Sie sind auf Seite 1von 4

41885

Rules and Regulations Federal Register


Vol. 72, No. 147

Wednesday, August 1, 2007

This section of the FEDERAL REGISTER Executive Order 12866 and Regulatory projected to be approximately $6.5
contains regulatory documents having general Flexibility Act million for FY–2007 (3.6 months) and
applicability and legal effect, most of which approximately negative $600,000 for
are keyed to and codified in the Code of This rule has been determined to be
‘‘non-significant’’ for the purposes of FY–2008 (¥0.3 months).
Federal Regulations, which is published under This fee increase should result in an
50 titles pursuant to 44 U.S.C. 1510. Executive Order 12866 and therefore
has not been reviewed by the Office of estimated average of $2.4 million in
The Code of Federal Regulations is sold by Management and Budget. additional revenues per year (effective
the Superintendent of Documents. Prices of Also, pursuant to the requirement set in FY–2007, if the fees were
new books are listed in the first FEDERAL forth in the Regulatory Flexibility Act implemented by October 1, 2006).
REGISTER issue of each week. (RFA), AMS has considered the However, fees would not be increased
economic impact of this action on small until later in FY–2007. Further, as a
entities. Accordingly, AMS proposes result, the next fee increase is delayed
DEPARTMENT OF AGRICULTURE this initial regulatory flexibility until March 2008 instead of the start of
analysis. FY–2008. These increases will not cover
Agricultural Marketing Service all of FPB’s costs. FPB will need to
The purpose of the RFA is to fit
regulatory actions to the scale of continue to increase fees in order to
7 CFR Part 51 cover the program’s operating cost and
businesses subject to such actions in
order that small businesses will not be maintain the required reserve balance.
[Docket #AMS–FV–07–0099; FV–06–308] unduly or disproportionately burdened. FPB believes that increasing fees
The action described herein is being incrementally is appropriate at this
RIN 0581–AC63 taken for several reasons, including that time. Additional fee increases beyond
additional user fee revenues are needed FY–2008 will be needed to sustain the
Multi-Year Revision of Fees for the to cover the costs for: (1) Providing program in the future. However, we will
Fresh Fruit and Vegetable Terminal current program operations and continue to reduce costs, wherever
Market Inspection Services services; (2) improving the timeliness in possible.
which inspection services are provided; Employee salaries and benefits are
AGENCY: Agricultural Marketing Service, and (3) improving the work major program costs that account for
USDA. environment. approximately 80 percent of FPB’s total
ACTION: Final rule. AMS regularly reviews its user-fee operating budget. A general and locality
financed programs to determine if the salary increase for Federal employees,
SUMMARY: This rule would revise the fees are adequate. The Fresh Products ranging from 2.87 to 5.62 percent
regulations governing the inspection Branch (FPB) has and will continue to depending on locality, effective January
and certification for fresh fruits, seek out cost saving opportunities and 2006, has significantly increased
vegetables and other products by implement appropriate changes to program costs and will continue to
increasing certain fees charged for the reduce its costs. Such actions can increase costs at a similar rate in future
inspection of these products at provide alternatives to fee increases. years. This salary adjustment will
destination markets for the next two FPB has reduced costs by approximately increase FPB’s costs by over $700,000
fiscal years (FY–2007 and FY–2008) by $2 million. However, even with these per year. Increases in health and life
approximately 15 percent each fiscal efforts, FPB’s existing fee schedule will insurance premiums, along with
year. This rule would increase fees 30 not generate sufficient revenue to cover workers compensation will also increase
days after publication in FY–2007 and program costs while maintaining the program costs. In addition, inflation also
again in March 2008. These revisions Agency mandated reserve balance. impacts FPB’s non-salary costs. These
are necessary in order to recover, as Revenue projections for FPB’s factors have increased FPB’s costs of
nearly as practicable, the costs of destination market inspection work operating this program by over $600,000
performing inspection services at during FY–2006 are $15.3 million with per year.
destination markets under the costs projected at $20.4 million and an Additional funds are necessary in
Agricultural Marketing Act of 1946 end-of-year reserve balance of order for FPB to continue to cover the
(AMA of 1946). The fees charged to approximately $12.7 million. However, costs associated with additional staff
persons required to have inspection on this reserve balance is due in part, to and to maintain office space and
imported commodities in accordance appropriated funding received in equipment. Additional revenues are also
with the Agricultural Marketing October 2001, for infrastructure, necessary to improve the work
Agreement Act of 1937 and for imported workplace, and technological environment by providing training and
peanuts under section 1308 of the Farm improvements. FPB’s costs of operating purchasing needed equipment. In
Security and Rural Investigation Act of the destination market program are addition, FPB began in 2001, developing
2002. expected to increase to approximately (with appropriated funds) the Fresh
DATES: Effective Date: August 31, 2007. $21.6 million during FY–2007 and $22.5 Electronic Inspection Reporting/
million during FY–2008. Revenues are Resource System (FEIRS) to replace its
FOR FURTHER CONTACT INFORMATION: Rita
sroberts on PROD1PC70 with RULES

