Beruflich Dokumente
Kultur Dokumente
Performing TC Recording
Before performing a call test, specify parameters related to TC recording. The setting method is as follows:
1 Run the ADD CALLRESRECORD command to add a recording point. An input window is
displayed. Set the related parameters. Perform TC recording for both the calling party and the
called party.
ADD CALLRESRECORD: RECINDEX=0, USERIDTYPE=BYMSISDN, MSISDN="13908881006",
RECORDTYPE=TC;
(calling party)
(called party)
Note:
All commands of the function are internal commands and are not described in the help document.
The value of RECINDEX ranges from 0 to 5. Each added recording point is identified by a unique index.
USERIDTYPE includes four values, as described in the following table:
TMSI
IMSI
IMEI
Note:
Because recording of up to four MSs can be performed simultaneously under the BSC, the value of
RECINDEX ranges from 0 to 3. If the message "The data to be added conflicts with the existing data" is
displayed when the command is executed, it indicates that the number of recording MSs reaches the
maximum value. In this case, you can run the following command to delete the previous recording:
RMV CALLRESRECORD: RECINDEX=0;
(2) Perform dialing tests and call tests. After all call tests are completed, extract the TC recording file from
the directory \\mbsc\bam\common\fam\tc_file.<0
1.2
1 On the BSC6900 LMT, right-click a tested cell and choose Configure Frequency Scan from the
shortcut menu.
2 Specify parameters in the Configure Frequency Scan window and click Start to perform the test.
Note:
The start time must be later than the current time; otherwise, the test cannot be performed.
(3) After the configuration is successful, right-click the tested cell and choose Query Frequency Scan
from the shortcut menu. Then, choose the names of the tested site and cell.
Note:
Open the Query Frequency Scan window immediately after the frequency configuration is successful,
and then wait for the query results; otherwise, the query results cannot be reported.
(4) Observe the query results. After the results are reported, record the data of each frequency, press Ctrl +
A to select all, press Ctrl + C to copy the data, and paste the data to an excel file.
Note:
The reporting time is long and may take 56 minutes.