Sie sind auf Seite 1von 67

42LH40 Direct View LCD

1080P
Direct View LCD

Updated February 17, 2010


Published July 2009

OUTLINE

Section 1
Contact Information, Preliminary Matters, Specifications,
LCD Overview, General Troubleshooting Steps,
Signal Distribution, Disassembly Instructions and Voltages
Section 2
Circuit Board Operation, Troubleshooting of :
Switch mode Power Supply/Ballast Combination
Main Board
Ft Control Board
Side Keys

July 2009 LCD DV

42LH40

Overview of Topics to be Discussed

42LH40 LCD Direct View Display


Section 1
This Section will cover Contact Information and remind the Technician of Important Safety Precautions for
the Customers Safety as well as the Technician and the Equipment.
Basic Troubleshooting Techniques which can save time and money sometimes can be overlooked. These
techniques will also be presented.
This Section will get the Technician familiar with the Disassembly, Identification and Layout of the LCD
Display Panel.
At the end of this Section the Technician should be able to Identify the Circuit Boards and have the ability
and knowledge necessary to safely remove and replace any Circuit Board or Assembly.

July 2009 LCD DV

42LH40

Preliminary Matters (The Fine Print)

IMPORTANT SAFETY NOTICE


The information in this training manual is intended for use by persons possessing an adequate background in
electrical equipment, electronic devices, and mechanical systems. In any attempt to repair a major Product,
personal injury and property damage can result. The manufacturer or seller maintains no liability for the
interpretation of this information, nor can it assume any liability in conjunction with its use. When servicing this
product, under no circumstances should the original design be modified or altered without permission from LG
Electronics. Unauthorized modifications will not only void the warranty, but may lead to property damage or
user injury. If wires, screws, clips, straps, nuts, or washers used to complete a ground path are removed for
service, they must be returned to their original positions and properly fastened.

CAUTION
To avoid personal injury, disconnect the power before servicing this product. If electrical power is required for
diagnosis or test purposes, disconnect the power immediately after performing the necessary checks. Also be
aware that many household products present a weight hazard. At least two people should be involved in the
installation or servicing of such devices. Failure to consider the weight of an product could result in physical
injury.

July 2009 LCD DV

42LH40

ESD Notice

(Electrostatic Static Discharge)

Todays sophisticated electronics are electrostatic discharge (ESD) sensitive. ESD can weaken or damage
the electronics in a manner that renders them inoperative or reduces the time until their next failure.
Connect an ESD wrist strap to a ground connection point or unpainted metal in the product. Alternatively,
you can touch your finger repeatedly to a ground connection point or unpainted metal in the product. Before
removing a replacement part from its package, touch the anti-static bag to a ground connection point or
unpainted metal in the product. Handle the electronic control assembly by its edges only. When
repackaging a failed electronic control assembly in an anti-static bag, observe these same precautions.

Regulatory Information
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to
Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful
interference when the equipment is operated in a residential installation. This equipment generates, uses,
and can radiate radio frequency energy, and, if not installed and used in accordance with the instruction
manual, may cause harmful interference to radio communications. However, there is no guarantee that
interference will not occur in a particular installation. If this equipment does cause harmful interference to
radio or television reception, which can be determined by turning the equipment off and on, the user is
encouraged to try to correct the interference by one or more of the following measures: Reorient or relocate
the receiving antenna; Increase the separation between the equipment and the receiver; Connect the
equipment to an outlet on a different circuit than that to which the receiver is connected; or consult the
dealer or an experienced radio/TV technician for help.

July 2009 LCD DV

42LH40

LG CONTACT INFORMATION
Customer Service (and Part Sales)

(800) 243-0000

Technical Support (and Part Sales)

(800) 847-7597

USA Website (GCSC)

aic.lgservice.com

Customer Service Website

us.lgservice.com

LG Web Training

lge.webex.com

LG CS Academy

lgcsacademy.com http://136.166.4.200

LG Learning Academy

LCD-DV: 32LG40, 32LH30, 37LH55, 42LG60, 42LG70, 42LH20, 42LH40, 42LH50, 47LG90, 47LH85
PLASMA: 42PG20, 42PQ20, 50PQ30, 50PG20, 50PS80, 50PS60

Also available on
the Plasma page

Plasma Panel
Alignment Handbook

New Training Materials on


the Learning Academy site

Published July 2009 by LG Technical Support and Training


LG Electronics Alabama, Inc.
201 James Record Road, Huntsville, AL, 35813.

July 2009 LCD DV

42LH40

SECTION 1: LCD DIRECT VIEW OVERVIEW


Safety and Handling Regulations
1. Approximately 20 minute pre-run time is required before any adjustments are performed.
2. Refer to the Voltage Sticker on the Switch Mode Power Supply silk screening. (+/- volt).
3. Be cautious of electric shock from the Backlight section, it uses high voltage AC. Check that
the Power Supply and Drive Circuits are completely discharged because of residual current
stored before Circuit Board removal.
4. C-MOS circuits are sensitive to static electricity.
Use caution when dealing with these IC and circuits.
5. Exercise care when making voltage and waveform checks to prevent costly short circuits
from damaging the unit.
6. Be cautious of lost screws and other metal objects to prevent a possible short in the
circuitry.

Checking Points to be Considered


1. Check the appearance of the Replacement Panel and Circuit Boards for both physical damage
and part number accuracy.
2. Check the model label. Verify model names and board model matches.
3. Check details of defective condition and history. Example: Oscillator failure dead set, etc

July 2009 LCD DV

42LH40

Basic Troubleshooting Steps


Define, Localize, Isolate and Correct
Look at the symptom carefully and determine what circuits could be causing
Define
the failure. Use your senses Sight, Smell, Touch and Hearing. Look for burned parts and
check for possible overheated components. Capacitors will sometimes leak dielectric material
and give off a distinct odor. Frequency of power supplies will change with the load, or listen for
relay closing etc. Observation of the front Power LED may give some clues.
Localize
After carefully checking the symptom and determining the circuits to be
checked and after giving a thorough examination using your senses the first check should
always be the DC Supply Voltages to those circuits under test. Always confirm the supplies
are not only the proper level but be sure they are noise free. If the supplies are missing check
the resistance for possible short circuits.
Isolate
To further isolate the failure, check for the proper waveforms with the
Oscilloscope to make a final determination of the failure. Look for correct Amplitude Phasing
and Timing of the signals also check for the proper Duty Cycle of the signals. Sometimes
glitches or road bumps will be an indication of an imminent failure.
Correct
The final step is to correct the problem. Be careful of ESD and make sure to
check the DC Supplies for proper levels. Make all necessary adjustments and lastly always
perform a Safety AC Leakage Test before returning the product back to the Customer.

July 2009 LCD DV

42LH40

42LH40 Product Information

This section of the manual will discuss the specifications of the 42LH40
LCD Direct View Display Panel.

July 2009 LCD DV

42LH40

Basic Specifications

Key Features

Full HD 1080p HD Resolution


70,000:1 Dynamic Contrast Ratio
TruMotion 120Hz
Intelligent Sensor Mode
2.7ms Response Time (GTG)
500 cd/m2 Brightness
Wide Color Gamut
Super IPS Panel
Wide Viewing Angle
XD Engine
24p Real Cinema
ISFccc Ready
Picture Wizard
AV Mode II (Cinema, Sports, Game)
60,000 Hour Panel Life (typical)
NTSC/ATSC Tuners with Clear QAM
10

July 2009 LCD DV

42LH40

Basic Specifications (LOGO Familiarization)


Full HD 1080p Resolution
Displays HDTV programs in full 1920 x 1080p resolution for a more detailed picture.