projected to be $15.3 million for end of manual paper and pen inspection
Bibbs-Booth, USDA, 1400 Independence the fiscal year. The reserve balance for reporting process. FEIRS was
Ave., SW, Room 0640–S, Washington, FY–2007 and FY–2008, will fall below implemented in 2004. This system has
DC 20250–0295, or call (202) 720–0391. the Agency’s mandated four-month been put in place to enhance and
SUPPLEMENTARY INFORMATION: reserve level. The reserve balance is streamline FPB’s fruit and vegetable

VerDate Aug<31>2005 15:44 Jul 31, 2007 Jkt 211001 PO 00000 Frm 00001 Fmt 4700 Sfmt 4700 E:\FR\FM\01AUR1.SGM 01AUR1
41886 Federal Register / Vol. 72, No. 147 / Wednesday, August 1, 2007 / Rules and Regulations

inspection process, however additional overlap or conflict with this proposed approximately $12.7 million. However,
revenue is required to maintain FEIRS. rule. this reserve balance is due in part, to
FPB has also begun to cover the costs The destination market grading appropriated funding received in
associated with the Training and services are voluntary (except when October 2001, for infrastructure,
Development Center (TDC) in required for imported commodities) and workplace, and technological
Fredericksburg, VA. A portion of the the fees charged to users of these improvements. FPB’s costs of operating
appropriated funds received in October services vary with usage. The impact on the destination market program are
2001, were for infrastructure all businesses, including small entities, expected to increase to approximately
improvements including the is very similar. However, except for $21.6 million during FY–2007 and $22.5
development and maintenance of the those persons who are required to million during FY–2008. Revenues are
inspector TDC. With appropriated obtain inspections, most of these projected to be $15.3 million for end of
funding now depleted, FPB is now businesses are typically under no the fiscal year. The reserve balance for
obligated to support the TDC under obligation to use these inspection FY–2007 and FY–2008, will fall below
revenues from the terminal market user services, and, therefore, any decision on the Agency’s mandated four-month
fee inspection program. their part to discontinue the use of the reserve level. The reserve balance is
services should not prevent them from projected to be approximately $6.5
This rule should increase user fee marketing their products. Further, even million for FY–2007 (3.6 months) and a
revenue generated under the destination though fees will be raised, the increase negative $584,000 for FY–2008 (¥0.3
market program by approximately 15 is not excessive and should not months).
percent each fiscal year. This action is significantly affect these entities. Employee salaries and benefits are
authorized under the Agricultural major program costs that account for
Marketing Act of 1946 (AMA of 1946) Executive Order 12988
approximately 80 percent of FPB’s total
(See 7 U.S.C. 1622(h)), which provides This rule has been reviewed under operating budget. A general and locality
that the Secretary of Agriculture may Executive Order 12988, Civil Justice salary increase for Federal employees,
assess and collect ‘‘such fees as will be Reform. This action is not intended to ranging from 2.87 to 5.62 percent
reasonable and as nearly as may be to have retroactive effect. This rule will depending on locality, effective January
cover the costs of services rendered not preempt any State or local laws, 2006, has significantly increased
* * *’’ There are more than 2,000 users regulations or policies, unless they program costs, and will continue to
of FPB’s destination market grading present an irreconcilable conflict with increase costs at a similar rate in future
services (including applicants who must this rule. There are no administrative years. This salary adjustment will
meet import requirements 1— procedures which must be exhausted increase FPB’s costs by over $700,000
inspections which amount to under 2.5 prior to any judicial challenge to the per year. Increases in health and life
percent of all lot inspections provisions of this rule. insurance premiums, along with
