Beruflich Dokumente
Kultur Dokumente
DDX6053BT
DDX4023BT
DDX4053BT
DDX3023
DDX3053
DDX42BT
DDX35
MONITOR WITH DVD RECEIVER
INSTRUCTION MANUAL
EN_GET0909-001A_EQ.indb 1
GET0909-001A (EN/QN)
12/11/13 15:26
Contents
Before use ..........................................3
Sound adjustment.......................... 37
INTRODUCTIONS
Initial Settings ...................................5
Initial setup ......................................................................5
Updating the system.................................................6
Setting the security function ...............................7
AV SOURCE OPERATIONS
Selecting the playback source ...... 14
Displaying the source control screen ..........14
Displaying all sources and items.....................15
Customizing the <Top Menu> screen ........15
BLUETOOTH OPERATIONS
(Only for DDX6023BT/DDX6053BT/
DDX4023BT/DDX4053BT/DDX42BT)
REFERENCE
Maintenance ................................... 65
More about this unit ...................... 66
Troubleshooting ............................. 68
Accessories/Installation
Procedure ................................. 72
Connecting Wires to Terminals ...... 74
Connecting a USB device/iPod/
iPhone ....................................... 75
Connecting Other Products ........... 76
Installing/Removing the Unit ........ 77
Specifications ................................. 79
KS-UBT1 (USB Bluetooth
adapter) .................................... 82
English
EN_GET0909-001A_EQ.indb 2
12/11/13 15:27
Before use
WARNINGS:
(To prevent accidents and damage)
DO NOT install any unit or wire any cable in
a location where;
it may obstruct the steering wheel and
gearshift lever operations.
it may obstruct the operation of safety
devices such as air bags.
it may obstruct visibility.
DO NOT operate the unit while driving.
If you need to operate the unit while
driving, be sure to look around carefully.
The driver must not watch the monitor
while driving.
For safety...
Do not raise the volume level too much,
as this will make driving dangerous by
blocking outside sounds, and may cause
hearing loss.
Stop the car before performing any
complicated operations.
DDX4023BT/DDX4053BT/DDX3023/DDX3053
Reset button
DDX42BT/DDX35
Reset button
EN_GET0909-001A_EQ.indb 3
12/11/13 15:27
For Turkey
Bu rn 28300 sayl Resmi Gazetede
yaymlanan Atik Elektrikli ve Elektronik
Eyalarin Kontrol Ynetmelie uygun olarak
retilmitir.
Eski Elektrik ve Elektronik Ekipmanlarn
mha Edilmesi Hakknda Bilgi (ayr atk
toplama sistemlerini kullanan lkeleri iin
uygulanabilir)
Semboll (zerinde arp
iareti olan p kutusu) rnler
ev atklar olarak atlamaz.
Eski elektrik ve elektronik
ekipmanlar, bu rnleri
ve rn atklarn geri
dntrebilecek bir
tesiste deerlendirilmelidir.
Yaadnz blgeye en
yakn geri dnm tesisinin
yerini renmek iin yerel
makamlara mracaat edin.
Uygun geri dnm ve atk
imha yntemi salmz ve
evremiz zerindeki zararl
etkileri nlerken kaynaklarn
korunmasna da yardmc
olacaktr.
English
EN_GET0909-001A_EQ.indb 4
12/11/13 15:27
INTRODUCTIONS
Initial Settings
Initial setup
When you power on the unit for the first time
or reset the unit, the initial setting screen
appears.
You can also change the settings on the
<Setup> screen. ( page 44)
For DDX6023BT/DDX6053BT:
For DDX4023BT/DDX4053BT/
DDX3023/DDX3053/DDX42BT/
DDX35:
AV Input
Select an external
component to play
[AV-IN2] or [iPod] (
page 46)
NAV I/F
Input *1
Select navigation or
Mirror Link to use. (
page 46)
R-CAM
Interrupt
Panel
Color
*1
English
EN_GET0909-001A_EQ.indb 5
12/11/13 15:27
On <Top Menu>:
Application
Version
DVD Version
English
EN_GET0909-001A_EQ.indb 6
12/11/13 15:27
English
EN_GET0909-001A_EQ.indb 7
12/11/13 15:27
6 AV button (Press)
Displays the current source screen.
AV OUT button (Hold)
Selects the AV source for external
monitor or amplifier.
7
MENU button
Turns off the power. (Hold)
Turns on the power. (Press)
Displays the <Top Menu> screen.
(Press) ( page 13)
8 TEL button (Press)
Displays the <Handsfree> screen. (
page 54)
VOICE button (Hold)
Activates voice dialing. ( page 54)
9 0 (Eject) button
Ejects the disc (Tilts the monitor panel
fully).
Opens/Closes the monitor panel.
p Remote sensor
English
EN_GET0909-001A_EQ.indb 8
12/11/13 15:27
DDX4023BT/DDX4053BT/
DDX3023/DDX3053
Monitor panel
1 Loading slot
2 0 (Eject) button
Ejects the disc.
3 Reset button/Power indicator/Security
indicator
Resets the unit. ( page 3)
Lights up while the unit is turned on.
Flashes when the security function is
activated. ( page 7)
4 Remote sensor
5
MENU button
Turns off the power. (Hold)
Turns on the power. (Press)
Displays the <Top Menu> screen.
(Press) ( page 13)
6 AV/AV OUT button
Displays the current source screen.
(Press)
Selects the AV source for external
monitor or amplifier. (Hold)
7 For DDX4023BT/DDX4053BT:
VOL/ATT/AUD knob ( page 11)
Attenuates the sound. (Press)
Adjusts the audio volume. (Turn)
Displays the <Tone> screen. (Hold) (
page 37)
DDX42BT/DDX35
Monitor panel
For DDX3023/DDX3053:
VOL/ATT knob ( page 11)
Attenuates the sound. (Press)
Adjusts the audio volume. (Turn)
For DDX42BT/DDX35:
Volume % (up)/ (down) buttons (
page 11)
Increases/decreases the volume.
(Press)
8 For DDX4023BT/DDX4053BT/
DDX42BT:
TEL/VOICE button
Displays the <Handsfree> screen.
(Press) ( page 54)
The function of the button when held
varies depending on the <TEL Key
Long Press> setting ( page 47).
For DDX3023/DDX3053/DDX35:
AUD/V.OFF button
Displays the <Tone> screen. (Press) (
page 37)
The function of the button when held
varies depending on the <AUD Key
Long Press> setting ( page 47).
9 For DDX42BT/DDX35 only:
USB input terminal
p For DDX42BT/DDX35 only:
iPod/AV-IN2 input terminal
English
EN_GET0909-001A_EQ.indb 9
12/11/13 15:27
screen.
On the source control screen:
NAV *
Radio Data
System
OFF
Synchronizes the
clock time with the
connected navigation
unit.
Synchronizes the clock
time with FM Radio
Data System.
Sets the clock manually.
