Beruflich Dokumente
Kultur Dokumente
34-SAMSS-611
20 March 2013
Scope............................................................. 2
Design............................................................ 3
Material........................................................... 4
12
Shipment (Addition)........................................ 5
Page 1 of 8
Scope
This specification together with Buyer's Quotation Request or purchase order and
Specification Sheet(s) SA-8020-611-ENG define the minimum technical requirements
for conventional and balanced type industrial safety relief valves.
API STD 526 is modified, as indicated in this specification, to cover requirements for
pressure relief valves that have threaded connections.
The following paragraph numbers refer to API STD 526, Sixth Edition, April 2009,
which is a part of this specification. The text in each paragraph below is an addition,
exception, modification, or deletion to API STD 526 as noted. Paragraph numbers not
appearing in API STD 526 are new paragraphs to be inserted in numerical order.
2
References (Addition)
Material or equipment supplied to this specification shall comply with the latest
edition of the references listed below unless otherwise noted.
Saudi Aramco Documents
Saudi Aramco Engineering Procedure
SAEP-302
Page 2 of 8
ASME B16.5
ASTM E18
1.5
1.6
Design
7.1
Page 3 of 8
Vessel Code and shall carry the appropriate stamp, including those for liquid
services.
7.3
7.4
Dimensions (Addition)
Dimensions for threaded pressure relief valves shall be per manufacturers
specification.
Threaded connections shall comply with ANSI B1.20.1.
7.6
Material
3.1
General (Addition)
In sour service all wetted parts, welds and heat affected zones of welds exposed
to corrosive components shall meet the hardness and heat treatment
requirements as specified in NACE MR0175/ISO 15156. This includes material
under overlays, platings or coatings.
3.2
tested. Components or base metal shall be tested on a heat lot basis. Test results shall
be traceable to Purchase Order line items.
9.4
9.5
9.6
a)
b)
Verification of the identification name plate for compliance with the data
of Appendix B.
c)
12
Shipment (Addition)
Export packing, marking and shipping shall be in accordance with the requirements of
the Purchase Order.
Threaded openings shall be plugged with suitable protective devices. Temporary plugs
should be readily distinguishable from permanent metal plugs.
Page 5 of 8
Inlet and outlet flanges shall be protected to prevent damage from or entrance of foreign
material during shipment.
20 March 2013
Revision Summary
Revised the Next Planned Update. Reaffirmed the contents of the document, and reissued
with editorial changes.
Page 6 of 8
Page 7 of 8
Page 8 of 8