Beruflich Dokumente
Kultur Dokumente
Technical Information
Antimussol UDF liq c
is stable and effective in the presence of high amounts of electrolyte and alkali
220381.12.06.e
Properties
Appearance
Chemical character
Ionic character
nonionic
Density at 20C
approx. 1.0
Viscosity at 25C
pH
ca. 7
Dilutability
Storage stability
Stability to
hard water
acids
alcalis
good
good
good
Compatibility with
good
Ecotoxicological data
220381.12.06.e
Scope of application
Antimussol UDF liquid conc is highly concentrated and therefore exhibits a high viscosity which
may make it unsuitable for use in automatic dosing system. Anyhow it can be formulated into a
liquid dosable form by simple dilution in cold soft water under moderate agitation. However only
dilutions until 50% concentration (1:1 ratio) provide storage-stable formulations which can be kept
over a long period.
Antimussol UDF liquid conc rapidly and efficiently eliminates undesirable foaming. It is very
economical in use. A very small addition in preparation baths, dyebaths and printing pastes inhibits
foam formation and destroys any existing foam almost instantaneously.
Antimussol UDF liquid conc acts as an antifoam:
in pretreatment for scouring and bleaching
in dyeing at any pH and temperature, especially when dyeing cotton with direct or reactive
dyes, polyamide with acid dyes and polyester with disperse dyes at high temperature
in printing
Application
For maximum efficiency and economy, it is advisable to pre-dilute Antimussol UDF liquid conc
before use. We recommend a dilution in cold soft water at for example a 1:19 ratio, the water being
added with slight stirring to the emulsion.
Dilutions are not stable for a long period, i.e. on prolonged storage a slight settling may occur. We
therefore recommend stirring or shaking the dilutions before use.
Recommended amounts
The quantity of Antimussol UDF liquid conc required to control foaming can only be determined
by experiment and depends on the process and machinery.
In general, however,
0.05 - 0.25 g/l of neat Antimussol UDF liquid conc
is required, the higher amounts being required when processing under alkaline conditions.
Many of their dyestuffs, pigments and chemicals are patented by Clariant Ltd or its affiliates in numerous industrial
countries.
Trademark registered by Clariant Ltd or Clariant GmbH in numerous countries.
* Trademark licensed to Clariant Ltd in numerous countries.
+ Manufacturers registered trade mark
The signs , * and + appear only at the first mention of the product.
The information and recommendations presented here were compiled with the utmost care,but cannot be extended to cover
every possible case. They are intended to serve as non-binding guidelines and must be adapted to the prevailing
conditions.
220381.12.06.e