( below)
10
English
EN_GET0909-001A_EQ.indb 10
12/11/13 15:27
Common operations
Turning on the power
DDX6023BT/DDX6053BT
DDX4023BT/DDX4053BT/
DDX3023/DDX3053
Decrease
Increase
DDX4023BT/DDX4053BT/DDX3023/
DDX3053
DDX42BT/DDX35
Decrease
Increase
DDX42BT/DDX35
DDX6023BT/DDX6053BT
Increase
(Hold)
DDX4023BT/DDX4053BT/
DDX3023/DDX3053
Decrease
(Hold)
DDX42BT/DDX35
English
EN_GET0909-001A_EQ.indb 11
11
12/11/13 15:27
DDX4023BT/
DDX4053BT*1
(Hold)
DDX3023/DDX3053*2
(Hold)
DDX42BT*1
(Hold)
DDX35*2
(Hold)
12
English
EN_GET0909-001A_EQ.indb 12
12/11/13 15:27
Switching screens
Source control screen
Pressing MENU
on the monitor
panel also displays
<Top Menu>.
*1 Appears only when
a navigation unit is
connected.
<Top Menu>
Changes the AV source.
Displays the <Setup> screen.
<Setup>
Changes the detailed settings.
page 15
You can arrange the items to display
on the <Top Menu> screen on
<Menu Customize> in <Display>
setting. ( page 45)
Press [
screen.
The operation buttons disappear by touching the screen or when no operation is done for
about 5 seconds.
*2 Not available for video from an external component and rear view camera.
English
EN_GET0909-001A_EQ.indb 13
13
12/11/13 15:27
AV SOURCE OPERATIONS
Selecting the playback source
To display all sources and items, page 15.
You can change the items (other than
[SETUP]) to display on the <Top Menu>
screen. ( page 15)
14
English
EN_GET0909-001A_EQ.indb 14
12/11/13 15:27
On <Top Menu>:
2
DDX6023BT/DDX6053BT/
DDX4023BT/DDX4053BT/DDX42BT
English
EN_GET0909-001A_EQ.indb 15
15
12/11/13 15:27
Disc operations
Playing a disc
If a disc does not have a disc menu, all tracks on it will be played repeatedly until you change
the source or eject the disc.
Inserting a disc
DDX6023BT/DDX6053BT
Label side
Ejecting a disc
DDX6023BT/DDX6053BT
DDX4023BT/DDX4053BT/DDX3023/
DDX3053
DDX42BT/DDX35
DDX4023BT/DDX4053BT/DDX3023/
DDX3053/DDX42BT/DDX35
Label side
16
English
EN_GET0909-001A_EQ.indb 16
12/11/13 15:27
Playable
DVD-Video *
Region Code:
For DDX6023BT/DDX4023BT/DDX3023/
DDX42BT: 2
For DDX6053BT/DDX4053BT/DDX3053/
DDX35: 5
DVD-Audio/DVD-ROM
DVD Recordable/
Rewritable
(DVD-R/-RW *2, +R/+RW *3)
DVD Video: UDF bridge
DVD-VR
DivX/MPEG1/MPEG2/
JPEG/MP3/WMA/WAV/
AAC: ISO 9660 level 1,
level 2, Romeo, Joliet
DVD-Video
Dual Disc
DVD side
DVD-VR *4
DivX/MPEG1/MPEG2
JPEG
MP3/WMA/WAV/AAC
MPEG4/DVD+VR/DVD-RAM
Non-DVD side
CD/VCD
CD Recordable/
Rewritable
(CD-R/-RW)
ISO 9660 level 1, level 2,
Romeo, Joliet
CD-DA
VCD (Video CD)
DivX/MPEG1/MPEG2
JPEG
MP3/WMA/WAV/AAC
MPEG4
*1 If you insert a DVD Video disc of an incorrect Region Code, Region code error appears on the screen.
*2 DVD-R recorded in multi-border format is also playable (except for dual layer discs). DVD-RW dual layer
discs are not playable.
*3 It is possible to play back finalized +R/+RW (Video format only) discs. DVD is selected as its disc type
when a +R/+RW disc is loaded. +RW double layer discs are not playable.
*4 This unit cannot play back contents protected with CPRM (Content Protection for Recordable Media).
English
EN_GET0909-001A_EQ.indb 17
17
12/11/13 15:27
Playback operations
To display the source control screen, page 14.
For DVD/DVD-VR/VCD/DivX/MPEG1/MPEG2/JPEG
Media type
Playing time
DVD Video: Title no./Chapter no.
DVD-VR: Program no. (or Playlist
no.)/Chapter no.*1
DivX/MPEG1/MPEG2: Folder no./
Track no.
JPEG: Folder no./File no.
VCD: Track no.
page 36
Playback mode
[ ]
[ ]*2
[3 8]
[7]*3
[4] []
[1] []
[MODE]*5
[MENU]
Reverse/forward search
during playback.*4
Plays back in slowmotion during pause.
Enters the <DISC Mode>
settings. ( page 22)
Displays the <Top Menu>
screen.
][
Selects a folder.
18
English
EN_GET0909-001A_EQ.indb 18
12/11/13 15:27
For CD/MP3/WMA/WAV/AAC
While playing, the jacket picture is shown if the
file has the tag data including the jacket picture.
Media type
Playing time
Track/file information
Pressing [<] scrolls the
text if not all of the text
is shown.
page 36
File type
Playback mode
][
] *1
[3 8]
[ ] [ ]*1
[4] []
[1] []
[MODE] *1
[MENU]
Selects a track.
Reverse/forward search.*2
Enters the <DISC Mode>
settings. ( page 22)
Displays the <Top Menu>
screen.
Returns to the
upper layer
Plays tracks/files in
the folder
English
EN_GET0909-001A_EQ.indb 19
19
12/11/13 15:27
ZOOM
Aspect
Picture
Adjust
Audio
Subtitle
Angle
MENU
T MENU
Highlight
CUR
20
English
EN_GET0909-001A_EQ.indb 20
12/11/13 15:27
ZOOM
Aspect
Picture
Adjust
MENU
Audio
Direct
Return
T-REP
REP
FO-REP
RDM
FO-RDM
EN_GET0909-001A_EQ.indb 21
21
12/11/13 15:27
Selectable setting/item
Initial: Underlined
Menu
Language
Select the initial disc menu language; Initial English ( page 67).
Subtitle
Language
Select the initial subtitle language or erase the subtitle (OFF); Initial
English ( page 67).
Audio
Language
Down Mix
For discs
except VCD/CD
Dynamic
You can change the dynamic range while playing Dolby Digital
Range Control software.
: Select this to enjoy a powerful sound at a low
Wide
volume level with its full dynamic range.
: Select this to reduce the dynamic range a
Normal
little.
: Select this to reproduce the movie dialog
Dialog
more clearly.
Screen Ratio
For DVD/DVD-VR
File Type
Select the playback file type when a disc contains different types of
files.
