Beruflich Dokumente
Kultur Dokumente
FIGURE 1
FIGURE 2
REMOVING INNER GEAR PLATE
See Fig. 3. Loosen set screw "B" and unscrew collar "C" by turning counterclockwise. Care should be exercised not to lose the small cushion of soft material
that is located under set screw "B". Gear "G" may now be removed by pulling
directly away from the head.
Next pry out Woodruff key "E" and pull collar "H" off from the spindle. Remove set
screw in collar "D" and two set screws "F" in gear "I".
With a lead hammer or a machinists hammer and a block of wood, carefully drive
the spindle "A" in the direction shown by the arrow until Woodruff key "J" appears
FIGURE 3
Next, it is necessary to remove the back gears. Drive out pin "K" in the eccentric
handle and removing the two set screws "L". Back gear shaft "0" can be pushed
out in the direction indicated by the arrow.
The old belt can now be pulled out of the machine and a new belt inserted.
TO REASSEMBLE
All parts should be cleaned and oiled before reassembly. By following figure 3
carefully, the various parts may be put back in their proper places.
First, put the back gear assembly together.
Next, assemble the spindle with it's various parts. Proper adjustment for the
correct pre-load is accomplished by adjusting collar "C" so there is a noticeable
drag on the spindle "A" when turning it over by hand.
All gears should be greased with a gear lubricant equivalent to Keystone #122
gear lubricant.