Beruflich Dokumente
Kultur Dokumente
Instructions
2YHUWKH5DQJH
0LFURZDYH2YHQ
AVM4160, JNM3161, JVM3160,
and RVM5160
IMPORTANT
Save these
instructions for local inspectors use.
Cooking
Convenience
Beve
rage
Beverage
orn
Popc
Popcorn
st
Defro
Defrost
at
Rehe
Reheat
t/Time
Weigh
Weight/Time
Pota
to
Potato
Cook
Cook
Time
Time
Time
Timerr
k
Express Coo
Add
Add
30
Sec.
30 Sec.
Turn
table
Turntable
ce
Surfa
Surface
Light
Light
Powe
Powerr
Level
Level
Set
Set
Clock
Clock
Vent
Vent
Cancel
Off
Off
On/Off
On/Off
Start
Pause
Pause
READ CAREFULLY.
KEEP THESE INSTRUCTIONS.
Installation Instructions
C Outside Back Exhaust.................................. 21-24
CONTENTS
General information
Important Safety Instructions........................................ 3
'DPDJH6KLSPHQW,QVWDOODWLRQ .................................. 7
Parts Included ................................................................... 7
0RXQWLQJ6SDFH ................................................................ 8
%HIRUH<RX8VH<RXU0LFURZDYH2YHQ ..................... 25
6WHSE\VWHSLQVWDOODWLRQJXLGH
3ODFHPHQWRI0RXQWLQJ3ODWH ................................... 9-11
Removing the Mounting Plate ............................. 9
Finding the Wall Studs.......................................... 9
Determining Mounting Plate Location ..............10
Aligning the Mounting Plate .............................. 11
Installation Types ..................................................... 12-23
Installation Instructions
IMPORTANT SAFETY INSTRUCTIONS
A qualified electrician must perform a ground continuity
check on the wall receptacle before beginning the
installation to ensure that the outlet box is properly
grounded. If not properly grounded, or if the wall
receptacle does not meet electrical requirements noted
(under ELECTRICAL REQUIREMENTS), a qualified electrician
should be employed to correct any deficiencies.
:KHUHDVWDQGDUGWZRSURQJZDOOUHFHSWDFOHLV
encountered, it must be replaced with a properly
JURXQGHGWKUHHSURQJZDOOUHFHSWDFOHLQVWDOOHGE\D
qualified electrician.
WARNING:
WARNING:
5LVNRI(OHFWULF6KRFN
Can cause injury or death:
5HPRYHKRXVHIXVHRU
RSHQFLUFXLWEUHDNHUEHIRUH
EHJLQQLQJLQVWDOODWLRQWRDYRLG
VHYHUHRUIDWDOVKRFNLQMXU\
CAUTION:
CAUTION:
WARNING:5LVNRI(OHFWULF6KRFN
CAUTION:
120 V Models
Ensure proper
ground exists
before use.
5LVNRI(OHFWULF6KRFN
Can cause injury or death: DO NOT, under any
FLUFXPVWDQFHVFXWGHIRUPRUUHPRYHDQ\RIWKHSURQJV
from the power cord. Do not use with an extension cord.
Failure to comply may cause fire.
7RDYRLGWKHULVNRISHUVRQDO
LQMXU\EDFNLQMXU\RURWKHULQMXULHVGXHWRH[FHVVLYH
ZHLJKWRIWKHPLFURZDYHRUSURSHUW\GDPDJH\RXZLOO
QHHGWZRSHRSOHWRLQVWDOOWKLVPLFURZDYH
ELECTRICAL REQUIREMENTS
120 V Models
Installation Instructions
TOOLS YOU WILL NEED
#1 and #2 Phillips
screwdriver
Pencil
Carpenter square
(optional)
Stud finder
3 16
Gloves
Safety goggles
7 16
Level
Hammer (optional)
Installation Instructions
HOOD EXHAUST
NOTE: 5HDGWKHVHQH[WWZRSDJHVRQO\LI\RXSODQWRYHQW\RXUH[KDXVWWRWKHRXWVLGH,I\RXSODQWRUHFLUFXODWHWKHDLU
EDFNLQWRWKHURRPSURFHHGWRSDJH6.%HORZDUHH[DPSOHVRI2XWVLGH7RS([KDXVWDQG2XWVLGH%DFN([KDXVWGXFWV\VWHP
OD\RXWV1RWHWKHSRVLWLRQRIWKHPLFURZDYHRYHQUHODWLYHWRWKHGXFWV\VWHP
2876,'(723(;+$867(;$03/(21/<
The following chart describes an example of one possible
ductwork installation.
EQUIVALENT
LENGTH x
NUMBER
USED
=
EQUIVALENT
LENGTH
Roof Cap
24 Ft.
(1)
24 Ft.
12 Ft.
(1)
12 Ft.
Rectangular-to-Round
Transition Adaptor*
5 Ft.
(1)
5 Ft.
DUCT PIECES
)W
*IMPORTANT: If a rectangular-to-round transition adaptor is used, the bottom corners of the damper will
have to be cut to fit, using the tin snips, in order to allow free movement of the damper.
2876,'(%$&.(;+$867(;$03/(21/<
The following chart describes an example of one possible
ductwork installation.
EQUIVALENT
LENGTH*
x
NUMBER
USED
=
EQUIVALENT
LENGTH
40 Ft.
(1)
40 Ft.
(1)
3 Ft.
90 Elbow
(2)
20 Ft.
DUCT PIECES
Wall Cap
10 Ft.
)W
NOTE: For back exhaust, care should be taken to align exhaust with space between studs, or wall should be prepared
at the time it is constructed by leaving enough space between the wall studs to accommodate exhaust.
Installation Instructions
NOTE: If you need to install ducts, note that the total duct
length of 314s x 10s rectangular or 6s diameter round duct
VKRXOGQRWH[FHHGHTXLYDOHQWIHHW
Outside ventilation requires a HOOD EXHAUST DUCT.
Read the following carefully:
NOTE: It is important that venting be installed using
the most direct route and with as few elbows as possible.
This ensures clear venting of exhaust and helps prevent
blockages. $OVRPDNHVXUHGDPSHUVVZLQJIUHHO\DQG
QRWKLQJLVEORFNLQJWKHGXFWV
0D[LPXPGXFWOHQJWK
For satisfactory air movement, the total duct length of
314s x 10s rectangular or 6s diameter round duct should
QRWH[FHHGHTXLYDOHQWIHHW
Exhaust connection:
The hood exhaust has been designed to mate with
a standard 314s x 10s rectangular duct.
If a round duct is required, a rectangular-to-round
transition adaptor must be used. Do not use less than
a 6s diameter duct.
EQUIVALENT
LENGTH
NUMBER
USED
Rectangular-to-Round
Transition Adaptor*
5 Ft.
Ft.
Wall Cap
40 Ft.
Ft.
