(129)
(192)
(261)
(338)
(420)
(508)
(602)
(700)
(802)
(908)
(1018)
(1131)
(1247)
(1366)
(1488)
(1612)
(1738)
(1866)
(1996)
(2128)
(2260)
(2394)
(2529)
(2665)
(2801)
(2938)
(3075)
(3212)
(3348)
(3485)
(3621)
(3756)
(3890)
(4023)
(4155)
(4286)
(4415)
(4542)
(4666)
(4789)
(4909)
(5026)
(5140)
(5251)
(5359)
(5462)
(5562)
(5656)
Concentrate
gal.
___
1
10
22
37
55
74
96
120
145
171
199
228
258
289
321
354
388
422
457
493
529
566
603
641
679
717
755
794
833
871
910
949
987
1026
1064
1102
1140
1177
1214
1250
1286
1322
1356
1390
1424
1456
1487
1518
1547
1575
in Tank
(L)
___
(5)
(36)
(82)
(140)
(207)
(282)
(364)
(453)
(547)
(648)
(753)
(862)
(976)
(1094)
(1215)
(1340)
(1468)
(1598)
(1731)
(1866)
(2004)
(2143)
(2284)
(2426)
(2569)
(2714)
(2859)
(3005)
(3151)
(3298)
(3444)
(3591)
(3737)
(3882)
(4027)
(4171)
(4314)
(4455)
(4595)
(4733)
(4869)
(5003)
(5134)
(5263)
(5388)
(5511)
(5630)
(5745)
(5856)
(5963)
1700 GALLONHORIZONTALBLADDERTANK
1800 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
Concentrate
gal.
___
1
10
23
39
58
79
102
127
154
182
211
242
274
307
341
376
412
448
486
524
562
601
640
680
720
761
802
842
883
924
965
1006
1047
1088
1128
1169
1209
1248
1287
1326
1364
1402
1438
1474
1510
1544
1577
1610
1641
1671
1699
in Tank
(L)
___
(5)
(38)
(88)
(149)
(220)
(300)
(387)
(482)
(583)
(689)
(800)
(917)
(1038)
(1163)
(1291)
(1424)
(1559)
(1697)
(1838)
(1982)
(2127)
(2275)
(2424)
(2575)
(2727)
(2880)
(3034)
(3188)
(3343)
(3499)
(3654)
(3809)
(3964)
(4118)
(4271)
(4424)
(4575)
(4725)
(4873)
(5019)
(5163)
(5305)
(5444)
(5581)
(5714)
(5844)
(5970)
(6093)
(6211)
(6324)
(6432)
Concentrate
gal.
___
2
11
25
42
62
84
109
135
163
193
224
257
290
325
361
398
436
475
514
554
595
636
678
720
762
805
848
891
934
977
1021
1064
1107
1150
1193
1236
1278
1320
1361
1402
1442
1482
1520
1559
1596
1632
1667
1702
1734
1766
1796
in Tank
(L)
___
(6)
(41)
(93)
(158)
(234)
(318)
(411)
(511)
(618)
(730)
(848)
(971)
(1099)
(1231)
(1368)
(1507)
(1650)
(1797)
(1946)
(2097)
(2251)
(2407)
(2564)
(2724)
(2884)
(3046)
(3209)
(3372)
(3535)
(3699)
(3863)
(4027)
(4191)
(4354)
(4516)
(4677)
(4836)
(4994)
(5151)
(5305)
(5458)
(5608)
(5755)
(5899)
(6040)
(6177)
(6311)
(6440)
(6565)
(6685)
(6799)
1900 GALLONHORIZONTALBLADDERTANK
2000 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Concentrate
gal.
___
2
11
26
44
65
89
115
143
172
204
237
271
307
344
381
420
460
501
542
585
627
671
715
759
804
849
894
939
985
1030
1076
1122
1167
1212
1258
1302
1347
1391
1434
1477
1520
1561
1602
1643
1682
1720
1757
1793
1828
1862
1893
in Tank
(L)
___
(6)
(43)
(99)
(167)
(247)
(337)
(435)
(540)
(653)
(771)
(896)
(1026)
(1161)
(1300)
(1444)
(1591)
(1742)
(1896)
(2053)
(2213)
(2375)
(2539)
(2705)
(2873)
(3042)
(3212)
(3383)
(3555)
(3728)
(3900)
(4073)
(4245)
(4418)
(4589)
(4760)
(4929)
(5097)
(5264)
(5429)
(5592)
(5752)
(5910)
(6065)
(6217)
(6366)
(6511)
(6651)
(6788)
(6920)
(7046)
(7167)
Concentrate
gal.