11

July 2009 LCD DV

42LH40

Pixel Count to Resolution Comparisons


FULL HD 1080p HD Resolution Pixels: 1920 (H) 1080 (V)
High definition television is the highest performance segment of the
DTV system used in the US. Its a wide screen, high-resolution video
image, coupled with multi-channel, compact-disc quality sound.

FORMATS
NTSC 480I
SD
480P
HD 1080I
HD 720P
HD 1080P
Possible Frame
Rates:
24FPS
30FPS
60FPS

Interlaced
Progressive
Interlaced
Progressive
Progressive

240 Lines
480 Lines
540 Lines
720 Lines
1080 Lines

1080P

BASIC
PIXEL COUNTS

720P Panel
1365 (H) 768 (V)

Interlaced
2 Fields to make a Frame
Progressive
Each Field is a Frame

1080P Panel
1920 (H) x 1080 (V)

Think of sync as the Panels Refresh Rate


12

July 2009 LCD DV

42LH40

Remote Control Familiarization

BOTTOM PORTION

TOP PORTION

13

July 2009 LCD DV

42LH40

Accessing the Service Menu


REMOTE
BOTTOM PORTION

SIDE KEYS

To access the Service Menu.


1) Turn the Set On
2) Simultaneously, Press and
Hold the Menu Key on the
Side Key pad and Press and
Hold the Menu Key on the
Remote approximately 5
seconds.
3) If Customers Menu appears,
continue to hold until it
disappears.
4) The Service Menu appears

Note: If a Password is required to enter the


Service Menu. Enter;
0000
14

July 2009 LCD DV

42LH40

Rear and Side Input Jacks


Rear In/Out Jacks

USB Port
Software Upgrades
Music, Photos

Side In/Out

Rear

MAIN PWB
Rear and Side
Input/Output locations

Side

15

July 2009 LCD DV

42LH40

USB DOWNLOAD
1) Create an LG_DTV folder on the USB Flash Drive

Shows the
Currently
Installed
Version

2) Copy new software (xxx.epk) to "LG_DTV"


folder. Make sure to have correct software file.
3) With TV turned on, insert USB flash drive.
4) You can see the message
TV Software Upgrade (See figure to right)
5) Cursor left and highlight "START" Button and
push Enter button using the remote control.
6) You can see the download progress Bar.
7) Do not unplug until unit has automatically
restarted.
8) When download is completed, you will see
COMPLETE.
9) Your TV will be restarted automatically.

Shows the
Software
Version
found on the
USB Flash
Drive

Shows the
Software file found
on the USB Flash
Drive

* CAUTION:
Do not remove AC power or the USB Flash Drive.
Do not turn off Power, during the upgrade
process.

16

July 2009 LCD DV

42LH40

42LH40 Product Dimensions


Wattage
Average: 143W
Stand By: less than 1W

There must be at least 4 inches of Clearance on all sides


40-13/16"
1036.3mm
7-7/8"
200mm

16-1/8"
410mm

25-13/16"
655.3mm

3-7/8"
97.8mm
28-3/8"
721.4mm
12-15/16"
327.8mm

9-1/16"
230mm

12-15/16"
327.8mm

20-7/16"
518mm

Center

8-7/8"
225.3mm

3-1/2"
88.9mm

7-7/8"
200mm

Model No.
Serial No.
Label

Remove 4 screws to
remove stand for
wall mount

2-9/16"
65.7mm
Weight without Stand: 36.4 lb
Weight with Stand: 40.3 lb

22-13/16"
580mm

17

11-9/16"
294mm

DISASSEMBLY AND TROUBLESHOOTING SECTION

Disassembly:
This section of the manual will discuss Disassembly, Layout and Circuit
Board Identification, of the 42LH40 LCD Direct View Television.
Upon completion of this section the Technician will have a better understanding of
the disassembly procedures, the layout of the printed circuit boards and be able to
identify each board.
Troubleshooting:
This section of the manual will also discuss troubleshooting.
Upon completion of this section the Technician will have a better understanding of
how to diagnosis and resolve problems.

18

July 2009 LCD DV

42LH40

Removing the Back Cover

Remove the 21 screws indicated.


Pay attention to the size and type of screw
as there are many different types.
Putting in an improper screw when
reassembling may Cause damage.

The Stand does not need to be removed before removing the back.

19

July 2009 LCD DV

42LH40

Circuit Board Layout


No T-CON or Ballast board
LVDS Cable

LVDS Cable

POWER SUPPLY

Main PWB
Side Keys

Backlight
Connections
RF
Input
AC
Input

Rear
Inputs
Speaker L

Speaker R
Master
Power
Switch

Ft IR/LED Control

20

July 2009 LCD DV

42LH40

POWER SUPPLY SECTION


This switch mode power supply has the ballast section built in.
The power supply develops Stand By 5V, 12V and 24V for the Main
board.
This power supply draws a little less that 1 watt during stand
by mode. The fuse F501 reads 157V (from hot ground) during
this time. When the controller chip (on the back) receives the
PWR-ON command via P201 Pin 19, the primary section
increases its current supplying ability. The Primary fuse F501
now reads 380V.
12V is routed out P201 pins 5 and 6 and
24V is routed out P201 pins 1 and 2.
Internally, the power supply also sends B+ (390V) voltage to
the Ballast section but it is not turned on at this time.
When the power supply receives the INV-ON command via
P201 pin 20, it is routed to the driver for the ballast (on the
back of the board). The driver now starts to deliver drive
information to the output FETs (on the far left hand heat sink)
which in turn switch the primary sides of the two ballast
transformers T703 and T704. They output 1.2Kv (48Khz)
pulses to the backlights via P401 and P402.

21

July 2009 LCD DV

42LH40

Power
Supply PWB
Removal
P201

Disconnect
P201, P401,
P402, AC In
SK101 and
SK102.

P201

Remove the 6
screws indicated
by the arrows
w/screw.

Press in
Two tabs
to release
lock

P402
1
10
SK

P401

AC In

SK102

22

July 2009 LCD DV

42LH40

Power Supply (Main Power Switch Type 1) Location


There are three types of Main Power switch used in LG televisions. This set utilizes Type 1.
Type 1:
Shuts off AC to the Power Supply.
Type 2:
Opens ground to the front IR board. (Stand-By 5V Remains, the Main board stays alive).
This prevents any activity of the IR or the Key Board. When the Switch is opened, a line called
Power Key pulls up high when ground opens. When the switch is closed, this same line called
Power Key feeds back to the Microprocessor and the Micro. Turns on the Power.
Type 3:
Opens ground to the front IR board. (Stand-By 5V turns off, the Main board is dead).
This prevents any activity of the IR or the Key Board. When the Switch is opened, a line called
Power Key pulls up high when ground opens. This line feeds back to the Main board and from
there it routes to the Power Supply. The high tells the Controller chip to turn off STBY-5V.
When the switch is closed, this same line called Power Key now goes high and feeds back to
the Power Supply and tells the controller chip to turn STBY-5V on.

If the TV wont come on, be sure to check the Main


Power Switch before assuming a failure has occurred.
This switch breaks AC to the SMPS.

