Beruflich Dokumente
Kultur Dokumente
Bulletin 639512
Revision A January 2005 Page 1 of 10
the ATC200-LITE program and the antenna definition file are installed
the program has been configured to use the current antenna definition file.
If these steps have not been accomplished, see the ATC200-LITE Users Guide
(Bulletin 639510).
It is recommended that the user check for software/manual updates on the Andrew web site (www.andrew.com) every 30 days.
PRE-INSTALLATION INSTRUCTIONS
1. While on the ground, connect actuators, one at a time, to the controller and
test for proper function.
2. Record the following information on the Site Configuration Worksheet provided.
Serial Number
Antenna Type
Andrew Corporation
DEVICE ADDRESSING
Click OK.
Andrew Corporation
Unaddressed Devices
Click OK.
Click OK.
Andrew Corporation
DEVICE CONFIGURATION
Non-Configured Devices
Andrew Corporation
Make appropriate
selections and text
entries.
All configuration data
is stored in the individual device.
*Denotes required
fields.
Configuring Device
Click OK.
Andrew Corporation
Andrew Corporation
2. Click Activate.
Click OK.
Andrew Corporation
Click Close.
Andrew Corporation
Andrew Corporation
2. Click <-Add.
4. Click Activate.
3. Enter a new electrical tilt angle. Review the electrical tilt range to
verify that the new tilt angle entered is valid for the antenna model.
Angles may be entered as whole degrees or as a combination of whole
degrees and tenths of a degree (Ex: 5.0 or 5.5).
Click OK.
Andrew Corporation
Base Station Antennas
2601 Telecom Parkway
Richardson, TX U.S.A. 75082
Telephone: 1-800-676-5342
FAX (U.S.A.): 1-800-229-4706
Internet: www.andrew.com