___
2
10
21
35
52
70
90
112
136
161
187
214
243
272
303
335
367
400
434
469
504
540
577
614
652
690
728
767
806
846
885
925
965
1005
1045
1085
1126
1166
1206
1246
1286
1325
1364
1404
1442
1481
1519
1556
1593
1630
1666
1701
1736
1770
1803
1835
1867
1897
1927
1955
1982
in Tank
(L)
___
(7)
(37)
(80)
(134)
(196)
(266)
(342)
(425)
(514)
(608)
(707)
(811)
(919)
(1031)
(1147)
(1266)
(1389)
(1515)
(1644)
(1775)
(1909)
(2046)
(2184)
(2325)
(2467)
(2611)
(2757)
(2903)
(3052)
(3201)
(3351)
(3501)
(3652)
(3804)
(3956)
(4108)
(4260)
(4412)
(4564)
(4715)
(4866)
(5016)
(5165)
(5312)
(5459)
(5604)
(5748)
(5890)
(6031)
(6169)
(6305)
(6439)
(6570)
(6698)
(6824)
(6946)
(7065)
(7181)
(7292)
(7400)
(7503)
2200 GALLONHORIZONTALBLADDERTANK
2400 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Concentrate
gal.
___
2
11
24
39
58
78
101
125
151
178
207
238
269
302
336
371
406
443
480
519
558
597
638
679
720
762
804
847
890
933
977
1020
1064
1108
1153
1197
1241
1285
1329
1373
1417
1460
1504
1547
1589
1631
1673
1715
1755
1796
1835
1874
1912
1950
1986
2022
2057
2090
2123
2154
2184
in Tank
(L)
___
(8)
(41)
(90)
(149)
(218)
(296)
(381)
(473)
(571)
(675)
(785)
(900)
(1019)
(1143)
(1271)
(1402)
(1538)
(1677)
(1819)
(1963)
(2111)
(2261)
(2414)
(2568)
(2725)
(2883)
(3044)
(3205)
(3368)
(3532)
(3697)
(3862)
(4029)
(4195)
(4362)
(4530)
(4697)
(4864)
(5031)
(5197)
(5362)
(5527)
(5691)
(5854)
(6015)
(6175)
(6333)
(6489)
(6644)
(6796)
(6946)
(7093)
(7238)
(7379)
(7518)
(7653)
(7784)
(7911)
(8035)
(8154)
(8268)
Concentrate
gal.
___
2
12
26
43
64
86
111
138
166
196
228
261
296
331
368
406
446
486
527
568
611
654
698
743
788
834
880
926
973
1021
1068
1116
1164
1212
1260
1308
1356
1404
1452
1500
1548
1595
1643
1690
1736
1782
1828
1873
1917
1961
2004
2047
2089
2130
2169
2208
2246
2283
2319
2353
2386
in Tank
(L)
___
(9)
(46)
(99)
(165)
(241)
(326)
(420)
(521)
(628)
(743)
(863)
(988)
(1119)
(1255)
(1394)
(1539)
(1687)
(1838)
(1993)
(2152)
(2313)
(2477)
(2643)
(2812)
(2983)
(3156)
(3330)
(3507)
(3684)
(3863)
(4043)
(4223)
(4405)
(4587)
(4769)
(4951)
(5133)
(5315)
(5497)
(5678)
(5859)
(6039)
(6217)
(6395)
(6571)
(6745)
(6918)
(7089)
(7257)
(7423)
(7587)
(7748)
(7906)
(8060)
(8212)
(8359)
(8503)
(8642)
(8777)
(8907)
(9032)
2600 GALLONHORIZONTALBLADDERTANK
2800 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Concentrate
gal.
___
3
13
29
48
70
94
121
150
181
214
248
285
322
361
401
442
485
528
573
618
664
711
759
807
856
906
956
1006
1057
1108
1160
1211
1263
1315
1367
1419
1472
1524
1576
1628
1679
1731
1782
1832
1883
1933
1982
2031
2079
2127
2174
2220
2265
2309
2353
2395
2436
2476
2515
2552
2588
in Tank
(L)
___
(10)
(50)
(108)
(180)
(263)
(356)
(458)
(568)
(686)
(810)
(941)
(1077)
(1219)
(1366)
(1518)
(1675)
(1835)
(2000)
(2168)
(2340)
(2515)
(2692)
(2873)
(3056)
(3241)
(3428)
(3617)
(3808)
(4001)
(4194)
(4389)
(4585)
(4781)
(4978)
(5175)
(5372)
(5570)
(5767)
(5964)
(6160)
(6356)
(6550)
(6744)
(6936)
(7127)
(7316)
(7503)
(7688)
(7870)
(8050)
(8228)
(8402)
(8573)
(8741)
(8905)
(9066)
(9221)
(9373)
(9519)
(9661)
(9797)
Concentrate in Tank
gal.