90 Elbow
10 Ft.
Ft.
45 Elbow
5 Ft.
Ft.
90 Elbow
25 Ft.
Ft.
45 Elbow
5 Ft.
Ft.
Roof Cap
24 Ft.
Ft.
1 Ft.
Ft.
DUCT PIECES
7RWDO'XFWZRUN
EQUIVALENT
LENGTH
)W
Installation Instructions
PARTS INCLUDED
'$0$*(6+,30(17
INSTALLATION
ADDITIONAL PARTS
PART
,IWKHXQLWLVGDPDJHGLQVKLSPHQW return
the unit to the store in which it was bought for
repair or replacement.
,IWKHXQLWLVGDPDJHGE\WKHFXVWRPHU repair or
replacement is the responsibility of the customer.
,IWKHXQLWLVGDPDJHGE\WKHLQVWDOOHU (if other than
the customer), repair or replacement must
be made by arrangement between customer
and installer.
Rear Wall
Template
INSTALLATION
INSTRUCTIO OW
NS N
MA ER
NU S
AL
HARDWARE PACKET
QUANTITY
Wood Screws
(3/16 x 2)
Top Cabinet
Template
PARTS INCLUDED
PART
QUANTITY
Installation
Instructions
and
Owners
Manual
1
1
Self-aligning Machine
Screw (1/4-28 x
3-1/4)
Grease
Filters
Exhaust
Adaptor
Tray
Turntable
Ring
Charcoal
Filter
(on some
models)
1*
* NOTE:
)RU-90DQG$90, filter is in accessory pack.
It is not installed in the product.
)RU-10filter is already installed in the product.
)RU590 filter not included.
Installation Instructions
MOUNTING SPACE
12s
max.
16-s
30s
2s
30s
min.
Bottom edge of
cabinet needs to
be 30s or more
from the cooking
surface
Backsplash
66s or
more from
the floor
to the
top of the
microwave
oven
NOTES:
The space between the cabinets must be 30s wide
and free of obstructions.
If the space between the cabinets is greater than
30s, a Filler Panel Kit may be used to fill in the gap
between the microwave oven and the cabinets.
Your Owners Manual contains the kit number for
your model.
This microwave oven is for installation over ranges
up to 36s wide.
If you are going to vent your microwave oven to the
outside, see Hood Exhaust Section for exhaust duct
preparation.
When installing the microwave oven beneath
smooth, flat cabinets, be careful to follow the
instructions on the top cabinet template for power
cord clearance.
0D[LPXPFDELQHWGHSWKDERYHDQGEHVLGHWKHXQLW
is 12s.
)RUPRGHOVVHWXSLQ5HFLUF([KDXVW'RQRWDOORZ
cabinetry or other objects to block the airflow of the
vent.
7KHSURGXFWVKRXOGQRWEHLQVWDOOHGRYHUDQ\FRRNWRS
or range with a combined BTU greater than 60,000
BTU.
Installation Instructions
1 PLACEMENT OF THE MOUNTING PLATE
A REMOVING THE MICROWAVE
29(1)5207+(&$5721
REMOVING THE MOUNTING PLATE
1 Open the box and fold back all four carton flaps fully
against the carton sides. Remove the following items
from the protective foam: installation instructions,
filters, exhaust adaptor, damper, and the small
hardware bag. Do not remove the foam protecting
the front of the microwave oven.
Wall
Studs
Center
Carton
Foam
Installation Instructions
C
Mounting Plate
Tabs Touching the
Back Frame of the
Cabinet
30s to Cooktop
3ODWH3RVLWLRQFDELQHWZLWKIURQWRYHUKDQJ
Mounting Plate
with Tabs Below
Cabinet Bottom
the Same Distance
as the Front
Overhang Depth
30s to Cooktop
10
Installation Instructions
D ALIGNING THE MOUNTING PLATE
30
Hole B
Draw a
Vertical Line
on Wall from
Center of Top
Cabinet
Hole A
Hole D
Hole C
Area E
CAUTION:
Notch
:HDUJORYHVWRDYRLGFXWWLQJ
ILQJHUVRQVKDUSHGJHV
1 Draw a vertical line on the wall at the center of the 30s
wide space.
2 Use the mounting plate as the template for the rear wall.
Place the mounting plate on the wall, making sure that
the tabs are WRXFKLQJWKHERWWRPRIWKHFDELQHWRU
WKHOHYHOOLQHGUDZQLQ6WHS&IRUFDELQHWVZLWKIURQW
RYHUKDQJ/LQHXSWKHQRWFKDQGFHQWHUOLQHRQ
WKHPRXQWLQJSODWHWRWKHFHQWHUOLQHRQWKHZDOO
3 While holding the mounting plate with one hand, draw
circles on the wall at holes A, B, C, and D (see illustration
above/actual plate marked with arrows). Four holes
PXVWEHXVHGIRUPRXQWLQJ
6HWWKHPRXQWLQJSODWHDVLGH
WARNING:
5LVNRIHOHFWULFVKRFN&DQFDXVH
LQMXU\RUGHDWK7DNHFDUHWRQRWGULOOLQWRHOHFWULFDOZLULQJ
inside walls or cabinets.
4 Drill holes on the circles. If there is a stud, drill a 316s hole
for wood screws. For holes that dont line up with a stud,
drill a 58s hole for toggle bolts.
NOTE: DO NOT MOUNT THE PLATE AT THIS TIME.
11
Installation Instructions
2 INSTALLATION TYPES
&KRRVH$%RU&
127(6HOHFWWKHW\SHRIYHQWLODWLRQUHTXLUHGIRU\RXU
installation and proceed to that section.
RECIRCULATING
1219(17(''8&7/(66
Cooking
Convenience
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Convenience
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Set
Clock
Power
Level
Cancel
Off
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Vent
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Start
Pause
Off
6HHSDJH
6HHSDJH
Cooking
Convenience
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Cancel
Off
6HHSDJH
12
Start
Pause
Add
30 Sec.
Cancel
Cooking
Beverage
Popcorn
Start
Pause
Installation Instructions
A RECIRCULATING
1RQ9HQWHG'XFWOHVV
INSTALLATION OVERVIEW
A1. Attach Mounting Plate to Wall
A2. Prepare Top Cabinet
A3. Adjust Blower Motor
A4. Install Charcoal Filter
A5. Mount the microwave oven
A6. Installing/Replacing the Charcoal Filter Without
Access to Top Screws and the Unit Has Already
Been Mounted.
Convenience
Cooking
Beverage
Popcorn
Defrost
Potato
Cook
Time
Weight/Time
Reheat
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
8
0
Set
Clock
Vent
Power
Level
Cancel
Off
Start
Pause
CAUTION:
%HFDUHIXOWRDYRLGSLQFKLQJ
ILQJHUVEHWZHHQWKHEDFNRIWKHPRXQWLQJSODWHDQG
the wall.
