Beruflich Dokumente
Kultur Dokumente
e-ISSN: 2278-2834,p- ISSN: 2278-8735.Volume 10, Issue 5, Ver. II (Sep - Oct .2015), PP 76-78
www.iosrjournals.org
Lecturer of Electrical and Electronics Eng, IUBATInternational University of Business Agriculture and
Technology, Uttara, Dhaka, Bangladesh
2
Senior Lecturer of Computer Science and Eng, IUBATInternational University of Business Agriculture and
Technology, Uttara, Dhaka, Bangladesh
Abstract: This paper presents about the micro-controller based touch switch using micro-controller chip
ATMega8 based on C language and the name of this program is AVR Studio. This proposed micro-controller
based touch switch is a digital switch. This system is more reliable than others.
Index Item: Introduction, Block Diagram, Circuit Diagram, Circuit Description.
I.
Introduction
Already touch switch are used in a factory or house. But that was an analog system. That is more costly.
The functions of that system are more difficult and need a lot of components. But our proposed system, Microcontroller based touch switch, is possible to more than one switch to add here. Thats why, it is a digital process.
In this proposed system there are some advantages- cost is low, functions are not difficult. It is suitable to utilize
in household chore.
II.
Methodology
III.
Block Diagram
DOI: 10.9790/2834-10527678
www.iosrjournals.org
76 | Page
Working Principle
Micro-controller gets the signal from the touch point and turn ON the load by relay. Again Microcontroller gets the signal from the touch point and turn OFF the load by relay.
V.
Component Used
VI.
Circuit Operation
DOI: 10.9790/2834-10527678
www.iosrjournals.org
77 | Page
VII.
Step 1
Step 2
Step 3
Step 4
Step 5
Step 6
Step 7
Step 8
Step 9
Step 10
Step 11
Step 12
Algorithm
VIII.
Conclusion
Its a smart system to OFF or ON a load. If we use this system, it is possible to increase the stability of
the light or fan. If we touch with wet hand in the touch point of the system, the possibility to get electric shock
decreases. Thats why; its a safe system than others.
IX.
Future Scope
It is possible from this system to control a large switch board of a large factory from small panel.
We can control the system by remote control, Bluetooth and internet.
It can be possible to control the load of our own house from a large distance.
X.
Acknowledgement
This work was supported by IUBATInternational University of Business Agriculture and Technology.
References
[1].
[2].
[3].
[4].
[5].
[6].
[7].
[8].
[9].
[10].
[11].
http://www.atmel.com/devices/ATMEGA8. aspx
http://www.ijettjournal.org/volume-4/issue-4/IJETT-V4I4P346.pdf
http://www.digikey.com/en/articles/techzone/2013/ jul/microcontrollers-with-a-touch-sensing-interface
http://www.eeweb.com/blog/circuit_projects/touch-sensor-project-with-avr-microcontroller
https://intranet.ee.ic.ac.uk/t.clarke/ee2lab/handouts/ ARM/ARM_handout.pdf
http://www.circuitstoday.com/touch-switch-circuit-using-ne-555
http://circuitdigest.com/electronic-circuits/touch-switch-circuit
http://www.engineersgarage.com/contribution/touch-switch
http://www.electroschematics.com/11865/ttp223-capacitive-touch-switch-circuit/
http://www.circuitstoday.com/avr-atmega8-microcontroller-an-introduction
https://www.futurlec.com/Atmel/ATMEGA8.shtml
DOI: 10.9790/2834-10527678
www.iosrjournals.org
78 | Page