Beruflich Dokumente
Kultur Dokumente
Q.12 (A) Dry battery cells used for say flash lights are called Primary cells
(B) The large storage batteries, like used in automobiles are called
secondary cells
a) Only (A) is correct
b) Only (B) is
correct
c) Both are correct*
d) Both are
incorrect
Q.13 Three batteries each charged for 1.8 volts & having the current
carrying capacities as 1.4 A, 2.1A and 1.1 A respectively are connected
in series, the change in overall value of current will be
a) No change in the overall value of the current* b) The total current
will be 4.6 A
b) The total current will be 2.1 A
d) None is correct
Q.14 The circuit component found practically in all electrical circuits i.e. the
fuse, is installed as the protection against
a) Excessive voltage flow
b) Excessive current flow*
c) The short circuiting
d) None is correct
Q.15 Which of the following is the correct Ohms law for eh calculation of the
current
a) I*R=E
v) R= E/I
c) I = E/R *
d) All are correct
Q.16 Why the side of each resistor, where the current enters is labeled as
negative (-ve)
a) Because the current flows from negative to positive terminals *
b) Because the current flows from positive to negative terminals
c) Because it is traditional representation
d) None is correct
Q.17 In the electrical circuits , what is the term bleeder current
a) The current drawn by the heavy load
b) The current
drawn by the lighter load
c) The current drawn by the voltage divider itself* d) None is correct
Q.18 The voltage divider device will have how many minimum terminals
a) Two
b) Three*
c) Four
d) None is correct
Q.19 While designing the instruments, how it is to be ensured that their
reading are least affected by the magnetic flux
a) These are surrounded by a material that offers an easier path to the
magnetic flux*
b) These are surrounded by the material, through which the magnetic
flux cannot penetrate
c) These are surrounded by the anti- magnetic material shield
d) Only (b) is correct
Q.20 The electromagnets used in the instruments, work on the principle of
a) The iron core held away from the center of the energized coil, will be
pushed away
b) The iron core held away from the center of the energized coil, will be
pushed to center*
c) The iron core held away from the center of the energized coil, will
remain still.
Q.21 The solenoid witches normally operate on
a) Low current*
b) High current
c) Medium current
d) None is correct
Q.22 In the lead acid batteries the plates are so assembled that
a) In between two positive plates, is one negative plate
b) In between two negative plates, is one positive plate*
c) The positive & negative plates are arranged alternately
Q.78
Q.79
Q.80
Q.81
Q.82
d) All*
Q.83 MOSFET is
a) MetalOxideSemiconductor Field-Effect Transistor*
b) Is a diode used for amplifying or switching electronic signals
c) MOSFET is a five-terminal device
d) All are
correct
Q.90
SCR consists of
a) The three terminals
b) As in (a) & It shall be operative only if a forward biased condition
exists when anode is more positive than cathode*
c) As in (a) & It shall be operative only if a forward biased condition
exists when cathode is more positive than anode
d) None is correct
Q.91 In case the signal has both RF and AF ingredients, which type of
filtering will be preferred
a) The low Pass filter*
b) The band pass filter
c) The high pass filter
d) None is correct
Q.92 In transistor when both junctions are reverse biased it is in a state
of(9A)
a) Cut-off*
b) Saturation
c) Active
region
Q.93 The signal in transistor is amplified because of ( 9A)
a) High input resistance*
b) High input resistance & capacitance
c) High input resistance & inductance d) High input resistance &
inductance and capacitance.
Q.94 If the input of half wave rectifier is 240V and transformer has a step
down ratio of 8:1, what
is the output r.m.s. value
a) 42.2V*
b) 30V
c) 21.3
V
Q.95
The working principle of the MOSFET can be based on
a) n Type MOSFET
b) p- Type MOSFET
c) Both are correct *
d) Only (b) is correct
Q.96 The Figure indicate ratio of V/I characteristics for
a) Diode*
b) Transistor
c ) SCR
Q.97. When on NPN transistor is used as an amplifier, the electron flow from
a) Base to emitter b) Emitter to base*
b) No statement is correct