Beruflich Dokumente
Kultur Dokumente
c) 50V
d) 55V
11. d
12. d
13. a
14. a
15. c
16. a
17. c
18. a
19. c
20. a
21. a
22. a
23. a
24. a
25. a
26. a
27. a
28. a
29. a
30. a
31. b
32. d
33. b
34. a
35. a
36. a
37. b
38. b
39. d
11. Out of the following memory types, one that is volatile
a) Magnetic Disk
b) Ferrite Core
c) Semi Conductor ROM
d) Semi Conductor RAM
12. A 4-bit date word is called
a) Data bus
b) Band
c) Byte
d) Nibble
13. The heart of digital computer is
a) I/O
b) Processor
c) CPU
d) None of the above
c) 100% efficient
d) 25% efficient
26. Which of the following transformer can approach 100% efficient
a) Iron core transformer
b) Ferrite core transformer
c) Copper core transformer
d) None of these
27. The range of frequency in the case of audio transformer is
a) 40 to 20000 c.p.s
b) 20 to 20000 c.p.s
c) 100 to 10000 c.p.s
d) 10 to 10000 c.p.s
b) Clipper circuit
c) Zener diode
d) LED
34. The self exited mixer is economical because
a) It does not require separate amplifier
b) It does not require tank circuit
c) It needs to generate f0 + fs
d) None
c) RF amp
d) Mixer
40. In a superhet receiver, the name, first detector is often given to
a) 1st RF amp
b) Local Oscillator
c) IF amp
d) Mixer
11. d
12. d
13. c
14. c
15. d
16. a
17. c
18. c
19. a
20. c
21. a
22. c
23. a
24. a
25. a
26. a
27. a
28. a
29. a
30. a
31. b
32. d
33. b
34. a
35. c
36. a
37. b
38. c
39. c
40. d
58. The Tension of brushes to provide brush pressure is approx.
a) 6 Psi b) 8 Psi c) 10 Psi d) 12 Psi
59. A four pole generator will have
a) 2 interpole b) 4 interpole c) 6 interpole d) 8 interpole
60. In a 3 phase system, the phase winding is spaced symmetrically so that the
voltage induced is
2. Potentiometer varies
(a) amount of current (b) amount of voltage
(c) both (a) & (b) (d) none
3. At the center of a coil, amount of flux is concentrated maximum at
(a) starting of a coil (b) end of a coil
(c) center of a coil (d) remain equal at all places
4. Negative plate of lead acid battery is
(a) lead (b) lead peroxide (c) lead sulphide (d) spongy lead
5. Plates of lead acid battery is made of
(a) lead + antimony on which active material is attached.
(b) lead + iron on which active material is attached.
(c) antimony + iron on which active material is attached.
(d) none
6. m.m.f. is measured in Gilbert and symbolized by the capital letter.
(a) G (b) F (c) M (d) W
7. Solenoid relay is operated on
(a) high current (b) low current (c) high voltage (d) low voltage
8. Construction of separator of a lead acid battery is made in such a way that it
circulates the electrolyte freely around the plates in addition it also provides a
path for sediments to settle.
(a) at the side of cell (b) at the top of cell
(c) at the bottom of cell (d) none
9. Thermal protector is used to
(a) protect a motor (b) to open the circuit automatically
(c) it operates when temperature is very high (d) all of the above
10. S/W designed for momentarily operation
(a) micro s/w (b) push button s/w (c) toggle s/w (d) none
11. Rotary S/W are used in
(a) voltmeter selector s/w (b) ignition s/w (c) both (a) & (b) (d) none
12. Starter relay s/w is made to operate
(a) intermitenty (b) continuously
(c) could cause over heating if operated continuously (d) both (a) and (c)
13. Oil capacitors generally restricted to be used in
(a) radio transmitting equipment (b) radar transmitting equipment
(c) both (d) none
14. In fixed mica capacitor the dielectric is made of
(a) metal plate (b) mica (c) both (a) & (b) (d) none
15. Mica prevents as a dielectric
(a) arching between the plates (b) can withstand higher voltage
(c) both (a) & (b) (d) none of these
16. The capacitor which provides large capacitance in small physical size is
(a) oil capacitor (b) mica capacitor
(c) electrolytic capacitor (d) paper capacitor
17. Wet-electrolytic capacitors must be mounted on
(a) horizontally (b) vertically (c) any position (d) none
18. The working voltage of a capacitor depends on
(a) type of material used as a di-electric (b) thickness of di-electric
(c) frequency (d) all of the above
76. The identical insulated wire coils are hung from air so that they are facing
each other and supplied with same direction a.c.