: Plays back audio files.
Audio
: Plays back JPEG files.
Still Image
: Plays back DivX/MPEG1/MPEG2 files.
Video
Audio&Video : Plays back audio files and DivX/MPEG1/MPEG2
files.
For playable file types, page 17.
If the disc contains no files of the selected type, the existing files
are played in the following order: audio, video, then still image.
22
English
EN_GET0909-001A_EQ.indb 22
12/11/13 15:27
USB operations
Playing a USB device
This unit can play JPEG/DivX/MPEG1/
MPEG2/MP3/WMA/WAV/AAC files stored in
a USB mass storage class device.
This unit can recognize a total of 5 000 files
and 250 folders (a maximum of 999 files per
folder).
Make sure all important data has been
backed up to avoid losing the data.
Cautions:
This unit may not play back files in a
USB device properly when using a USB
extension cable.
USB devices equipped with special
functions such as data security functions
cannot be used with the unit.
Do not use a USB device with 2 or more
partitions.
Depending on the shape of the USB
devices and connection ports, some USB
devices may not be attached properly or
the connection might be loose.
This unit may not recognize a memory card
inserted into the USB card reader.
When connecting with a USB cable, use the
USB 2.0 cable.
The maximum number of characters:
Folder names : 50 characters
File names : 50 characters
Avoid using the USB device if it might
effect driving safety.
Do not pull out and connect the USB
device repeatedly while Reading... is
shown on the screen.
Electrostatic shock at connecting a USB
device may cause abnormal playback of
the device. In this case, disconnect the USB
device then reset this unit and the USB
device.
Operation and power supply may not work
as intended for some USB devices.
Do not leave a USB device in the car,
or expose to direct sunlight or high
temperature to avoid deformation or
damage to the device.
English
EN_GET0909-001A_EQ.indb 23
23
12/11/13 15:27
Track/file information
(for MP3/WMA/WAV/
AAC)
Pressing [<] scrolls
the text if not all of
the text is shown.
page 36
Playback mode
File type
1 2
*1 To cancel random or repeat mode, press the button repeatedly until the indicator disappears.
*2 You cannot activate the repeat mode and the random mode at the same time.
*3 Search speed varies depending on the type of disc or file.
4:3 LB
(Letterbox)
4:3 PS
(PanScan)
24
Audio
Still Image
Video
English
EN_GET0909-001A_EQ.indb 24
12/11/13 15:27
Audiobooks
Artwork
On <Top Menu>:
English
EN_GET0909-001A_EQ.indb 25
25
12/11/13 15:27
Playing time
Song/video
information
Pressing [<] scrolls
the text if not all of
the text is shown.
For some iPod/iPhone models, the performance may be abnormal or unstable during
operation. In this case, disconnect the iPod/iPhone device, then check its condition.
If the performance is not improved or is slow, reset your iPod/iPhone.
For the latest compatible list and software version of iPod/iPhone, see:
www.kenwood.com/cs/ce/ipod
26
English
EN_GET0909-001A_EQ.indb 26
12/11/13 15:27
Returns to the
previous layer
Video menu:
Switches between audio (
) and video (
English
EN_GET0909-001A_EQ.indb 27
27
12/11/13 15:27
On <Top Menu>:
28
English
EN_GET0909-001A_EQ.indb 28
12/11/13 15:27
kenwood.com/cs/ce/),
download the update data,
and save it to the root folder
of an SD or SDHC card.
Use a ball-point pen or the like
to remove the SD cover. While
the power is on, insert the SD
or SDHC card containing the
update data.
LED
Reset button
SMARTPHONE ADAPTER unit
(KCA-ML100)
English
EN_GET0909-001A_EQ.indb 29
29
12/11/13 15:27
Text information
Pressing [<] scrolls the text if not
all of the text is shown.
Standby reception indicators
( page 33)
page 36
RDS indicator
ST/MONO indicator
LO.S indicator ( page 31)
AF indicator ( page 34) Seek mode indicator
EON indicator:
Lights up when a Radio Data
System station is sending EON
signals.
The ST indicator lights up when receiving an FM stereo broadcast with sufficient signal
strength.
[P1]
[P6]
[MODE]
[TI]
[MONO]*
[TEXT]
[PTY]*
[AM]
[FM]
[SEEK]
[4]
[]
[MENU]
30
English
EN_GET0909-001A_EQ.indb 30
12/11/13 15:27
1
PS (station name) for FM Radio Data
System when PS signal is coming in
Displays the text
information
Preset list
(Hold)
Manual presetting
2
(Hold)
ON
OFF
English
EN_GET0909-001A_EQ.indb 31
31
12/11/13 15:27
(Hold)
32
Only English/Spanish/French/German/
Dutch/Portuguese are available for
the text language here. If another
language has been selected in
<Language> ( page 46), the text
language is set to English.
English
EN_GET0909-001A_EQ.indb 32
12/11/13 15:27
TI indicator
NEWS indicator
TI indicator
TI Standby Reception
Lights in
white
Lights in
orange
Goes off
Deactivated.
00min
90min
OFF
Deactivates News
Standby Reception.
English
EN_GET0909-001A_EQ.indb 33
33
12/11/13 15:27
2
To deactivate, select <OFF>.
AF
Cancels.
34
English
EN_GET0909-001A_EQ.indb 34
12/11/13 15:27
page 36
[MODE]
[MENU]
You can connects external components to the AV-IN1 and iPod/AV-IN2 input terminals.
Preparation:
If you want to use AV-IN2, select [AV-IN2] for <AV Input> setting. (page 46)
No preparation is required for AV-IN1.
English
EN_GET0909-001A_EQ.indb 35
35
12/11/13 15:27
On <Top Menu>:
or
On any screen:
Guidance
Volume
NAV Mute
36
NAV Setup
On <Top Menu>:
English
EN_AV_external.indd 36
12/11/13 15:54
Sound adjustment
Using the sound equalization
The adjustment is memorized for each source until you adjust the sound again. If the source
is a disc, the adjustment is stored for each of the following categories.
DVD/DVD-VR/VCD
CD
DivX/MPEG1/MPEG2/MP3/WMA/WAV/AAC
You cannot adjust the sound when the unit is in standby.
On <Top Menu>:
2
3 Adjust the level of each band
3 Select a sound mode.
English
EN_GET0909-001A_EQ.indb 37
37
12/11/13 15:27
On <Top Menu>:
Flat
38
English
EN_GET0909-001A_EQ.indb 38
12/11/13 15:27
On <Top Menu>:
([Background] or [Panel
Color]).
4 Select a background/panel
color.
To select a background
English
EN_GET0909-001A_EQ.indb 39
39
12/11/13 15:27
[38]*
[ 3]*
Starts/Pauses playback.
Advances scenes frame-byframe.
Magnifies the scene.
[ ]
(<OFF>, <Zoom1>
<Zoom3>)
[5] [] Moves the zooming frame.
