Beruflich Dokumente
Kultur Dokumente
METRIC PRODUCTS
Nucor Fastener Division has offered a line of metric fasteners for many years, including the following products:
FASTENER TYPE
GRADE/SPECIFICATION
SIZES
REMARKS
Hex Head
Capscrews
Structural Bolts
Structural Nuts
Class 10S
METRIC PRODUCTS
The following table shows the lengths for thread-to-head (full thread) vs. full body (partial thread):
DIAMETER
M6 (6mm)
Exclusive To 25mm
30 - 200mm
10mm
M8 (8mm)
Exclusive To 35mm
40 - 200mm
13mm
M10 (10mm)
Exclusive To 40mm
45 - 200mm
16mm - 17mm
M12 (12mm)
Exclusive To 45mm
50 - 200mm
18mm - 19mm
M14 (14mm)
Exclusive To 55mm
60 - 100mm
21mm - 22mm
M16 (16mm)
Exclusive To 60mm
65 - 200mm
24mm
M20 (20mm)
Exclusive To 70mm
75 - 180mm
30mm
M24 (24mm)
Exclusive To 80mm
85 - 180mm
36mm
Structural Bolts
Metric Structural Bolts are made to the requirements of ASTM A325M. The ASTM A325M Bolt is equivalent to
the properties of an ASTM F568 Class 8.8 Bolt. These properties are essentially identical to Class 8.8 in ISO
898/I. Surface discontinuity limits are specified in ANSI B18.2.3.7M. The threads are rolled as specified in
ANSI B1.13M, to a metric coarse thread with Grade 6g tolerance.
Structural Nuts
The nuts are covered by ASTM A563M. The 10S Nut is listed as a suitable nut for an ASTM A325M Bolt (8S
is recommended for non-plated parts, but a higher class nut is also suitable). The nuts are made to the Heavy
Hex dimensions of ANSI B18.2.4.6M. The threads are cut per the metric coarse thread series as specified in
ANSI B1.13M (with Grade 6g tolerances). Surface discontinuities are covered in ASTM F812/F812M.
Distributed By:
ASTM A563M
Class 10S
ISO 7414 Class 10S