4 Tighten all bolts. Pull the plate away from the wall
to help tighten the bolts.
7RXVHWRJJOHEROWV:
Spacing for Toggles More
Than Wall Thickness
Toggle Wings
Mounting
Plate
Toggle
Bolt
Wall
Bolt End
CAUTION:
:HDUVDIHW\JRJJOHVZKHQ
GULOOLQJKROHVLQWKHFDELQHWERWWRP
13
Installation Instructions
A3 ADJUST BLOWER MOTOR
A3 $'-867%/2:(502725FRQW
Fan Blades
Wires
Back of
Mircrowave
Blower Plate
Blower
Motor
Screw
Back of
Mircrowave
WARNING:
5LVNRI(OHFWULF6KRFN
Can cause injury or death. Do not pull or stretch the
EORZHUXQLWZLULQJ0DNHVXUHWKHZLUHVDUHQRW
pinched.
4 Slide the blower plate back onto the microwave
by placing the side tabs into the slots and pushing
gently until the back tab is seated into the rear slot.
Replace 3 screws.
Side Tab
Rear Tab
Side Slot
14
Rear Slot
Installation Instructions
A4 INSTALLING THE CHARCOAL FILTER
CAUTION:
7RDYRLGWKHULVNRISHUVRQDO
LQMXU\EDFNLQMXU\RURWKHULQMXULHVGXHWRH[FHVVLYH
ZHLJKWRIWKHPLFURZDYHRUSURSHUW\GDPDJH\RX
ZLOOQHHGWZRSHRSOHWRLQVWDOOWKLVPLFURZDYH
Convenience Cooking
Popcorn
Beverage
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
Express Cook
On/Off
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Cancel
Start
Off
Pause
WARNING:
5LVNRI(OHFWULF6KRFN&DQ
FDXVHLQMXU\RUGHDWK,ILQVWDOOLQJXQLWZLWKPHWDO
FRXQWHUWRSVFRYHUWKHHGJHRIWKHSRZHUVXSSO\
FRUGKROHZLWKWKHSRZHUVXSSO\FRUGEXVKLQJ
4 Insert the top of the filter up and into the grooves on
both sides of the inside of the top opening. Once you
have cleared the bottom tab, push the bottom of the
filter in until it rests in place behind the tab.
Grooves in
Microwave for
Filter on Each Side
Power Cord
Bottom Tab
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Grille
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
Grille
Ensure bottom
tabs are seated
as shown.
15
Installation Instructions
A5 MOUNT THE MICROWAVE OVEN
FRQW
A6 , 167$//,1*5(3/$&,1*7+(
CHARCOAL FILTER WITHOUT
ACCESS TO TOP SCREWS AND THE
UNIT HAS ALREADY BEEN MOUNTED
1
1
3 Insert 3 self-aligning screws ( 4s-28 x 2 4) through
outer top cabinet holes. Turn two full turns on each
screw.
Cabinet Front
Cabinet Bottom Shelf
Filler Block
Equivalent
to Depth
of Cabinet
Recess
This distance
can NOT
exceed 2
to ensure
proper
installation
CAUTION:
7RDYRLGWKHULVNRISHUVRQDO
LQMXU\EDFNLQMXU\RURWKHULQMXULHVGXHWRH[FHVVLYH
ZHLJKWRIWKHPLFURZDYHRUSURSHUW\GDPDJH\RXZLOO
QHHGWZRSHRSOHWRXQLQVWDOOWKLVPLFURZDYH
Self-Aligning Screw
Microwave Oven Top
WARNING:
5LVNRI(OHFWULF6KRFN&DQ
FDXVHLQMXU\RUGHDWK,IUHPRYLQJXQLWZLWKPHWDO
FRXQWHUWRSVFRYHUWKHHGJHRIWKHSRZHUVXSSO\FRUG
KROHZLWKWKHSRZHUVXSSO\FRUGQ\ORQJURPPHW
IMPORTANT: If filler blocks are not used, case damage
may occur from overtightening screws.
Conveni
ence Cooking
Potato
Beverage
Popcorn
Defrost
Cook
Time
Weight/Time
Reheat
Timer
On/Off
Express
Power
Level
Cook
3
6
9
Set
Clock
Add
30 Sec.
Turntable
Surface
Light
Vent
Start
Cancel
Pause
Off
ce Cooking
Convenien
Potato
Beverage
Popcorn
Defrost
Cook
Time
Weight/Time
Reheat
Timer
On/Off
Express
7
Power
Level
8
0
Cook
3
6
9
Set
Clock
Add
30 Sec.
Turntable
Surface
Light
Vent
Start
Cancel
Pause
Off
Convenience
Popcorn
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
16
Installation Instructions
B OUTSIDE TOP EXHAUST
9HUWLFDO'XFW
INSTALLATION OVERVIEW
B1. Attach Mounting Plate to Wall
B2. Prepare Top Cabinet
B3. Adjust Blower Motor
B4. Install Exhaust Adaptor
B5. Mount Microwave Oven
B6. Connect Ductwork
Convenience
Cooking
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Cancel
Off
Pause
7RXVHWRJJOHEROWV:
Spacing for Toggles More
Than Wall Thickness
Start
Mounting
Plate
Toggle Wings
Toggle
Bolt
Wall
Mounting Plate
C
Bolt End
3 Insert the toggle wings into the holes in the wall and
place the mounting plate against the wall.
NOTE: Before tightening toggle bolts and wood screw,
make sure the tabs on the mounting plate touch the
bottom of the cabinet when pushed flush against the
wall and that the plate is properly centered under the
cabinet.
CAUTION:
%HFDUHIXOWRDYRLGSLQFKLQJ
ILQJHUVEHWZHHQWKHEDFNRIWKHPRXQWLQJSODWHDQG
the wall.
4 Tighten all bolts. Pull the plate away from the wall
to help tighten the bolts.
17
Installation Instructions
B3 $'-867%/2:(502725FRQW
Rotate 90
Back of
Mircrowave
Wires
Back of
Mircrowave
CAUTION:
:HDUVDIHW\JRJJOHVZKHQ
GULOOLQJKROHVLQWKHFDELQHWERWWRP
WARNING:
5LVNRI(OHFWULF6KRFN
Can cause injury or death. Do not pull or stretch the
EORZHUXQLWZLULQJ0DNHVXUHWKHZLUHVDUHQRW
pinched.