[2] [3]
To cancel the capture screen, press
[Cancel].
* Not displayed when playing an external
component connected to AV-IN1 or iPod/
AV-IN2 input terminal.
40
English
EN_GET0909-001A_EQ.indb 40
12/11/13 15:27
Picture adjustment
You can adjust the picture quality.
English
EN_GET0909-001A_EQ.indb 41
41
12/11/13 15:27
Zooming picture
You can zoom the picture (<Zoom1> to
<Zoom3>).
When <Aspect> is set to <JUST> or
<Auto> ( the left column), the picture
is zoomed with the aspect ratio of the
<FULL> setting.
2
2
4:3 signal
16:9 signal
FULL*:
For 16:9
original
pictures
JUST:
For 4:3LB
original
pictures
Normal*:
For 4:3 original
pictures
Auto:
42
English
EN_GET0909-001A_EQ.indb 42
12/11/13 15:27
On <Top Menu>:
DDX4023BT/
DDX4053BT*1
DDX3023/
DDX3053*2
2
(Hold)
DDX42BT*1
(Hold)
DDX35*2
(Hold)
(Hold)
English
EN_GET0909-001A_EQ.indb 43
43
12/11/13 15:27
You cannot change <Audio> settings when [STANDBY] is selected on <Top Menu>.
( page 12)
Menu item
Initial: Underlined
Fader/Balance
Equalizer
Loudness
Audio
44
Selectable setting/item
Xover
Volume Offset
Subwoofer
ON
OFF
Speaker Select
English
EN_GET0909-001A_EQ.indb 44
12/11/13 15:27
Menu item
Dimmer
Selectable setting/item
Auto
ON
OFF
NAV
Initial: Underlined
User Customize
OSD Clock
ON
OFF
: Repeats scrolling.
ON
: Scrolls the displayed information once.
Once
: Cancels.
OFF
Pressing [<] scrolls the text regardless of the setting.
Menu Customize
Screen Adjust
Video Output *
Angle
Only for DDX6023BT/
DDX6053BT
Display
Scroll
* Please power off appears when the setting is changed. Turn off the power, then turn on to enable the
change.
English
EN_GET0909-001A_EQ.indb 45
45
12/11/13 15:27
Selectable setting/item
Initial: Underlined
AV Input
R-CAM Interrupt
ON
OFF
NAV Mute *2
Navigation *3
Language *1
System
Input
Menu item
*1 Please power off appears when the setting is changed. Turn off the power, then turn on to enable the
change.
46
English
EN_GET0909-001A_EQ.indb 46
12/11/13 15:27
System
Menu item
Selectable setting/item
Initial: Underlined
Clock
Beep
ON
OFF
Remote Sensor
ON
OFF
SETUP Memory
You can memorize, recall, clear, or lock the settings you have
made. ( page 48)
Bluetooth Setup
Only for DDX6023BT/
DDX6053BT/
DDX4023BT/
DDX4053BT/DDX42BT
DivX(R) VOD
This unit has its own Registration Code. Once you have played
back a file with the Registration Code recorded, this units
Registration Code is overwritten for copyright protection.
Press [Enter] to display the information.
To return to the previous screen, press [OK].
Security Code
SI
Serial Number
System Information
English
EN_GET0909-001A_EQ.indb 47
47
12/11/13 15:27
Memorizing/recalling the
settings
You can memorize the settings changed
in the <Setup> menu and recall the
memorized settings anytime.
The memorized settings are kept even
when the unit is reset.
On <Setup>:
On <Setup>:
2
2
To unlock the setting, press [Unlock].
3 Select an operation.
On <Setup>:
48
English
EN_GET0909-001A_EQ.indb 48
12/11/13 15:27
BLUETOOTH OPERATIONS
(Only for DDX6023BT/DDX6053BT/DDX4023BT/DDX4053BT/DDX42BT)
Bluetooth operations
Preparation:
Bluetooth is a short-range wireless radio
communication technology for the mobile
device such as mobile phones, portable PCs,
and other devices. The Bluetooth devices
can be connected without cables and
communicate with each other.
DDX6023BT/DDX6053BT
DDX4023BT/DDX4053BT/DDX42BT
English
EN_GET0909-001A_EQ.indb 49
49
12/11/13 15:27
On <Top Menu>:
50
English
EN_GET0909-001A_EQ.indb 50
12/11/13 15:27
Deleting a registered
Bluetooth device
Connecting a registered
Bluetooth device
English
EN_GET0909-001A_EQ.indb 51
51
12/11/13 15:27
Setting up Bluetooth
You can perform general operations such as connection and initialization through <Bluetooth
Setup> on the <Setup> menu.
On <Top Menu>:
Selectable setting/item
Initial: Underlined
Paired Device
List
Press [Enter] to show the list of the registered devices. You can connect the
device or delete the registration ( page 51).
PIN Code
Device Name
Bluetooth HF/ Select the speakers used for Bluetooth (both phone and audio player).
Audio
Front Only : From front speakers only.
: From all speakers.
All
Auto Pairing
ON
OFF
Initialize
52
Hold [Enter] to initialize all settings you have made for using Bluetooth
mobile phone and Bluetooth audio player.
English
EN_GET0909-001A_EQ.indb 52
12/11/13 15:27
Call information
(if acquired)
Ending a call
While talking...
While talking...
Switching between
handsfree mode and phone
mode
While talking...
English
EN_GET0909-001A_EQ.indb 53
53
12/11/13 15:27
While talking...
Making a call
Hold: Adds +
Presets the entered phone number on the
preset list ( page 56)
On <Top Menu>:
Voice dialing
Available only when the connected mobile
phone has the voice recognition system.
Or
DDX6023BT/
DDX6053BT
(Hold)
DDX4023BT/
DDX4053BT*
DDX42BT*
(Hold)
(Hold)
54
English
EN_GET0909-001A_EQ.indb 54
12/11/13 15:27
Outgoing
Incoming
Missed
Phonebook
English
EN_GET0909-001A_EQ.indb 55
55
12/11/13 15:27
On <Top Menu>:
On <Top Menu>:
3
3 Select a phone number.
(Hold)
English
EN_GET0909-001A_EQ.indb 56
12/11/13 15:27
English
EN_GET0909-001A_EQ.indb 57
57
12/11/13 15:27
On <Top Menu>:
Menu items
Selectable setting/item
Phone
Device
Auto
Response
ON
OFF
SMS Notify
ON
OFF
Initial: Underlined
Ring Mode
System
Phone
Ring Tone
Change
When <Ring Mode> is set to <System>, press [Enter], then select the ring
tone for received calls and SMS from <Tone1>, <Tone2>, <Tone3>.
: Selects the ring tone for phone calls.
Call Tone
: Selects the ring tone for SMS.
