Sie sind auf Seite 1von 3

HIGH GAS PRESSURE REGULATING AND REDUCING-METERING

STATIONS

High gas pressure regulating stations were designed for gas pressure reducing from high to
lower value determined by clients. High gas pressure reducing-metering stations were
designed for both gas pressure reducing and gas flow metering.
The range of inlet pressure: 0.4 10.0 MPa
The range of outlet pressure: arbitrary
In the range of foregoing pressures we construct stations of arbitrary flow capacities and
various configurations: in locker, in brick building or without locker. Standard stations are
built in two- or multi-line configuration. The one of line is the reserve line. The reserve line
as well as working lines have 100% of stations flow capacity. The reserve line secures
working of the station and supply with gas in the amount equal to maximum flow capacity of
the station, when working lines are turned off.
Standard configurations of lines reduce high pressure:
The line is made up of slam-shut valve and pressure regulator with a built-in slam-shut valve.

The line is made up of slam-shut valve, pressure regulator-passive controller, and main
pressure regulator.

The line is made up of slam-shut valve, pressure regulator-active


controller, and main pressure regulator.

A preferable configuration of the pressure reducing


reducing line is a controlled system. The ALSI
Company is the precursor of the system on the polish market. The controlled system
improves operational reliability and operational safety. The system secures continuity of the
supply with a gas and it is environmental-friendly.
envi
friendly. The fittings applied in reducing lines and
plants made by the ALSI and the Pietro Fiorentini guarantee the highest quality,
operational reliability and operational safety. These installations have required technical
approvals.
Standard
dard configurations of metering systems fitted in stations.
Meter system U-1

DESCRIPTION OF DIAGRAMS
1. Inlet ball valve
2. Dust filter
3. Differential manometer
4. Gas-heater
5. Slam-shut valve
6. Pressure regulator with slam-shut
slam
valve
7. Plate-type manometer
8. Blow-off valve
9. Vent valve
10. Ball valve after the pressure regulator
11. Pressure regulator-passive
passive controller
12. Main pressure regulator
13. Pressure regulator-active
active controller
14. Ball valve of the meter system
15. Turbine gas meter
16. Vent valve
17. Ball valve of the by-pass off the meter system
18. Hole plug eyepiece
19. Plug-in
in socket for control thermometer
20. Temperature transducer
21. Absolute pressure transducer
22. Volume corrector
23. By-pass
24. Flux straightener

Meter systems meet internal standards PGNiG: Pomiary paliw gazowych. These systems are
equipped with the highest-quality measuring devices, i.e. a rotor gas meters made by
Canadian ROMET Ltd. Company, a turbine gas meters made by our company under
American EQUMETER Companys licence, and a electronic gas volume correctors made by
ALSI. The electronic gas volume corrector converts measured gas flow to the standard
conditions and it telemetrically transmits data provided information on operating conditions
and the amount of transferred gas. We install other manufacturers devices on request.

Das könnte Ihnen auch gefallen