Side Tab
Rear Tab
Blower
Motor
Screw
Side Slot
18
Rear Slot
Installation Instructions
B5 MOUNT THE MICROWAVE OVEN
Blower
Plate
Damper
CAUTION:
7RDYRLGWKHULVNRISHUVRQDO
LQMXU\EDFNLQMXU\RURWKHULQMXULHVGXHWRH[FHVVLYH
ZHLJKWRIWKHPLFURZDYHRUSURSHUW\GDPDJH\RX
ZLOOQHHGWZRSHRSOHWRLQVWDOOWKLVPLFURZDYH
WARNING:
5LVNRI(OHFWULF6KRFN&DQ
FDXVHLQMXU\RUGHDWK,ILQVWDOOLQJXQLWZLWKPHWDO
FRXQWHUWRSVFRYHUWKHHGJHRIWKHSRZHUVXSSO\
FRUGKROHZLWKWKHSRZHUVXSSO\FRUGEXVKLQJ
IMPORTANT: If filler blocks are not used, case damage
may occur from overtightening screws.
NOTE: When mounting the microwave, thread power
cord through hole in bottom of top cabinet. Keep it
tight throughout Steps 13. Do not pinch cord or lift
microwave oven by pulling cord.
1 Lift microwave, tilt it forward, and hook slots at
back bottom edge onto four lower tabs of mounting
plate.
Power Cord
Convenience
Popcorn
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
19
Installation Instructions
B6 CONNECTING DUCTWORK
House Duct
Convenience
Cooking
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Off
ience
Conven
Cancel
Start
Pause
g
Cookin
Beverag
Popcorn
Defrost e
Weight/Tim
Reheat
Potato
Cook
Time
Timer
On/Off
s Cook
Expres
1
4
7
Power
Level
2
5
8
0
3
6
9
Set
Clock
Add
30 Sec.
Turntab
le
Surface
Light
Vent
Start
Cancel
Pause
Off
This distance
can NOT
exceed 2
to ensure
proper
installation
Self-Aligning Screw
Microwave Oven Top
20
Installation Instructions
C OUTSIDE BACK EXHAUST +RUL]RQWDO'XFW
INSTALLATION OVERVIEW
C1. Prepare Rear Wall
C2. Attach Mounting Plate to Wall
C3. Prepare Top Cabinet
C4. Adjust Blower
C5. Mount the Microwave Oven
Cooking
Convenience
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Cancel
Off
Start
Pause
21
Installation Instructions
C2 ATTACH THE MOUNTING PLATE
TO THE WALL cont
7RXVHWRJJOHEROWV
Mounting
Plate
Wall
Bolt
End
CAUTION:
%HFDUHIXOWRDYRLGSLQFKLQJ
ILQJHUVEHWZHHQWKHEDFNRIWKHPRXQWLQJSODWHDQG
the wall.
4 Tighten all bolts. Pull the plate away from the wall
to help tighten the bolts.
Screw
Fan Blades
Wires
Back of Microwave
CAUTION:
:HDUVDIHW\JRJJOHVZKHQ
GULOOLQJKROHVLQWKHFDELQHWERWWRP
Back of mircrowave
22
Installation Instructions
C4 ADAPTING BLOWER FOR
OUTSIDE BACK EXHAUSTcont.
6 Gently place the fan back into the cavity with the
exhaust portion of the fan at the top and facing the
back of the unit.
CAUTION:
7RDYRLGWKHULVNRISHUVRQDO
LQMXU\EDFNLQMXU\RURWKHULQMXULHVGXHWRH[FHVVLYH
ZHLJKWRIWKHPLFURZDYHRUSURSHUW\GDPDJH\RX
ZLOOQHHGWZRSHRSOHWRLQVWDOOWKLVPLFURZDYH
IMPORTANT: Do not grip or use handle during
installation.
WARNING:
5LVNRI(OHFWULF6KRFN&DQ
FDXVHLQMXU\RUGHDWK,ILQVWDOOLQJXQLWZLWKPHWDO
FRXQWHUWRSVFRYHUWKHHGJHRIWKHSRZHUVXSSO\
FRUGKROHZLWKWKHSRZHUVXSSO\FRUGEXVKLQJ
Screw
Slide
exhaust
adaptor into
guides on
microwave
oven rear.
Damper
(hinge side up)
Power Cord
Exhaust
Adaptor
Locking
Tabs
Back of
Microwave
Oven
Convenience
Popcorn
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
Side Slot
Rear Slot
23
Installation Instructions
C5 MOUNT THE MICROWAVE OVEN
FRQW
3 Insert a self-aligning screw through top-center
cabinet hole. Temporarily secure the microwave
oven by turning the screw at least two full
turns after the threads have engaged. (It will be
completely tightened later.) Insert 2 self-aligning
screws (14s-28 x 2 14s) through outer top cabinet
holes. Turn two full turns on each screw.
nience
Conve
Popcor
ng
Cooki
ge
Bevera
t
Defrosime
Potato
Cook
Time
Weight/T
Reheat
Timer
On/Off
ss Cook
Expre
1
4
7
Power
Level
l
Cance
2
5
8
0
3
6
9
Set
Clock
Add
30 Sec.
ble
Turnta
e
Surfac
Light
Vent
Start
Pause
Off
Cabinet Front
Cabinet Bottom Shelf
Filler Block
Equivalent
to Depth
of Cabinet
Recess
This distance
can NOT
exceed 2
to ensure
proper
installation
Self-Aligning Screw
Microwave Oven Top
24
Installation Instructions
BEFORE YOU USE YOUR MICROWAVE OVEN
1
Ensure proper
ground exists
before use.
25
Installation Instructions
Printed in China
26
Instrucciones
de Instalacin
ANTES DE COMENZAR
Lea estas instrucciones en su totalidad y
atentamente.
IMPORTANTE
Conserve estas
instrucciones para uso del inspector local.
IMPORTANTE
ing
Cookking
Convenience Coo
Beve
rage
Beverage
orn
Popc
Popcorn
st
Defro
Defrost
at
Rehe
Reheat
t/Time
Weigh
Weight/Time
Pota
to
Potato
Cook
Cook
Time
Time
Time
Timerr
k
Cook
Express Coo
Add
Add
30
Sec.
30 Sec.
Turn
table
Turntable
ce
Surfa
Surface
Light
Light
Powe
Powerr
Level
Level
Set
Set
Clock
Clock
Vent
Vent
Cancel
Off
Off
On/Off
On/Off
Start
Pause
Pause
LEER DETENIDAMENTE.
CONSERVE ESTAS INSTRUCCIONES.
