Beruflich Dokumente
Kultur Dokumente
1. Introduction
Micro strip antennas are started in early 1970s when conformal antennas were
required for missiles. These antennas are attractive due to their light weight,
22
Asim Kumar et al
conformability and low cost.These antennas can be integrated with printed strip-line
feed networks and active devices. A major contributing factor for recent advances of
micro strip antennas is the revolution in electronic circuit miniaturization. As
conventional antennas are bulky and costly, micro strip antennas based on
photolithographic technology have low cost and small size.This is a relatively new area
of antenna engineering.
The aim of the thesis is to design and fabricate a circularly polarizedMicro strip
Patch Antenna with the help of IE 3D simulator and study the effect of antenna
dimensions Length (L),and substrate parameters relative Dielectric constant (r),
substrate thickness (t) on the Radiation parameters of Bandwidth and Beam-width.
23
24
Asim Kumar et al
25
4. Conclusion
The design of rectangular patch Micro strip antenna for circular polarization has been
completed using IE3D software. The simulation gave results good enough to satisfy
our requirements to fabricate it on hardware which can be used wherever needed. The
paper has been limited mostly to theoretical studies and simulations due to lack of
fabrication facilities.Detailed experimental studies can be taken up at a later stage to
fabricate the antenna.
References
[1]
[2]
[3]
[4]
26
Asim Kumar et al