Beruflich Dokumente
Kultur Dokumente
Installation Overview
Mounting Template
Loading
Left Hand Models
15
14
13
15
14
J2 13
Remote Display
(Optional)
12
11
10
9
8
7
6
Serial Port A
Serial Port C
USB Port
Ethernet Port
Serial Port D
J4
GPIO Port B
Parallel Port
8
7
6
12
11
10
8
7
6
5
J1
3
2
1
1
1
J3
5
4
3
2
1
GPIO Port A
USB Host
(Optional)
SDIO Host
(Optional)
Note: Depending upon the model, features, options and configuration, this information will vary; consult the Operators Manual for detailed instructions.
Signal
Signal
Direction[1]
Ground
Jumper
Position
JMP 8
N/A
2
3
+5 VDC
Slew Label
Toggle /
Pause
Reprint
+24 VDC
Ground
10
11
12
13
Installed
Removed
Removed
N/A
Printer chassis.
When inactive,
outputs pulled up to
a voltage determined
by jumper settings,
where:
Media Out
Data Ready
15
Option
Fault
Output
JMP 1
or,
None = Common
external voltage
(not to exceed
+30VDC) via
external pull-ups
(providing a 20K
ohm feedback thru
any two outputs).
Jumper
+5 VDC
JMP 11
Input 6
N/A
N/A
Input 3
N/A
N/A
Output 6
JMP 7
[1]
[1]
; Active LOW.
Position
Function / Description
Installed
Removed
Removed
Output 3
JMP 4
Ground
JMP 10
Input 5
N/A
N/A
Programmed function.
Input 2
N/A
N/A
Programmed function.
Output 5
JMP 6
N/A
Service
Required
End Of
Print
14
N/A
Ribbon Low
Ribbon Out
[3]
Signal &
Direction [1]
Pin
1
Installed
Start Of
Print [2]
JMP 9
Function / Description
Removed
N/A
N/A
N/A
Programmed function.
N/A
N/A
Programmed function.
10
Output 2
JMP 3
11
+24 VDC
12
Input 4
13
Input 1
14
Output 4
JMP 5
Removed
15
Output 1
[1]
JMP 2
Removed
WARNING: Failure to properly configure the GPIO Port jumper settings may result in damage to the printer and / or applicator.