Beruflich Dokumente
Kultur Dokumente
Page 1 of 6
CSD Exercises
Page 2 of 6
CSD Exercises
Page 3 of 6
CSD Exercises
Light Data
Page 4 of 6
CSD Exercises
Impedance Data
DcZ1 R = 500 Ohm
DcZ2 R = 2000 Ohm
2. Study Case Use Study Case: CSD
3. CSD Simulation Sequence Operation
Set Simulation Method to Sequence of Operation. Close dcS2 and dcS3.
Run simulation by pressing the pushbutton or clicking the Run button.
Check Event View
4. CSD Simulation Simulation with Vd Calc
Set Simulation Method to Load Flow Calculation. Close dcS2 and dcS3.
Run simulation by pressing the pushbutton or clicking the Run button.
Check Event View and Report
Check updated composite CSD duty cycle after you click Turn-On and Turn-Off button.
5. CSD Simulation Pickup V
Repeat Step 4 with DCS2 open.
6. CSD Simulation Dropout V
Set Simulation Method to Load Flow Calculation. Close dcS2 and dcS3.
Press the Turn-On button.
Open dcS2 and then open dcS3
7. CSD Simulation Pickup V
Set Simulation Method to Load Flow Calculation. Close dcS2 and dcS3.
Add a Macro-Controlled Switch (MC1) in series with dcS2
ON from 0 to 150 ms
OFF from 150 to 1000 ms
ON After 1000 ms
Run Simulation by pressing the Turn-On button.
8. CSD Simulation Use Duty Cycle Model
Insert a node between Light-1 and contact LightCtl-2
Connect a Macro-Controlled Switch (MC2) in parallel to contact LightCtl-2
OFF from 0 to 100 ms
ON from 100 to 100030 ms
OFF after 100030 ms
Connect a Macro-Controlled Switch (MC3) in parallel to contact LightCtl-3
OFF from 0 to 200 ms
ON from 200 to 100015 ms
OFF after 100015 ms
Reconnect MC1 in parallel to contact LightCtl-1
ON from 0 to 100000 ms
OFF after 100000 ms
Change coil LightCtl Calculation Model to Duty Cycle and edit Duty cycle as follows
Constant Z at 333.33% load from 0 to 50 ms
Relay at 105% load from 50 to 100000 ms
ETAP Workshop Notes
Page 5 of 6
CSD Exercises
Run Simulation by pressing the Run button and check results.
Page 6 of 6