Beruflich Dokumente
Kultur Dokumente
3240
1. Unscrew the two bolts (19 mm) and set the removed brake caliper on the frame.
Tightening torque:
(85 ~ 105 Nm)
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
35
NOTICE
T/C
M / T
A/T
3240
SP
AXLE
CLUTCH
Tightening torque:
(28 ~ 30 Nm)
STNG
4. Unscrew the three wheel end hub mounting bolts (10 mm).
Installation Notice
100 ~ 130 Nm
5. Slightly pull the wheel end hub until the wheel speed sensor is visible. Unscrew the mounting bolt (5 mm) and
remove the wheel speed sensor.
Tightening torque:
(6 ~ 8 Nm)
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
A / CON
A / BAG
BRAKE
Tightening torque
36
3240
Disconnect connector
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
3240
37
A/T
M / T
4 ~ 8 Nm
AXLE
CLUTCH
Tightening torque
T/C
Installation Notice
SP
2. Pull out the upper arm lock pin and unscrew the mounting nut (19 mm).
3. Pull out the steering gear linkage lock pin from the knuckle. Unscrew the mounting nut (19 mm) and remove
the tie rod end.
Lock pin
Tightening torque:
(110 ~ 130 Nm)
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
A / CON
Tightening torque:
(140 ~ 160 Nm)
A / BAG
BRAKE
STNG
38
3240
Tightening torque:
(140 ~ 160 Nm)
5. Remove the knuckle between upper arm and lower arm with special tool.
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
39
Hub Actuator
1. Unscrew the three bolts (10 mm) on the disassembled locking hub actuator assembly and remove the hub actuator.
AXLE
CLUTCH
T/C
M / T
Tightening torque:
(8 ~ 12 Nm)
A/T
3240
SP
STNG
Vacuum tube
A / CON
A / BAG
BRAKE
Vent tube
Detail
7Shift seal
1
Clutch ring
2
Shift fork
Housing
6
Piston
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
Diaphragm
Spring
PART TIME TRANSFER CASE & LOCKING HUB SYSTEM
KYRON SM - 2005.09
40
3240
Inspection
1. Check the internal seal ring of hub actuator for damage.
Installation Notice
* Completely clean the parts and apply the grease them before installation.
Be careful not to damage the internal seal ring of the hub actuator.
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN