Beruflich Dokumente
Kultur Dokumente
A
D
M
E
C
REPRSENTED BY:
ADMEC MULTIMEDIA INSTITUTE
PRESENTED BY:
ANKIT SINGH
INFER CONSTRAINT
This options shortcut key is ctrl + shift + i.
By using this option when we are creating an object
then geometric constraints is apply on the object
automatically.
This option automatically applies geometric
constraints between the object which we are
creating and point attached to object snap. Infer
constraints are applied on object when the objects
condition is constraints. In the inferring
constraints result the objects position are not
changed.
SNAP MODE
Shortcut of Snap mode is F9.
For switch on the snap mode we can press the snap
mode button.
SNAP SPACING
It is stop the cursor movement to specified X and
Y gaping to the location of Rectangular Grid of Snap.
Snap X spacing
If the snap spacing direction is X then the value
will be positive.
Snap Y Spacing
If the snap spacing direction is Y then the value
will be positive.
GRID DISPLAY
Shortcut of Grid Display is F7.
For switch on the Grid Display we can press the GRID
button in the status bar.
ORTHO MODE
Shortcut of Ortho mode is F8.
For switch on the Ortho mode press the ORTHO button
in the status bar.
POLAR TRACKING
Shortcut of the Polar Tracking is F10.
For switch on the Polar Tracking press the POLAR
button in status bar.
OBJECT SNAP
Shortcut of the Object Snap is F3.
For switch on the Object Snap press the OSNAP button
in the status bar.
OBJECT SNAP
TRACKING
Shortcut of the Object Snap Tracking is F11.
For switch on the Object Snap Tracking press the
OTRACK button in the status bar.
DYNEMIC UCS
Shortcut of the Dynamic UCS is F6.
For switch on the Dynamic UCS press the DUCS
button in the status bar.
DYNAMIC INPUT
Shortcut of the Dynamic Input is F12.
For switch on the Dynamic Input press the DYN button
in the status bar.
LINEWEIGHT
For switch on the Line weight press the LWT button
on the status bar. Its used to see the weight of the line.
THANK
YOU