Beruflich Dokumente
Kultur Dokumente
PART 1 - GENERAL
A. Drawings and general provisions of the Contract, including General and Supplementary
Conditions and Division 1 Specification Sections, apply to this Section.
1.2 SUMMARY
A. Section Includes:
1.3 SUBMITTALS
B. Product Schedule: Indicating type, quantity, size, and installation location of each ensemble
required.
C. Maintenance data.
PART 2 - PRODUCTS
2.1 MATERIALS
A. Stainless Steel Sheet: ASTM A 240/A 240M, steel sheet; Type 304, directional satin finish.
B. Aluminum Plate and Sheet: ASTM B209 (ASTM B 209M), Alloy 6061-T6.
1. Exterior Construction: All stainless steel exterior face plate, weather shroud, depository
door and entry chute.
a. Exterior portion of chute has an upward angle and is welded to the bottom of the
weather shield.
b. Depository door has a spring-loaded hinge welded in place and is completely
weatherstripped.
4. Dimensions:
a. Overall Finished: 20 in. wide by 25-1/2 in. long by 22-1/4 in. high (508 mm by
647.7 mm by 565.2 mm).
b. External Faceplate: 20 in. wide by 13 in. high by 12-3/4 in. deep (508 mm by 330
mm by 324 mm).
c. Interior Chute Assembly: 15-11/16 in wide by 19-13/16 in. long by 19-15/16 in.
high (398 mm by 503 mm by 506 mm).
d. Depository Opening: 15-1/8 in. by 3-7/8 in. high (384.2 mm by 98.4 mm).
PART 3 - EXECUTION
3.1 INSTALLATION
A. External Rough-Cut Dimensions: 11-1/4 in. high by 18-1/4 in. wide (268 mm by 464 mm).
1. Maximum dimension from finished floor to bottom of rough-cut opening: 40-3/4 in.
(1035.1 mm).
B. Interior Rough-Cut and Trim: Maintain 3 in. (76.2 mm) horizontal from front to back, then
angle 90 degrees downward 7 in. (177.8 mm) ands continue horizontally through back of wall.
PART 1 - GENERAL
A. Drawings and general provisions of the Contract, including General and Supplementary
Conditions and Division 1 Specification Sections, apply to this Section.
1.2 SUMMARY
A. Section Includes:
1.3 SUBMITTALS
B. Product Schedule: Indicating type, quantity, size, and installation location of each ensemble
required.
C. Maintenance data.
PART 2 - PRODUCTS
2.1 MATERIALS
B. Aluminum Plate and Sheet: ASTM B209 (ASTM B 209M), Alloy 6061-T6.
2. Construction Methods:
a. Outer Shell: Fabricated from two pieces with welded seams.
b. Bottom panel welded in place.
c. Cushion Drop: Lowers as materials are received and raises as materials are
removed.
PART 3 - EXECUTION