(L)
___
___
3
(11)
14
(54)
31
(117)
51
(194)
75
(284)
101
(384)
130
(494)
162
(612)
195
(738)
230
(872)
267
(1012)
306
(1159)
346
(1311)
388
(1469)
431
(1632)
476
(1800)
521
(1973)
568
(2149)
615
(2329)
664
(2513)
714
(2701)
764
(2891)
815
(3085)
867
(3281)
919
(3479)
972
(3680)
1026
(3882)
1080
(4087)
1134
(4293)
1189
(4500)
1244
(4708)
1299
(4918)
1355
(5128)
1411
(5339)
1466
(5550)
1522
(5761)
1578
(5973)
1634
(6184)
1689
(6395)
1745
(6605)
1800
(6814)
1855
(7022)
1910
(7230)
1964
(7435)
2018
(7640)
2072
(7842)
2125
(8042)
2177
(8241)
2229
(8436)
2280
(8629)
2330
(8819)
2379
(9006)
2428
(9190)
2476
(9370)
2522
(9546)
2567
(9718)
2612
(9885)
2655
(10047)
2696
(10205)
2736
(10356)
2775
(10502)
3000 GALLONHORIZONTALBLADDERTANK
Depth of Concentrate
in.
(cm)
__
____
2
(5.1)
3
(7.6)
4
(10.2)
5
(12.7)
6
(15.2)
7
(17.8)
8
(20.3)
9
(22.9)
10
(25.4)
11
(27.9)
12
(30.5)
13
(33.0)
14
(35.6)
15
(38.1)
16
(40.6)
17
(43.2)
18
(45.7)
19
(48.3)
20
(50.8)
21
(53.3)
22
(55.9)
23
(58.4)
24
(61.0)
25
(63.5)
26
(66.0)
27
(68.6)
28
(71.1)
29
(73.7)
30
(76.2)
31
(78.7)
32
(81.3)
33
(83.8)
34
(86.4)
35
(88.9)
36
(91.4)
37
(94.0)
38
(96.5)
39
(99.1)
40
(101.6)
41
(104.1)
42
(106.7)
43
(109.2)
44
(111.8)
45
(114.3)
46
(116.8)
47
(119.4)
48
(121.9)
49
(124.5)
50
(127.0)
51
(129.5)
52
(132.1)
53
(134.6)
54
(137.2)
55
(139.7)
56
(142.2)
57
(144.8)
58
(147.3)
59
(149.9)
60
(152.4)
61
(154.9)
62
(157.5)
Concentrate in Tank
gal.
(L)
___
___
3
(11)
16
(59)
33
(126)
55
(210)
81
(306)
109
(414)
141
(532)
174
(660)
210
(796)
248
(939)
288
(1090)
330
(1248)
373
(1411)
418
(1581)
464
(1756)
512
(1936)
560
(2121)
610
(2311)
662
(2504)
714
(2702)
767
(2902)
821
(3107)
876
(3314)
931
(3524)
987
(3737)
1044
(3952)
1101
(4169)
1159
(4388)
1218
(4609)
1276
(4831)
1335
(5055)
1395
(5279)
1454
(5504)
1514
(5730)
1574
(5956)
1633
(6183)
1693
(6409)
1753
(6635)
1813
(6861)
1872
(7086)
1932
(7311)
1990
(7534)
2049
(7756)
2107
(7977)
2165
(8195)
2223
(8412)
2279
(8627)
2335
(8840)
2391
(9049)
2446
(9256)
2499
(9460)
2552
(9661)
2604
(9858)
2655
(10051)
2705
(10240)
2754
(10424)
2801
(10604)
2848
(10778)
2892
(10947)
2935
(11110)
2977
(11267)
Page 1
001330
INTRODUCTION
Page 1
INTRODUCTION
This manual is designed to serve as a guide to inspection
procedures for ANSUL Foam Concentrates and Pre-mix
Solutions.
