Beruflich Dokumente
Kultur Dokumente
61. Taper tap is used in tapping procedure during starting the tap used for starting operation:
a) Taper tap
b) Plug tap
c) Bottoming tap
d)
62. Which screw driver is used during verneal space limitation:
a) off-set screw driver
b) stubby screw driver
c) simple screw driver
d)
63. If 1 cm. of main scale is divided in 20 equal part, 24 division of main scale is equal to 25 division of
vernier scale. Least count is:
a) 0.0002 mm.
b) 0.002 cm
c) 0.02 inches
d) 2 cm
64. Which thread gives/takes great strength/load in one direction:
a) buttress thread
b) square thread
c) ,
d)
65. V block is used to:
a) to hold cylindrical object
b) to hold square object
c) .
d) .
66. Which one is in increasing order to strength:
a) 2S, 24ST, 17ST, A17ST
b) 2S, A17ST, 24ST, 17ST
c) 2S, A17ST, 17ST, 24ST
d) 2S, 17ST, A17ST, 24ST
67. In flexible hose, slack is given:
a) 2 to 3% of total length
b) 5 to 8% of total length
c) 3 to 9% of total length
d) 10% of total length
68. Which has greater tensile strength & lower compressive strength:
a) carbon
b) graphite
c) boron
d) aramid
69. Mark the correct statement:
a) turbo fan engine require lesser runway length for take off than jet engine.
b) Jet engine, at higher altitude is efficient in comparison with piston engine
c) Jet engine has more weight to get equivalent power
d) Turbo jet engine requires longer runway.
70. Modern digital computer consist of:
a) Central processor (CPU) input/output device
b) Hardware
c) Software
d)
71. Speed of motor increases when load decreases current decrease because of:
a) frictional loss between motors moving part
b) frictional loss between winding & other parts
c) induced back emf increases
d)
72. Jo bolt is:
a) externally threaded two piece rivet
b) externally threaded three piece rivet
c) internally thread three piece rivet
d)
73. For parallel A.C. generators:
a) voltage, phase equal
b) phase, frequency same
c) voltage, frequency phase
d)
74. Quantity & quality of X-ray depends on:
a) intensity and penetrating power of x-ray
b) frequency & penetrating power
c) frequency & intensity of x-ray
d)
75. 7075-0 indicates:
a) normalizing
b) annealed
c) hardened & tempered
d)
76. Gasoline having octane no. more than 100 indicated by:
a) octane no.
b) performance no.
c) .
d)
77. Which is used to form rivet head:
a) snap and dolly
b) hammer and punch
c) punch & plier
d) rivet & bucking bar
78. De-magnetization is done in megnaflux method, after magnetization:
a) By slowly moving parts out of magnetic field demagnetize the part after magnetic flow
inspection by
b) The parts are demagnetize by passing D.C.
c) By flowing A.C. through the part and the part is immediately taken out of the electromagnetic field
79. A bolt should be installed (with load):
a) Upward & downward
b) Upward & forward
c) Downward and forward
d) Downward and rearward
80. Ventral fin is used for:
a) Directional stability
b) Longitudinal stability
c) Lateral stability
d) Both (b) & (c) are correct