performed). A small portion of these workers compensation will also increase
users are small entities under the Action
program costs. In addition, inflation also
criteria established by the Small The AMA of 1946 authorizes official impacts FPB’s non-costs. These factors
Business Administration (13 CFR inspection, grading, and certification, on have increased FPB’s costs of operating
121.201). There would be no additional a user-fee basis, of fresh fruits, this program by over $600,000 per year.
reporting, recordkeeping, or other vegetables and other products such as Additional revenues are necessary in
compliance requirements imposed upon raw nuts, Christmas trees and flowers. order for FPB to continue to cover the
small entities as a result of this rule. In The AMA of 1946 provides that costs associated with additional staff
compliance with the Paperwork reasonable fees be collected from the and to maintain office space and
Reduction Act of 1995 (44 U.S.C. users of the services to cover, as nearly equipment. Additional revenues are also
Chapter 35), the information collection as practicable, the cost of the services necessary to continue to improve the
and recordkeeping requirements in Part rendered. This rule would amend the work environment by providing training
51 have been approved previously by schedule for fees and charges for and purchasing needed equipment. In
OMB and assigned OMB No. 0581– inspection services rendered to the fresh addition, FPB began in 2001, developing
0125. FPB has not identified any other fruit and vegetable industry to reflect (with appropriated funds) an automated
Federal rules which may duplicate, the costs necessary to operate the system known as FEIRS, to replace its
program. manual paper and pen inspection
1 Section 8e of the Agricultural Marketing AMS regularly reviews its user-fee reporting process. Approximately
Agreement Act of 1937, as amended (7 U.S.C. 601– financed programs to determine if the $10,000 in additional revenue per
674), requires that whenever the Secretary of fees are adequate. The Fresh Products month will be needed to maintain the
Agriculture issues grade, size, quality or maturity Branch (FPB) has and will continue to
regulations under domestic marketing orders for
system. This system has been put in
certain commodities, the same or comparable seek out cost saving opportunities and place to enhance FPB’s fruit and
regulations on imports of those commodities must implement appropriate changes to vegetable inspection processes. FPB has
be issued. Import regulations apply during those reduce its costs. Such actions can also begun to cover the costs associated
periods when domestic marketing order regulations provide alternatives to fee increases.
are in effect. Section 1308 of the Farm Security and
with the TDC in Fredericksburg, VA. A
Rural Investment Act of 2002 (Pub. L. 107–171), 7 FPB has reduced costs by approximately portion of the appropriated funds
U.S.C. 7958, required USDA among other things to $2 million. However, even with these received in October 2001, were for
develop new peanut quality and handling standards efforts, FPB’s existing fee schedule will infrastructure improvements including
for imported peanuts marketing in the United not generate sufficient revenue to cover
States.
the development and maintenance of
Currently, there are 14 commodities subject to 8e
program costs while maintaining the the inspector TDC. With appropriated
import regulations: Avocados, dates (other than Agency mandated reserve balance. funding now depleted, FPB is now
sroberts on PROD1PC70 with RULES

dates for processing), filberts, grapefruit, kiwifruit, Revenue projections for FPB’s obligated to support the TDC under
olives (other than Spanish-style green olives), destination market inspection work revenues from the terminal market user
onions, oranges, potatoes, prunes, raisins, table
grapes, tomatoes and walnuts. A current listing of
during FY–2006 are $15.3 million with fee inspection program.
the regulated commodities can be found under 7 costs projected at $20.4 million and an Based on the aforementioned analysis
CFR Parts 944, 980, 996 and 999. end-of-year reserve balance of of this program’s increasing costs, AMS