As Tyco Fire Protection Products manufactures many types
of foam concentrates, locate the product data sheet for the
specific concentrate to be tested. Product Data Sheets can
be accessed at www.ansul.com.
The designated inspector should be a responsible, experienced person with sound, basic knowledge of fire equipment hardware and extinguishing agents. A thorough
briefing on the procedures to be followed should include the
need for precise execution of each analysis step.
See Field Inspection Record at the end of this manual to
record proportioning results.
Form Part No. 428680, Foam Analysis Request, is for use
in recording the information required when sending in
samples to the Tyco Fire Protection Products Agents
Laboratory. This form also outlines the correct procedure
for submitting samples. Review and complete the form as
thoroughly as possible. This form is included in the Foam
Agent Test Kit, Part No. 428679. It is also available on
www.ansul.com under Foam Products. (Note: There is a
charge for this testing service.)
FReqUeNCy aND aCCURaCy OF TesTs
Tyco Fire Protection Products recommends that proportioning tests be done at system commissioning and every three
(3) years minimum thereafter.
exception: Pre-primed foam-water sprinkler systems
should be flushed, drained and pre-primed with fresh solution annually. During this process correct proportioning
should be verified.
Tyco Fire Protection Products recommends that Standard
Quality Analysis Testing be done annually by the Tyco Fire
Protection Products Agents Laboratory which not only tests
the chemical properties of the sample, but also does lab
scale fire testing to assure the products performance.
Packages of two (2) sample containers with labels can be
purchased under Part No. 428679.
sTORage CONDITIONs
Tyco Fire Protection Products recommends that its concentrates be stored at the temperatures indicated on the
specific product data sheet.
Accelerated aging studies have been conducted with the
concentrate and pre-mix solutions stored at 150 F
(65.5 C) with no adverse effect. However, Underwriters
Laboratory Standard No. 162 requires that the maximum
storage temperature be listed at 120 F (48.9 C).
FOamsOlUTIONCONCeNTRaTIONDeTeRmINaTION
Page 2
Using the graph paper, plot the meter reading on the X axis
and the percent concentrate reading on the Y axis. This
plotted curve will serve as the known baseline for the
proportioning test. Meters may have different scales and
the plotted resolution should be as large as possible with
the complete range of the calibration solutions known. The
scale you set must be linear.
Collect foam solution sample(s) from the proportioning
system, using care to ensure that each sample is taken at
an adequate distance downstream from the proportioner
being tested. (Usually any place downstream of the first
change in direction is adequate if samples are taken in the
riser room.) Stabilize a water flow through your discharge
device within the known acceptable range for the proportioner and open the concentrate control valve. Take the
sample about 30 to 60 seconds after foam appears from
the test connection. Take meter readings of the sample(s)
and compare readings to the plotted curve to determine the
percentage for each sample.
Per NFPA 11, Standard for Low-, Medium-, and HighExpansion Foam, acceptable ranges of proportioning
systems are not less than the rated concentration and not
more than 30% above the rated concentration or one
percentage point above the rated concentration, whichever
is less. For example, the acceptable range for a 3%
concentrate is from 3 to 3.9%.
Note: There is some variability dependent on the accuracy
of the meter, the accuracy to which the calibration samples
were made, and if temperatures between calibration standards and discharge samples have not normalized.
Conductivity is especially susceptible to reading fluctuation,
thus the sample should be continuously stirred until a stabilized reading can be estimated. Care should be taken to
not bump the sides or bottom of the sample container or
contaminate the sample with salts or solids, i.e. dirty fingers
while stirring. The conductivity of water stored in or for
systems can vary throughout a discharge which may affect
results. Conductivity should not be used for sea, salt, or
brackish water supplies. Although conductivity can be the
most accurate means of measuring foam solution in clean
water supplies under ideal conditions, the refractive index
method is best for most real world testing.
If discharge samples are sent to the Tyco Fire Protection
Products Test Lab for analysis, they should be packaged
per the instructions with the Test Kit and sent in for immediate processing. Largely dependent on water quality and the
type of concentrate used, foam solutions may start to
biodegrade in a short period of time which can affect results
(possibly as little as three to five days with nutrient-rich
water and detergent-based foam concentrates).
The following graphs are examples of typical refractive
index values for various concentrate pre-mixes. Results
may vary depending on the concentrate pre-mix type, site
water supply, and actual concentrate lot number. Therefore,
it is important that a new calibration curve be developed on
each date a proportioning test is required.
