Beruflich Dokumente
Kultur Dokumente
AccuSine PCS is designed to correct for harmonics and poor displacement power factor. By completing the following inform
program will define the amount of corrective current to be provided by AccuSine PCS to meet the objective.
1. Review site carefully to determine all of the loads to which AccuSine PCS will be applied. AccuSine PCS is best applied t
common bus. Be sure to include all loads for proper evaluation.
2. Be sure there are no power factor capacitors downstream of the selected CT location. Any and all capacitors downstream
CTs must be removed or AccuSine PCS performance will be diminished greatly and/or resonance may occur.
3. Use of series line reactors in front of all SCR type converters is required. At least 3% impedance is required.
4. PWM VFDs require either a 3% impedance DC bus choke or a 3% impedance input line reactor for operation with AccuS
5. If AccuSine PCS is on an electrical system that contains a combination of linear and nonlinear loads, all linear loads may
grouped as if they were one load for the purposes of this selection program.
6. When TDD (total demand distortion of the current) is maintained below 5%, the upstream total harmonic voltage distortio
[THD(V)] will not exceed 5% THD(V) due to the loads.
7. AccuSine PCS selection is based solely upon current requirements. Be sure to select the correct model that matches you
voltage.
Project Identification:
Date:
Company name:
Address:
City:
Contact
Job ID:
Ref #:
St:
Postal Code:
Completed by:
Phone #:
Fax #:
e-mail ID:
Comments:
This program requires no data entry for the "Electrical System Data." The program defaults to 480VAC and 5%TDD as the o
A. Desired TDD level to be met:
(If you want the objective TDD to be selected according to IEEE 519-1992, Table 10.3
guidelines, leave "A" blank and enter the "Input Transformer Information" below.)
KVA
Impedance
0.0 SCA
amps
A3.
B.
Enter if known. Program will calculate demand load based upon loads defined below if not provided.
Short circuit current ratio (A1/A2):
SCR (Isc/Iload)
Electrical system voltage:
If no value is entered for voltage, 480V is assumed.
Nonlinear Loads:
DC Drives
# Qty HP
UPS
Other SCR converters
Diode Converter SCR Converter Inductive
Resistive
# Qty KVA
# Qty KVA # Qty KVA # Qty KVA
1
2
3
4
5
6
7
8
9
10
11
12
Are VFD loads centrifugal pump or fan loads?
(Program defaults to 'No'.)
D.1List the total KVA of installed UV equipment:
6, 12, or 18 pulse or 5, if a 5th harmonic tuned filter is used:
KVA
Linear Loads:
E. Total Linear Loads Installed:
Enter full load KVA capacity of linear loads.
KVA
480 volts.
0.0 amps.
0.0 amps.
0.950
0.950
The TDD of the electrical system before AccuSine PCS is 0.00% TDD.
The objective TDD is
The required rating of the AccuSine PCS system is
0.00% TDD.
0.0
amperes of correctio
System
System with
without
AccuSine
AccuSine
Operating
0.0
0.0 Amps
0.0
0.0 Amps
0.0
0.0 Amps
0.00%
0.00%
0.0
0.0 Amps
0.0 kVAR
election Program
e is required.
for operation with AccuSine PCS.
Date:
5%
8%
12%
15%
20%
ot provided.
6-Pulse
PWM VFDs
Qty
PWM VFDs
HP
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0.00%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
VVI VFDs
0
0%
0.00%
CSI VFDs
0
0%
0.00%
DC Drives
0
0%
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
PWM UPS
0%
SCR PWM
0%
SCR Ind
0%
SCR Res
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
SCR Cap
PWM VFDs
VVI VFDs
CSI VFDs
DC Drives
UPS Diode
UPS SCR
SCR Ind
SCR Res
SCR Cap
TDD
6-pulse
12-pulse 18-pulse
0.0%
0.0% 4-15
0.0%
0.0% 19-30
0.0%
0.0% 34-45
0.0%
0.0% 49-60
0.0%
0.0% 64-75
0.0%
0.0% 79-90
0.0%
0.0% 94-105
0.0%
0.0% 109-120
0.0%
0.0% 124-135
Totals 6-pulse
Totals 12-pulse
Totals 18-pulse
Total UV
Totals tuned
%TDD
amps
0.00%
0.00%
5.00%
20.00%
0.00%
w/Linear loads
0.00%
HP/KVA
5th filter
6-pulse
0.0%
0.0%
0.0%
0.0%
0.0%
0.0%
0.0%
0.0%
0.0%
0%
12-pulse
0
0
0
0
0
0
0
0
0
18-pulse
0
0
0
0
0
0
0
0
0
Tuned
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Irms
%THD(I)
0.00
0.00%
0.00%
DPF
0.950
0.950
0.00%
0.00%
0.00 amps
0.00
0.00
18-pulse
0.00
5.00%
0.95
Irms
%THD(I)
0.00
0.00%
0.00%
DPF
0.950
0.950
Irms'
Revised
0.00
PWM VFDs
QTY%
1
2
3
4
5
6
7
HP%
40%
35%
31%
27%
24%
21%
20%
VVI VFDs %
QTY%A
HP%A
1
36%
2
31%
3
27%
4
23%
5
20%
6
18%