Message
Tone
58
English
EN_GET0909-001A_EQ.indb 58
12/11/13 15:27
Playing time *
Tag data (current track title/
artist name/album title) *
Pressing [<] scrolls the text if
not all of the text is shown.
page 36
The operation buttons, indications and information displayed on the screen differ
depending on the connected device.
[3]
[8]
[4][]
[MENU]
Starts playback.
Pauses.
Selects a track. (Press)
Reverse/forward search* (Hold)
Displays the <Top Menu> screen.
English
EN_GET0909-001A_EQ.indb 59
59
12/11/13 15:27
CAUTION
Put the Remote Controller in a place where
it will not move during braking or other
operations. A dangerous situation could
result, if the Remote Controller falls down
and gets wedged under the pedals while
driving.
Do not leave the battery near fire or
under direct sunlight. A fire, explosion or
excessive heat generation may result.
Do not recharge, short, break up or heat
the battery or place it in an open fire. Such
actions may cause the battery to leak fluid.
If spilled fluid comes in contact with your
eyes or on clothing, immediately rinse with
water and consult a physician.
Place the battery out of reach of children. In
the unlikely event that a child swallows the
battery, immediately consult a physician.
AUDt
DVDt
T Vt
Battery installation
Use two AAA/R03-size batteries.
Insert the batteries with the + and poles
aligned properly, following the illustration
inside the case.
60
English
EN_GET0909-001A_EQ.indb 60
12/11/13 15:27
ENTER
Enters options.
Hands-free communication
When a call comes in, it answers the call.
Volume control
Adjusts the volume.
Function
Switches the control screen.
Volume attenuating
Press the key once to lower the volume. Press
again to restore the previous volume.
NAV/V.SEL
Switches to the navigation screen.
Cursor key
Moves the cursor when displaying menu.
MODE
Switches the aspect ratio.
Aspect ratio changes each time you press
this key.
OPEN
(Only for DDX6023BT/DDX6053BT )
Adjusts the panel angle.
The panel angle changes each time you press
this key.
English
EN_GET0909-001A_EQ.indb 61
61
12/11/13 15:27
Play/Pause
Pauses the track.
Press again to resume playing.
Stop
Memorizes the last point where the disc
stopped.
Direct search
ABC
DVD Menu
Displays the DVD menu.
DVD-VR
Chapter number
Program/Playlist
Cancel
62
English
EN_GET0909-001A_EQ.indb 62
12/11/13 15:27
SUBTITLE
Switches the subtitle language.
ZOOM
Switches the zoom ratio each time you press
this key.
Play/Pause
Pauses the track.
Press again to resume playing.
Direct search
Picture Angle
Switches the picture angle each time you
press this key.
Pressing this key switches the features that
can be searched directly.
Music Disc
AUDIO
Switches the voice language each time you
press this key.
Track number
Cancel
Audio files in DVD/CD disc
Folder number
File number
Cancel
Folder search
Selects the folder to be played.
Numeric keypad
English
EN_GET0909-001A_EQ.indb 63
63
12/11/13 15:27
Music/Video search
Selects the music/video to be played.
Play/Pause
Pauses the music/video.
Press again to resume playing.
Direct tuning
After pressing this key, use the keypad to
specify the broadcast station you wish to
receive.
File search
Selects the file to be played.
or
Example: 810kHz (AM)
8TUV
or
Numeric keypad
64
Play/Pause
Pauses the file.
Press again to resume playing.
English
EN_GET0909-001A_EQ.indb 64
12/11/13 15:27
REFERENCE
Maintenance
Caution on cleaning the unit
Do not use
any solvent
(for example,
thinner, benzine,
etc.), detergent,
or insecticide. This may damage the monitor
or the unit.
Recommended cleaning method:
Gently wipe the panel with a soft, dry cloth.
Moisture condensation
Moisture may condense on the lens inside
the unit in the following cases:
After starting the heater in the car.
If it becomes very humid inside the car.
Should this occur, the unit may malfunction.
In this case, eject the disc and leave the unit
turned on for a few hours until the moisture
evaporates.
Warped disc
Stick-on label
Unusual shape
English
EN_GET0909-001A_EQ.indb 65
65
12/11/13 15:27
66
English
EN_GET0909-001A_EQ.indb 66
12/11/13 15:27
Language
Afar
Abkhazian
Afrikaans
Ameharic
Arabic
Assamese
Aymara
Azerbaijani
Bashkir
Byelorussian
Bulgarian
Bihari
Bislama
Bengali, Bangla
Tibetan
Breton
Catalan
Corsican
Czech
Welsh
Code
GL
GN
GU
HA
HI
HR
HU
HY
IA
IE
IK
IN
IS
IW
JA
JI
JW
KA
KK
KL
Language
Galician
Guarani
Gujarati
Hausa
Hindi
Croatian
Hungarian
Armenian
Interlingua
Interlingue
Inupiak
Indonesian
Icelandic
Hebrew
Japanese
Yiddish
Javanese
Georgian
Kazakh
Greenlandic
Code
MI
MK
ML
MN
MO
MR
MS
MT
MY
NA
NE
NO
OC
OM
OR
PA
PL
PS
QU
RM
DZ
EL
EO
ET
EU
FA
FI
FJ
FO
FY
GA
GD
Bhutani
Greek
Esperanto
Estonian
Basque
Persian
Finnish
Fiji
Faroese
Frisian
Irish
Scots Gaelic
KM
KN
KO
KS
KU
KY
LA
LN
LO
LT
LV
MG
Cambodian
Kannada
Korean (KOR)
Kashmiri
Kurdish
Kirghiz
Latin
Lingala
Laothian
Lithuanian
Latvian, Lettish
Malagasy
RN
RO
RW
SA
SD
SG
SH
SI
SK
SL
SM
SN
Language
Maori
Macedonian
Malayalam
Mongolian
Moldavian
Marathi
Malay (MAY)
Maltese
Burmese
Nauru
Nepali
Norwegian
Occitan
(Afan) Oromo
Oriya
Panjabi
Polish
Pashto, Pushto
Quechua
RhaetoRomance
Kirundi
Rumanian
Kinyarwanda
Sanskrit
Sindhi
Sangho
Serbo-Croatian
Singhalese
Slovak
Slovenian
Samoan
Shona
Code
SO
SQ
SR
SS
ST
SU
SW
TA
TE
TG
TH
TI
TK
TL
TN
TO
TR
TS
TT
TW
Language
Somali
Albanian
Serbian
Siswati
Sesotho
Sundanese
Swahili
Tamil
Telugu
Tajik
Thai
Tigrinya
Turkmen
Tagalog
Setswana
Tonga
Turkish
Tsonga
Tatar
Twi
UK
UR
UZ
VI
VO
WO
XH
YO
ZU
Ukrainian
Urdu
Uzbek
Vietnamese
Volapuk
Wolof
Xhosa
Yoruba
Zulu
English
EN_GET0909-001A_EQ.indb 67
67
12/11/13 15:27
Troubleshooting
What appears to be trouble is not always serious. Check the following points before calling a
service center.