TypICal CalIbRaTION CURve ResUlTs WheN UsINg paRT NO. 405713 haNDhelD ReFRaCTOmeTeR
Page 3
006876
NOTes
Page 4
NOTes:
METER READING
FOAM CONCENTRATE
WATER
PRE-MIX #1
PRE-MIX #2
PRE-MIX #3
CalIbRaTION CURve
METER READING
METER READING
VerTICal
blaDDer TaNKS
FOAM SYSTEMS
PARTS LIST
VerTICalblaDDerTaNKS
FIGure
NO.
ParT
NO.
DeSCrIPTION
68338
19841
26039
19875
19872
19873
16450
68335
68826
68779
68777
70150
598
2367
25423
25940
63421
See Table 1
See Table 1
19
20
21
Reducing Bushing
2 1/2 in. x 1 in.
Tee 2 1/2 in.
Pipe Plug 2 1/2 in.
Short Nipple 2 1/2 in.
19
20
21
Reducing Bushing
3 in. x 1 in.
Tee 3 in.
Pipe Plug 3 in.
Short Nipple 3 in.
24080
23555
71181
16526
ParT
NO.
31
31
31
31
31
31
31
31
31
31
7 11 4 4
32
19974
16085
19825
32
SIze
ParT NO. ParT NO. ParT NO.
ParT NO.
GallONS ePOxy
eNamel CeNTer Tube blaDDer
50
70501
70502
70514
70504
100
69000
69001
69040
69030
150
70516
70517
70519
70505
200
69002
69003
69041
69031
300
69004
69005
69042
69032
400
419153
419154
419173
419168
500
419155
419156
419174
419169
600
69010
69011
69045
69035
700
69012
69013
69046
69036
800
419157
419158
419175
419170
900
419159
419160
419176
419171
1000
419161
419162
419177
419172
1100
71118
71119
71128
70970
1200
71120
71121
71129
70971
1300
71122
71123
71130
70972
1400
71124
71125
71131
70973
1500
71126
71127
71132
70974
19836
68425
68424
68423
68422
68421
68426
Table 1
002552
24
25
26
27
28
29
30
31
DeSCrIPTION
FIGure
NO.
67691
67690
67692
67693
435627
67694
67695
72418
72616
436887
72765
74177
438812
438813
VerTICalblaDDerTaNKS
FIGure
NO.
ParT
NO.
DeSCrIPTION
68338
19841
26039
19875
19872
19873
16450
68335
68826
68779
68777
70150
598
2367
25423
25940
63421
See Table 1
See Table 1
19
20
21
Reducing Bushing
2 1/2 in. x 1 in.
Tee 2 1/2 in.
Pipe Plug 2 1/2 in.
Short Nipple 2 1/2 in.
19
20
21
Reducing Bushing
3 in. x 1 in.
Tee 3 in.
Pipe Plug 3 in.
Short Nipple 3 in.
24080
23555
71181
16526
ParT
NO.
31
31
31
31
31
31
31
31
31
31
7 11 4 4
32
19974
16085
19825
32
SIze
ParT NO. ParT NO. ParT NO.
ParT NO.
GallONS ePOxy
eNamel CeNTer Tube blaDDer
50
70501
70502
70514
70504
100
69000
69001
69040
69030
150
70516
70517
70519
70505
200
69002
69003
69041
69031
300
69004
69005
69042
69032
400
419153
419154
419173
419168
500
419155
419156
419174
419169
600
69010
69011
69045
69035
700
69012
69013
69046
69036
800
419157
419158
419175
419170
900
419159
419160
419176
419171
1000
419161
419162
419177
419172
1100
71118
71119
71128
70970
1200
71120
71121
71129
70971
1300
71122
71123
71130
70972
1400
71124
71125
71131
70973
1500
71126
71127
71132
70974
19836
68425
68424
68423
68422
68421
68426
Table 1
002552
24
25
26
27
28
29
30
31
DeSCrIPTION
FIGure
NO.
67691
67690
67692
67693
435627
67694
67695
72418
72616
436887
72765
74177
438812
438813
VerTICal
blaDDer TaNKS
FOAM SYSTEMS
PARTS LIST
hOrIzONTAl
blADDer TANKS
FOAM SYSTEMS
PARTS LIST
hOrIzONTAlblADDerTANKS
FIGure
NO.
DeSCrIPTION
PArT
NO.
