Beruflich Dokumente
Kultur Dokumente
NAME:
DATE:
PROFESSOR:
Category
Points
Description
1
2
1
2
1
2
1
2
Section 1
Configuring NAT and PAT
20 points
Task 1: Step 4
Related
Explanation or
Response
Task 1: Step 14
Related
Explanation or
Response
Task 1: Step 16
Related
Explanation or
Response
Task 1: Step 17
Related
Explanation or
Response
Summary
Paragraph
Question: Where is the remote router located to which router NYEDGE1 has
achieved neighbor status? (Hint) Read and study the explanations within the
lab for assistance. (2 points)
Task 1, Step 14: Paste a screenshot showing the output of the Show ip nat
Translations command. (1 point)
Task 1, Step 16: Paste a screenshot showing the output of both the
extended Ping command and the debug. (1 point)
Question: Which piece of the debug output shows the original source
address and the address to which it is translated?
(Hint) Read and study the explanations within the lab for assistance. (2
points)
Task 1, Step 17: Paste a screenshot showing the Show ip nat Statistics
command. (1 point)
Question 1: According to the output, what is the access list number that is
used to identify inside source devices that are permitted to have their
addresses translated?
(Hint) Read and study the explanations within the lab for assistance. (1 point)
Question 2: Scan back up through the commands that were used in the lab
and locate the specific command that links the access list to the inside global
address used by the translation and write it below.
(Hint) Read and study the explanations within the lab for assistance. (1 point)
Category
Points
Description
Section 2
Configuring a Cisco
Router as a DHCP Server
- 20 Points
Task 1: Step
13
Related
Explanation
or Response
Task 1: Steps
14-16
Related
Explanation
or Response
Task 1: Step
17
Related
Explanation
or Response
Task 1: Step
18
Related
Explanation
or Response
Summary
Paragraph
1
2
1
2
1
2
1
2
Question: What command can be used to determine the address that a host
will use to access the DNS server?
(Hint) Read and study the explanations within the lab for assistance. (2
points)
Task 1, Step 17: Paste a screenshot after you have executed the Show ip
Dhcp Pool command from router NYEDGE1. (1 point)
Question: Compare the address that was assigned to the VLAN 1 interface of
NYCORE1 to that of the Current index value shown in your output above.
What information do you think is conveyed by the Current index value?
(Hint) Read and study the explanations within the lab for assistance. (2
points)
Task 1, Step 18: Paste a screenshot below of the output of the Show ip
Dhcp Server Statistics command that was issued on router NYEDGE1. (1 point)
Question: What action do you think will cause the value of the DHCPOFFER
field to increase?