For operations with the external components, refer also to the instructions supplied with
the adapters used for the connections (as well as the instructions supplied with the external
components).
Remedy/Cause
Start the playback on the external component connected to AV-IN1
or iPod/AV-IN2 input terminal.
Check the cords and connections.
Signal input is too weak.
A speaker cord has shorted or it has come in to contact with the car
chassis. Wire or insulate the speaker cord as appropriate, then reset the
unit ( pages 3 and 74).
Miswiring DC
Offset Error
Warning DC
Offset Error
Parking off
No playback picture is shown when the parking brake is not engaged.
Authorization Error Check whether the connected iPod/iPhone is compatible with this
unit. ( page 25)
USB Device Error
The USB power voltage is abnormal.
Turn off and turn on the unit.
Connect another USB device.
Panel Mecha Error The panel does not work properly. Reset the unit.
No Navigation
No navigation unit is connected.
No Voice Device
No Data
Initialize Error
Dial Error
Hung Up Error
Pick Up Error
68
Remedy/Cause
The Bluetooth adapter (KS-UBT1) is removed.
The device is registered but the connection has failed. Connect the
registered device. ( page 51)
The unit is preparing to use the Bluetooth function. If the message
does not disappear, turn off and turn on the unit, then connect the
device again (or reset the unit).
The connected mobile phone does not have the voice recognition system.
No phonebook data is contained in the connected Bluetooth phone.
The unit has failed to initialize the Bluetooth module. Try the operation
again.
Dialing has failed. Try the operation again.
The call has not ended yet. Park your car, and use the connected
mobile phone to end the call.
The unit has failed to receive a call.
English
EN_GET0909-001A_EQ.indb 68
12/11/13 15:27
AV-IN1/
AV-IN2
DivX/MPEG1/MPEG2/
JPEG/MP3/WMA/WAV/AAC
Disc in general
TUNER
General
Symptom
Remedy/Cause
Recordable/Rewritable discs
cannot be played back.
Tracks on the Recordable/
Rewritable discs cannot be
skipped.
English
EN_GET0909-001A_EQ.indb 69
69
12/11/13 15:27
USB
iPod/iPhone
Symptom
70
Remedy/Cause
Sound is distorted.
Reading... keeps flashing on the Turn off the power and on again.
screen.
While playing a track, sound is
sometimes interrupted.
English
EN_GET0909-001A_EQ.indb 70
12/11/13 15:27
Symptom
Remedy/Cause
The unit does not respond when You may have tried to copy the same entries (as
you try to copy the phonebook stored) to the unit.
to the unit.
English
EN_GET0909-001A_EQ.indb 71
71
12/11/13 15:27
Accessories/Installation Procedure
6 Connect the wiring harness connector to
the unit.
7 Install the unit in your car.
8 Reconnect the battery.
9 Press the reset button.
10 Perform the Initial Setup.
Accessories
1
6 *2
..........1
2
..........1
7 *3
..........1 (2m)
..........1 (3m)
..........1
*1 DDX4023BT/
DDX4053BT/
DDX3023/DDX3053/
DDX42BT/DDX35 only.
2
* DDX6023BT/
DDX6053BT only.
*3 DDX6023BT/
DDX6053BT/
DDX4023BT/
DDX4053BT/DDX42BT
only.
4 *1
..........2
5*
..........2
Installation Procedure
1 To prevent a short circuit, remove the key
from the ignition and disconnect the
battery.
2 Make the proper input and output wire
connections for each unit.
3 Connect the speaker wires of the wiring
harness.
4 Take Connector B on the wiring harness
and connect it to the speaker connector
in your vehicle.
5 Take Connector A on the wiring harness
and connect it to the external power
connector on your vehicle.
72
WARNING
If you connect the ignition wire (red) and the
battery wire (yellow) to the car chassis (ground),
you may cause a short circuit, that in turn may
start a fire. Always connect those wires to the
power source running through the fuse box.
Do not cut out the fuse from the ignition wire
(red) and the battery wire (yellow). The power
supply must be connected to the wires via the
fuse.
English
EN_GET0909-001A_EQ.indb 72
12/11/13 15:27
If the fuse blows, first make sure the wires are not
touching to cause a short circuit, then replace the
old fuse with one with the same rating.
Insulate unconnected wires with vinyl tape or
other similar material. To prevent a short circuit,
do not remove the caps on the ends of the
unconnected wires or the terminals.
Connect the speaker wires correctly to the
terminals to which they correspond. The unit may
be damaged or fail to work if you share the
wires or ground them to any metal part in the car.
When only two speakers are being connected
to the system, connect the connectors either to
both the front output terminals or to both the
rear output terminals (do not use one from each).
For example, if you connect the connector
of the left speaker to a front output terminal, do
not connect the connector to a rear output
terminal.
After the unit is installed, check whether the brake
lamps, blinkers, wipers, etc. on the car are working
properly.
Mount the unit so that the mounting angle is 30
or less.
Do not press hard on the panel surface when
installing the unit to the vehicle. Otherwise scars,
damage, or failure may result.
This unit has the cooling fan to decrease the
internal temperature. Do not mount the unit
in a place where the cooling fan of the unit is
blocked. Blocking these openings will prevent the
cooling of the internal temperature and result in
malfunction.
DDX6023BT/DDX6053BT only
1 Before installation, remove the screws.
Cooling fan
DDX4023BT/DDX4053BT/DDX42BT only
Install the Bluetooth adapter (KS-UBT1) besides
the place enclosed by the metal.
CAUTION
Install this unit in the console of your
vehicle.
Do not touch the metal part of this unit
during and shortly after the use of the
unit. Metal part such as the heat sink and
enclosure become hot.
