Beruflich Dokumente
Kultur Dokumente
SW- ENGINEERING
PROJECT:
ASTRONIC2
Date
15.02.2010
Page
1/2
Download the installation routine named: GS3.3_test_02_2010.zip from the ZFServiceLine Download area; unzip with password: astronic
Start installation routine: Double click on file: GS3.3_test_02_2010.exe
Start the ZF-TESTMANpro. If necessary, note customer-specific data from the
transmission actuator (such as e.g. i Ha (rear axle ratio); Intarder etc.) and then,
program the test program. Load ZF-TESTMANpro /Flash programming/Parts lists. Open
file GS3.3_test_02_2010.txt and program. (Processor 1,2 and E data will be
programmed and the previously programmed driving program is deleted.)
Editor: F.Schelkle
Department:
BKS
ZFF
ELECTRONICS
SW- ENGINEERING
PROJECT:
ASTRONIC2
Date
15.02.2010
Page
2/2
Air supply, at minimum 7bar, to be connected to the pressure reduction valve of the
transmission actuator.
Connect the table mode adaptor cable to the transmission actuator (vehicle side) and
then, connect to the laptop via the junction cable, DPA05, 24V supply voltage.
Start ZF-TESTMANpro. Select main menu/AS Tronic/Assembly inspection AS2.
Caution:
This test inspection may not be carried out with the vehicles engine running!
Gears 1-16
Gears 16-1
Note:
The test software shifts through the gears 1-16 and the 2 R gears.
After the functions/leakage test, the correct software according to the vehicle
application, engine/transmission/software allocation etc. must be programmed.
(Source: ZF-ServiceLine)
Editor: F.Schelkle
Department:
BKS
ZFF