VerDate Aug<31>2005 15:44 Jul 31, 2007 Jkt 211001 PO 00000 Frm 00002 Fmt 4700 Sfmt 4700 E:\FR\FM\01AUR1.SGM 01AUR1
Federal Register / Vol. 72, No. 147 / Wednesday, August 1, 2007 / Rules and Regulations 41887

will increase the fees for destination charges for fresh fruit and vegetable the applicant and the Administrator, the
market inspection services. The inspection as found in 7 CFR 51.38. changes in the schedule of fees as found
following table compares current fees Unless otherwise provided for by in § 51.38 are:
and charges with the proposed fees and regulation or written agreement between

Service Current 2007 2008

Quality and condition inspections of products each in quantities of 51 or more packages


and unloaded from the same land or air conveyance:
• Over a half carlot equivalent of each product ............................................................ $114.00 $131.00 $151.00
• Half carlot equivalent or less of each product ............................................................ 95.00 109.00 125.00
• For each additional lot of the same product ............................................................... 52.00 60.00 69.00
Condition only inspections of products each in quantities of 51 or more packages and un-
loaded from the same land or air conveyance:
• Over a half carlot equivalent of each product ............................................................ 95.00 109.00 125.00
• Half carlot equivalent or less of each product ............................................................ 87.00 100.00 115.00
• For each additional lot of the same product ............................................................... 52.00 60.00 69.00
Quality and condition and condition only inspections of products each in quantities of 50
or less packages unloaded from the same land or air conveyance:
• For each product ......................................................................................................... 52.00 60.00 69.00
• For each additional lot of any of the same product ................................................... 52.00 60.00 69.00
Lots in excess of carlot equivalents will be charged proportionally by the quarter carlot..
Dock side inspections of an individual product unloaded directly from the same ship:.
• For each package weighing less than 30 pounds ...................................................... 12.9 13.3 13.8

• For each package weighing 30 or more pounds ........................................................ 14.4 15.1 15.9

• Minimum charge per individual product ...................................................................... 114.00 131.00 151.00


• Minimum charge for each additional lot of the same product .................................... 52.00 60.00 69.00
Hourly rate for inspections performed for other purposes during the grader’s regularly
scheduled work week:
• Hourly rate for non-carlot equivalent inspections such as count, size, temperature,
container, etc. or work associated with inspections such as digital image services
will be charged at a rate that reflects the cost of providing the service .................... 56.00 64.00 74.00
Overtime rate (per hour additional) for all inspections performed outside the grader’s reg-
ularly scheduled work week ............................................................................................... 29.00 33.00 38.00
Holiday pay ............................................................................................................................ 29.00 66.00 74.00
Hourly rate for inspections performed under 40 hour contracts during the grader’s regu-
larly scheduled work week ................................................................................................. 56.00 64.00 74.00
Rate for billable mileage ........................................................................................................ 1.00 1.15 1.32
1In cents.

A notice of proposed rulemaking was ■ 2. Section 51.38 is revised to read as (iii) $60 ($69, on or after March 1,
published in the Federal Register on follows: 2008) for each additional lot of the same
December 1, 2006, (71 FR 69497). FPB product.
received one comment after the § 51.38 Basis for fees and rates. (3) For quality and condition
comment period closed. (a) When performing inspections of inspection and condition only
As previously stated, because the FY– product unloaded directly from land or inspection of products in quantities of
2007 fee increase in effect in the latter air transportation, the charges shall be 50 or less packages unloaded from the
part of the fiscal year, AMS is changing determined on the following basis: same conveyance:
the effective date of the FY–2008 fee (1) Quality and condition inspections (i) $60 ($69, on or after March 1, 2008)
increase to March 1, 2008, to provide a of products in quantities of 51 or more for each individual product:
sufficient amount of time between the packages and unloaded from the same (ii) $60 ($69, on or after March 1,
two fee increases. Finally, the regulatory air or land conveyance: 2008) for each additional lot of any of
text in the proposed section 51.38(e) is (i) $131 ($151, on or after March 1, the same product. Lots in excess of
corrected to reflect separate fees for 2008) for over a half carlot equivalent of carlot equivalents will be charged
overtime and holiday note that appeared an individual product; proportionally by the quarter carlot.
in the supplementary information (ii) $109 ($125, on or after March 1, (b) When performing inspections of
section of the proposed rule. 2008) for a half carlot equivalent or less palletized products unloaded directly
of an individual product; from sea transportation or when
List of Subjects in 7 CFR Part 51 (iii) $60 ($69, on or after March 1, palletized product is first offered for
Agricultural commodities, Food 2008) for each additional lot of the same inspection before being transported
grades and standards, Fruits, Nuts, product. from the dock-side facility, charges shall
Reporting and recordkeeping (2) Condition only inspection of be determined on the following basis:
requirements, Trees, Vegetables. products each in quantities of 51 or (1) Dock side inspections of an
■ For reasons set forth in the preamble, more packages and unloaded from the individual product unloaded directly
7 CFR Part 51 is amended as follows: same land or air conveyance: from the same ship:
(i) $109 ($125, on or after March 1, (i) 3.3 (3.8, on or after March 1, 2008)
sroberts on PROD1PC70 with RULES