Instrucciones de Instalacin
C Escape de Salida Trasero ............................ 21-24
CONTENIDOS
Informacin General
Instrucciones Importantes de Seguridad .................... 3
'DxR(QYtR,QVWDODFLyQ .............................................. 7
3DUWHV,QFOXtGDV ................................................................ 7
*XtDGHLQVWDODFLyQSDVRDSDVR
Colocacin de la Placa de Montaje ..........................9-10
Retiro de la Placa de Montaje ............................. 9
Bsqueda de los Montajes de Pared .................. 9
Determinacin de la Placa de Montaje ............ 10
Alineacin de la Placa de Montaje.................... 11
Tipos de Instalacin ................................................. 12-23
Instrucciones de Instalacin
INSTRUCCIONES IMPORTANTES DE SEGURIDAD
Un electricista calificado deber realizar un control de
la continuidad de la conexin a tierra en el receptculo
de la pared antes de comenzar con la instalacin, a
fin de asegurar que la caja del tomacorriente est
correctamente conectada a tierra. Si no se encuentra
conectado a tierra de forma correcta, o si el receptculo
de pared no cumple con los requisitos establecidos (bajo
REQUISITOS ELCTRICOS), se deber solicitar los servicios
de un electricista calificado para corregir cualquier
deficiencia
ADVERTENCIA:
Riesgo de Descarga
Elctrica. Puede ocasionar lesiones o la muerte: NUNCA,
EDMRQLQJXQDFLUFXQVWDQFLDFRUWHGHIRUPHRHOLPLQH
QLQJXQDGHODVSXQWDVGHOFDEOHGHFRUULHQWH1RXVHXQ
prolongador. Si no se cumple con esto, se podrn
producir incendios.
ADVERTENCIA:
Riesgo de Descarga
Elctrica.
Puede ocasionar lesiones o
ODPXHUWH5HWLUHHOIXVLEOH
GHOKRJDURGLV\XQWRU
DELHUWRDQWHVGHFRPHQ]DU
ODLQVWDODFLyQDILQGHHYLWDU
OHVLRQHVVHYHUDVRWRWDOHV
por descarga.
PRECAUCIN:
3RUUD]RQHVGH
VHJXULGDGODVXSHUILFLHGHPRQWDMHGHEHUiSRGHU
VRSRUWDUODFDUJDGHOJDELQHWHDGHPiVGHOSHVR
DJUHJDGRGHHVWHSURGXFWRGHHQWUH\OLEUDV
DGHPiVGHFDUJDVDGLFLRQDOHVHQHOKRUQRPLFURRQGDV
GHKDVWDOLEUDVRXQSHVRWRWDOGHHQWUH\
OLEUDV
PRECAUCIN:
3RUUD]RQHVGH
seguridad, este producto no se puede instalar en
DUUHJORVGHDODFHQDWDOHVFRPRXQDLVODRSHQtQVXOD6H
GHEHPRQWDU7$172DXQJDELQHWHVXSHULRU&202D
una pared trasera.
PRECAUCIN:
Modelos de 120 V
Asegrese de
contar con una
conexin a
tierra adecuada
antes de usar.
$ILQGHHYLWDUHOULHVJR
de lesin personal (lesin en la espalda u otras lesiones
GHELGRDXQSHVRH[FHVLYRGHOKRUQRPLFURRQGDVR
GDxRVVREUHODSURSLHGDGGHEHUiFRQWDUFRQODD\XGD
GHGRVSHUVRQDVSDUDLQVWDODUHVWHKRUQRPLFURRQGDV
(OFDEOHGHFRUULHQWHGHHVWH
electrodomstico contiene
XQHQFKXIHGHSDWDV
(conexin a tierra) que se
conecta a un tomacorriente
de pared estndar de
FDEOHVFRQH[LyQD
WLHUUDSDUDPLQLPL]DUOD
SRVLELOLGDGGHULHVJRVGH
descargas elctricas por
parte del mismo.
REQUISITOS ELCTRICOS
Modelos de 120 V
Instrucciones de Instalacin
HERRAMIENTAS NECESARIAS
Destornillador
Phillips n1 y n2
Lpiz
Escuadra de
carpintero
(opcional)
Regla o cinta mtrica y extremo
recto
Gafas de seguridad
Detector de
montantes
Nivel
Martillo (opcional)
Instrucciones de Instalacin
CAMPANA DE ESCAPE
127$/HDODVGRVVLJXLHQWHVSiJLQDVVyORVLSODQHDYHQWLODUVXHVFDSHGHVGHODSDUWHH[WHULRU6LSODQHDKDFHUTXHHO
DLUHYXHOYDDFLUFXODUHQODKDELWDFLyQSDVHDODSiJLQD$FRQWLQXDFLyQILJXUDQHMHPSORVGHGLDJUDPDVGHOVLVWHPDGHO
FRQGXFWRGHO(VFDSHGH6DOLGD6XSHULRU\GHO(VFDSHGH6DOLGD7UDVHUR2EVHUYHODSRVLFLyQGHOKRUQRPLFURRQGDVUHODWLYDDO
VLVWHPDGHWXEHUtDV
NMERO
USADO
EQUIVALENT
=EQUIVALENTE
24 pies
(1)
24 pies
Conducto Recto
de 12 pies (Crculo de 6)
12 pies
(1)
12 pies
Adaptador de Transicin
Rectangular a Circular*
5 pies
(1)
5 pies
41 pies
*IMPORTANTE: Si se utiliza un adaptador de transicin rectangular a circular, las esquinas inferiores del regulador se
debern cortar para que coincidan, usando las tijeras para hojalata, a fin de permitir un movimiento libre del regulador.
NMERO
USADO =
LONGITUD
EQUIVALENTE
Tapas de Pared
40 pies
(1)
40 pies
Conducto Recto
de 30 Pies (Rectangular
de 3 x 10)
3 pies
(1)
3 pies
Codo de 90
10 pies
(2)
20 pies
63 pies
NOTA: Para el escape trasero, ser necesario alinear con cuidado el escape con el espacio entre los montajes, o la pared
deber ser preparada en el momento de su construccin, dejando espacio suficiente entre los montajes de pared para
ubicar el escape.
Instrucciones de Instalacin
NOTA: Si necesita instalar tuberas, deber observar que la
longitud total de una tubera rectangular de 3 1/4 x 10 o
una circular de 6 de dimetroQRGHEHUiVXSHUDUORV
SLHVGHHTXLYDOHQFLD
La ventilacin externa requiere un CONDUCTO DE SALIDA DE
LA CAMPANA. Lea la siguiente informacin detenidamente.
NOTA: Es importante que la ventilacin sea instalada
utilizando la ruta ms directa y con la menor cantidad de
codos posible. Esto asegura una ventilacin despejada del
escape y ayuda a evitar bloqueos. Adems, asegrese de
TXHORVUHJXODGRUHVVHEDODQFHHQOLEUHPHQWH\TXHQDGD
EORTXHHODVWXEHUtDV
/RQJLWXGPi[LPDGHODWXEHUtD
LONGITUD
EQUIVALENTE
NMERO
USADO
LONGITUD
EQUIVALENTE
Adaptador de Transicin
Rectangular a Circular*
5 pies
Pies
Tapas de Pared
40 pies
Pies
Codo de 90
10pies
Pies
Codo de 45
5 pies
Pies
Codo de 90
25 pies
Pies
Codo de 45
5 pies
Pies
24 pies
Pies
1 pies
Pies
PIEZAS DE TUBERA
7XEHUtD7RWDO
,03257$17(6LVHXWLOL]DXQDGDSWDGRUGHWUDQVLFLyQ
rectangular a circular, las esquinas inferiores del regulador
VHGHEHUiQFRUWDUSDUDTXHFRLQFLGDQXVDQGRODVWLMHUDVSDUD
KRMDODWDDILQGHSHUPLWLUXQPRYLPLHQWROLEUHGHOUHJXODGRU
3LHV
Instrucciones de Instalacin
PARTES INCLUIDAS
'$f2(192
INSTALACIN
PIEZAS ADICIONALES
6LODXQLGDGVHGDxDGXUDQWHHOHQYtRdevuelva
la unidad a la tienda donde fue comprada para su
reparacin o reemplazo.
