Beruflich Dokumente
Kultur Dokumente
Zoom
Zoom
Zoom
Remove:
Anti-roll bar link from link.
Bolt from brake pipe bracket.
Detach pipes from clips.
Zoom
Counterhold strut with 5037 and loosen nut a few turns with socket 5036.
NOTE: Use the wrench handle carefully. On certain models the ignition coil can be damaged if accidently hit.
Zoom
Zoom
Lower jack.
Pull down spring strut to free it from wing.
Zoom
Place compressor tools opposite each other and with three free spring coils between the tool jaws.
Compress each side alternately.
Zoom
NOTE: For replacement of axial bearing only, remove washer, bearing, and axial bearing, then proceed to: Locate New Axial Ball
Bearing in Spring Plate section below.
Remove:
Washer.
Mount.
Axial bearing.
Shaped washer.
Spring seat.
Rubber spacer.
Bump stop.
Bellows.
Guide sleeve.
Spring.
NOTE: The spring seat and rubber spacer are one unit on 760 and 780 models 1988 and on.
NOTE: When replacing the spring only proceed to: Remove Spring Compressor Tool 5407 section below.
Zoom
Use hook spanner 5406, key 5303 and a wrench handle as a brace.
Install the new shock absorber and mounting nut.
Tighten nut using hook spanner 5406, key 5303 and a wrench handle as a brace.
NOTE: For replacement of shock absorber only, proceed to: Component Inspection section below.
Zoom
Zoom
Remove spring compressor tool by loosening alternately from the old spring.
Zoom
Place compressor tool 5607 opposite each other and with three free spring coils between the tool jaws.
Compress each side alternately.
Compress the spring until the length is approximately 275 mm (10.8 in) between ends.
Component Inspection
Check:
mount.
axial bearing.
rubber spacer.
bellows, etc. for wear and damage.
Replace as needed.
NOTE: The picture shows only parts for the 740 model, not the 760 or 780 models from 1988.
Zoom
Install Spring
Zoom
Zoom
Zoom
Zoom
Zoom
Zoom
Install:
Anti-roll bar to link.
Zoom
Zoom
Install wheels
Torque to 85 Nm (63 ft lb) .