MAIN POWER SWITCH LOCATION


TYPE 1
(Bottom Right Side viewed from front)

23

Of f

July 2009 LCD DV

On

42LH40

POWER SUPPLY SECTION


This switch mode power supply has the ballast section built in.
The power supply develops Stand By 5V, 12V and 24V for the Main
board.
This power supply draws a little less that 1 watt during stand
by mode. The fuse F501 reads 157V (from hot ground) during
this time. When the controller chip (on the back) receives the
PWR-ON command via P201 Pin 19, the primary section
increases its current supplying ability. The Primary fuse F501
now reads 380V.
12V is routed out P201 pins 5 and 6 and
24V is routed out P201 pins 1 and 2.
Internally, the power supply also sends B+ (390V) voltage to
the Ballast section but it is not turned on at this time.
When the power supply receives the INV-ON command via
P201 pin 20, it is routed to the driver for the ballast (on the
back of the board). The driver now starts to deliver drive
information to the output FETs (on the far left hand heat sink)
which in turn switch the primary sides of the two ballast
transformers T703 and T704. They output 1.2Kv (48Khz)
pulses to the backlights via P401 and P402.

21

July 2009 LCD DV

42LH40

42LH40 Power Supply Start Up Sequence


Master (Main)
Power Sw

POWER SUPPLY (SMPS)

Power Supply will


not be on if Main
Power Switch is off.

Off
On

BALLAST SECTION

Ballast
Driver FETs

380V
Regulator
Drive Sig

In Stand-By
Primary side
AC In
is 178V
In Run
Stand
By 5V Reg it is 380V

Inverter
On

12V/24V
Regulators

64K
1.2Kv

Inverter On
Starts the Ballast
Drive Signal

1.2Kv

Manipulates
Backlights

Backlights
Light

10

P-DIM

Stand
By 5V

12V 24V

At point 3 TV is in
Stand-By state.
Energy Star compliant.
Less than 1 Watt

Inv
On

PWR

5V Reg

5
Resets
Microprocessor
Main Board

A-DIM
Fixed

8
24V
Audio

12V Video
Processing

Other Circuits

Other Circuits
+5V
General 5

Relay On (PWR)

Other
Regs

3.3V Reg
for Micon
2

DC Up, Backlight brightness Up

MAIN PWB

Microprocessor
section of Mstar
IC100

8
7

P-DIM

Intelligent Sensor feedback

Video
Processing
section of Video
Mstar IC100
12V

Cust Menu for Backlight


Picture Content

TFT Driver Section Main PWB


IC1100
Tru-Motion

12V LVDS

LVDS
12V

LVDS Panel Control

25

To
Panel

Blue LED lights to assist


Backlight Lamp Firing
Ft Control

Power Det. Circuit

Video

Inv On/Off

TFT
Controler
Section

11

Remote or Key
Power On

42LH40 P700 on Main Board to SMPS P201 Turn On Circuit Diagram


LVDS 12V Panel Power

12V

Q706

L728

L708

R739 47K

6V

MAIN PWB

P201

P700

n/c
PWR
Gnd
Gnd
Gnd
Gnd

1
2
3
4
5
6
7

SBY5V
Gnd
Gnd
12V
Gnd
Gnd
24V
n/c
INV.On
A.DIM
ERR Out
n/c
PWM-DIM

8
9
10
11
12

n/c
4.98V
Gnd
Gnd
Gnd
Gnd
5V
5V
5V
5V
Gnd
Gnd

18
19
20
21
22
23
24

21.3V
n/c
3.8V

1.8V
0V
n/c
3.38V

R708

L706

10

C726
220uF

11
12

10K
R702

Relay On
E5 GPIO 134
R257

C745
100uF

100

Error 5V: Normal 0V:


Lamps try to fire 4 time,
if Error line is high, Micro
shuts off television.

STBY5V

L707

12V
C722
47uF

15
16

L704

18

C721
68uF

19

C727
68uF

Error Out

22

n/c

24

PWM-DIM (PWM Dimming) Manipulates the


Backlight Brightness via Customers OSD.
Manipulates the Backlight Brightness via the
Video Processor Chip. Darker Picture,
Darker Backlights to facilitate improved
Contrast Ratio. 0.6V ~ 3.3V Range

Q702

R719 1K

R714

INV ON/OFF

21

R717
3.3K

+5V General
24V

17

23

R245
100

5.2V

20

R726
10K

Power On

14

21.3V

Q703

14

17

Q701 Q700

13

16

0.2V

C711
150pF

12V
Gnd

0.6V

PWR ON

13
15

L709
L701

n/c

12V
Gnd

+5V General

STBY5V

+5V

0V

0.6V

R740 47K

L715
SMPS

R732
22K

Q705 Q704

Stby = 5V Run = 0V

R201
100

100

GPIO137 H5
LVDS Panel
Control

IC100
Mstar

G5 GPIO 136
R713
0

R244
100

Inverter On/Off
E8 GPIO 97
AB13 PWM0

A-DIM
L700

Analog Dimming (Fixed Value)

R704
C706
1uF 4.7K

C182 R185
1uF 1.2K

R760

R189

100

Digital Dimming (Variable)


PWM-DIM
L705

26

C725
1uF

A-DIM

P-DIM
AB12 PWM2

C181
1uF

TEST 1 Power Supply PWB Low Voltage Test


AC Should not be applied at any time while adding resistors or while
unplugging connectors as damage to the circuit PWB may occur.
a) The SMPS PWB MUST be producing STBY 5V on either pin 7, 8,
9 or 10 (5V).
If 5V Standby is not being generated, the SMPS PWB is defective and
must be replaced. There is no need to continue with the next test.
(b) Unplug P700 on the Main PWB.
TEST 1:
(1) Add a 100 resistor between (5V STBY) pin 7, 8, 9 or 10 and Pin 2
(PWR). Apply AC. This will turn on the power supply.
a) Check that the 24V and 12V power supplies are
turned on,
P201 (24V pins 17 and 18)
P201 (12V pins 13 and 14)
(2) Remove AC power.
Use P700
Side to insert
resistors

27

July 2009 LCD DV

42LH40

TEST 2 Power Supply PWB Backlights Test


P700 Connector disconnected from the Main PWB. Apply AC after adding jumper.
Continue if the 1st test was OK. Leave original resistor in place.
(3) Add another 100 resistor between (5V) pin 7, 8, 9 or 10 and
Pin 20 (INV On).
(4) Apply AC Power. Simulating a Power and Backlight On command.
Backlights Normal:
a) If normal, the backlights should turn on. SMPS OK.
Backlights Abnormal:
a) Recheck all connections.
b) Confirm the INV On/Off line pulling up to at least 3V.
REMOVE AC POWER:
c) Check the connections to the Backlights.
DO NOT check these when AC is applied as they carry 1.2Kv each.
Note, either of the connections are unplugged, the backlights will not
light.
Use P700
Side to insert
resistors

28

July 2009 LCD DV

42LH40

General Backlight Information

To Backlights
Over 1.2KV
Ballast Section of SMPS

To Backlights
Over 1.2KV

Currently, number of lamps Unknown

EEFL (External Electrode Fluorescent Lamp)


LOW COST Large number of lamps driven by a single inverter
29

July 2009 LCD DV

42LH40

Introducing EEFL
Simple structure, Low price

Simple structure
Complicated structure

Lamp manufacturing process


Lamp assembly structure

30

Low Cost
Large number of Lamp
Drive by single inverter

July 2009 LCD DV

42LH40

Introducing EEFL Contacts (Bulb Design)


Key: Long Life Time

For CCFL, Hg gas is consumed mainly near the internal electrode


For EEFL, longer life time is expected because there is no internal electrode consuming Hg gas

31

July 2009 LCD DV

42LH40

Ballast Section of SMPS Layout

Viewed from rear

SMPS PWB

Backlights
Test Point
Bottom of
R406 or R403
38V P/P

48Khz
To Backlights
Left Side

T703

1.2Kv

To Backlights
Right Side

T704

32

July 2009 LCD DV

42LH40

42LH40 Ballast Control Signals Circuit Diagram


MAIN PWB

POWER SUPPLY

BALLAST
SECTION

P201

Stand By 5V
Reg

To Backlights
1.2Kv
P402

P700

10

10

20

20

Controller

Two
Transformers

Ballast
Power

380V
Reg

390V

160V
Reg

0V~130V

12V
Reg

0V~130V

INV On/Off

390V

Drive Circuit
FETs Q709/10

13

13

14

14

17

17

18

18

22

22

On Back of PWB

IC600

21

R759
0

R244
100

Q702

GPIO 136

PWR
R704 4.7K

Q701
R706

R703

12V

R237
100

24V

STBY5V

0V
ERR

A-DIM

RL-ON

Q700
R201
100

GPIO 97

E8
R743 100

ERROR-Out

R189 100

24
21

GPIO 134

E5

1.67V

VBR-A (Analog Dimming)


This line is not used.