Si la unidad es daada por el cliente, la reparacin
o reemplazo es responsabilidad del cliente.
6LODXQLGDGHVGDxDGDSRUHOLQVWDODGRU(si no es
el cliente), la reparacin o reemplazo deber ser
realizado por arreglo entre el cliente y el instalador.
PARTE
PARTES INCLUIDAS
INSTALLATION
INSTRUCTIO OW
NS N
MA ER
NU S
AL
PAQUETE DE PIEZAS
PARTE
CANTIDAD
Tornillos de Madera
(3/16 x 2)
Tornillos con resorte
y tuercas mariposa)
(1/4 x 3)
Tornillo de Mquina
con Auto Alineacin
(1/4-28 x 3-1/4)
CANTIDAD
Plantilla del
Gabinete
Superior
Plantilla de
la Pared
Trasera
Instrucciones
de
Instalacin
del Manual
del
Propietario
1
1
Filtros de
Grasa
Adaptador
del Escape
Bandeja
Anillo
del Plato
Giratorio
Filtro de
Carbn
(en algunos
modelos)
1*
Arandela Aislante
de Nylon (para
gabinetes metlicos)
* NOTA:
3DUD-90\$90el filtro est en el paquete de
accesorios. No se encuentra instalado en el producto.
3DUD-10el filtro ya se encuentra instalado en el
producto.
3DUD590 el filtro no est incluido.
Instrucciones de Instalacin
ESPACIO DE MONTAJE
Mx. de
12s
16-s
30s
2s
Mn. de
30s
El extremo inferior
del gabinete debe
estar a 30 o ms
desde la superficie
de coccin.
Tablero posterior
66 o ms
desde el
piso hasta
la parte
superior
del horno
microondas
NOTAS:
El espacio entre los gabinetes debe ser de 30 de
ancho y estar libre de obstrucciones.
Si el espacio entre los gabinetes es superior a 30,
se podr usar un Kit de Panel de Relleno para
completar la brecha entre el horno microondas y
los gabinetes. En su Manual del Propietario figura el
nmero de kit de su modelo.
Este horno microondas debe ser instalado sobre
estufas de hasta 36 de ancho.
Si har que la ventilacin de su horno microondas
salga hacia el exterior, consulte la Seccin Escape
de la Campana para la preparacin de la tubera de
escape.
Al instalar el horno microondas debajo de gabinetes
lisos y finos, asegrese de seguir las instrucciones
que figuran en la plantilla del gabinete superior
para que haya un despeje del cable de corriente..
/DSURIXQGLGDGGHOJDELQHWHSRUHQFLPD\DO
FRVWDGRGHODXQLGDGHVGH
3DUDODFRQILJXUDFLyQGHPRGHORVFRQ(VFDSHFRQ
Recirculacin: No permita que el gabinete u otros
objetos bloqueen el flujo de aire de la ventilacin.
(OSURGXFWRQRGHEHUtDVHULQVWDODGRVREUHXQDSODFD
de coccin o estufa con un BTU combinado superior a
60,000 BTU.
Instrucciones de Instalacin
1 COLOCACIN DEL PLATO DE MONTAJE
A RETIRO DEL HORNO MICROONDAS
'(/$&$-$5(7,52'(/3/$72
DE MONTAJE
Montaje de
Pared
Centro
Caja
Gomaespuma
Instrucciones de Instalacin
C
3RVLFLyQGHOD3ODFDJDELQHWHLQIHULRUSODQR
Las Lengetas de
la Placa de Montaje
Tocan la Estructura
Inferior del Gabinete
Las lengetas
de la Placa de
Montaje Tocan la
Parte Inferior del
Gabinete
30 a la Placa de
Coccin
3RVLFLyQGHOD3ODFDJDELQHWHFRQIUHQWH
saliente
Placa de Montaje
con Lengetas
Debajo de la
Parte Inferior del
Gabinete a la
Misma Distancia
que la Profunidad
del Frente Saliente
30 a la Placa de Coccin
10
Instrucciones de Instalacin
D ALINEE LA PLACA DE MONTAJE
30
Hole B
Dibuje una Lnea
Vertical en la
Pared desde el
Centro a la Parte
Superior del
Gabinete
Agujero A
Hole D
Agujero C
rea E
PRECAUCIN
Ranura
8VHJXDQWHVSDUDHYLWDUFRUWHVGH
dedos en extremos puntiagudos.
1 Dibuje una lnea vertical en la pared en el centro del
espacio de 30 de ancho.
2 Use la placa de montaje como plantilla para la pared
trasera. Coloque la placa de montaje en la pared,
asegurndose de que las lengetas estn tocando la
SDUWHLQIHULRUGHOJDELQHWHRODOtQHDDQLYHOGLEXMDGDHQ
HOSDVR&SDUDJDELQHWHVFRQIUHQWHVDOLHQWH$OLQHHOD
UDQXUD\ODOtQHDFHQWUDOGHODSODFDGHPRQWDMHFRQOD
OtQHDFHQWUDOGHODSDUHG
3 Mientras sostiene la placa de montaje con una mano,
dibuje crculos en la pared en los agujeros A, B, C y D
(consulte la ilustracin ms arriba/ la placa real est
marcada con flechas). 6HGHEHUiQXVDUFXDWURDJXMHURV
para el montaje.
ADVERTENCIA:
Riesgo de Descarga
(OpFWULFD3XHGHRFDVLRQDUOHVLRQHVRODPXHUWH'HEHUi
WHQHUFXLGDGRGHQRWDODGUDUVREUHFDEOHDGRVHOpFWULFRV
GHQWURGHSDUHGHVRJDELQHWHV
4 Haga agujeros sobre los crculos. Si hay un montaje,
haga un agujero de 3/16 para tornillos de madera.
Para aquellos agujeros que no estn alineados con un
montaje, haga un agujero de 5/8 para tornillos con
resorte.
NOTA: NO MONTE LA PLACA EN ESTE MOMENTO.