68338
19841
26039
19875
19872
19873
16450
68335
68826
68779
68777
70150
598
2367
25423
25940
63421
17249
1133
18107
See Table 1
See Table 1
See Table 1
22
23
24
Reducing Bushing
2 1/2 in. x 1 in.
Tee 2 1/2 in.
Pipe Plug 2 1/2 in.
Short Nipple 2 1/2 in.
28
29
30
31
32
33
34
PArT
NO.
35
35
35
35
35
35
35
35
35
35
35
23555
71181
16526
19836
68425
68424
68423
68422
68421
68426
24080
36
36
DeSCrIPTION
FIGure
NO.
71144
19974
16085
19825
TAble 1
PArT NO.
PArT NO.
SIze
PArT NO. PArT NO. CeNTer Tube CeNTer Tube PArT NO.
GAllONS ePOxy
eNAmel VerTICAl
hOrIzONTAl blADDer
100
69090
69091
69140
69130
69120
150
70521
70522
69141
70534
70525
200
69092
69093
69141
69131
69121
300
69094
69095
69142
69132
69122
400
419178
419179
69144
419198
419193
500
419180
419181
69144
419199
419194
600
69100
69101
69144
69135
69125
700
69102
69103
69144
69136
69126
800
419182
419183
69144
419200
419195
900
419184
419185
69144
419201
419196
1000
419186
419187
69144
419202
419197
1100
71100
71101
71142
71133
70975
1200
71102
71103
71142
71134
70976
1300
71104
71105
71142
71135
70977
1400
71106
71107
71142
71136
70978
1500
71108
71109
71142
71137
70979
1600
71110
71111
71142
71138
70980
1700
71112
71113
71142
71139
70981
1800
71114
71115
71142
71140
70982
1900
71116
71117
71142
71141
70983
2000
71150
71151
71143
71162
70984
2200
71152
71153
71143
71163
70985
2400
71154
71155
71143
71164
70986
2600
71156
71157
71143
71165
70987
2800
71158
71159
71143
71166
70988
3000
71160
71161
71143
71167
70989
67691
67690
67692
67693
435627
67694
67695
72418
72616
436887
72765
74177
438812
438813
hOrIzONTAlblADDerTANKS
FIGure
NO.
DeSCrIPTION
PArT
NO.
68338
19841
26039
19875
19872
19873
16450
68335
68826
68779
68777
70150
598
2367
25423
25940
63421
17249
1133
18107
See Table 1
See Table 1
See Table 1
22
23
24
Reducing Bushing
2 1/2 in. x 1 in.
Tee 2 1/2 in.
Pipe Plug 2 1/2 in.
Short Nipple 2 1/2 in.
28
29
30
31
32
33
34
PArT
NO.
35
35
35
35
35
35
35
35
35
35
35
23555
71181
16526
19836
68425
68424
68423
68422
68421
68426
24080
36
36
DeSCrIPTION
FIGure
NO.
71144
19974
16085
19825
TAble 1
PArT NO.
PArT NO.
SIze
PArT NO. PArT NO. CeNTer Tube CeNTer Tube PArT NO.
GAllONS ePOxy
eNAmel VerTICAl
hOrIzONTAl blADDer
100
69090
69091
69140
69130
69120
150
70521
70522
69141
70534
70525
200
69092
69093
69141
69131
69121
300
69094
69095
69142
69132
69122
400
419178
419179
69144
419198
419193
500
419180
419181
69144
419199
419194
600
69100
69101
69144
69135
69125
700
69102
69103
69144
69136
69126
800
419182
419183
69144
419200
419195
900
419184
419185
69144
419201
419196
1000
419186
419187
69144
419202
419197
1100
71100
71101
71142
71133
70975
1200
71102
71103
71142
71134
70976
1300
71104
71105
71142
71135
70977
1400
71106
71107
71142
71136
70978
1500
71108
71109
71142
71137
70979
1600
71110
71111
71142
71138
70980
1700
71112
71113
71142
71139
70981
1800
71114
71115
71142
71140
70982
1900
71116
71117
71142
71141
70983
2000
71150
71151
71143
71162
70984
2200
71152
71153
71143
71163
70985
2400
71154
71155
71143
71164
70986
2600
71156
71157
71143
71165
70987
2800
71158
71159
71143
71166
70988
3000
71160
71161
71143
71167
70989
67691
67690
67692
67693
435627
67694
67695
72418
72616
436887
72765
74177
438812
438813
hOrIzONTAl
blADDer TANKS
FOAM SYSTEMS
PARTS LIST