R719
1K

G5 INV-On/Off

PWM-DIM
24

Ballast Control IC
Drive Control

R714
100

INV On/Off

4.89V

24V
Reg

Varies with
PDIM

STBY5V

3.8V

IC301

Hot Gnd

IC100
Mstar

+5V General

On Back of PWB

P401

R717
3.3K

AB13

PWM-2

AB12

PWB-0

L733
L700

R704 4.7K

R185 1.2K

VBR-B (PWM Dimming) Manipulates the Backlight Brightness via Customers OSD.
Manipulates the Backlight Brightness via the Video Processor.
Darker Picture, Darker Backlights to facilitate improved Contrast Ratio. 0.6V ~ 3.3V Range

33

Power Supply Backlight Drive Signal Effects

Note:
Backlights will
attempt to fire 4
time. During these
attempts, the Error
line will change
from 5V to 0V.

PWMDIM
manipulates
the Burst
Triangle
Oscillator in
the ballast
drive IC.

0V when lamp tries


to fire or is lit.
5V when the lamps
are not lit.
After 4 attempts, if
the Error Out line
returns to 5V, this
tells the Micro to
turn the set off.

ADIM also
manipulates
the Burst
Triangle
Oscillator
But it is not
used.

34

July 2009 LCD DV

42LH40

Power Supply Connector P201 Voltage and Resistance


P201 Odd "SMPS" to P700 "Main PWB"

P201 Even "SMPS" to P700 "Main PWB"

Pin

Label

STBY

Run

Diode
Check

Pin

STBY

Run

Diode
Check

23

nc

nc

nc

nc

24

PDIM

0V

3.2V

Open

A.DIM

0V

1.66V

Open

22

Err Out

0V

0V

Open

19

nc

nc

nc

nc

20

INV.ON

0V

3.8V

2.25V

17

24V

0V

21.4V

0.81V

18

24V

0V

21.4V

0.81V

15

Gnd

Gnd

Gnd

Gnd

16

Gnd

Gnd

Gnd

Gnd

13

12V

0V

12.3V

1.2V

14

12V

0V

12.3V

1.2V

11

Gnd

Gnd

Gnd

Gnd

12

Gnd

Gnd

Gnd

Gnd

5V

5.14V

5.14V

2.85V

10

5V

5.14V

5.14V

2.85V

5V

5.14V

5.14V

2.85V

5V

5.14V

5.14V

2.85V

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

nc

nc

nc

nc

PWR-ON

0V

4.98V

1.19V

21

Label

ADIM Pin 21 Fixed and not used

PDIM Pin 24 can vary according to type of signal


being processed and the OSD Backlight setting.
0.6V 0% to 3.3V 100%. Output from the Video
Processor IC100.

Diode Mode values taken with all Connectors Removed

35

July 2009 LCD DV

42LH40

Power Supply Connector SK100 and SK101 Voltage and Resistance


Diode Mode values taken with all Connectors Removed

SK100 "SMPS" to AC IN
Pin

Label

STBY

Run

SK101 "SMPS" to MASTER POWER SWITCH


Diode Check

Pin

Label

OL

n/a

OL

n/a

120Vac

AC Voltage Readings Across Pins 1 and 2


for STBY and RUN.
Bottom
Right of
SMPS

Run

Diode Check

120Vac

OL
OL

AC Voltage Readings for either pin 1 or pin


2 in STBY and RUN with one lead on
Neutral of SK100.
With the Master Power Switch
Closed (On) AC flows.
When Open (Off) AC open and does
not flow.

F100

Neutral

SK101

STBY

Live

F100
6.3A/250V
AC IN

SK100
36

July 2009 LCD DV

42LH40

MAIN PWB SECTION


The Main PWB also contains the T-CON (TFT Driver) section. This set does not use a normal T-CON
board.
There are two LVDS cable feeds that go directly to the Panel. These carry the TruMotion 120Hz duel
12 bit LVDS, (video signal) that has already been prepared for the panel drivers.
The Main board receives its operational B+ from the Power Supply via P700.
RUN

STAND-BY
STBY 5V pins 7~10

12V pins 13 and 14


24V pins 17 and 18.

The Main board also develops several B+ sources on the board.


LVDS

AUDIO
3.3V
1.8V

VCC-LCM+3.3V,
VDD-LCM+16V,
VGH+24V
VGHM+24V
VGL-5V

Mstar IC100 (Video) / MICROPROCESSOR


1.2V, 1.26V, 1.8V, and 3.3V

TUNER and VSB CIRCUIT


9V which is used to make 5V TU
5V
3.3V
1.2V

37

July 2009 LCD DV

42LH40

Removing the Main PWB


Disconnect P700, P1204,
P600, P1400 and P1401.

Press in on the top


and bottom release
tabs to remove P700.

Remove any tape holding down any cables.


Remove the 6 screws indicated by the arrows.
Flip the locking tab upward, pull the LVDS ribbon out.

P1400

P700

P1401

P1200
P600
NOTE: Be sure to check
on top and behind the
Video Processor ICs.
Look for a piece of
Chocolate
(Heat Transfer Material).
Be sure to transfer to
new PWB if present.

38

July 2009 LCD DV

42LH40

Main PWB
Layout

IC100
Microprocessor
and
Video Processor

To SMPS

MICRO and VIDEO


PROCESSOR IC100 and
Tru-Motion IC1100 run
Hot. This is normal.

P1400, P1401 to Panel

P1401

P1400

P700
To SMPS
IC1100

IC100

To Ft
Control PWB

X1100
USB

P1200
LD1000

X100
P600
To Speakers

X1005

SW100
Reset

LD1000
Tuner OK
when
Green

19

Tuner
TU1001

39

July 2009 LCD DV

42LH40

Main PWB (Front Side) Component Locations

40

July 2009 LCD DV

42LH40

42LH40 Front Side Component Voltages


42LH40 MAIN (FRONT SIDE) SIMICONDUCTORS
IC701

1.8V DDR
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC704

n/c
3.2V
3.2V
n/c
n/c
1.8V
0.79V
Gnd
3.3V Reg

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

0.79V
Gnd
5V
7.7V
4.9V
3.3V
3.3V
2.1V

Pin
A
J
K

LVDS 16V
Source
14.7V
20V
27V

D1400

IC705

3.3V / 1.26V

IC101

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

0.8V
Gnd
5V
6.12V
4.99V
1.3V
1.3V
3.19V
5V General
LVDS 12V
5.1V
Gnd
12V
0.67V
12V
12V
5V
5V