11
Instrucciones de Instalacin
2 TIPOS DE INSTALACIN
(Elija A, B o C)
127$6HOHFFLRQHHOWLSRGHYHQWLODFLyQUHTXHULGDSDUDVX
LQVWDODFLyQ\SURFHGDDGLFKDVHFFLyQ
RECIRCULACIN (SIN
CONDUCTOS NO VENTILADOS)
Cooking
Convenience
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Convenience
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Set
Clock
Power
Level
Cancel
Off
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Vent
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Start
Pause
Off
Cooking
Convenience
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Cancel
Off
12
Start
Pause
Add
30 Sec.
Cancel
Cooking
Beverage
Popcorn
Start
Pause
Instrucciones de Instalacin
A RECIRCULACIN
Convenience
Cooking
Beverage
Popcorn
Defrost
Potato
Cook
Time
Weight/Time
Reheat
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Set
Clock
Vent
Power
Level
Cancel
Off
Start
Pause
PRECAUCIN:
Tuercas mariposa
Tornillo
con
Resorte
Pared
Extremo
del Tornillo
PRECAUCIN:
13
Instrucciones de Instalacin
A3 AJUSTE EL MOTOR DEL
CALENTADOR
Cables
Parte Trasera
del Microondas
Plato
Calentador
Gire 90
Parte Trasera
del Microondas
Tornillo del
Motor del
Calentador
ADVERTENCIA:
Riesgo de Descarga
Elctrica. Puede ocasionar lesiones o la muerte. No
HPSXMHQLH[WLHQGDHOFDEOHDGRGHODXQLGDGGHO
VRSODGRU$VHJ~UHVHGHTXHORVFDEOHVQRSRVHDQ
cortes.
4 Deslice el plato calentador nuevamente hacia el
microondas, colocando las lengetas laterales en
las ranuras y empujando suavemente hasta que
la lengeta trasera quede ubicada en la ranura
trasera. Reemplace los 3 tornillos.
Lengeta Lateral
Ranura Lateral
Lengeta Lateral
14
Ranura Lateral
Instrucciones de Instalacin
A4 CMO INSTALAR EL FILTRO DE CARBN
PRECAUCIN:
$ILQGHHYLWDUHO
riesgo de lesin personal (lesin en la espalda u
RWUDVOHVLRQHVGHELGRDXQSHVRH[FHVLYRGHOKRUQR
PLFURRQGDVRGDxRVVREUHODSURSLHGDGGHEHUi
contar con la ayuda de dos personas para instalar
HVWHKRUQRPLFURRQGDV
Convenience Cooking
Popcorn
Beverage
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
Express Cook
Power
Level
On/Off
Add
30 Sec.
Turntable
Surface
Light
Set
Clock
Vent
Cancel
Start
Off
Pause
ADVERTENCIA:
Riesgo de Descarga
Elctrica. Puede ocasionar lesiones o la muerte: Si
LQVWDODODXQLGDGFRQHQFLPHURVGHPHWDOFXEUDHO
DJXMHURGHOH[WUHPRGHOFDEOHGHVXPLQLVWURGH
FRUULHQWHFRQDLVODQWHSDUDHOFDEOHGHOVXPLQLVWUR
de corriente.
Lengeta Inferior
Cable de Corriente
Rejilla
Convenience
Popcorn
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
Asegrese de
que las lengetas
inferiores queden
colocadas como se
muestra.
7 Cierre la puerta.
15
Instrucciones de Instalacin
A5 MONTE EL HORNO (cont.)
A6 ,167$/$&,15((03/$=2'(/
FILTRO DE CARBN SIN ACCESO A
LOS TORNILLOS SUPERIORES Y LA
UNIDAD YA FUE MONTADA
DESMONTE EL HORNO MICROONDAS
Esta distancia
NO puede
superar
las 2 para
asegurar una
instalacin
adecuada
PRECAUCIN:
$ILQGHHYLWDUHOULHVJR
de lesin personal (lesin en la espalda u otras lesiones
GHELGRDXQSHVRH[FHVLYRGHOKRUQRPLFURRQGDVR
GDxRVVREUHODSURSLHGDGGHEHUiFRQWDUFRQODD\XGD
GHGRVSHUVRQDVSDUDLQVWDODUHVWHKRUQRPLFURRQGDV
IMPORTANTE: No tome ni use la manija durante el retiro.
Tornillo Autoalineante
Parte Superior del Horno
Microondas
Tornillos Autoalineantes
ADVERTENCIA:
Riesgo de Descarga
Elctrica. Puede ocasionar lesiones o la muerte: Si retira
ODXQLGDGFRQHQFLPHURVGHPHWDOFXEUDHOH[WUHPRGHO
DJXMHURGHOFDEOHGHOVXPLQLVWURGHFRUULHQWHFRQDLVODQWH
SDUDHOFDEOHGHOVXPLQLVWURGHFRUULHQWH
IMPORTANTE: Si no se usan bloqueos de filtro, se podrn producir
daos en la caja debido al ajuste excesivo de los tornillos.
Conveni
ence Cooking
Potato
Beverage
Popcorn
Defrost
Cook
Time
Weight/Time
Reheat
Timer
On/Off
Express
Power
Level
Cook
3
6
9
Set
Clock
Add
30 Sec.
Turntable
Surface
Light
Vent
Start
Cancel
Pause
Off
Convenien
ce Cooking
Potato
Beverage
Popcorn
Defrost
Cook
Time
Weight/Time
Reheat
Timer
On/Off
Express
7
Power
Level
8
0
Cook
3
6
9
Set
Clock
Add
30 Sec.
Turntable
Surface
Light
Vent
Start
Cancel
Pause
Off
Convenience
Popcorn
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
16
Instrucciones de Instalacin
B ESCAPE SUPERIOR EXTERIOR
(Conducto Vertical)
VISIN GENERAL DE LA
INSTALACIN
B1. Adjunte la Placa de Montaje a la Pared
B2. Prepare el Gabinete Superior
B3. Ajuste el Motor del Calentador
B4. Instale el Adaptador del Escape
B5. Monte el Horno Microondas
B6. Conecte la Tubera
Convenience
Cooking
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Set
Clock
Vent
7
Power
Level
Cancel
Off
Pause
Placa de
Montaje
Start
Pared
PRECAUCIN:
17
Instrucciones de Instalacin
B3 AJUSTE EL MOTOR DEL
CALENTADOR (cont.)
Gire 90
Parte trasera
del Microondas
Cables
Parte trasera
del Microondas
PRECAUCIN:
Use gafas de
VHJXULGDGDOUHDOL]DUDJXMHURVHQODSDUWHLQIHULRU
GHOJDELQHWH
ADVERTENCIA:
Existe riesgo de
descargas elctricas que pueden ocasionar lesiones
RODPXHUWH1RHPSXMHQLH[WLHQGDHOFDEOHDGRGHOD
XQLGDGGHOVRSODGRU$VHJ~UHVHGHTXHORVFDEOHV
no posean cortes.
