Sie sind auf Seite 1von 2

Sidestream

Dissolved Gas
Solutions for
Water and
Wastewater
How Does
BlueInGreen Do It?
We have the worlds most efficient
method for dissolving gases into water.
We design, manufacture and build
equipment that dissolves oxygen,
carbon dioxide or ozone into water
or wastewater.

Where is it applied?

CO2

O3

SDOX

SDOX-CS

CDOX

HyDOZ

Supersaturated
dissolved oxygen is used
anywhere improved
dissolved oxygen levels
are needed.

Dissolved oxygen is
used in sewer collection
systems to eliminate
odor and prevent
corrosion.

Supersaturated
dissolved carbon dioxide
is used to lower pH for
water recarbonization or
remineralization.

Hyper-concentrated
dissolved ozone is used
for disinfection of both
water and wastewater.

The result?
Water treatment equipment that provides the lowest total cost of ownership.
700 W. Research Center Blvd. | Suite 1207 | Fayetteville, AR 72701 | 479-527-6378 | www.blueingreen.com | info@blueingreen.com

Henrys Law
Willam Henry discovered that the pressure above a body of water and the temperature of the water determines
how much of a gas will be absorbed by the body of water. All efforts to dissolve or inject a gas into water is
governed by Henrys law. We apply Henrys law in an innovative way.

Technology
BlueInGreens systems have a tank that is pressurized: half-filled with water
and half-filled with the gas that is to be dissolved into the liquid. Water
is sprayed through the gaseous headspace of the tank where the water
droplets become supersaturated with the gas. Water is constantly pulled
from the bottom of the tank at the same rate it is pumped into the tank. The
supersaturated water is then returned to the main stream.

Sidestream Gas Dissolution a sidestream


of water is pulled off the main line and passed
through BlueInGreens system. The water is
supersaturated with the desired gas and then
returned to the main line where rapid liquidto-liquid mixing occurs. Sidestream dissolution
means lower maintenance cost, smaller piping/
equipment and lower energy cost.

Skid Mounted
All of BlueInGreens products come ready to run. Each one is skid mounted and factory tested before
shipment. Pipe-in, hook up electrical power, attach an Ethernet cable for SCADA if desired, and pipe-out.
There is no piecing together of pumps, PLCS, valves or piping.

VFD Turndown Efficiencies


Water treatment systems are always designed for maximum flow rates, but water and wastewater treatment
facilities rarely run at full capacity. BlueInGreen has 10:1 turndown capacities on all of its equipment so that
we can run efficiently at your normal flow rates, as well as at maximum flow.

Service Before and After the Sale


We know that after we ship our equipment, our work has just begun. We arent successful until you are
successful. BlueInGreen has a staff of engineers and a sales network that is committed to the success of
your project.

700 W. Research Center Blvd. | Suite 1207 | Fayetteville, AR 72701 | 479-527-6378 | www.blueingreen.com | info@blueingreen.com

Das könnte Ihnen auch gefallen