IC708

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

D1402

Pin
A
J
K

LVDS (-5V)
Source
(-5V)
(-2.38V)
Gnd

Q706

D1401

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Flash Boot
Memory
0V
3.2V
2.5V
Gnd
0V
0V
3.2V
3.2V

IC103

Q105

Reset
Pin
[1] Gnd
[2] 0V
[3] 3.3V

IC601
Q106

Gnd
0.79V
1.26V
1.26V
1.8V
5V
0V
5V

LVDS 3.3V
Pin Source
A Gnd
K 3.3V

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Power On
Pin
Delay
E Gnd
B 0V
C 1.96V

3.3V Reg
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC707

Reset
Pin
E Gnd
B 0V
C 3.3V

D1204
Pin
A
K
A

41

LED Moving
Ft LED
0V
0.14V
0V

5V EXT
1.8V MEMC
0.8V
Gnd
4.9V
6.5V
4.84V
1.8V
1.8V
4.83V

1.8V Amp
Pin
[1] Gnd
[2] 1.8V
[3] 3.3V

IC1001
Pin
[1]
[2]
[3]
[4]
[5]

3.3V FE
4.9V
4.9V
Gnd
3.36V
1.19V

IC1000
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Flash Boot
Memory
0V
3.36V
3.36V
n/c
n/c
1.19V
0.79V
Gnd

IC1002
Pin
[1]
[2]
[3]
[4]
[5]

5V for Tuner
8.9V
1.93V
5V
n/c
Gnd

Main PWB
(Back View)

42

July 2009 LCD DV

42LH40

42LH40 Front Side Component Voltages


42LH40 MAIN (BACK SIDE) SIMICONDUCTORS
Q1000
Pin
E
C
B

Tuner SIF
2.4V
0V
3.0V

Q1001
Pin
E
C
B

Tuner Video
analog
2.5V
0V
3.2V

IC1201
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]

RS232
3.3V
5.6V
0V
0V
5.5V
5.5V
5.5V
0V
3.3V
3.26V
0V
3.3V
0V
5.6V
Gnd
3.3V

IC1200
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

HDMI
Gnd
Gnd
Gnd
Gnd
4.8V
4.8V
4.8V
4.8V

IC1101
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

0V
1V
3.26V
Gnd
0V
0.1V
3.26V
3.26V

IC702

STBY 3.3V

Q1202

Moving LED
Pin
Driver
E 0.1V
C 0V
B 3.3V

IC1003
Pin
[1]
[2]
[3]

9V Reg
for Tuner
12.3V
8.9V
Gnd

Q600

Audio Mute

Q703
Pin
E
C
B
Q704

Turns on 5V
General Q706
0V
0V
0.62V

Pin
[1] Gnd
[2] 3.3V
[3] 5.1V

PWR-On to
Pin P700 pin 2
E 5.12V
C 4.99V
B 3.07V
Turned on by Q700

Q705
Pin
E
C
B

Turns on LVDS
12V Q706
0V
0V
0.66V

Q701

Q702
Pin
E
C
B

EEPROM
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Turns on
Pin
Q705
E 0V
C 0V
B 0.62V

Flash
Pin
E 0.1V
C 3.2V
B 0V

IC104

IC1100
Pin
G
D
S

IC107
IC105

HDCP EEPROM
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

INV-On to
P700 pin 20
0V
3.8V
0V

41

Gnd
Gnd
5.05V
Gnd
5.05V
5.05V
3.25V
3.25V

Pin
[1]
[2]
[3]
D102
Pin
A
K
A

Gnd
Gnd
Gnd
Gnd
3.25V
3.25V
0V
3.25V
LD1100 Driver
0.29V
2.9V
0V

Power Det
Reset
0.0V
3.3V
3.2V
Audio Mute
Routing
0V
0.1V
0V

D1403

LVDS 16V
Pin Source
A 12.2V
K 16.6V

IC1203
Pin
[1]
[2]
[3]
[4]
[5]
D1100

SPDIF Optic
3.25V
3.24V
Gnd
1.6V
3.25V

LD1100 (Q1100)
Pin Gate
A 0V
K 0.33VV

D1223
Pin
A
K
A

B+ Routing
RGB
5.1V
4.8V
0V

Main PWB X100, X1100 and X1005 Crystal Check


IC100 Microprocessor Crystal

TruMotion IC1100 Crystal


Set on. Use bottom leg.
2.4Vp/p 12Mhz

X1100

3.2Vp/p 12Mhz

Set on or off. Use bottom leg.


Tuner
Control
IC1005
Crystal

X1005
X100

MAIN PWB

4.95Vp/p 25Mhz

Set on. Use top leg.

44

July 2009 LCD DV

42LH40

Main PWB LD1000 Function

LD1000

Use LD1000 as a visual aid.


This lets you know if the tuner internal PLL
(Phase Locked Loop) system is locked.
Illuminated PLL is normal.
Off is abnormal tuner lock.
Main PWB
LD1000 Location

45

July 2009 LCD DV

42LH40

Main PWB Tuner with Shield Off (Pin ID)

19
18
13
12
9
8
4
1

46

July 2009 LCD DV

42LH40

Main PWB Tuner Video and SIF Output Check


USING COLOR BAR SIGNAL INPUT

Note: Video Out Signal only when


receiving an analog Channel.

MAIN PWB
Tuner Location
Pin 19
Video
Signal

2.24Vp/p
Pin 16
SIF
Signal
Pin 12 and Pin 13
Dig IF Signal

450mVp/p

Note:
Dig IF Signal only when
receiving a Digital Channel.

700mVp/p

47

July 2009 LCD DV

42LH40

Main PWB Tuner Clock and Data Lines


Note:
SCL and SDA only active during
an actual Channel Change.

Pin 9 SCL

1V per/div

100uS

5V p/p

Pin 8 SDA

1V per/div

48

100uS

5V p/p

July 2009 LCD DV

42LH40

Main Board LVDS Power Supply Voltage Generation Circuit


VCC
3.3V
VGL
-5V

VGHM
26V

VDD
16V
50

July 2009 LCD DV

42LH40

Main PWB Connector P700 to Power Supply Voltage and Resistance


P700 Main PWB" to P201 SMPS PWB"
Even Pins

Odd Pins
Pin

Label

STBY

Run

Diode
Check

Pin

Label

STBY

Run

Diode
Check

nc

nc

nc

nc

PWR-ON

0V

4.98V

1.87V

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

5V

5.14V

5.14V

1.1V

5V

5.14V

5.14V

1.1V

5V

5.14V

5.14V

1.1V

10

5V

5.14V

5.14V

1.1V

11

Gnd

Gnd

Gnd

Gnd

12

Gnd

Gnd

Gnd

Gnd

13

12V

0V

12.3V

2.1V

14

12V

0V

12.3V

2.1V

15

Gnd

Gnd

Gnd

Gnd

16

Gnd

Gnd

Gnd

Gnd

17

24V

0V

21.4V

Open

18

24V

0V

21.4V

Open

19

nc

nc

nc

nc

20

Inv.Out

0V

3.8V

1.9V

A.DIM

0V

1.7V

2V

22

Err Out

0V

0V

Open

nc

nc

nc

nc

24

0V

3.2V

Open

21
23
1

PDIM

ADIM Pin 21 Fixed and not used

PDIM Pin 24 can vary according to type of signal


being processed, OSD Backlight setting. 0.6V 0%
to 3.3V 100% and the Intelligent Sensor. Output
from the Video Processor IC100.