(a) both are attracted to each other (b) both are repelled
(c) clockwise rotation (d) anticlockwise rotation
59. To pentralise the surface of Ni-Cd battery compartment
(a) boric acid (b) water (c) backing soda (d) all
39. If information of physical data is large such as in altimeter, display is known
as
(a) long range display (b) short range display
(c) smooth range display (d) wide range display
40. Nick name of digital display is
(a) alphanumeric display (b) straight scale display
(c) circular scale display (d) platform scale display
41. The soldering of Al-alloy differs from another metal due to
(a) high specific heat and conduction (b) greater heat input
(c) uneven expansion and contraction avoided (d) all
42. Kirchoffs Law is applicable to
(a) DC (b) AC (c) DC circuit having resistance (d) AC & DC
43. In modulation, the available band is
(a) one (b) two (c) no band (d) many band
44. The modulation in which, amplitude is kept constant and frequency is
changed is called
10. When two sphere are of same mass, one is positive charge and the other is
negative charge then new mass will remain
(a) change (b) unchanged (c) sum of both mass
11. If the conductor is of 4 and if it is stretched to twice its length then its
resistance is
(a) 1 (b) 2 (c) 16 (d) 32
12. A & B are big and small battery having same emf internal resistance of
battery A is
(a) less than B (b) greater than B (c) equal to B (d) unaffected
13. Which statement is correct?
(a) Battery terminal voltage is equal to battery emf.
(b) Battery terminal voltage is less than battery emf.
(c) Battery terminal voltage is more than battery emf.
(d) Depends on direction of current flow.
58. The unit where calculations are preferred is called
(a) Central processing unit (CPU) (b) Control Unit
(c) Arithmetic and logic unit (ALU) (d) Computing unit
59. EDP stands for
(a) Electrical data processing (b) Electronic data processing
(c) Entry data processing (d) Electronic discrete programme
60. Assembler is
(a) An individual who assembles computer (b) Language
(c) Program (d) None of the above
61. Input unit of computer communicates between
(a) Operator and Computer (b) Memory with printer
(c) CPU with monitor (d) Output and Computer
62. The symbol for Hexadecimal is
(a) 2 (b) 8 (c) 10 (d) 16
63. In computer terminology, MICR means
(a) Magnetic Ink Character Recognition
(b) Magnetic Ink Computer Recognition
(c) Monitor Indicating Computer Relay
(d) Mass Information Computer Record
64. Speed of processor is measured in
(a) Kilobit / Sec (b) Hertz (c) Byte (d) RPM
77. The relationship between voltage and current in a purely inductive circuit is
given by
(a) Voltage leads the current by 90
(b) Current lags the voltage by 90
(c) both (a) & (b)
(d) None of the above
78. By voltage division rule the voltage drop V1 in the circuit will be
(a) V1 = (R2 x Vs) / (R1+R2)
(b) V1 = (R1 x Vs) / (R1+R2)
(c) V1 = Vs x (R1+R2) / R1
(d) None
79. If inductance is doubled and the capacitance is halved , then resonant
frequency F0
(a) Doubled (b) Halved
(c) Remains same (d) Squared root of F0
80. 50000000 Hz stands for
(a) 5 MHz (b) 0.5 MHz (c) 50MHz (d) 500 MHz
66. A capacitor consists of two
(a) conductors separated by an insulator called the di-electric.
(b) insulators separated by a conductor.
(c) insulators separated by air medium.
(d) conductors separated by air medium.
67. In a capacitor electric charge is stored in
(a) metal plates (b) di-electric (c) both (a) & (b) (d) none of these
68. Unit of m.m.f. is
(a) weber (b) gilbert (c) maxwell (d) henry
69. Joule/coloumb is the unit of
(a) electric field potential (b) potential (c) charge (d) none of these
70. In a lead-acid battery, excessive formation of lead sulphate occurs due to
(a) idleness of battery for a long time (b) low level of electrolyte
(c) persistent under charging (d) all of them
b. 12 amp
c. 15 amp
d. 1 amp
31. In N-type semiconductors, the concentration of minority carriers mainly
depends upon
a) Doping technique b) Number of donor atoms
c) Temperature of material d) quality of intrinsic material
32. Peak Inverse Voltage (PIV) across the non-conducting diode (Reverse
biased) in center tape full wave rectifier is equal to
a) Vm b) 2/Vm c) Vm/2 d) 2Vm
33. Zinor Breakdown in a diode is due to
a) High electric field causes covalent bonds to break
b) Due to the increased velocities of minority carriers
c) Due to heating of junction due to heavy current
d) None of the above
34. Two switches are connected ___________ to obtain AND gate function
a) In series b) In parallel c) Either parallel or series d) None of above
35. Which gate is known as universal gate
a) OR gate b) NOR gate c) AND gate d) XOR gate
61. When calculating power in a reactive or inductive ac circuit, the true power
is
a) More than the apparent power b) Less than the apparent power
c) As in b) in reactive circuit and as in a) in inductive circuit d) None of these
62. The correct way to connect a test voltmeter in a circuit is
a) In series with the unit b) Between the source voltage and the load
c) In parallel with the unit
63. Transfer of electrical energy from one conductor to another without the add
of electrical connections
a) is called induction b) is called air gap transfer