7
18%
CSI VFDs %
QTY%B
HP%B
1
35%
2
32%
3
29%
4
27%
5
26%
6
25%
7
24%
DC Drives %
QTY%C
HP%C
1
35%
2
31%
3
27%
4
24%
5
22%
12-pulse
PWM VFDs
Qty
0
0
0
0
0
0
0
0
0
0
0
0
12-pulse
VVI VFDs
0
0
0
0
0
0
0
0
0
0
0
0
0
CSI VFDs
12-pulse
0
0
0
0
0
0
0
0
0
0
0
0
DC Drives
12-pulse
0
0
0
0
0
HP
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
12-pulse harmonics
0
0%
0.00%
0.0%
0
0
0
0
12-pulse harmonics
0
0%
0.00%
0.0%
0
0
0
0
12-pulse harmonics
0
0%
0.00%
0.0%
0
0
0
0
0
0%
0%
6
7
21%
20%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
12-pulse harmonics
PWM UPS %
QTY%D
HP%D
1
28%
2
25%
3
23%
4
21%
5
20%
6
19%
7
18%
PWM UPS
12-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
SCR PWM %
QTY%E
HP%E
1
31%
2
28%
3
26%
4
24%
5
22%
6
21%
7
20%
SCR PWM
12-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
SCR Ind %
QTY%F
HP%F
1
35%
2
32%
3
30%
4
28%
5
26%
6
25%
7
24%
SCR Ind
12-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0.0%
0
0
0
0
12-pulse harmonics
0%
0.0%
0
0
0
0
12-pulse harmonics
12-pulse harmonics
0
0%
0
0%
0%
0.0%
0
0
0
0
0
0%
0%
0.0%
SCR Res %
QTY%G
HP%G
1
38%
2
35%
3
32%
4
30%
5
28%
6
26%
7
24%
SCR Res
12-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
SCR Cap %
QTY%H
HP%H
1
40%
2
37%
3
34%
4
32%
5
30%
6
28%
7
26%
SCR Cap
12-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
Current
6-pulse
12-pulse 18-pulse
tuned
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
Current
6-pulse
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0
0.0
0
0
0
0
0.0
0
0
0
0
12-pulse harmonics
0
0%
0%
0.0%
0
0
0
0
12-pulse harmonics
0
0%
0%
0.0%
12-pulse 18-pulse
0.0
0.0
0.0
0.0
0.0
0.0
0
0
0.0
0.0
0
0
0
0
0
0
0
0
0.0
0.0
0.0
f
18.2
18.2
18.2
f
18.2
18.2
Fund
sin (f)
tan (f)
If
0.312
0.329
0.00
0.312
0.329
0.00
Correction Current:
Harm
Reactive
Ih
Ir
0.00
0.00
0.00
0.00
0.00
0.00
All loads
Fund
Irms
If
0.00
0.00
0.00
0.00
Correction Current
Harm
Reactive
Ih
Ir
0.00
0.00
0.00
0.00
0.00
0.00
Fund
Irms
Iw
0.00
0.00
0.00
0.00
Current Correction
0.00%
0.00%
HP
AccuSine
Rating
rms
0.00
0.00
correction needed
0.00
0.00
0.00
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
18-pulse
PWM VFDs
Qty
0
0
0
0
0
0
0
0
0
0
0
0
18-pulse
VVI VFDs
0
0
0
0
0
0
0
0
0
0
0
0
18-pulse
VVI VFDs
0
0
0
0
0
0
0
0
0
0
0
0
18-pulse
DC Drives
0
0
0
0
0
HP
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
18-pulse
PWM UPS
0
0
0
0
0
0
0
0
0
0
0
0
18-pulse
SCR PWM
0
0
0
0
0
0
0
0
0
0
0
0
SCR Ind
18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
SCR Res
18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
SCR Cap
18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
0
0
0
0
0
0
0
0
0
0
0
0
0 Total HP 18-pulse
Constant Table
PF
K1
0.600
0.605
0.610
0.615
0.620
0.625
0.630
0.635
0.640
0.645
0.650
0.655
0.660
0.665
0.670
0.675
0.680
0.685
0.690
1.333
1.316
1.299
1.282
1.266
1.249
1.233
1.217
1.201
1.185
1.169
1.154
1.138
1.123
1.108
1.093
1.078
1.064
1.049
SCR Res
5th Harmonic filter
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
SC Cap
5th harmonic filter
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Reactive
Ir
0
0
0.00
Iw
Ivar
0
0.695
0.700
0.705
0.710
0.715
0.720
0.725
0.730
0.735
0.740
0.745
0.750
0.755
0.760
0.765
0.770
0.775
0.780
0.785
0.790
0.795
0.800
0.805
0.810
0.815
0.820
0.825
0.830
0.835
0.840
0.845
0.850
0.855
0.860
0.865
0.870
0.875
0.880
0.885
0.890
0.895
0.900
0.905
0.910
0.915
0.920
0.925
0.930
0.935
0.940
0.945
0.950
1.035
1.02
1.006
0.992
0.978
0.964
0.95
0.936
0.923
0.909
0.896
0.882
0.868
0.855
0.842
0.829
0.815
0.802
0.789
0.776
0.763
0.75
0.737
0.724
0.711
0.698
0.685
0.672
0.659
0.646
0.633
0.62
0.607
0.593
0.58
0.567
0.553
0.54
0.526
0.512
0.498
0.484
0.47
0.456
0.441
0.426
0.411
0.395
0.379
0.363
0.346
0.329
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0%
0.00%
0.0%
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0.00%
0.0%
largest hp
Close qty
Total Hp
Close Total HP
0
0%
0
0%
0.00%
0.0%
0
0
0
0
0
0%
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0%
0.0%
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
0.0%
0
0%
0%
0.0%
0
0
0
0
0
0%
0%
0.0%
largest hp
Close qty
Total Hp
Close Total HP
0
0
0
0
largest hp
Close qty
Total Hp
Close Total HP
5th harmonic filter
0
0%
0%
0.0%
0
0
0
0
0
0%
0%
0.0%
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0