EN_GET0909-001A_EQ.indb 73
73
12/11/13 15:27
Purple/White
(Reverse sensor wire)
Light Green
Antenna Cord
Blue/White
(Power control/antenna
control wire)
Brown
(Mute control wire)
Unit
Connector A
Yellow
(Battery wire)
Connector B
Pin
A4
A5
A6
A7
A8
74
Vehicle
Yellow (A4)
Default wiring
Battery
Power Control
Dimmer
Ignition (ACC)
Earth (Ground) Connection
Pin
B1/B2
B3/B4
B5/B6
B7/B8
English
EN_GET0909-001A_EQ.indb 74
12/11/13 15:27
CA-U1EX*
(Optional Accessory)
USB terminal
(0.8 m)
KCA-iP202
(Optional Accessory)
(1.8 m)
For DDX4023BT/DDX4053BT
iPod (commercially available)
USB device
(commercially available)
CA-U1EX*
(Optional Accessory)
USB terminal
(0.8 m)
KCA-iP202
(Optional Accessory)
(1.8 m)
For DDX42BT/DDX35
iPod (commercially available)
USB device
(commercially
available)
CA-U1EX
(Optional
Accessory)
USB terminal
KCA-iP22F
(Optional Accessory)
iPod/Audio Visual
input 2 (iPod/AV-IN2)
(iPod/AV Input 2
switchable)
English
EN_GET0909-001A_EQ.indb 75
75
12/11/13 15:27
Audio/Visual Output
Visual output (Yellow)
Audio output (3.5 mini plug)
Resistance-free stereo type mini plug
Connection cable
(Included in the
Navigation System)
SMARTPHONE
(commercially
available)
Rear Preout
Audio left output (White)
Audio right output (Red)
Front Preout
Audio left output (White)
Audio right output (Red)
SMARTPHONE ADAPTER
(KCA-ML100 : Optional
Accessory)
GPS antenna
(CX-G100 : Optional Accessory)
76
Battery
English
EN_GET0909-001A_EQ.indb 76
12/11/13 15:28
Accessory 3
Catch
Lock
Bracket
Accessory 6
EN_GET0909-001A_EQ.indb 77
77
12/11/13 15:28
Accessory 7
78
English
EN_GET0909-001A_EQ.indb 78
12/11/13 15:28
Specifications
Monitor section
Picture Size
: 6.95 inches (diagonal) wide
156.6 mm (W) 81.6 mm (H)
(DDX6023BT/DDX6053BT)
: 6.1 inches (diagonal) wide
136.2 mm (W) 72 mm (H)
(DDX4023BT/DDX4053BT/DDX3023/
DDX3053/DDX42BT/DDX35)
Display System
: Transparent TN LCD panel
Drive System
: TFT active matrix system
Number of Pixels
: 1,152,000 (800H 480V RGB)
Effective Pixels
: 99.99%
Pixel Arrangement
: RGB striped arrangement
Back Lighting
: LED
Sampling frequency
: 44.1/48/96 kHz
Quantifying Bit Number
: 16/20/24 bit
Bluetooth section
(DDX6023BT/DDX6053BT/
DDX4023BT/DDX4053BT/
DDX42BT)
Technology
: Bluetooth 2.1 + EDR
Frequency
: 2.402 GHz 2.480 GHz
Output Power
: +4 dBm (MAX), 0 dBm (AVE), Power
Class 2
Maximum Communication range
: Line of sight approx. 10m
Profile
: HFP (Hands Free Profile),
OPP (Object Push Profile),
PBAP (Phonebook Access Profile),
A2DP (Advanced Audio Distribution
Profile),
AVRCP (Audio/Video Remote Control
Profile),
GAP (Generic Access Profile),
SDP (Service Discovery Profile),
English
EN_GET0909-001A_EQ.indb 79
79
12/11/13 15:28
FM tuner section
Frequency Range (50 kHz)
: 87.5 MHz 108.0 MHz
Usable Sensitivity (S/N: 26 dB)
: 0.7 V/75
Quieting Sensitivity (S/N: 46 dB)
: 1.6 V/75
Frequency Response ( 3.0 dB)
: 30 Hz 15 kHz
S/N Ratio (dB)
: 65 dB (MONO)
Selectivity ( 400 kHz)
: 65 dB
Stereo Separation
: 35 dB (1 kHz)
LW tuner section
Frequency Range (9 kHz)
: 153 kHz 279 kHz
Usable Sensitivity
: 45 V
MW tuner section
Frequency Range (9 kHz)
: 531 kHz 1611 kHz
Usable Sensitivity
: 25 V
Video section
Color System of External Video Input
: NTSC/PAL
External Video Input Level (RCA/mini jack)
: 1 Vp-p/75
External Audio Max Input Level (RCA/
mini jack)
: 2 V/25 k
Video Output Level (RCA jack)
: 1 Vp-p/75
Audio Output Level (mini jack)
: 1.2 V/10 k
Analog RGB input
: 0.7 Vp-p/75
80
Audio section
Maximum Power (Front & Rear)
: 50 W 4
Full Bandwidth Power (Front & Rear)
(PWR DIN 45324, +B=14.4V)
: 30 W 4
Preout Level (V)
: 4 V/10 k
Preout Impedance
: 600
Speaker Impedance
: 48
Tone
Bass:
100 Hz 8 dB
Middle:
1 kHz 8 dB
Treble:
12.5 kHz 8 dB
General
Operating Voltage
: 14.4 V (10.5 V 16 V allowable)
Maximum Current Consumption
: 10 A
Dimensions (W H D)
: 182 111 160 mm
(DDX6023BT/DDX6053BT)
182 112 163 mm
(DDX4023BT/DDX4053BT/DDX3023/
DDX3053/DDX42BT/DDX35)
Operational Temperature Range
: 10C +60C
Weight
: 2.5 kg
(DDX6023BT/DDX6053BT )
2.1 kg
(DDX4023BT/DDX4053BT)
2.0 kg
(DDX3023/DDX3053/DDX42BT/
DDX35)
Although the effective pixels for the
liquid crystal panel is given as 99.99% or
more, 0.01% of pixels may not light or
may light incorrectly.
Specifications are subject to change
without notice.
English
EN_GET0909-001A_EQ.indb 80
12/11/13 15:28
DVD Logo is a trademark of DVD Format/Logo Licensing Corporation registered in the US,
Japan and other countries.
The AAC logo is a trademark of Dolby Laboratories.
Microsoft and Windows Media are either registered trademarks or trademarks of Microsoft
Corporation in the United States and/or other countries.
Manufactured under license from Dolby Laboratories. Dolby and the double-D symbol are
trademarks of Dolby Laboratories.
Manufactured under license under U.S. Patent Nos: 5,956,674; 5,974,380; 6,487,535 & other
U.S. and worldwide patents issued & pending. DTS, the Symbol, & DTS and the Symbol
together are registered trademarks & DTS 2.0 Channel is a trademark of DTS, Inc. Product
includes software. DTS, Inc. All Rights Reserved.
Made for iPod, and Made for iPhone mean that an electronic accessory has been designed
to connect specifically to iPod, or iPhone, respectively, and has been certified by the
developer to meet Apple performance standards. Apple is not responsible for the operation
of this device or its compliance with safety and regulatory standards. Please note that the use
of this accessory with iPod or iPhone may affect wireless performance.
iPhone, iPod, iPod classic, iPod nano, and iPod touch are trademarks of Apple Inc., registered
in the U.S. and other countries.
iTunes is a trademark of Apple Inc.
DivX, DivX Certified and associated logos are trademarks of Rovi Corporation or its
subsidiaries and are used under license.
ABOUT DIVX VIDEO: DivX is a digital video format created by DivX, LLC, a subsidiary of Rovi
Corporation. This is an official DivX Certified device that plays DivX video. Visit divx.com for
more information and software tools to convert your files into DivX videos.
ABOUT DIVX VIDEO-ON-DEMAND: This DivX Certified device must be registered in order
to play purchased DivX Video-on-Demand (VOD) movies. To obtain your registration code,
locate the DivX VOD section in your device setup menu. Go to vod.divx.com for more
information on how to complete your registration.