Diode Mode values taken with all Connectors Removed

49

July 2009 LCD DV

42LH40

Main PWB Connector P1400 to the Panel Voltage and Resistance


P1400 CONNECTOR "Main" to The Panel"
Pin

Label

Run

Diode
Test

Pin

Label

Diode Mode values taken with all Connectors Removed


Run

Diode
Test

Pin

Label

Run

Diode
Test

Gnd

Gnd

Gnd

21

POL

1.63V

1.3V

41

LMLV0P

1.2V

0.89V

VGL

(-5V)

0.925V

22

SOE_L

0.2V

1.45V

42

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

23

Gnd

Gnd

Gnd

43

OPT_N

3.24V

1.3V

VGH M

26V

Open

24

LMLV8N

1.2V

1.29V

44

GMA10

7.9V

1.4V

VCOM_FB

7V

Open

25

LMLV8P

1.23V

1.29V

45

GMA12

6V

2.0V

VCOM_L

7V

1.4V

26

LMLV7N

1.2V

1.29V

46

GMA13

5.2V

2.0V

GMA1

14V

2.0V

27

LMLV7P

1.25V

1.24V

47

GMA14

4V

1.4V

GMA2

16V

1.4V

28

LMLV6N

1.22V

1.29V

48

GMA15

3V

2.0V

GMA3

14V

1.36V

29

LMLV6P

1.21V

1.3V

49

GMA16

2.3V

2.0V

10

GMA4

13.3V

2.0V

30

LMLV5N

1.2V

0.9V

50

GMA17

0.3V

1.39V

11

GMA5

12.3V

2.0V

31

LMLV5P

1.2V

1.29V

51

GMA18

2.3V

2.0V

12

GMA6

11.2V

1.37V

32

LMCLKN

1.26V

1.29V

52

Gnd

Gnd

Gnd

13

GMA7

10.3V

2.0V

33

LMCLKP

1.25V

1.29V

53

VCC

3.3V

1.6V

14

GMA9

8.4V

2.0V

34

LMLV3N

1.23V

1.29V

54

VCC

3.3V

1.6V

Gnd

35

LMLV3P

1.23V

0.89V

55

Gnd

Gnd

Gnd

1.3V

36

LMLV2N

1.3V

1.29V

56

VDD

16V

2.0V

1.3V

37

LMLV2P

1.2V

1.29V

57

VDD

16V

2.0V

LMLV1N

1.3V

1.29V

58

VDD

16V

2.0V

59

LTD_L

8.2V

Open

60

Gnd

Gnd

Gnd

15
16
17

Gnd
GOE
GSP_R

Gnd
0.6V
0.6V

18

GSC

1.63V

1.3V

38

19

H_CONV

0V

Open

39

LMLV1P

1.2V

1.29V

20

GSP_R

0V

1.3V

40

LMLV0N

1.28V

1.29V

51

July 2009 LCD DV

42LH40

Main PWB Connector P1401 to the Panel Voltage and Resistance


P1401 CONNECTOR "Main" to The Panel"
Pin

Label

Run

Diode
Test

Pin

Label

Diode Mode values taken with all Connectors Removed


Run

Diode
Test

Pin

Label

Run

Diode
Test

Gnd

Gnd

Gnd

21

H_CONV

OV

Open

41

RMLV1P

1.25V

1.3V

LTD_R

8.9V

Open

22

GSP

OV

1.3V

42

RMLON

1.20V

1.3V

VDD

16.55V

2.0V

23

POL

1.62V

1.3V

43

RMLOP

1.26V

1.3V

VDD

16.55V

2.0V

24

SOE

0.2V

1.5V

44

Gnd

Gnd

Gnd

VDD

16.55V

2.0V

25

Gnd

Gnd

Gnd

45

OPT_N

3.23V

1.31V

Gnd

Gnd

Gnd

26

RMLV8N

1.2V

0.89V

46

OPT_P

OV

0.9V

VCC

3.3V

1.6V

27

RMLV8P

1.25V

1.3V

47

GMA10

7.93V

1.4V

VCC

3.3V

1.6V

28

RMLV7N

1.19V

1.3V

48

GMA12

6V

2.0V

29

RMLV7P

1.21V

1.3V

49

GMA13

5.18V

1.5V

Gnd

Gnd

Gnd

30

RMLV6N

1.2V

1.3V

50

GMA14

4.86V

1.4V

10

GMA1

14V

2.0V

31

RMLV6P

1.2V

1.3V

51

GMA15

3V

2.0V

11

GMA2

16V

1.4V

32

RMLV5N

1.19V

1.3V

52

GMA16

2.3V

1.4V

12

GMA3

14V

1.36V

33

RMLV5P

1.25V

1.3V

53

GMA17

1.3V

1.4V

13

GMA4

13.4V

2.0V

34

RMCLKN

1.25V

1.3V

54

GMA18

2.3V

2.0V

14

GMA5

12.3V

2.0V

35

RMCLKP

1.23V

1.3V

55

VCOM_R

7V

2.0V

15

GMA6

11.2V

1.4V

36

RMLV3N

1.21V

1.3V

56

n/c

n/c

n/c

16

GMA7

10.4V

2.0V

37

RMLV3P

1.26V

1.3V

17

GMA9

8.45V

2.0V

57

VGH

26V

Open

38

RMLV2N

1.19V

1.3V

18

GOE

0.6V

1.3V

58

Gnd

Gnd

Gnd

39

RMLV2P

1.26V

1.3V

19

GSP_Rev

0V

1.3V

59

VGL

(-5V)

0.925V

40

RMLV1N

1.22V

1.3V

20

GSC

1.6V

1.3V

60

Gnd

Gnd

Gnd

52

July 2009 LCD DV

42LH40

Main PWB Connector P1204 to (Ft. IR/LED Control) Voltage and Resistance
P1204 CONNECTOR "MAIN PWB" to P1 "Front IR / LED PWB Assy"
Pin

Label

STBY

Run

Diode Check

SCL

3.3V

3.3V

1.14V

SDA

3.3V

3.3V

1.14V

Gnd

Gnd

Gnd

Gnd

Key1

3.3V

3.3V

1.08V

Key2

3.3V

3.3V

1.08V

5V ST

5.1V

5.1V

1.13V

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

IR

4.8V

4.8V

Open

10

Gnd

Gnd

Gnd

Gnd

11

3.3V_ST

3.29V

3.29V

0.6V

12

POWER On/Off

0V

3.29V

2.17V

Diode Mode values taken with all Connectors Removed

53

July 2009 LCD DV

42LH40

Main PWB Connector P600 to Speakers Voltage and Resistance

P600 CONNECTOR "Main" to "Speakers"

Pin

LABEL

SBY

Run

Diode
Check

SPK-R(-)

0V

10.7V

1.5V

SPK-R(+)

0V

10.7V

1.5V

SPK-L(-)

0V

10.7V

1.5V

SPK-L(+)

0V

10.7V

1.5V

Use speaker out to test for defective Audio Amp IC600

Diode Mode values taken with all Connectors Removed

54

July 2009 LCD DV

42LH40

FRONT CONTROL (IR and INTELLIGENT SENSOR) SECTION


The Front Control PWB (located on the bottom left as viewed from the rear) contains the IR (Infrared
Remote Sensor) and the Intelligent Sensor plus the front Power LEDs.
This board also connects with the Side Key PWB.
This board receives it operating B+ via pin 6 (STBY 5V) and pin 11 (STBY 3.3V) on connector P1.
It is received from the Main PWB via the connector P1200.
The Intelligent Sensor communicates with the Video Processor IC100 via clock and data lines on the
same connector pins 1 and 2.
The IR pulses (5V p/p) are sent to the Microprocessor (same IC100) via pin 9.
The Key board connector P3000 is routed to the Ft control board via P2. Then through the front
Control board and out P2 to the Microprocessor via P1200 pins 4 and 5.
Finally, the front Power LEDs are controlled by pin 12 and pin 8.

