Beruflich Dokumente
Kultur Dokumente
Step 2
Please enter username and password when prompted and click Login.
The default username is admin and the password field should be left
blank.
Step 3
If a local language pack is installed, please remove this by following the
step 3. Otherwise, please continue to step 4.
Select Maintenance from the top menu and then Save and Restore
from the left-hand side menu.
Click on Delete button next to Delete Language Pack.
Step 4
Select Firmware Update on the left-hand side menu from within
Maintenance.
Install the intermediate firmware by clicking on the Browse button,
select the unzipped file DIR300_middle_firmware_upgrade.bin and
click Upload.
Step 5
The intermediate firmware will now be installed. This will take around two
minutes. Please make sure that you DO NOT POWER OFF the device
during this time. There will be status information on screen, as below.
Step 6
Once the intermediate firmware is installed, you will see that the firmware
version shown on the top right-hand corner of the login screen. Please
make sure that this shows Firmware Version: 2.10. If it does not,
please repeat steps 3-5.
Please log back into the device web configuration. The now default
username is admin and the password field should be left blank, click
Login.
Step 7
Select TOOLS from the top menu and then FIRMWARE from the lefthand side menu.
Install the new firmware by clicking on the Browse button, select the
unzipped firmware file DIR300B5_FW214WWb01.bin and click
Upload.
Step 8
The new firmware will now be installed. This will take around two and a
half minutes. Please make sure that you DO NOT POWER OFF the device
during this time. There will be status information on screen, as below.
Step 9
Once the new firmware is installed, you will see that the firmware version
shown on the top right-hand corner of the login screen. Please make sure
that this shows Firmware Version: 2.14. If it does not, please repeat
steps 6-8.
The firmware upgrade is now complete. You can now reinstall your local
language packs and reconfigure/reload your previous configuration.