PART 51—[AMENDED] 2008) for over a half carlot equivalent of cents per package weighing less than 30
an individual product; pounds;
■ 1. The authority citation for 7 CFR (ii) $100 ($115, on or after March 1, (ii) 5.1 (5.9, on or after March 1, 2008)
Part 51 continues to read as follows: 2008) for a half carlot equivalent or less cents per package weighing 30 or more
Authority: 7 U.S.C. 1621–1627. of an individual product; pounds;

VerDate Aug<31>2005 15:44 Jul 31, 2007 Jkt 211001 PO 00000 Frm 00003 Fmt 4700 Sfmt 4700 E:\FR\FM\01AUR1.SGM 01AUR1
41888 Federal Register / Vol. 72, No. 147 / Wednesday, August 1, 2007 / Rules and Regulations

(iii) Minimum charge of $131 ($151, hourly rate in addition to the carlot Naturalization Benefit Application and
on or after March 1, 2008) per equivalent fee, package charge, or Petition Fee Schedule,’’ amending 8
individual product; hourly charge specified in this subpart. CFR part 103 to prescribe new fees to
(iv) Minimum charge of $60 ($69, on Waiting time shall be rounded to the fund the cost of processing applications
or after March l, 2008) for each nearest half hour. and petitions for immigration and
additional lot of the same product. Dated: July 26, 2007. naturalization benefits and services, and
(2) [RESERVED] USCIS’ associated operating costs
(c) When performing inspections of Lloyd C. Day,
pursuant to section 286(m) of the
products from sea containers unloaded Administrator, Agricultural Marketing
Immigration and Nationality Act (INA),
directly from sea transportation or when Service.
8 U.S.C. 1356(m). 72 FR 29851. That
palletized products unloaded directly [FR Doc. E7–14826 Filed 7–31–07; 8:45 am]
rule provides that applications that are
from sea transportation are not offered BILLING CODE 3410–02–P submitted to USCIS with the incorrect
for inspection at dock-side, the carlot fee will be rejected. For the reasons
fees in ‘‘a’’ of this section shall apply. described below, USCIS, through this
(d) When performing inspections for DEPARTMENT OF HOMELAND rule, is amending the fees again on a
Government agencies, or for purposes SECURITY temporary basis for certain applications.
other than those prescribed in This rule will become effective
paragraphs (a) through (c) of this U.S. Citizenship and Immigration immediately after the final fee rule
section, including weight-only and Services published on May 30, 2007, and makes
freezing-only inspections, fees for only temporary modifications to that
inspections shall be based on the time 8 CFR Part 103 rule to respond to the events described
consumed by the grader in connection below. The rule provides limited relief
[CIS No. 2415–07; Docket No. USCIS–2007–
with such inspections, computed at a 0039] for specific applicants from the final fee
rate of $64 ($74, on or after March 1, rule published on May 30, 2007. The
2008) per hour; RIN 1615–AB60 effect of this rule is limited to those
Provided, that: applications filed before August 18,
(1) Charges for time shall be rounded Temporary Adjustment of the 2007. For applications filed on or after
to the nearest half hour; Immigration and Naturalization Benefit August 18, 2007, the fees set forth in the
(2) The minimum fee shall be two Application and Petition Fee Schedule final rule published on May 30, 2007,
hours for weight-only inspections, and for Certain Adjustment of Status and will be required. USCIS will remove this
one-half hour for other inspections; Related Applications regulation by another rule to be
(3) When weight certification is published in Federal Register on or
provided in addition to quality and/or AGENCY: U.S. Citizenship and
Immigration Services, DHS. about August 17, 2007, to be effective
condition inspection, a one hour charge August 18, 2007.