55

July 2009 LCD DV

42LH40

FRONT CONTROL BOARD CONNECTIONS IDENTIFIED


The below picture shows the connections to the Front Control board.

p/n EBR59216901

Side
Key
P3000

P2
P1
Main Power
Switch
56

July 2009 LCD DV

42LH40

FRONT CONTROL (IR and INTELLIGENT SENSOR) IDENTIFIED


The Front Control PWB (located on the bottom left as viewed from the rear) contains the
IR (Infrared Remote Sensor) and the Intelligent Sensor plus the front Power LEDs.

Power LEDs
Light
Diffuser

Intelligent Sensor

Infrared Sensor

57

July 2009 LCD DV

42LH40

Ft. IR / LED Control Connector P1 and P2 Voltage and Diode Check


P1 CONNECTOR "Front IR / LED PWB Assembly " to P1204 " MAIN PWB "
Pin

Label

STBY

Run

Diode
Check

SCL

3.3V

3.3V

Open

SDA

3.3V

3.3V

Open

Gnd

Gnd

Gnd

Gnd

Key1

3.3V

3.3V

Open

Key2

3.3V

3.3V

Open

5V ST

5.1V

5.1V

1.13V

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

IR

4.8V

4.8V

Open

10

Gnd

Gnd

Gnd

Gnd

11

3.3V_ST

3.29V

3.29V

Open

12

POWER
On/Off

0V

3.29V

Open

P2 Connector to Side Key" P1


Pin

Label

STBY

Run

Key 1

3.3V

3.3V

Diode
Check
Open

Gnd

Gnd

Gnd

Gnd

Key 2

3.3V

3.3V

Open

Gnd

Gnd

Gnd

Gnd

Diode Mode values taken with all Connectors Removed

58

July 2009 LCD DV

42LH40

Side Key Assembly

SW3001
SW3002
SW3003
SW3004
SW3005
SW3006
SW3007
SW3008

P3000

To Ft Control

P3000

59

July 2009 LCD DV

42LH40

Side Key Assembly P3000 Voltage and Diode Check

P3000 Resistance Measurements with Key pressed.


KEY

Pin 1 measured
from Gnd

KEY

Pin 3 measured
from Gnd

Power

270.5 Ohms

Volume (-)

270.5 Ohms

Input

1.8K Ohms

Volume (+)

1.8K Ohms

Menu

4.8K Ohms

CH (Dn)

4.8K Ohms

Enter

10K Ohms

CH (Up)

10K Ohms

P3000 Voltage Measurements with Key pressed.


KEY

Pin 1 measured
from Gnd

KEY

Pin 3 measured
from Gnd

Power

0.179V

Volume (-)

0.179V

Input

0.906V

Volume (+)

0.906V

Menu

1.65V

CH (Dn)

1.65V

Enter

2.24V

CH (Up)

2.24V

P3000 Connector Side Key" to IR/LED Control PWB P1

c
P3000

Pin

Label

STBY

Run

Diode Check

Key1

3.3V

3.3V

Open

Gnd

Gnd

Gnd

Gnd

Key2

3.3V

3.3V

Open

Gnd

Gnd

Gnd

Gnd

60

July 2009 LCD DV

42LH40

Invisible Speaker System Overview (Full Range Speakers)


The 42LH40 contains the full progression of the Invisible Speaker system.
First: The woofer layout is the basic system. The Full Range Speakers point
downward, so there is no front viewable speaker grill or air ports.

Main Speaker
(Full Range Frequencies)

Tweeter
(High Frequencies)

Magnet (Weight)
Prevents vibrations

Tweeter
p/n EAB58536001

Full Range
p/n EAB58534502

61

July 2009 LCD DV

42LH40

Invisible Speaker System Overview (Tweeters)


2nd: Progression
Elimination of the
conventional
speaker.
Invisible Speaker has a
sticky surface which
adheres to front bezel.
WARNING: Removing the Tweeter will
destroy the speaker as shown above.
The diaphragm/spider is glued to the
front bezel. When removing, it will tear.

The front bezel is shown below. Note: the outlined


circle is the location for the front sticky pad on the
Invisible Speaker. This prevent the coil from
bouncing off the plastic causing vibrations.

Tweeter
p/n EAB58536001

Speaker
Attachment
post

Cabinet works as
a diaphragm.

Outlined
Circle

62

Invisible Speaker Tweeter


shown separately. The Front (down)
has sticky surface which adheres to
front bezel. Note, there is no
diaphragm, only voice coil.

July 2009 LCD DV

42LH40

Invisible Speaker System Overview


Invisible Speaker
Shown separately. Front
(to left) has sticky surface
which adheres to front
bezel. Note, there is no
Cone (Diaphragm), only
voice coil.

Mount
Speaker
Terminals
Spider
Speaker Wires

Dust Cap
with
adhesive

Magnet

Voice Coil
Inside
Frequency Pass
Capacitor

Mount

63

July 2009 LCD DV

42LH40

11 X 17 FOLDOUT SECTION

This section shows the 11X17 foldout thats available in the Paper
and Adobe version of the Training Manual.
The Adobe version of this Training Manual allows the viewer to
zoom in and out making reading of the small text easier.
This Power Point shows a graphical representation of the 11 X 17
foldout page so clarity is limited.

64

July 2009 LCD DV

42LH40

42LH40 INTERCONNECT DIAGRAM


TO TFT MODULE

SMPS TEST 1: To Force Power Supply On.


Disconnect P700 on Main PWB.
Jump pin 7,8,9 or 10 (5V) to pin 2 using a 100
resistor. (Test Voltage Outputs 12V, and 24V).
SMPS TEST 2: Jump pin 2 to pin 20 (INV-ON).
(Backlights and all voltages should turn on).
P201 SMPS" to P700 "Main PWB"
Pin

Label

STBY

Run

Diode
Check

24

2 PDIM

0V

3.2V

Open

23

nc

nc

nc

nc

SMPS
Switch Mode
Power Supply

23

24

16V Pin 42 IC1300


For Panel

P201
1

26V Pin 8 IC1300


For Panel

Err Out
1 A.DIM

0V

0V

Open

21

0V

1.66V

Open

-5V Anode D1401


For Panel

20

INV.ON

0V

3.8V

2.25V

3.3V Top Side of


L1301 For Panel

22

nc

nc

nc

nc

17,18

24V

0V

21.4V

0.81V

15,16

Gnd

Gnd

Gnd

Gnd

13,14

12V

0V

12.3V

1.2V

11,12

Gnd

Gnd

Gnd

Gnd

7,8,9,10

5V

5.14V

5.14V

2.85V

19

0V

nc

Gnd

Gnd
4.98V

nc

R406
R403

1.19V

nc

D1403
L1300

250V 82mF

Q703

D1400

IC704

P1200
IC706

L718

IC104

T704

Tuner

L607

D102
Q105

P600
F100

IC1003

SK101
AC IN

IC601
IC1002

Q1100
P1100
Software
Upgrades
N/C

L712 IC707

IC1000
IC1001

X100
12 Mhz
IC103

Q1202
IC600

T703

IC708

D1204

L606

SK100

IC101 Q100

IC102

IC702

1.2KV
P401

IC1100
Video
Processor
Tru-Motion
IC300

IC100
Micro and
Video
Processor
Mstar

IC1
IC105

1.2KV

R406 / R403
Bottom leg
48Khz
53V p/p

IC301

X1100
12 Mhz

Q706

F100
6.3A/250V
AC IN

P402

IC2

L710

Q705 Q704

D1100

IC1101

L726
IC701

Q701

nc

1 ADIM Pin 21 Fixed and not used


2
PDIM Pin 24 can vary according to type of signal
being processed and the OSD Backlight setting.
0.6V 0% to 3.3V 100%. Output from the IC100.

