Beruflich Dokumente
Kultur Dokumente
Commissioning
2.1. Settings to be made before login
Go to Control Panel Go to Network Connections Go to LAN Properties
Go to TCP/IPv4 Click on Obtain IP address automatically
URL-http://172.17.254.253/
Press OK
LAN Port
Equipment Configuration
Radio Configuration
AMR/Radio Mapping
Network Management Configuration
E1/STM-1/Cross Connect Setting
Current Metering
Channel Spacing28MHz
Reference ModulationQPSK
Radio Mode-High Capacity
TX RF Frequency-As per LB
Frame ID - 1
TX Power Control - ATPC
Press OK
Press OK
Press OK
Enter number of E1 as
required
2nd
Press Next
Press Next
4th
3rd
Press OK
Press OK
Press OK
2.7. Network
Management
Enter IP Address
(As mentioned in LB),
Subnet Mask
& Default gateway as
shown in the Image.
2.8. TX Power
Enter TX Power(as per LB) as shown in the Image below.
2.10.
E1 Port Settings
Press OK
2.11.
N = Number of E1 required
2.12.
3. E1 Patching
3.1. E1 punching on DDF
CH-1 to CH-8 TX
CH-9 to CH-16 TX
NEC DDF
Connection with IDU
PCM Cable
RX6
RX5
WHITE
GREEN
WHITE
BROWN
GND
RX4
RX3
RED
BLUE
RED
ORANGE
GND
RX2
RX1
TX8
TX7
RED
GREEN
RED
BROWN
BLUE
ORANGE
GND
TX6
TX5
TX4
TX3
GREEN
BROWN
YELLOW
BLUE
YELLOW
ORANGE
GND
TX2
TX1
3.4. Metering at
both ends.
Verify the desired RSL in Metering
as shown in the Image
YELLOW
GREEN
YELLOW
BROWN