Beruflich Dokumente
Kultur Dokumente
Question 2:
Two routers named Boston and Idaho are connected by their serial interfaces as shown in
the exhibit, but there is no data connectivity between them. The Boston router is known to
have a correct configuration. Given the partial configurations shown in the exhibit, what is
the problem on the Idaho router that is causing the lack of connectivity?
Question 4
A network administrator has configured two switches, named London and Madrid, to use
VTP. However, the switches are not sharing VTP messages. Given the command output
shown in the graphic, why are these switches not sharing VTP messages?
The network administrator has created a new VLAN on Switch1 and added host C and host
D. The administrator has properly configured switch interfaces FastEthernet0/8 through
FastEthernet0/24 to be members of the new VLAN. However, after the network
administrator completed the configuration, host A could communicate with host B, but host
A could not communicate with host C or host D. Which commands are required to resolve
this problem?
Question 7:
Refer to the exhibit. Hosts on the same VLAN can communicate with each other but are
unable to communicate with hosts on different VLANs. What is needed to allow
communication between VLANs?
Question 9:
Refer to the exhibit. While troubleshooting a connectivity issue from a PC you obtain the
following information:
127.0.0.1 - Successful
10.0.0.35 - Successful
10.0.0.1 - Unsuccessful
10.2.50.250 - Unsuccessful
Question 1:
A network administrator is troubleshooting the OSPF configuration of routers R1 and R2.
The routers cannot establish an adjacency relationship on their common Ethernet link. The
graphic shows the output of the show ip ospf interface e0 command for routers R1 and R2.
Based on the information in the graphic, what is the cause of this problem?
Question 2:
This graphic shows the results of an attempt to open a Telnet connection to
router ACCESS1 from router Remote27. Which of the following command
sequences will correct this problem?
Question 3:
Refer to the exhibit. A network administrator attempts to ping Host2 from Host1 and
receives the results that are shown. What is a possible problem?
Question 5:
When upgrading the IOS image, the network administrator receives the exhibited error
message. What could be the cause of this error?
A.The new IOS image is too large for the router flash memory.
B. The TFTP server is unreachable from the router.
C. The new IOS image is not correct for this router platform.
D. The IOS image on the TFTP server is corrupt.
E. There is not enough disk space on the TFTP server for the IOS image.