This item incorporates copy protection technology that is protected by U.S. patents and
other intellectual property rights of Rovi Corporation. Reverse engineering and disassembly
are prohibited.
MirrorLink Certified, the Design Only Certification Logo, MirrorLink and the MirrorLink
Logo are certification marks and trademarks of the Car Connectivity Consortium LLC.
Unauthorized use is strictly prohibited.
English
EN_GET0909-001A_EQ.indb 81
81
12/11/13 15:28
Specifications
CAUTION
Changes or modifications not approved by us
could void the users authority to operate the
equipment.
This adapter has been designed exclusively
for use with Kenwood car receivers. Do not
use this adapter with any other car receiver.
The Bluetooth word mark and logos are
registered trademarks owned by Bluetooth
SIG, Inc. and any use of such marks by
JVC KENWOOD Corporation is under
license. Other trademarks and trade names
are those of their respective owners.
Bluetooth Version:
Bluetooth Ver. 2.1 +EDR
Power Class:
Class2 Radio
Service Area:
10 m (10.9 yd)
USB Standards:
USB V1.1 (Full Speed)
Power Consumption: 54.3 mA/5 V (max.)
Dimensions (L W H):
15 mm 19 mm 5.6 mm
(5/8 3/4 1/4 )
Keep the Bluetooth adapter inserted when
using the Bluetooth function.
When the adapter is removed, store it in a
safe place.
0168-12-5373
(01)07898929117502
Este equipamento opera em carter secundrio, isto
, no tem direito proteo contra interferncia
prejudicial, mesmo de estaes do mesmo tipo, e no
pode causar interferncia a sistemas operando em
carter primrio.
82
English
EN_GET0909-001A_EQ.indb 82
12/11/13 15:28
EU Representatives:
Kenwood Electronics Europe BV
Amsterdamseweg 37, 1422 AC UITHOORN, The Netherlands
English
Hereby, JVC KENWOOD declares that this unit KS-UBT1 is in
compliance with the essential requirements and other relevant
provisions of Directive 1999/5/EC.
Franais
Par la prsente JVC KENWOOD dclare que lappareil KS-UBT1 est
conforme aux exigences essentielles et aux autres dispositions
pertinentes de la directive 1999/5/CE.
Par la prsente, JVC KENWOOD dclare que ce KS-UBT1 est
conforme aux exigences essentielles et aux autres dispositions de
la directive 1999/5/CE qui lui sont applicables.
Deutsch
Hiermit erklrt JVC KENWOOD, dass sich dieser KS-UBT1 in
bereinstimmung mit den grundlegenden Anforderungen und
den anderen relevanten Vorschriften der Richtlinie 1999/5/EG
befindet. (BMWi)
Hiermit erklrt JVC KENWOOD die bereinstimmung des Gertes
KS-UBT1 mit den grundlegenden Anforderungen und den anderen
relevanten Festlegungen der Richitlinie 1999/5/EG. (Wien)
Nederlands
Hierbij verklaart JVC KENWOOD dat het toestel KS-UBT1 in
overeenstemming is met de essentile eisen en de andere
relevante bepalingen van richtlijn 1999/5/EG.
Bij deze verklaat JVC KENWOOD dat deze KS-UBT1 voldoet aan
de essentile eisen en aan de overige relevante bepalingen van
Richtlijn 1999/5/EC.
Italiano
Con la presente JVC KENWOOD dichiara che questo KS-UBT1
conforme ai requisiti essenziali ed alle altre disposizioni pertinenti
stabilite dalla direttiva 1999/5/CE.
Espaol
Por medio de la presente JVC KENWOOD declara que el KS-UBT1
cumple con los requisitos esenciales y cualesquiera otras
disposiciones aplicables o exigibles de la Directiva 1999/5/CE.
Portugus
JVC KENWOOD declara que este KS-UBT1 est conforme com os
requisitos essenciais e outras disposies da Directiva 1999/5/CE.
Polska
JVC KENWOOD niniejszym owiadcza, e KS-UBT1 spenia
zasadnicze wymogi oraz inne istotne postanowienia dyrektywy
1999/5/EC.
esk
JVC KENWOOD tmto prohlauje, e tento KS-UBT1 je ve shode
se zkladnmi poadavky a dalmi prslunmi ustanovenmi
smernice 1999/5/ES.
Magyar
Alulrott, JVC KENWOOD, kijelenti, hogy a jelen KS-UBT1
megfelel az 1999/5/EC irnyelvben meghatrozott alapvet
kvetelmnyeknek s egyb vonatkoz elrsoknak.
Svenska
Hrmed intygar JVC KENWOOD att denna KS-UBT1 str l
verensstmelse med de vsentliga egenskapskrav och vriga
relevanta bestmmelser som framgr av direktiv 1999/5/EG.
Suomi
JVC KENWOOD vakuuttaa tten ett KS-UBT1 tyyppinen laite on
direktiivin 1999/5/EY oleellisten vaatimusten ja sit koskevien
direktiivin muiden ehtojen mukainen.
Slovensko
S tem JVC KENWOOD izjavlja, da je ta KS-UBT1 v skladu z
osnovnimi zahtevami in ostalimi ustreznimi predpisi Direktive
1999/5/EC.
Slovensky
Spolonos JVC KENWOOD tmto vyhlasuje, e KS-UBT1 spa
zkldn poiadavky a alie prislun ustanovenia Direktvy
1999/5/EC.
Dansk
Undertegnede JVC KENWOOD erklrer harved, at flgende udstyr
KS-UBT1 overholder de vsentlige krav og vrige relevante krav i
direktiv 1999/5/EF.
Eesti
Sellega kinnitab JVC KENWOOD, et see KS-UBT1 vastab direktiivi
1999/5/EC philistele nudmistele ja muudele asjakohastele
mrustele.
Latvieu
Ar o, JVC KENWOOD, apstiprina, ka KS-UBT1 atbilst Direktvas
1999/5/EK galvenajm prasbm un citiem ts nosacjumiem.
Lietuvikai
iuo, JVC KENWOOD, pareikia, kad is KS-UBT1 atitinka
pagrindinius Direktyvos 1999/5/EB reikalavimus ir kitas svarbias
nuostatas.
Malti
Hawnhekk, JVC KENWOOD, jiddikjara li dan KS-UBT1 jikkonforma
mal-tiijiet essenzjali u ma provvedimenti orajn relevanti li
hemm fid-Dirrettiva 1999/5/EC.
Trke
Bu vesileyle JVC KENWOOD, KS-UBT1 nitesinin, 1999/5/EC
Direktifinin balca gereksinimleri ve dier ilgili hkmleri ile
uyumlu olduunu beyan eder.
English
EN_GET0909-001A_EQ.indb 83
83
12/11/13 15:28
EN_GET0909-001A_EQ.indb 84
12/11/13 15:28