P1400

P1401

IC705

IC1300

P700

250V 82mF

PWR-On

Q702

3.15A/250V
Run 380V
STBY 157V
From Hot Gnd

Pin 2 (-5V)
Pin 4 (26V)

L1301

250V 82mF

250V 82mF

Gnd

Pin 56,57,58 (16V)


Pin 53,54 (3.3V)
IC1301

D1401

Gnd

Pin 3,4,5 (16V)


Pin 7,8 (3.3V)

D1402

0
F5

3,4,5,6

Pin 59 (-5V)
Pin 57 (26V)

Q106

Video Reset
SW1100
IC1201

IC502
IC501

Q600
Micro Reset
SW100

IC1200

D500

IC1203

D1223

IC1202

X1005
25Mhz

LD1100
IC1004
8vsb/
QAM
LD1000

TUNER TU1001
Q1001
Video 19
SIF 16
(5V) 15
DIF - 13
DIF + 12

Q1000

P1204 CONNECTOR "MAIN PWB" to J1 "Front IR / LED PWB


Label

STBY

Run

Diode Check

SCL

3.3V

3.3V

Open

SDA

3.3V

3.3V

1.67V

Gnd

Gnd

Gnd

Gnd

Key1

3.3V

3.3V

1.4V

Key2

3.3V

3.3V

1.1V

5V ST

5.1V

5.1V

1.5V

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

Gnd

IR

4.8V

4.8V

Open

10

Gnd

Gnd

Gnd

Gnd

11
12

3.29V 3.29V
3.3V_ST
POWER On/Off
0V
3.29V

Side (Key) Controls

Pin

P3000

MAIN (Digital) Board

Q1200

Components that are Grayed out are on the back.

(5V) 4
1

P1

P2

Front PWB
Assembly
IR Receiver
Intelligent Sensor

0.76V
Open

Main Power SW

Component Voltage on Next Page


P2 "Front IR / LED PWB to P3000 Keys
Pin Label STBY Run
1
2
3
4

Key1
Gnd
Key2
Gnd

3.3V
Gnd
3.3V
Gnd

3.3V
Gnd
3.3V
Gnd

Diode
Check
Open
Gnd
Open
Gnd

42LH40 MAIN (BACK SIDE) SIMICONDUCTORS


Q1000
Pin
E
C
B

Tuner SIF
2.4V
0V
3.0V

Q1001
Pin
E
C
B

Tuner Video
analog
2.5V
0V
3.2V

IC1201
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]

RS232

IC1200

HDMI
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC1101

3.3V
5.6V
0V
0V
5.5V
5.5V
5.5V
0V
3.3V
3.26V
0V
3.3V
0V
5.6V
Gnd
3.3V

Gnd
Gnd
Gnd
Gnd
4.8V
4.8V
4.8V
4.8V

Q1202

Moving LED
Pin
Driver
E 0.1V
C 0V
B 3.3V

Q703

9V Reg
for Tuner
12.3V
8.9V
Gnd

Q704

IC1003
Pin
[1]
[2]
[3]

Pin
E
C
B

Turns on 5V
General Q706
0V
0V
0.62V

IC702

STBY 3.3V
Pin
[1] Gnd
[2] 3.3V
[3] 5.1V

Gnd
Gnd
Gnd
Gnd
3.25V
3.25V
0V
3.25V

D1403

Audio Mute
Pin
E 0.1V
C 3.2V
B 0V

PWR-On to
Pin P700 pin 2
E 5.12V
C
E C 4.99V
B
B 3.07V
Turned on by Q700

Q705
Pin
E
C
B

Turns on LVDS
12V Q706
0V
0V
0.66V

Q701

Q702
Pin
E
C
B

INV-On to
P700 pin 20
0V
3.8V
0V

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Flash Boot
Memory
0V
3.2V
2.5V
Gnd
0V
0V
3.2V
3.2V

HDCP EEPROM
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Gnd
Gnd
5.05V
Gnd
5.05V
5.05V
3.25V
3.25V

Pin
[1]
[2]
[3]

Power Det
Reset
0.0V
3.3V
3.2V

Pin
A
K
A

Audio Mute
Routing
0V
0.1V
0V

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

5V EXT
1.8V MEMC
0.8V
Gnd
4.9V
6.5V
4.84V
1.8V
1.8V
4.83V

D102

SPDIF Optic
Pin
[1]
[2]
[3]
[4]
[5]

LD1100 Driver
Pin
S G G 0.29V
D 2.9V
S 0V
D

IC107
IC105

LVDS 16V
Pin Source
A 12.2V
K 16.6V

IC1203

IC1100
Q600

0V
1V
3.26V
Gnd
0V
0.1V
3.26V
3.26V

EEPROM
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Turns on
Pin
Q705
E 0V
C 0V
B 0.62V

Flash
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC104

3.25V
3.24V
Gnd
1.6V
3.25V

42LH40 MAIN (FRONT SIDE) SIMICONDUCTORS


IC701

1.8V DDR
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC704

n/c
3.2V
3.2V
n/c
n/c
1.8V
0.79V
Gnd
3.3V Reg

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

0.79V
Gnd
5V
7.7V
4.9V
3.3V
3.3V
2.1V

Pin
A
J
K

LVDS 16V
Source
14.7V
20V
27V

D1400

IC705

3.3V / 1.26V
0.8V
Gnd
5V
6.12V
4.99V
1.3V
1.3V
3.19V
5V General
LVDS 12V
5.1V
Gnd
12V
0.67V
12V
12V
5V
5V

IC708

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

D1402

Pin
A
J
K

LVDS (-5V)
Source
(-5V)
(-2.38V)
Gnd

Q706

D1401
A

K
J

IC101

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC103

Q105

Reset
Pin
[1] Gnd
[2] 0V
[3] 3.3V
Power On
Pin
Delay
E Gnd
B 0V
C 1.96V

3.3V Reg
Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

IC601
Q106

Gnd
0.79V
1.26V
1.26V
1.8V
5V
0V
5V

LVDS 3.3V
Pin Source
A Gnd
K 3.3V

IC707

Reset
Pin
E Gnd
B 0V
C 3.3V

IC1001

3.3V FE
Pin
[1]
[2]
[3]
[4]
[5]

4.9V
4.9V
Gnd
3.36V
1.19V

Pin
[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]

Flash Boot
Memory
0V
3.36V
3.36V
n/c
n/c
1.19V
0.79V
Gnd

IC1000

1.8V Amp
Pin
[1] Gnd
[2] 1.8V
[3] 3.3V

IC1002

D1204
Pin
A
K
A

LED Moving
Ft LED
0V
0.14V
0V

5V for Tuner
Pin
[1]
[2]
[3]
[4]
[5]

8.9V
1.93V
5V
n/c
Gnd

D1100

LD1100 (Q1100) D1223


B+ Routing
Pin Gate
Pin RGB
A 0V
A 5.1V
K 0.33VV
K 4.8V
A 0V

42LH40
Direct View LCD
This concludes the 42LH40
training session.

Das könnte Ihnen auch gefallen