Lengeta
Lateral
Lengeta
Trasera
Ranura Lateral
18
Ranura Trasera
Instrucciones de Instalacin
B5 MONTE EL HORNO MICROONDAS
B4 ENSAMBLE E INSTALE EL
ADAPTADOR
Plato
Calentador
Regulador
PRECAUCIN:
$ILQGHHYLWDUHO
riesgo de lesin personal (lesin en la espalda u
RWUDVOHVLRQHVGHELGRDXQSHVRH[FHVLYRGHOKRUQR
PLFURRQGDVRGDxRVVREUHODSURSLHGDGGHEHUi
contar con la ayuda de dos personas para instalar
HVWHKRUQRPLFURRQGDV
ADVERTENCIA:
Riesgo de Descarga
Elctrica. Puede ocasionar lesiones o la muerte: Si
LQVWDODODXQLGDGFRQHQFLPHURVGHPHWDOFXEUDHO
DJXMHURGHOH[WUHPRGHOFDEOHGHVXPLQLVWURGH
FRUULHQWHFRQDLVODQWHSDUDHOFDEOHGHOVXPLQLVWUR
de corriente.
IMPORTANTE: Si no se usan bloqueos de filtro, se
podrn producir daos en la caja debido al ajuste
excesivo de los tornillos.
NOTA: Al montar el horno microondas, haga pasar
el cable de corriente a travs del agujero de la parte
inferior del gabinete superior. Mantenga el mismo
apretado siguiendo los Pasos 1 a 3. Evite cortes en el
cable o que se levante el horno microondas por tirar
del cable.
1 Levante el horno microondas, incline el mismo hacia
adelante, y enganche las ranuras en el extremo
inferior trasero sobre las cuatro lengetas inferiores
de la placa de montaje.
Cable de Corriente
Convenience
Popcorn
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
19
Instrucciones de Instalacin
B6 CONEXIN DEL CONDUCTO
Convenience
Cooking
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
ience
Conven
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Defrost e
Weight/Tim
Potato
Cook
Time
Timer
On/Off
7
Power
Level
2
5
8
0
3
6
9
Set
Clock
Add
30 Sec.
Turntab
le
Surface
Light
Vent
Start
Cancel
Pause
Off
Start
Pause
g
Cookin
Beverag
s Cook
Expres
1
4
Add
30 Sec.
Off
Reheat
Cancel
Popcorn
Esta
distancia
NO puede
superar
las 2 para
asegurar una
instalacin
adecuada
Tornillo Autoalineante
Parte Superior del Horno Microondas
20
Instrucciones de Instalacin
C ESCAPE EXTERIOR TRASERO
(&RQGXFWR+RUL]RQWDO
VISIN GENERAL DE LA
INSTALACIN
C1. Prepare la Pared Trasera
C2. Adjunte la Placa de Montaje
a la Pared
C3. Prepare el Gabinete Superior
C4. Ajuste el Calentador
C5. Monte el Horno Microondas
Cooking
Convenience
Beverage
Popcorn
Defrost
Reheat
Weight/Time
Potato
Cook
Time
Timer
On/Off
Express Cook
Add
30 Sec.
Turntable
Surface
Light
Power
Level
Set
Clock
Vent
Cancel
Off
Start
Pause
C1 PREPARACIN DE LA PARED
TRASERA PARA EL ESCAPE EXTERNO
TRASERO
Es necesario cortar una abertura en la pared trasera del
escape externo.
21
Instrucciones de Instalacin
C2 ADHIERA LA PLACA DE MONTAJE
A LA PARED (cont.)
Tornillo con
Resorte
Plato
Calentador
Pared
2 Retire el tornillo de la
parte trasera de la unidad.
PRECAUCIN:
Tornillo
Paletas del
Ventilador
Cables
PRECAUCIN:
22
Placas Preperforadas:
Recorte las 4 redes en
cada panel preperforado y
retire las preperforaciones
metlicas para el flujo
de aire trasero. Se
deber eliminar cualquier
extremo punteagudo
creado al retirar las placas
preperforadas.
Instrucciones de Instalacin
C4 ADAPTACIN DEL CALEFACTOR PARA
EL ESCAPE TRASERO EXTERIOR (cont.)
PRECAUCIN:
$ILQGHHYLWDUHO
riesgo de lesin personal (lesin en la espalda u
RWUDVOHVLRQHVGHELGRDXQSHVRH[FHVLYRGHOKRUQR
PLFURRQGDVRGDxRVVREUHODSURSLHGDGGHEHUi
contar con la ayuda de dos personas para instalar
HVWHKRUQRPLFURRQGDV
IMPORTANTE: No tome ni use la manija durante la
instalacin.
ADVERTENCIA:
Riesgo de Descarga
Elctrica. Puede ocasionar lesiones o la muerte: Si
LQVWDODODXQLGDGFRQHQFLPHURVGHPHWDOFXEUDHO
DJXMHURGHOH[WUHPRGHOFDEOHGHVXPLQLVWURGH
FRUULHQWHFRQDLVODQWHSDUDHOFDEOHGHVXPLQLVWURGH
corriente.
Tornillo
Regulador (lado
de la bisagra
hacia arriba)
Adaptador
del Escape
Lengetas
de Bloqueo
Parte Trasera
del Horno
Microondas
Power Cord
Cooking
Beverage
Reheat
Potato
Defrost
Cook
Time
Weight/Time
Express Cook
Timer
On/Off
2
4
3
5
Add
30 Sec.
6
8
Power
Level
Turntable
9
0
Cancel
Off
Surface
Light
Set
Clock
Vent
Start
Pause
Lengeta Lateral
Lengeta
Trasera
Ranura Lateral
Ranura Lateral
23
Instrucciones de Instalacin
C5 MONTE EL HORNO MICROONDAS
(cont.)
3 Inserte un tornillo autoalineante a travs del agujero
de la parte superior del centro del gabinete. En
forma temporaria asegure el horno dando al tornillo
por lo menos dos giros completos una vez que las
roscas fueron colocadas. (Ms tarde se ajustar
completamente). Inserte 2 tornillos autoalineantes
(1/4 28 x 2 ) a travs de los agujeros del
gabinete superior externo. D dos giros completos a
cada tornillo.
nience
Conve
Popcor
ng
Cooki
ge
Bevera
t
Defrosime
Potato
Cook
Time
Weight/T
Reheat
Timer
On/Off
ss Cook
Expre
1
4
7
Power
Level
l
Cance
2
5
8
0
3
6
9
Set
Clock
Add
30 Sec.
ble
Turnta
e
Surfac
Light
Vent
Start
Pause
Off
Esta distancia
NO puede
superar
las 2 para
asegurar una
instalacin
adecuada
Tornillo Autoalineante
Parte Superior del Horno Microondas
24
Instrucciones de Instalacin
ANTES DE USAR EL HORNO MICROONDAS
1
Asegrese de contar
con una conexin
a tierra adecuada
antes de usar.
25
Instrucciones de Instalacin
Impreso en China
26