Beruflich Dokumente
Kultur Dokumente
Check features
CHECK ADDRESS
1
All you have to do is to select an address and then click on the symbol to
-
1:
2:
3:
4:
5:
-
FIND PORTS To find the module(s) in which the selected address is used.
When you click on this icon the search result window appears:
Resize window
Go to selected module
Minelec
Go to port of
selected module
Close window
Resize window
1
Minelec N.V., Isidoor Van Beverenstraat 59, 1702 Groot-Bijgaarden, Belgium
Tel : +322 460 31 75, Fax : +322 461 00 24, www.luxom.be
Test features
CHECK MODULE
6
7
8
6:
PING FOR OPEN STRAP/BUTTON To trace the MIN number of a module.
Push the MIN button on the module briefly (the MIN led starts blinking) and click to trace the MIN
number:
This window contains all the detailed information about the module.
In treeview, if the module is present in your project, a lightning flash is displayed over the module:
Note: The MIN led stops blinking automatically after 3 minutes, OR when you push again briefly on the
MIN button OR when you push the MIN button of another module.
7: PING MODULE(s) To check if the module is present on the network.
You can check the presence of a single module or a complete group of modules.
The term group (location) means all modules that may be present in a:
Project, Building, Floor, Area or Electrical Cabinet.
In the treeview, select the module or location which you wish to check, click on the right mouse button
and select PING Module(s).
Minelec
2
Minelec N.V., Isidoor Van Beverenstraat 59, 1702 Groot-Bijgaarden, Belgium
Tel : +322 460 31 75, Fax : +322 461 00 24, www.luxom.be
Test features
If the module is not present on the network, the module icon changes from
to
8: CHECK MODULE(s) If you want to compare the content of the module with the project database.
In the treeview, select the module or location you wish to check, click on right mouse button and select
Check Module(s).
Check window:
.
3
Test features
ICON TERMINOLOGY
-
- : Data in the computer is different from that in the module. Data still needs to be written to the
module. This icon appears:
- After youve written the MIN number
- After youve changed data in the module OFF-line.
- When programming was interrupted
Note: The first time this icon appears on a module, this indicates that the module needs to be
formatted. This happens automatically and depending on the type of module it can take
a few minutes.
- : Normal, module OK. The data in the computer is the same as in the module.
Minelec
4
Minelec N.V., Isidoor Van Beverenstraat 59, 1702 Groot-Bijgaarden, Belgium
Tel : +322 460 31 75, Fax : +322 461 00 24, www.luxom.be
Test features