shall be added to the carlot fee; ACTION: Final rule.
(4) When inspections are performed to 2. Visa Availability—Summary
certify product compliance for Defense SUMMARY: This rule temporarily amends
The INA establishes formulas and
Personnel Support Centers, the daily or the applicable fees for employment-
numerical limits for regulating persons
weekly charge shall be determined by based Forms I–485, ‘‘Application to
immigrating to the United States for
multiplying the total hours consumed to Register Permanent Residence or Adjust permanent residence, to include
conduct inspections by the hourly rate. Status,’’ and applications for derivative defining the employment-based
The daily or weekly charge shall be benefits associated with such Forms I– immigrant visa classifications. INA sec.
prorated among applicants by 485 filed pursuant to the Department of 201 et seq., 8 U.S.C. 1151 et seq. The
multiplying the daily or weekly charge State’s July Visa Bulletin No. 107, dated INA provides an annual world-wide
by the percentage of product passed June 12, 2007. The fees for all other numerical limit on the number of aliens
and/or failed for each applicant during petitions and applications administered who may immigrate to the United
that day or week. Waiting time and by U.S. Citizenship and Immigration States, as well as an annual per-country
overtime charges shall be charged Services will continue in force as numerical limit on the number of aliens
directly to the applicant responsible for effective on July 30, 2007. who may emigrate from a particular
their incurrence. DATES: Effective Date: This rule is country. INA sections 201(d) and
(e) When performing inspections at effective July 30, 2007, at 12:02 a.m. 202(a)(2), 8 U.S.C. 1151(d) and
the request of the applicant during EST. 1152(a)(2). In addition, the INA
periods which are outside the grader’s FOR FURTHER INFORMATION CONTACT: allocates the total number of world-wide
regularly scheduled work week, a Efren Hernandez III, Business and Trade visas among five employment-based
charge for overtime or holiday work Services, Service Center Operations categories or preferences. INA sec.
shall be made at the rate of $33 for (Business and Trade Services), U.S. 203(b), 8 U.S.C. 1153(b). Taken together,
overtime and $66 for holiday work ($38 Citizenship and Immigration Services, the total number of visas, the country
for overtime and $74 for holiday work, Department of Homeland Security, 111 from which an alien emigrates, and the
on or after March 1, 2008) per hour or Massachusetts Avenue, Suite 3000, allocation of visas among the preference
portion thereof in addition to the carlot Washington, DC 20001, telephone (202) categories, determines whether a
equivalent fee, package charge, or 272–8400. particular alien may immigrate to the
hourly charge specified in this subpart. United States at a certain date.
SUPPLEMENTARY INFORMATION:
Overtime or holiday charges for time The Department of State (DOS)
shall be rounded to the nearest half I. Background determines the availability of immigrant
sroberts on PROD1PC70 with RULES

hour. visa numbers. See INA sections 203(e)


(f) When an inspection is delayed 1. USCIS Fee Schedule and (g), 8 U.S.C. 1153(e) and (g). DOS
because product is not available or On May 30, 2007, USCIS published also controls individual allocation of
readily accessible, a charge for waiting the final rule, effective July 30, 2007, employment-based immigrant visas. 22
time shall be made at the prevailing ‘‘Adjustment of the Immigration and CFR 42.32. DOS publishes a ‘‘Visa

VerDate Aug<31>2005 15:44 Jul 31, 2007 Jkt 211001 PO 00000 Frm 00004 Fmt 4700 Sfmt 4700 E:\FR\FM\01AUR1.SGM 01AUR1

Das könnte Ihnen auch gefallen